There are 31 owner-reported engine complaints for the 2009 BMW 5 Seriesin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2009 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was an abnormal burning odor coming from the vehicle. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2009 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the vehicle would overheat. An unknown warning light was illuminated and a warning message that the vehicle was overheating and to slow down and stop the vehicle to prevent further damage was displayed. The local dealer was contacted and informed the contact that the part to do the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 172,000. VIN tool confirms parts not available.
The contact owns a 2009 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that he started to smell a burning odor inside the cabin of the vehicle. The contact stated that the check engine warning light was illuminated. VIN tool confirms parts not available. The failure mileage was unknown.
The contact owns a 2009 BMW 528I. The contact received notification of NHTSA Campaign Number: 17V683000 (Engine and Engine Cooling) and 22V119000 (Engine and Engine Cooling) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated the vehicle was overheating and unsafe to drive. The contact was advised to seek a loaner vehicle while waiting for parts to become available. The approximate failure mileage was 205,000. VIN tool confirms parts not available.
The contact owns a 2009 BMW 528I. The contact stated while turning on the heater, there was a bad odor coming from the heater. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was not available. VIN tool confirms parts are not available
While driving I have received engine malfunction and steering becomes hard and unsafe. Have had the engine belt shred to pieces and case major issues. Same repair has been completed multiple times. Great vehicle becoming unsafe to have on the road. What component or system failed or malfunctioned, and is it available for inspection upon request? Engine Malfunction, Battery Malfunction and Yes. How was your safety or the safety of others put at risk? This put my safety at risk because I was on the expressway and the steering was hard to turn or direct. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No there were not any other messages or symptoms of the problem prior to the failure. When the light came on, I pulled over in a safe place. This has happened the first time on August 20, 2019; 2nd time November 9, 2019; 3rd time March 22, 2020; 4th time January 20, 2021; 5th time June 6, 2022. This is too costly for BMW certified parts to continue to occur. As reputable as the product is and with certified technicians, there should be a recall on the continuous leaks and belt shredding causing major issues to the vehicle. 17-22-2-245-358 - (2) O-Ring 83-19-2-451-316 - BMW Non-Chlor. Brak 11-28-7-628-653 - Ribbed V-Belt. 11-42-7-573-212 - Thermostat Housing 11-42-8-637-820 - Gasket 17-22-2-245-358 – (2) O-Ring 83-19-2-451-316 - BMW Non-Chlor. Brak 11-42-7-525-334 - Oil Filter Cover 11-42-7-573-212 - Thermostat Housing 11-42-8-637-820 - Gasket 17-22-2-245-358 – (2) O-Ring 83-19-2-451-316 - BMW Non-Chlor. Brak 11-42-7-525-334 - Oil Filter Cover
AS I AM DRIVING MY BMW AFTER 5 MINUTES OF START IT. I SMELLED OIL COMING OUT OF THE ENGINE. EVEN AFTER NOT DRINK THE CAR FOR ABOUT ONE WEEK THE SMELL WAS STILL THERE. I AM CONCERN THAT SOMETHING IS WRONG WITH THE ENGINE. EVEN ON A COOL 60 DEGREE DAY THE ENGINE IS TOO HOT TO TOUCH. I FEEL THAT THE COOLANT IN NOT GOING TO THE ENGINE SINCE AFTER PUTTING A FULL AMOUNT OF COOLANT THE COOLANT IS DEPLETE AFTER ONE HOUR.
TL* THE CONTACT OWNS A 2009 BMW 535I. WHILE DRIVING 40 MPH, THE VEHICLE MISFIRED AND IDLED ROUGHLY. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. BLAGOI'S INTERNATIONAL CAR SERVICE (1880 RIVERSIDE DR, COLUMBUS, OH 43221, (614) 486-2449) DIAGNOSED THAT THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.
THE ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN RECALL FOR THE E60 BMW 535I NEEDS TO BE TAKEN SERIOUSLY! THE CAR WILL BLOW UP. BMW NEEDS THIS PROBLEM EXPLICITLY TAKEN OFF THE STREET. YOU DONT EXPECT THE ULTIMATE DRIVING MACHINE TO EXPLODE. IN ACCORDANCE TO A TOTAL LOSS CLAIM MY INSURANCE USAA CLAIM NUMBER 013162236000000007001 . THE ENGINE CAUGHT COMPLETE FIRE AND ENGULFED THE CAR. I WAS INSIDE THE BAVARIAN MOTOR WORKS VEHICLE. I COULD HAVE DIED. MAGNESIUM IN THE CAR MEANS IT IS THEN SUBJECT TO COMBUSTION AND ALSO TO CATCH FIRE AGAIN WHICH IT DID. IN THE MORNING THE CAR WAS A FULL BLAZE AFTER THE FIRE DEPARTMENT LEFT THE PREVIOUS NIGHT. BMW NEEDS TO COMPENSATE INDIVIDUALS WHO HAVE LOST THEIR NICE CAR, LOST LOTS OF DAYS AT WORK , AND NEARLY LOST THEIR LIFE, BECAUSE OF THAT RECALL COULD HAVE THE CAR BLOW UP AT ANY TIME. MARCH 2 2018 (2009 535 BMW )
TL* THE CONTACT OWNS A 2009 BMW 528XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR FOR MONTHS. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SUDDEN LOSS OF POWER AND SMOKE APPEARED UNDER THE HOOD INTO THE INTERIOR OF THE VEHICLE. THE VEHICLE STALLED AND WAS TOWED. TWO DEALERS WERE CONTACTED: (BMW OF CHARLOTTESVILLE, 1295 RICHMOND RD, CHARLOTTESVILLE, VA 22911, (434) 270-8664) AND (BMW OF STERLING, 21710 AUTO WORLD CIR, STERLING, VA 20166, (571) 434-1944). THE MANUFACTURER WAS CONTACTED TO DETERMINE WHEN THE REMEDY AND PART WOULD BE SUPPLIED TO THE DEALER BUT THE MANUFACTURER WAS UNABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA RECALL NUMBER17V683 RECALL ISSUED FOR FAULTY PCV VALVE HEATER IN OCTOBER 2017 WITH NO REMEDY AS OF TODAY, SEPTEMBER 10, 2018.
AS MY WIFE WAS DRIVING HOME, IN AN ONLY ANKLE DEEP PUDDLE INSIDE OF OUR SUBDIVISION, WATER WAS ABLE TO GET INTO THE AIR INTAKE CAUSING THE VEHICLE TO HYDROLOCK AND EVENTUALLY DESTROY THE ENGINE. I BELIEVE SUCH A SMALL AMOUNT OF WATER SHOULD NOT BE ABLE TO DISABLE A CAR IN THE MIDDLE OF A RAINSTORM. I OBSERVED NUMEROUS OTHER VEHICLES TRAVELING THRU JUST FINE INCLUDING A LATE MODEL INFINITI Q50.
TL* THE CONTACT OWNS A 2009 BMW 535I. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED ON SEVERAL OCCASIONS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
ECCENTRIC SHAFT SENSOR FAILS SUDDENLY AND THEIR ISSUE OF VECHILE STALLING WHILE DRIVING I GOT JERKING MOTION WHEN DRIVING , IT HAD STALLED @ TRAFFIC SIGNAL IT MAY LEAD TO IMPACT
TL* THE CONTACT OWNS A 2009 BMW 528I. WHILE SERVICING THE VEHICLE, THE TECHNICIAN INFORMED THE CONTACT THAT THE HEAD CYLINDER BULLET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.
TAKATA RECALL, I BOUGHT THE CAR BACK IN LATE AUGUST, AT A DEALERSHIP CALLED DELUXE AUTO LOCATED IN LINDEN, NEW JERSEY. THE DEALERSHIP OFFERED ME A WARRANTY, 30 DAYS FREE AND 90 DAYS TO DECIDE TO GET THE WARRANTY OR NOT. THE INITIAL OFFER WAS ABOUT 60$ MONTHLY, AT 79K MILES. AFTER HAVING THE CAR FOR A MONTH DRIVING ON THE HIGHWAY LATE AT NIGHT THE CAR STARTING SHAKING AND TURNED OFF ON THE HIGHWAY. FUEL PUMP ERRORS. CAR WAS TOWED OFF THE HIGHWAY. AFTER A FEW HRS CAR STARTED AND RAN NORMALLY. WENT TO THE DEALERSHIP, GOT WARRANTY. THE OFFER NOW WAS AT 120$ A MONTH. THEY DID THE JOB, CAR RAN NORMALLY. HAPPENED AGAIN IN BROOKLYN, SENT CAR BACK TO DEALER THEY SAID NOTHING CAME UP ON THE COMPUTER, NOTHING THEY CAN DO. AFTER A FEW MONTHS SAME THING HAPPENED. THIS TIME IN CONNECTICUT, SENT IT TO THE NEAREST MECHANIC SHOP, BILL CAME TO 850, NOT INCLUDING TOWING 138$. NOW BACK TO MY DEALERSHIP, WHEN I WENT TO THEM TO PAY FOR THE WARRANTY, MY FATHER USED HIS CREDIT CARD, SINCE THEN I FIGURED IT WOULD CHARGE IT MONTHLY AUTOMATICALLY. THAT IS NOT THE CASE, AS I FOUND OUT THE DEALERSHIP SAID NOTHING THEY CAN DO. OTHER PROBLEM, CAR STARTED LEAKING OIL, ON OIL HOUSING UNIT, ENGINE OIL VALVE. GOT THEM BOTH FIXED AT ABOUT 500$ AT A LOCAL MECHANIC SHOP. NOW A WEEK LATER, AT 1AM OF MARCH 7TH OF 2016 I'M STARTING THE CAR, IT TURNS ON AND GIVES AN ERROR "ENGINE REDUCED POWER" AND "ENGINE PRESSURE TOO LOW, SHUT OFF ENGINE IMMEDIATELY ". I'M ABOUT TO BE 22, GONNA START COLLEGE SOON, I HAVE BEEN MAKING PAYMENTS TO A 20K CAR, ON TOP OF ALL THE MAINTANCE PROBLEMS THAT THIS DEALERSHIP SOLD ME AND TRICKED ME INTO. I DONT KNOW IF ME WRITING ALL THIS WOULD HELP ME IN ANY WAY BUT THIS SUCKS, ON TOP OF ME BEING TRAPPED ON A HIGHWAY UNTIL A TOW TRUCK COMES, IN NYC, 2 TIMES WHERE CARS FLY BY YOU I WANT THAT WHEN DEALERSHIP SELL CARS TO BE SURE THAT THE CUSTOMERS ARE SAFE DRIVING THEM.I HOPE IT HELPS.
TL* THE CONTACT OWNS A 2009 BMW 535I. WHILE DRIVING 50 MPH, THE VEHICLE DECELERATED AND THE REDUCE ENGINE POWER WARNING MESSAGE ILLUMINATED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE IT WAS TURNED OFF AND RESUMED NORMAL OPERATION AFTER RESTARTING THE ENGINE. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S CUSTOMER SERVICE RECALL; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
WHILE DRIVING "ENGINE FAILURE, REDUCE POWER" LIGHT CAME ON, POWER ON ENGINE REDUCED BUT DRIVABLE. WHEN CAR SHUT DOWN AND RESTARTED LIGHT GOES OFF BUT IF STEPPING ON THE GAS HARD THE LIGHT COMES BACK WITH ENGINE HAVING REDUCED POWER. THIS WAS REPAIRED TWICE, LAST BY BMW ON 7/29/13, THEY REPLACED VANS SOLENOIDS (INTAKE AND EXHAUST) AND REPROGRAMED THE TRANSMISSION. AT THAT TIME THEY TOLD ME IF THE PROBLEM RETURNS THE TRANSMISSION MAY NEED TO BE REPLACED. READING THROUGH FORUMS AND THE WEB I CAME UPON MANY COMPLAINTS FOR THE SAME PROBLEM IN WHICH DEALERS STATED DIFFERENT ROOT CAUSES, MANY SOLUTIONS PROPOSED BUT OFTEN PROBLEM RETURNS. I BELIEVE THIS IS DESIGN FLAW WITH THIS CAR AND SHOULD BE INVESTIGATED.
IN PASSING ON 2 LANE HIGHWAY WITH ONCOMING TRAFFIC A WARNING OF REDUCED ENGINE POWER OCCURRED WITH CORRESPONDING REDUCTION IN ENGINE POWER WITH SIGNIFICANTLY REDUCED MARGIN OF SAFETY WITH RESPECT TO ONCOMING TRAFFIC. THIS IS HAPPENING MULTIPLE TIMES AND HAS BEEN IN FOR REPAIR ONCE. RELIABILITY IS UNPREDICTABLE. *TR
DRIVING ON A POSTED SPEED LIMIT ROAD OF 30MPH WHEN WE SEE THIS MESSAGE ON OUR SCREEN "ENGINE MALFUNCTION POWER REDUCED". *JS
Showing 1–20 of 31 complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 26, 2026