2010 BMW X5 Fuel System Problems

The contact owns a 2010 BMW X5. The contact stated while starting the vehicle, after several minutes the vehicle failed to turn off as needed. There was no warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that metal shavings were found in the engine, and the oxygen heat sensor had failed. The vehicle was repaired. The contact advised the previous owner was notified of NHTSA Campaign Number: 16V746000 (FUEL SYSTEM, GASOLINE). The contact was not aware of the recall notification. The contact stated that the prior owner had the recall repair performed; however, the failure occurred. The manufacturer was not notified of the failure. The failure mileage was 127,911.

The contact owns a 2010 BMW X5. The contact stated that the vehicle had been parked and unoccupied for almost twelve hours, upon returning to the vehicle the battery was completely drained. The vehicle was jumpstarted and then driven to the residence. The contact stated that while pulling into the driveway at the residence, he smelled something hot coming from the vehicle. The contact exited the vehicle and saw flames underneath the vehicle. The contact stated that the flames were coming from the fuel filter heater. The contact removed several items from the vehicle before connecting a nearby garden house and extinguished the fire. No injuries were sustained. The Fire Department was not notified of the fire. A Police report was not filed. The contact stated that the vehicle was no longer drivable. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 13V339000 (FUEL SYSTEM, DIESEL); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 148,000.

THIS VEHICLE HAS HAD AN OPEN RECALL 18V-336 SINCE MAY OF 2018 . THE VEHICLE MANUFACTURER HAS YET TO PROVIDE A REMEDY TO CORRECT THIS DANGEROUS DEFECT IN THE VEHICLE. WHEN WILL A REMEDY BE PROVIDED? IT SEEM ALMOST A YEAR WOULD BE ENOUGH TIME TO FIX THIS DEFECT .

TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. IN ADDITION, THE BATTERY FAILED WITHOUT WARNING. THE FAILURE ONLY OCCURRED WHEN THE VEHICLE HAD BEEN PARKED IN BELOW FREEZING TEMPERATURES. THE VEHICLE WAS TAKEN TO THE DEALER (SANDIA BMW, 6001 PAN AMERICAN FWY, ALBUQUERQUE, NM 87109), BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 13V339000 (FUEL SYSTEM), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED AND STATED. THE FAILURE MILEAGE WAS 57,000. *TT *TR

I PURCHASED A CAR IN 2/4/2017, ON SECOND DRIVING, THE CAR STALL ON THE GREEN LIGHT. I DID CONTACT DEALERSHIP NAMED SHARPEST RIDES, TO ASK WHAT CAUSE THE PROBLEM, AS THEY TOLD ME TO DROP CAR AT THEIR PLACE TO INVESTIGATE AND DIAGNOSIS. I DID DROP, AFTER DAY THEY CONTACT ME AND MENTIONED THAT THEY CANNOT DUPLICATE THE PROBLEM, BECAUSE NOT ENOUGH TOOLS, SO THEY REFER TO BMW OF DENVER DOWNTOWN. THE BMW DEALER DID TEST AND DIAGNOSIS OF COUPLE DAYS AND RESPOND WITH "WE CANNOT DUPLICATE OF PROBLEM", SO THEY RETURN MY CAR TO ME WITH UNSAFE CONDITION. AFTER WHILE I STARTING HAVE SAME PROBLEM WITH STALL ENGINE IN THE MIDDLE OF ROAD, AT PARKING LOT, OR ONE DAY WASN'T EVEN START ENGINE, OR WHEN CAR STALL AND I AM LUCKY THE GUY DIDN'T HIT ME IN THE BACK, BUT HE DID HORNED ON ME, SHOWED ME FINGER, AND SO ON. I DID CONTACT MULTIPLE TIMES WITH DEALERSHIPS, WITH CORPORATE HEADQUARTER AT US NORTH AMERICA AND DID HAVE A CHANCE OPEN A CASE, HAVE A CHANCE TALK TO SUPERVISING, BUT EVERYONE SAYING TO ME BECAUSE CAR DIDN'T SHOWED ERROR MASSAGE AND THEY CANNOT DUPLICATE PROBLEM THEY WONT REPLACE FUEL PUMP, EVEN THEY KNEW THIS IS A FUEL PUMP CAUSING A PROBLEM. IN ADDITION, THEY DID RECALL 136000 FUEL PUMP, BUT THEY DIDN'T WANT CHANGE NOW, AND I DID TRY EXPLAIN THEM EVERYDAY WE ARE ON THE ROAD, WE MUST KEEP OUR LIFE SAFE AND KEEP OUR ENVIRONMENT SAFE, BUT THEY STILL TELLING ME WE CANNOT DUPLICATE A PROBLEM. MY CAR WAS A SECOND TIME AT SAME DEALERSHIP ON 4/72017 WITH SAME PROBLEM, AND THEY STILL TELLING ME EVERYTHING FINE WITH YOUR CAR, JUST DRIVE, I HAVE FOUR WITNESS THAT CAN VERBALLY IN WRITING PROOF THAT MY CAR STALL. MAYBE THE CAR IS DRIVE-ABLE BUT UNSAFE, BECAUSE YOU CANNOT PREDICT WHERE IT CAN BE STOP. PLEASE REVIEW AND SEE IF MANUFACTURE OR DEALERSHIP FOLLOWING ON ALL SAFETY PROCEDURE TO LET PEOPLE DRIVE IN HIGH RISK AND DANGEROUS OF LIFE ON ROAD. PLEASE CALL ME [XXX]. THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND A FUEL AND SMOKE ODOR WAS PRESENT. IN ADDITION, BLACK SMOKE EMITTED FROM THE EXHAUST PIPE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.

A KNOWN DEFECT OF AN ENGINE COMPARTMENT PARTITION/SEAL CAUSED OUTSIDE WATER TO ENTER THE ENGINE COMPARTMENT. THE WATER DRIPS AND ACCUMULATES OVER THE LAST FUEL INJECTORS, LEADING TO AN EVENTUAL SHORT. WHEN THE SHORT OCCURS, THE VEHICLE LOOSES ALL POWER. THE ENGINE SHUTS OFF PREVENTING ACCELERATION, POWER STEERING NO LONGER FUNCTIONAL, POWER BRAKES NO LONGER ASSISTED. THE SHORT OCCURRED WHILE DRIVING THROUGH AN INTERSECTION. THE CAR STALLED IN THE MIDDLE OF THE INTERSECTION AND NEEDED TO BE TOWED. FORTUNATELY, TRAFFIC WAS MINIMAL AND OTHER VEHICLES WERE ABLE TO SLOW DOWN AND DRIVE AROUND MY VEHICLE, PREVENTING A COLLISION. *TR

I HAD THE FUEL HEATER REPLACED AND BATTERY ON MY BMW X5-35D A COUPLE OF MONTHS AGO AT CONSIDERABLE COST. THE ENGINE WAS ALSO THROWING THE FUEL HEATER ACTIVATION CODE. I HAVE DOCUMENTATION OF THE REPAIR. I HAVE RECENTLY LEARNED OF RECALL 13V-339 THAT COVERS THIS PART FOR THIS EXACT REASON WITH A BUILD DATE WINDOW MERE WEEKS FROM THE BUILD DATE OF MY VEHICLE. THE BUILD DATE RANGE ON THIS RECALL IS JUNE 13, 2009- NOVEMBER 9, 2009. THE BUILD DATE FOR MY VIN IS LISTED AS DECEMBER 2009. BMW DID NOT COVER DESPITE THE PROXIMITY OF THE BUILD DATE AND THE EXACT SAME PROBLEM. I CAN SEE THAT THERE ARE OTHER COMPLAINTS ON THE NHTSA.DOT.GOV WEBSITE FOR THIS PROBLEM FOR VEHICLES WITH A DECEMBER 2009 BUILD DATE'

THE FUEL FILTER HEATER WAS RECALLED (RECALL NO. 13V-339). WE HAD TO HAVE OUR FUEL FILTER HEATER REPLACED AND WAS NOT COVERED UNDER WARRANTY BECAUSE THE RECALL WAS FOR VEHICLES PRODUCED FROM 6/2009 - 11/2009 AND OUR CAR WAS PRODUCED IN 12/2009. WE HAD OUR FUEL FILTER HEATER REPLACED BECAUSE WE HAD A CHECK ENGINE LIGHT ON AND WHEN WE TOOK TO DEALER WE WERE TOLD THAT WE NEEDED A NEW FUEL FILTER HEATER, THEREFORE WE FEEL WE ARE INTITLLED TO THE RECALL.

TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT THE NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS), 16V364000 (AIR BAGS), AND 16V746000 (FUEL SYSTEM, GASOLINE) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE DEALER (BMW OF DALLAS, 6200 LEMMON AVE, DALLAS, TX, 75209) STATED THAT THEY WERE SCHEDULING APPOINTMENTS FOR PARTS WITHIN THE NEXT THREE MONTHS, WHEN THE CONTACT CALLED THREE MONTHS LATER SHE WAS INFORMED THE SAME INFORMATION, AND ALSO MADE AWARE THAT THE PARTS FOR THE RECALL REPAIR WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT STATED HER VEHICLE SLOWED DOWN WHILE DRIVING ON THE EXPRESSWAY AND THEN STALLED. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO THE SAME DEALER BMW OF DALLAS WHERE THE VEHICLE WAS REPAIRED BUT THE REPAIRS PERFORMED WERE UNKNOWN. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT AND VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBERS: 16V071000 (AIR BAGS) AND 16V071000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (CRITZ BMW OF SAVANNAH, GEORGIA) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 08/11/17 *BF THE CONSUMER STATED THE FUEL THROTTLE ALSO MALFUNCTIONED. UPDATED 08/23/2017*JS

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW X5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V071000 (AIR BAGS) AND 16V746000 (FUEL SYSTEM, GASOLINE). THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT..UPDATED 01/04/17 *BF*DT *TR

TL* THE CONTACT OWNS A 2010 BMW X5. WHILE DRIVING AT VARIOUS SPEEDS, FUEL WAS LEAKING UNDER THE FRONT OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING COVER CASES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

I HAVE BEEN HAVING CHECK ENGINE LIGHT (CEL) PROBLEMS FOR YEARS. HAVE BEEN TOLD IT WAS FROM THE EGR SYSTEM. BMW FIRST CHARGED ME OVER $1500 FOR A REPAIR THAT DID NOT WORK. THEN THEY REPLACED THE WHOLE SYSTEM AND SAID IT WAS "UNDER WARRANTY" WHEN THE PROBLEM RESURFACED . NOW THE DIAGNOSTICS ARE AGAIN SAYING THE EGR SYSTEM IS FAULTING AND CAUSING THE CEL AGAIN. I FEEL BMW NEEDS TO RECALL THIS SYSTEM AND CONTINUALLY REPAIR IT AS IT IS AN ENGINEERING FAULT OF THEIRS

EXHAUST IS ENTERING THE CABIN THROUGH THE VENTING FILLING THE CAR WITH HARMFUL GASES. I BROUGHT IT TO THE DEALER AND THEY DIAGNOSED IT AS A EGR COOLER/VALVE ISSUE. THERE IS CURRENTLY AN "OPEN CAMPAIGN" FOR THE ERG BRACKET TO BE REPLACED BY BMW BUT NO SAFETY RECALLS ON THE EGR COOLER OR VALVE. I AM CONCERNED ABOUT THE SAFETY OF THIS ISSUE SINCE THE LEAK STARTS OFF SLOW AND UNDETECTABLE AT FIRST THEN GROWS TO BE A SERIOUS BURN IN YOUR EYES AND NOSE. THIS COULD BE ESPECIALLY HARMFUL TO FAMILIES WITH YOUNG CHILDREN. *TR

I WAS TOLD BY BMW THAT IT WAS THE EGR HIGH PRESSURE HEATER LEAKING, WHEREIN THE LEAK CAUSES DIESEL EXHAUST FUMES TO ENTER THE CABIN WHILE DRIVING WITHOUT WARNING. I OBSERVED THIS MOSTLY AS I PULL BACK FROM MY GARAGE, WHEN IDLING AND RANDOMLY AS I DRIVE. I'VE NOTICED A STRONG NOXIOUS SMELL IN THE CABIN, WHICH GAVE ME NAUSEA AND HEADACHE. I REMEDIED IT BY VENTING THE CABIN THEN RECIRCULATING THE AIR. IT HAPPENS CONSTANTLY EXCEPT WHEN I CIRCULATE THE AIR IN THE CABIN REGARDLESS OF WHEN I'M IN THE ROAD OR PARKED IN FRONT OF MY GARAGE. (I FIGURED THIS PREVENTS THE FUMES FROM THE HOOD ENTERING THE CABIN).I AM FINALLY HAVING IT REPAIRED FOR $800 MAYBE MORE AS I WILL FIND OUT TOMORROW THE FINAL COST. I'VE READ IN THE FORUMS THAT THIS IS NOT UNCOMMON EVEN BELOW 15K MILEAGE X5S WHICH IS VIRTUALLY NEW AND HAS OCCURRED IN DIFFERENT VEHICLE MILEAGES. THIS IS POTENTIALLY DANGEROUS AND A HEALTH HAZARD TO DRIVERS AND INFANTS. BMW SHOULD BE SHOULDERING THIS UNACCEPTABLE HARDWARE FAILURE! *TR

TL* THE CONTACT OWNS A 2010 BMW X5. WHILE DRIVING 30 MPH, THE ENGINE SHOOK, SMOKE APPEARED, AND THE ENGINE STALLED. THERE WAS NO FIRE. THE ENGINE MALFUNCTION INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO BMW OF DENVER DOWNTOWN (1040 S COLORADO BLVD, DENVER, CO 80246 (303) 954-4856) WHERE IT DIAGNOSED THAT THE SECONDARY FUEL PUMP AND THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 53,220.

IGNITION FAILED TO RESTART ENGINE DUE TO BATTERY DRAIN. IN ONE INSTANCE, BATTERY DISCHARGED DESPITE CAR HAVING BEEN DRIVEN FOR >1HR AND THEN STOPPED FOR LESS THAN 15 MINUTES BEFORE FAILURE TO RESTART. TWO OTHER OCCASIONS WERE FAILURE TO START ON THE MORNING AFTER VEHICLE LAST DRIVEN. AVERAGE OUTSIDE AIR TEMPS 5-30 DEGREES F. VEHICLE HAD LESS THAN 25K MILES AT FIRST OCCURRENCE AND LESS THAN 34K AT TWO MOST RECENT OCCURRENCES. BATTERY THIS NEW SHOULD NOT HAVE ISSUES HOLDING A CHARGE. SUSPECT DIESEL FUEL FILTER HEATER FAILURE TO SHUT OFF, RESULTING IN BATTERY DRAIN (SEE NHTSA CAMPAIGN NUMBER: 13V339000). 3 OCCURRENCES TO DATE, ALL WERE DURING COLD TEMPERATURES WHEN FFH WOULD HAVE BEEN ACTIVATED. JAN 2013, JANUARY 3, 2014 AND FEBRUARY 17, 2014. ADDITIONAL ELECTRICAL SYSTEM FAILURES NOTED AS A RESULT OF BATTERY DRAIN ISSUES INCLUDE MULTIPLE WARNING INDICATORS (PASSENGER AIRBAG, DIESEL EXHAUST FLUID INDICATOR WARNING, BRAKE PAD WARNING, AMONG OTHERS). *TR

MY BRAND NEW 2010 BMW X5 35D HAS STALLED MULTIPLE TIMES, IN MAJOR INTERSECTIONS COMPLETELY OUT OF THE BLUE. THE VEHICLE FLASHES "ENGINE MALFUNCTION" AND "REDUCED POWER." THERE IS NO WAY TO CURE THIS ISSUE, AND IT ONLY SELF-CORRECTS AFTER A MATTER OF MANY MINUTES. WHEN THROTTLE IS APPLIED, DURING SUCH AN INCIDENT, THE VEHICLE BUCKS WILDLY, BETWEEN STALLING AND STARTING. THERE ARE MANY OTHER BMW X5 OWNERS HAVING THIS ISSUE. NO FAULT CODES ARE REGISTERING ON THE COMPUTER AND THE VEHICLE SELF-CORRECTS AFTER STARTING AND STOPPING THE ENGINE MULTIPLE TIMES VIA THE PUSH-BOTTOM STOP BUTTON. ONCE THIS TOOK 3-HOURS TO RECTIFY, WHILE I WAS STUCK ON THE SIDE OF A BUSY HIGHWAY. THIS HAS ALSO HAPPENED AT TIMES IN WHICH I'M MAKING LEFT-HAND TURNS IN BUSY INTERSECTIONS, NARROWLY AVOIDING A HIGH-SPEED IMPACT. MY VEHICLE HAS ONLY 4,000 MILES ON IT. MY DEALER HAS BEEN UNRECEPTIVE TO THE ISSUE. I CONTACTED BMW NORTH AMERICA'S CUSTOMER SERVICE TWICE AND THEY TOOK A REPORT BUT NEVER CONTACTED ME BACK. I'VE LEFT MESSAGES WITH THE CUSTOMER SERVICE DEPARTMENT AT BMW NORTH AMERICA AND STILL NO RESOLVE. THIS IS A VERY DANGEROUS SITUATION. I HAVE NO IDEA AS TO WHEN THE VEHICLE WILL STALL OR MALFUNCTION. I FEEL I CAN HANDLE AN EMERGENCY, OR AT LEAST LESSEN A POTENTIAL IMPACT IN A WORST CASE SCENARIO, BUT I DO NOT FEEL THE SAME ABOUT MY WIFE. THE CAR LOOSES ALL BRAKE AND STEERING PRESSURE, AND I FEEL VERY UNSAFE DRIVING MY FAMILY IN THIS VEHICLE. MULTIPLE OTHER OWNERS HAVE SOLD THEIR VEHICLES AS A RESULT, BUT THOSE VEHICLES ARE GOING TO END UP IN THE HANDS OF OWNERS WHO WILL EXPERIENCE THE SAME ISSUES. IT'S ONLY A MATTER OF TIME BEFORE SOMEONE EXPERIENCES THIS ISSUE, IN AN INTERSECTION, AND IS KILLED BY ONCOMING TRAFFIC. PLEASE ASSIST US IN OBTAINING RELIEF TO THIS KNOWN ISSUE. YOU CAN VISIT THIS FORUM, WHICH IS ONE OF DOZENS, THAT COMPLAINS ABOUT THE ISSUE IN QUESTION. HTTP://WWW.XOUTPOST.COM/BMW-SAV-FORUMS/X5-E70-FORUM/68822-ENGINE-WARNING-BATTERY-FAILURE-SAME-TIME.HTML. *TR