There are 15 stored owner reports matching the engine leading-label group for the 2021 Chevrolet Blazer in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 15 of 15 matching reports.
Open the full vehicle complaint log (all categories)The vehicle had an oil leak from both the left and right camshaft carriers. The dealer confirmed the issue and carried out the necessary repairs. Because the leak was not easily detectable, it could have led to engine failure while driving. There were no warning indicators; only small oil droplets were found on the ground.
The 2021 GMC Blazer (and related Chevy Blazer models) is experiencing recurring radiator failures, often requiring multiple replacements within short timeframes. The radiator was replaced in March 2024 and in early 2025 I went for an oil change and complained of smelling coolant and asked if it could be checked and was told nothing was wrong. I was told again in November 2025 that it has a leak and went to have an oil change in February 7, 2026 and was reminded that the coolant was low and the radiator needs replacing when I was first told I did not believe it to be true as it has been replaced before and I asked that it be checked and was told nothing was wrong.
Radiator failure caused power steering assist to not function properly and insufficient vehicle heat function. Engine electric fan would run continuously after vehicle shutdown.
Was informed at today's oil change that my radiator is leaking and it's something that they are seeing a bunch.
Coolant smell when parked with engine running. Radiator was replaced under warranty at 16,000 miles Coolant smell again 49,000 miles. "Pressure tested at dealership with following notes: "Found radiator core on driver side seeping/leaking. provided estimate on cost. no repair made during this visit." Many forums on 2021 Chevrolet Blazer note poor quality in radiators. This would be the 3rd radiator in less than 50,000 miles on the vehicle.
Radiator leak, leaking antifreeze
Took 2021 Chevy Blazer to a Chevy dealer for small leak. 25000 miles and dealer said I have a leak in the radiator and needs to be replaced. If I didn't notice the small leak the engine could overheat, and possibly start a fire.
The contact owns a 2021 Chevrolet Blazer. The contact stated that upon turning off the vehicle, the fan remained engaged for approximately 10 minutes. Additionally, the contact stated that the A/C system was intermittently inoperable. The contact stated while driving at an undisclosed speed, the vehicle made an abnormal sound, and the contact noticed that there was a coolant leak onto the floor of the vehicle. An unknown warning light was illuminated. The vehicle was taken to East Houston Auto Electric, where it was diagnosed that the thermostat was stuck and needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 95,000.
On [XXX], I was driving my Blazer up to our local Museum to grab some information. The Museum is about a mile and a half from my house. When I had left my house, the car was driving like normal. I pulled into a parking spot at the Museum, and I went to shut the vehicle off, and I thought maybe the check engine light had come on but wasn't completely paying attention to the dash. About 10 minutes later I went to restart the vehicle to leave and I noticed the check engine light on. Since the vehicle seemed to be driving okay I thought I could make it home and check the car's computer to see what the issue was. As I was leaving the parking lot I stopped at the end of the parking lot to look before pulling out onto the road and the Blazer said shift to neutral and restart the vehicle. When I did that the vehicle would not start. It would just crank and crank and then it would finally start for a few seconds. I was going to back my vehicle up out of the road but each time I would try the car would die. I am very thankful this did not happen on the highway or even on the freeway. A friend and myself had to push my vehicle back into a parking spot. The DTC code is a P023F. When this happens, you can't technically shift the vehicle into neutral to push it out of the way because the car has to be running to shift. I was able to force it into neutral, however. I made an appointment with Awesome Chevrolet in Chehalis WA and had to have it towed to the dealer. They stated it was the fuel pump module. I had at that time 18,388 miles on the odometer. Unfortunately, I no longer feel safe with this vehicle in case it happens again. Where I am hours from home or on a 2-lane road or freeway. The fuel pump module failure appears to be a known issue with GM vehicles. The fuel pump module was replaced and was able to be replaced under warranty. I hope that it does not happen again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The Radiator has a crack in the upper left front of the core causing the fluid to leak and lose pressure causing the engine to overheat. This is a manufacture defect that has not been addressed as of 10/16/2024. The leak was discovered by a certified GM mechanic at a dealership when doing routine maintenance and inspection. The vehicle has never had any indication or advisory light that would alert the operator. As the engine overheats it can cause many of the other components of the vehicle to disable, including but not limited to the ADAS systems as well as power steering and/or collision safety components. This is a manufactures defect with the aluminum radiator that needs to be addressed immediately. Given the information from multiple GM dealerships the amount of newer low mileage Blazers that have been confronted with this problem is unprecedented. This not only creates a danger for the passengers of the vehicle but also every other vehicle on the road.
Leaking coolant from bad radiator “just out of warranty”. Roughly $2000 repair estimate
I have a 2021 Chevy Blazer which has had to have two radiators replaced with less than 50,000 miles on the vehicle. The first time was in March of 2023. I took my vehicle in for an oil change and the technician told me the radiator was cracked and all of the coolant was drained from the vehicle. It must have just run out because I regularly check my fluids and the vehicle was not overheating prior to the appointment. The vehicle had about 32k miles on it, so the radiator was covered under warranty. Now in April of 2024 with 49k miles, I take my vehicle in for another oil change and the radiator is cracked, again, with coolant leaking. The technician told me two things that are concerning about this. 1.) This is a known issue on the Blazers that they’ve done multiple repairs on. 2.) There is a piece of plastic under the radiator that catches the coolant when it leaks, making it hard to notice an issue because the coolant doesn’t pool on the ground underneath. My service advisor went to bat for me against GM, who partially paid for the second radiator. This brought my installation cost to $235, even though it was no longer under warranty. Radiators cracking is a serious safety issue because if the driver doesn’t notice the engine overheating, it could cause a vehicle fire putting the occupants and surrounding environment in danger. There are no warning lights on the vehicle to tell you if there is low coolant, other than noticing the temperature gauge when it is too late. I don’t know if GM didn’t install rubber bushings to absorb the impact of bumps on the road, or if it needs some rubber washers on the bolts, but something is missing. Online forums will confirm that this is an ongoing issue for owners of the Chevy Blazer
The contact owns a 2021 Chevrolet Blazer. The contact stated that the check engine warning light was illuminated. The contact was unable to use the electrical features in the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the purge pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case. The approximate failure mileage was 36,000.
I had just purchased my vehicle around December 9 2021. On around Decmeber 16, 2021 around 8 am I was driving on the highway 65 miles an hour. & the vehicle came to a complete stop. It kepts saying my fuel tank was empty. I quickly turned off the vehicle & tried turning it on & it did. I dropped it off at the dealership & it came back it was fuel pump. It was supposibly fixed. Comes January 26 vehicle did the same thing gettinf out of work. I got the vehicle back February 17. & today February 19, 2022 the truck did the same thing.
The contact owns a 2021 Chevrolet Blazer. The contact stated that oil was leaking from the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the cam shaft carrier needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to an independent mechanic, who determined that there was a separation in the transmission, oil cooler line, valve, and hoses that needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and submitted a complaint. The failure mileage was approximately 63,000.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.