2004 Chevrolet Colorado Engine Problems

I RECENTLY TOOK MY CHEVROLET COLORADO IN TO A CHEVROLET DEALERSHIP BECAUSE MY "CHECK ENGINE" LIGHT WAS ON. IT WAS DIAGNOSED THAT A SENSOR ON THE GAS TANK WAS RUSTED AND NEEDED TO BE REPLACED. THE SERVICE MANAGER ADMITTED THIS WAS COMMON FOR A COLORADO. PARTS WERE ORDERED AND I WAS TOLD IT WOULD COST ABOUT $800 TO FIX. I BROUGHT MY TRUCK IN A FEW DAYS LATER TO HAVE THE WORK DONE. LATER THAT DAY I WAS CALLED AND ASKED TO COME IN BECAUSE THEY FOUND ANOTHER PROBLEM WITH MY TRUCK THAT I NEEDED TO SEE. UPON ARRIVAL, I WAS TAKEN OUT TO SEE MY TRUCK ON A LIFT AND SHOWN A FRAME THAT WAS COMPLETELY RUSTED OUT. THE SERVICE MANAGER POKED A SCREWDRIVER INTO THE FRAME CAUSING PIECES OF RUST TO FALL TO THE FLOOR EXPOSING A HOLE IN THE FRAME. I WAS ALSO SHOWN WHERE THE FRAME WAS CRACKED RIGHT UNDER THE GAS TANK. THEY OFFERED NO EXPLANATION WHEN I ASKED WHY THEY HAD NOT FOUND THIS PROBLEM WHEN THEY DIAGNOSED THE PROBLEM WITH THE GAS TANK. ALL IN THIS PAST YEAR A THE SAME DEALERSHIP, I HAVE HAD MY TRUCK IN FOR NEW TIRES AND SHOCKS WITH NO MENTION ABOUT MY RUSTED FRAME. THEY BLAMED THE RUSTED FRAME ON THE SALT BRINE USED ON MAINE ROADS DURING THE WINTER MONTHS. I WAS TOLD MY TRUCK WAS PRETTY MUCH WORTHLESS. WHEN I ASKED WHY CHEVROLET DIDN'T BUILT FRAMES TO BETTER RESIST THE SALT BRINE THEY OFFERED NO ANSWER. I HAVE TAKEN MY TRUCK TO MULTIPLE CAR SHOPS WHERE THEY REPORTED THEY SEE THIS FREQUENTLY AND THE ONLY THING I CAN DO IS EITHER SELL MY TRUCK FOR PARTS OR REPLACE THE FRAME WHICH WOULD COST IN EXCESS OF $15,000. I CAN'T IMAGINE THAT MY TRUCK IS AN ANOMALY AND WONDER HOW MANY OTHER PEOPLE MIGHT BE DRIVING A VEHICLE THAT LOOKS ALMOST NEW LIKE MY TRUCK DOES BUT HAS A ROTTED FRAME. TOYOTA RECALLED THEIR TOKOMA TRUCKS DUE TO THIS SAME PROBLEM. I AM HOPEFUL SOMETHING CAN BE DONE. OTHER THAN THE ROTTED FRAME ON MY TRUCK THE REST OF THE UNDER CARRIAGE IS PRETTY MUCH PRISTINE. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER AND THEY ADVISED HIM THAT THE 02 SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE CATALYTIC CONVERTER WELD BECAME FRACTURED AND SEPARATED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THE EXHAUST MANIFOLD AND CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 182,000. MA 10/25/15

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED WHEN DRIVING AT A SPEED OF AT LEAST 50 MPH, THE ENGINE WOULD IDLE ROUGHLY AND THE CHECK ENGINE LIGHT WOULD ILLUMINATE ON THE WARNING PANEL. THE DEALER ADVISED THE ENGINE INTAKE VALVES WERE STRAINING AND ALL FIVE CYLINDERS WERE LEAKY DUE TO THE DEFECTIVE INTAKE VALVES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 110,000.

2004 COLORADO PICKUP 2.8 FOUR CYL. LEAK ON LOWER RADIATOR HOSE CAUSED BY POOR DESIGN, HOSE RUBS ON SHARP EDGE OF FRAME IN CURRENT ROUTING. *TR

TRUCK WIL STALL AND LOOSE POWER TO STEERING AND BRAKES AT LOW RPM (IN TURNS OR WHEN STOPPING ) HAVE RECIVED LETTER FROM MANUFACTUER ABOUT PROBLEM. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE VEHICLE MISFIRED AND THE SERVICE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THERE WAS A SAFETY RECALL FOR THE ENGINE INTAKE VALVE, HOWEVER; NO NHTSA CAMPAIGN ID WAS FOUND. THE DEALER WANTED TO CHARGE HIM $75.00 FOR THE REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 65,000. THE CONSUMER PROVIDED DOCUMENTATION FROM GM CORP STATING NO COST FOR THE DEFECT. UPDATED 09/12/07 *TR

MY 2004 CHEVROLET COLORADO HAS HAD REPEATED A RECURRING PROBLEM WHERE IT WILL NOT RESPOND TO THE THROTTLE AT ALL WHILE DRIVING. IN ALL CASES THIS HAS HAPPENED WHEN THE ENGINE IS WARMING UP FROM A COMPLETE COLD START IN THE MORNING. WHILE DRIVING AT 45-50 MILES PER HOUR THE ENGINE WILL DROP TO IDLE SPEED AND THERE IS NO RESPONSE TO THROTTLE INPUT. THE DEALER HAS HAD THE VEHICLE IN FOR SERVICE ON THIS ISSUE 5 TIMES NOW AND CAN NOTHING WRONG. THERE ARE NO CODES SET IN THE COMPUTER AND THE CHECK ENGINE LIGHT NEVER COMES ON. THE PROBLEM WILL CLEAR ITSELF AFTER 20 TO 30 SECONDS AND MAY NOT OCCUR AGAIN FOR WEEKS. *TR

EXHAUST MANIFOLD COMPLETELY CRACKED. AT THE CYLINDER CLOSET TO THE FIREWALL, THE MANIFOLD COMPLETELY CRACKED ALL AROUND AND ALL THE WAY THROUGH. STRANGE BECAUSE RELATIVELY NEW AND THE MANIFOLD WAS STEEL. *AK

THE CHECK ENGINE LIGHT COMES ON ACCOMPANIED BY AN ENGINE MISFIRE DUE TO WEAK EXHAUST VALVE SPRINGS WHICH MUST BE REPLACED. RECENTLY GMC ISSUED A BULLETIN TO THEIR SERVICE DEPARTMENTS ADVISING MECHANICS ON THE ISSUE, AND RECOGNIZING THE PROBLEM WITH THE VALVE SPRINGS AND HOW TO FIX IT, BUT WILL NOT ACKNOWLEDGE A MANUFACTURER'S DEFECT. ACCORDING TO THE BULLETIN THIS PROBLEM OCCURS IN ALL CHEVROLET COLORADOS 2004-2006, GMC CANYONS 2004-2006, AND THE HUMMER H3. THE ESTIMATED COST OF REPAIR IS ABOUT $2000, QUOTED BY THE DEALER MECHANIC. NOT ONLY DOES THE CHECK ENGINE LIGHT COME ON AND STAY ON, IT ALSO CAUSES THE VEHICLE TO STALL WHILE IN OPERATION. THE TRUCK SHUT DOWN IN THE MIDDLE OF THE INTERSECTION WHILE DRIVING. ADDITIONALLY YOU WILL HAVE DIFFICULTY WHEN YOU START YOUR CAR, IT WILL MISFIRE AND YOU MAY HAVE TO RESTART AGAIN. THIS WILL BEGIN TO HAPPEN REGULARLY UNTIL YOU DIAGNOSE THE PROBLEM. I WENT TO DIFFERENT DEALERS TO DIAGNOSE THE PROBLEMS BECAUSE DIFFERENT MECHANICS COULD NOT FIND THE PROBLEM WITH THE CHECK ENGINE LIGHT. THE LAST STEP WAS A DEALER MECHANIC THAT HAD JUST RECEIVED THE ABOVE MENTIONED BULLETIN. THEY DID NOT FIX THE PROBLEM WITH THE VALVE SPRINGS, INSTEAD THEY RESET THE COMPUTER TO STOP THE CHECK ENGINE LIGHT FROM OCCURRING. THE MISFIRING AND STALLING CONTINUED TO HAPPEN.*AK

VEHICLES CHECK ENGINE LIGHT CAME ON THEN WENT OFF AFTER A COUPLE OF DAYS. VEHICLE IDLE DROPPED TO 500 RPMS. THE TRUCK STARTED TO ACT SLUGGISH AND ACTED AS IF IT WOULD SHUT OFF AT IDLE. DURING ACCELERATION THE VEHICLE WAS AGAIN SLUGGISH. TOOK THE TRUCK TO A LOCAL SHOP AND HAD THE CODES RUN. IT CAME BACK AS AN ENGINE LOW RPM CODE. I DON'T RECALL THE ACTUAL CODE NUMBER. HAD THEM DO A MOTOR VACUUM TO CLEAN THE FUEL SYSTEM AND RESET CODE. THE CHECK ENGINE LIGHT HAS GONE AWAY AND HAS NOT COME BACK ON. VEHICLE DOES FROM TIME TO TIME ACT AS IT IS GOING TO BOG DOWN. I THOUGHT THAT I SHOULD SUBMIT THIS COMPLAINT BECAUSE IT SEEMS THERE ARE SEVERAL OTHERS WITH THE SAME PROBLEM.*AK

RATTLE OR VIBRATION AT 2000 RPM. DEALER REPLACED PART(S) BUT DID NOT FIX PROBLEM. *JB

WHILE DRIVING THE VECH. ONCE IT GOES UNDER 10MPH IT WILL STALL OUT. I THEN HAVE TO PUT IT IN N AND RESTART. THIS HAS BEEN GOING ON FOR A WHILE. EVER SINCE IT ABOUT 40-45,000 MILES...I HAVE NOT BEEN ABLE TO AFFORD TO PAY TO HAVE IT FIXED. I WAS TOLD BY A CHEVY DEALER SERVICE MANAGER THAT IT HAS A FAULTY COIL SYSTEM AND CHEVY DOES KNOW ABOUT IT BUT WHEN THEY CHOOSE TO ISSUE A RECALL NOTICE IS THERE CHOICE. *TR

DT*: THE CONTACT STATED WHILE DRIVING 65MPH UP AN INCLINE THE VEHICLE BEGAN TO LOOSE POWER. THE NEXT DAY THE CHECK ENGINE LIGHT ILLUMINATED. AFTER INSPECTING THE VEHICLE THE INDEPENDENT REPAIR SHOP RESET THE CHECK ENGINE LIGHT. THE PROBLEM HAS NOT RETURNED.

2004 COLORADO TRUCK STALLED WITHOUT WARNING AT 70 MPH WHILE GOING UP A STEEP INCLINE. *TS THE VEHICLE'S SPEED DROPPED FROM 70 TO 15 MPH WITHIN SECONDS. THE CONSUMER WAS UNABLE TO PULL OVER BECAUSE THERE WAS NO SHOULDER. THE CONSUMER LOOKS AT THE INSTRUMENT PANEL AND NOTICED THAT THE DIC WAS FLASHING REDUCE POWER. THE CONSUMER LATER FOUND OUT THAT IF THE VEHICLE ENCOUNTERS A LITTLE EMISSION PROBLEM IT SHUTS DOWN. THE CONSUMER'S VEHICLE DIDN'T HAVE AN EMISSION PROBLEM BUT A COMPUTER GLITCH. *NM

2004 CHEVROLET COLORADO Z71 - RANDON STALLING CAUSING LOSS OF STEERING AND BRAKING. *NM

WHILE DRIVING THE AIR BAG LIGHT WARNING LIGHT TURNED ON, TAKEN TO DEALERSHIP TO BE FIXED, PROBLEM PERSISTED EVEN AFTER THE DEALERSHIP SAID AIR BAG CONNECTORS WERE CLEANED AND/OR REPLACED, CURRENTLY UNAWARE IF AIR BAGS WILL DEPLOY IN THE EVENT OF AN ACCIDENT. VEHICLE RPM'S FLUCTUATE DOWN TO 500 WHILE VEHICLE IS SLOWING TO A STOP DURING COLD WEATHER. DEALERSHIP WAS ISSUED SERVICE BULLETIN AND PROBLEM WAS ADDRESSED BUT RETURNED WITHIN DRIVING APPROXIMATELY 50 MILES, DURING SEVERELY COLD WEATHER VEHICLE IS ABLE TO STALL THE ENGINE WHILE IN MOTION. *NM

ODI 10150645, ODI 10150645: 3RD RECURRING PROBLEM. CUSTOMER INVOICE: DRIVERS WINDOW INOPERATIVE, SCREWS BACKED OUT OF WINDOW MOTOR CAUSING IT TO BIND R & R WINDOW MOTOR AND REINSTALLED BOLTS. NOISE GONE AFTER REPAIRS. UPON ENGAGE DRIVER'S SIDE TURN SIGNAL, FAILURE TO OPERATE VISIBLE TURN INDICATION. DAYTIME RUNNING LIGHT ALSO INOPERABLE, BULB NOT WORKING. CUSTOMER INVOICE: DRIVER SIDE DAYTIME RUN LIGHT INOPERATIVE. LF TURN SIGNAL BULB BURNT OUT. REPLACED BULB UPON ENGAGING BRAKE SYSTEM, BRAKES EXHIBIT HIGH FREQUENCY SQUEAKING, MORE ON LEFT THAN RIGHT. EXTREME TIRE WEAR IS APPARENT ON THE INSIDES OF BOTH FRONT TIRES. CUSTOMER INVOICE: BRAKES NOISY AT STOPS ALL THE TIME. UNABLE TO VERIFY CUSTOMER CONCERN AT THIS TIME. VEHICLE HAS A LOT OF MUD UNDERNEATH. ENGAGING 4WD HIGH, VEHICLE BECAME STUCK IN 4WD. CONTINUED TO DRIVE VEHICLE IN CONDITION UNTIL SERVICE DEPARTMENT OPENED FOR THE WEEK. FOUR WHEEL DRIVE BECAME OPERATIONAL INTERMITTENTLY. CUSTOMER INVOICE: AXLE/DIFFERENTIAL, VEHICLE STUCK IN FOUR WHEEL DRIVE ONCE. UNABLE TO VERIFY CUSTOMER CONCERN AT THIS TIME. NO CODES & WORKING AS DESIGNED. ENGAGING A/C & HEATING OPERATION THE AC DIMINISHES BLOWER POWER AND BEGINS BLOWING SMOKE-LIKE COOLANT FROM DASH VENTS. DASHBOARD CONDENSATES EXTENSIVELY. CONDENSATION MUST BE WIPED DRY TO DETER INTERIOR DAMAGE. AFTER RUNNING A/C AT MAXIMUM POWER FOR 20 MINUTES OR LONGER, OPERATIONAL PROBLEMS DISCONTINUE UNTIL VEHICLE IS STARTED 'COLD'. CUSTOMER INVOICE: A/C CUTS OFF AND BLOWS SMOKE OUT OF VENTS ALL THE TIME. WHILE DRIVING. UNABLE TO VERIFY CUSTOMER CONCERN. CHECKED PRESSURES. ALL OK, WORKING AS DESIGNED. *NM

AXLE/DIFFERENTIAL FAILURE. ENGAGING REVERSE, VEHICLE WILL LUNGE FORWARD WITH POWER AND THEN JUMPS IN REVERSE AS IF TRANSMISSION IS SLIPPING OR MISSING REVERSE GEAR. VEHICLE STRAINS TO SWITCH GEARS TO REVERSE WHEN VEHICLE IS AT A COMPLETE STOP. CSTMER INVOICE: AT TIME VEHICLE LUNGES AND JUMPS IN REVERSE. REPROGRAMMED PCM WITH UPDATE. START VEHICLE IDLE 5 MINUTES OR MORE, ENGAGING D GEAR, ENGAGE A/C OPERATION AND THEN ACCELERATING IN 80-95 DEGREE F ENVIROMENTAL CONDITIONS, VEHICLE WILL LOOSE TORQUE, RPMS REDLINE WHILE APPLING NORMAL ACCELRATOR PEDAL PRESSURE. VEHICLE STALLS BUT NEVER DIES, COASTED TO NEARBY PARKING LOT AND CALLED DEALERSHIP FOR A WRECKER, TOWED BACK TO DEALERSHIP FOR REPAIRS. DEALER CUSTOMER INVOICE: AT TIMES VEHICLE WILL NOT ACCELERATE. UNABLE TO VERIFY CUSTOMER CONCERN. OPERATING AS DESIGNED. NO CODES. *NM

ENGINE & COOLING SYSTEMS, CHECK ENGINE LIGHT STAYS ON WHILE VEHICLE IN USE.ENGINE MISSES OR VIBRATES SLIGHTLY.VALVES SPRINGS ARE BAD @ 15,000 MILES. *AK