2001 Chevrolet Corvette Fuel System Problems

We purchased the car on 12/17/21. I went to Costco on 12/18/21 to get gas. I had a preset amount of $50 to put into the car. When I got to $50 I shut the pump off myself, the tank was not full enough for it to shut off automatically. As I look down on the ground I saw a fluid running out from underneath the car and rolling along the ground. I touched it with my finger and discovered it was gasoline. I put the nozzle back into the holder and I checked underneath the car and saw it was dripping from the drivers side in the area just behind the drivers door. I pulled the car over to the side to inspect it further. By now the gas had stopped dripping. Since the exhaust pipe is right next to the fuel tank I was afraid of a fire or explosion. Had some fuel vapors but they dissipated shortly after. My gas gauge was registering full at this time. Since then I have not had any gasoline leaks and or vapors present. I have not put any more gas in the car since then. (I contacted the previous owner and he said in an email response, if you overfill there is a vent hole that gas will leak out of at the top of the filler neck. It happened once when I put like 20 gallons in it.) I did some research and found that there is a problem with the Corvette gas tanks and or the crossover tube. I think this is a dangerous situation, thinking that if that gas ignited, the car and my passenger could have caught fire and possibly ignited the Costco gas station with an explosion. (This car will be going into the repair shop in January to have a diagnostic smoke test done to determine where the leak and or leaks are coming from.) I hope the NHTSA recognizes this as a very dangerous situation. All of this will be coming out of my own pocket for the repairs necessary to make this car safe to drive and not be dangerous to myself and family. I consider this a very serious dangerous situation.

WHEN YOU FILL UP THE FUEL TANKS YOU GET A VERY STRONG SMELL OF GAS IN THE CAR AS WELL AS IN THE GARAGE. GENERAL MOTORS KNOWS ABOUT THIS COMPLAINT AND WILL HELP THEIR CUSTOMERS. IN FACT THERE IS A CLASS ACTION LAWSUIT AGAINST GM FOR YEAR CORVETTE 2004. IT WILL COST ABOUT $ 2,000.00 TO $ 2,500.00 TO MAKE THE REPAIRS. A LOT OF TIMES THE RIGHT TANK IS CRACKED OR THE CROSSOVER TUBE IS CRACKED . I HAVE CALLED GM AND ASKED FOR HELP AND THEY WILL NOT ACCEPT THIS AS A WARRANTY ISSUE. THERE ARE MANY COMPLAINTS ABOUT THIS ISSUE . BY THE WAY ALL THE GM DEALERS ARE AWARE OF THE ISSUE. CAN YOU HELP ME OUT ? YOU SMELL THE FUEL WHEN THE CAR IS STOPPED.

AFTER FILLING FUEL TANK. PARKED VEHICLE IN GARAGE AND NOTICED A FUEL LEAK ON PASSENGER SIDE UNDERNEATH FUEL TANK.

GASOLINE SMELL WHEN YOU FILL THE TANK. IT IS MOST PREVALENT AT REAR PASSAGE SIDE OF THE CAR. WHEN PARKED IN GARAGE THE GAS SMELL FILLS THE GARAGE.

GAS FUMES AFTER FILLING. FILLS THE GARAGE OVER NIGHT. HAPPENS ALL OF THE TIME.

IN 2005 MY STEERING COLUMN LOCKED. THE CAR WAS TOWED TO CHEVROLET DEALERSHIP IN ALEXANDRIA VA. THEY UNLOCKED THE STEERING COLUMN BUT DID NOT REPLACE THE NECESSARY PARTS. NOW THE COMPUTER READS THAT THE STEERING COLUMN IS GOING TO LOCK AND THE FUEL PUMP SHUTS OFF. WHEN THE CAR WAS INSPECTED BY WYNNGARDNER CHEVROLET THEY INFORMED ME THEN WARRANTY HAD BEEN SATISFIED. IF THE DEFECTED PARTS WERE REPLACED THEY WOULD NOT HAVE TO REPLACE THEN SAID PARTS WERE REPLACED INITIALLY. THE VEHICLE HAS BEEN INSPECTED AND SAID PARTS ARE NOT THERE. THE DEALERSHIP USED THE VIN NUMBER IN 2005, NOW WHEN THE VIN NUMBER IS USED, IT SHOWS THAT THE RECALL WAS SATISFIED. THIS IS NOT THE CASE.

WHEN I FILL UP MY GAS TANK THERE ARE STRONG GAS FUMES IN THE GARAGE. THE FUMES ARE NOT THERE WHEN THE TANK IS 3/4 FULL OR LESS. THIS IS A CONTINUING ISSUE.

UPON FILLING MY FUEL TANK FULL OF GASOLINE, I PARKED THE CAR IN MY GARAGE AND NOTICED A VERY PREDOMINATE FUEL VAPRO SMELL THAT SEEMS TO BE COMING FROM THE DRIVERS SIDE. THERE NEVER HAS BEEN ANY EVIDENCE OF FUEL LEAKAGE OR POOLING ON THE FLORR BELOW THE CAR. WHEN I INADVERTENTLY FILL THE FUEL TANK FULL, I HAVE TO TAKE A DRIVE AND PUT ABOUT 30MILES ON THE CAR THEN THE FUEL VAPOR ODOR PROBLEM IS SOLVED FROM READING THE INTERNET BLOGS, IT WOULD APPEAR THAT I AM NOT ALONE IN THE SYMPTOMS FOR MY CAR

GAS TANKS LEAKING FROM THE TOP

FUEL TANK LEAK RIGHT SIDE TOP OF TANK. *TR

FUEL LEAK AT THE FUEL TANK. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. THE CONTACT STATED THE FUEL TANK WOULD LEAK AND EXHIBITED GASOLINE FUMES INSIDE THE VEHICLE. THE VEHICLE WAS REPAIRED ONE YEAR PRIOR TO THE MOST RECENT FAILURE WHERE THE DEALER SEALED THE FUEL TANK TO STOP THE LEAK BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE THE FUEL SENDING UNIT AND PUMP SEAL REPLACED A SECOND TIME. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 55,000.

DEFECTIVE/CRACKED RIGHT FUEL TANK (WHERE FUEL PUMP CONNECTED TO FUEL TANK). STRONG FUEL SMELL NOTICED THIS PAST SUMMER, WHILE PARKED IN HOME GARAGE - SMELL WOULD ONLY BE NOTICEABLE AFTER TANK WAS FILLED. TANK REPLACED BY CARR CRAFT, INC., OF PORTAGE, MI., WITH 'ORIGINAL EQUIPMENT' TANK FROM CHEVROLET. CAR OWNER CALLED CHEVROLET CUSTOMER SERVICE AND DELIVERED TANK TO KRUM/COLE CHEVROLET DEALERSHIP IN VICKSBURG, MI FOR INSPECTION AND CONFIRMATION OF CRACK (AT REQUEST OF CHEVROLET CUSTOMER SERVICE). CHEVROLET SERVICE REPRESENTATIVE ADVISED THAT IT WAS DUE TO "NORMAL WEAR AND TEAR", RATHER THAN A MANUFACTURING ISSUE AND WOULD NOT CONSIDER COMPENSATION FOR REPLACEMENT OF THE TANK. VEHICLE HAS NEVER BEEN IN ANY KIND OF ACCIDENT AND IS OWNED BY ORIGINAL PURCHASER.

TOPPED OFF GAS TANK AND DETECTED STRONG GASOLINE ODOR WITHIN VEHICLE. PARKED CAR IN GARAGE AND STRONG GASOLINE ODOR EMANATING FROM REAR HALF OF VEHICLE. UNABLE TO DETECT ANY GASOLINE LEAKS FROM VEHICLE ON THE FLOOR OR VISIBLE PARTS OF THE UNDERSIDE OF THE VEHICLE. OPENED GARAGE DOORS TO VENT OUT THE FUMES. FUMES DISSIPATED AFTER SEVERAL HOURS. I NO LONGER TOP OFF THE TANK IN AN EFFORT TO AVOID A POTENTIALLY VOLATILE SITUATION. ORIGINAL OWNER REPORTED FUEL TANK RELATED PROBLEMS AROUND 15,000 MILES BUT REFUSED TO FILL UP THE TANK DURING SERVICE AT DEALERSHIP.

I HAVE A 2001 CORVETTE THAT HAS LEAKED GAS FROM AROUND THE GAS TANK AREA AT THE REAR OF THE CAR. I HAVE READ NUMEROUS COMPLAINTS ONLINE THAT OTHER CORVETTES OF THAT ERA ALSO HAVE FAULTY FUEL COMPONENTS THAT LEAK. WHAT IS MY RECOURSE? *TR

2001 CORVETTE GAS TANK ODOR. I READ THAT YOU HAVE OPENED A CASE ON THE 2004 CORVETTES. MY 2001 IS IDENTICAL TO THE 2004 MODEL AND HAS THE EXACT SAME PROBLEM. IF THE GAS TANK IS FILLED FULL, A VERY BAD GASOLINE ODOR IS PRESENT. THE ODOR GOES AWAY AS THE GAS TANK EMPTIES. *TR

LEAKY GAS TANK OR CROSS OVER. WHEN TANK IS FILLED GAS LEAKS AND FUMES CAN BE SMELLED FOR DAYS. *TR

THE FUEL TANK LEAKS WHEN FILLED TO THE NORMAL CUTOFF POINT WHEN FILLING. THERE WAS NO EVENT LEADING TO THE FAILURE, IT OCCURS WHEN THE FUEL TANK IS FILLED. THE FUEL TANK NEEDS TO BE REPLACED TO CORRECT THE DEFECTIVE FUEL TANKS. GM/CHEVY DOES NOT STAND BEHIND THE DEFECTIVE TANKS AND THE COSTS ARE BORN BY THE OWNER. GM DID NOT RESPOND TO THE ISSUE WHILE IT WAS UNDER EITHER THE VEHICLE'S EXTENDED GMPP WARRANTY NOR THE EMISSIONS WARRANTY, BOTH NOW JUST EXPIRED. *TR

IMMEDIATELY AFTER GAS FILL-UPS, CAR AND GARAGE SMELLS OF GASOLINE. CONTINUES TO SMELL UNTIL APPROXIMATELY 50 MILES ARE REGISTERED ON VEHICLE. HAS BEEN A CONSTANT PROBLEM SINCE PURCHASE OF PRE-OWNED 2001 VEHICLE IN SEPTEMBER OF 2007 FROM GM DEALERSHIP. *TR

2001 CORVETTE. 2 YEARS AGO (1)ENGINE CHECK LIGHT ALWAYS ON (2)TRACTION CONTROL WARNING LIGHTS ON (3)ABS WARNING LIGHTS ON (4)LOW FUEL WARNING LIGHT GOES ON IF UNDER 1/2 TANK AND GAUGE DROPS TO ZERO FUEL (5)DRIVER SIDE HEADLIGHT WILL NOT OPEN UP (6)LIGHTS DO NOT WORK ON HEATING ,A/C DIRECTIONAL FLOW THESE COMPLAINTS FROM WHAT I HAVE READ ON BLOG SITES FROM HUNDREDS OF OTHER CORVETTE OWNERS ARE VERY COMMONPLACE PROBLEM LIES IN THE FACT THAT WHEN MY WARNING LIGHTS ARE LIT UP I HAVE NO ANTILOCK BRAKES WORKING ON MY CAR NOR DO I HAVE TRACTION CONTROL. THIS IS EXTREMELY DANGEROUS. SOME TIME THE LIGHTS WORK SOMETIMES THEY GO OFF WELL I AM IN MOTION. THIS CAN CAUSE A DANGEROUS SITUATION IF I AM JUST HITTING THROTTLE AND THIS OCCURS CAUSING ME TO LOSE CONTROL AND RISKING A COLLISION. THESE ARE POWERFUL CARS EVEN WHEN DRIVEN IN A SAFE MANNER. I OWN AN AUTOMATIC TRANSMISSION AND IT DOES NOT TAKE MUCH THROTTLE FOR THE ENGINE TO GEAR DOWN AND ACCELERATE. I STOP AT GEN. MOTORS DEALER FREQUENTLY HOPING FOR A CAMPAIGN. TO CORRECT THIS PROBLEM. THE SAME STORY ALWAYS IS THAT IT IS A DEFECTIVE COMPUTER BOARD AND THAT I AM LOOKING AT APPROX $4000.00 DOLLARS TO REPAIR. READING BLOG SITE IT IS THE SAME. SOME WOULD SAY THAT IF ONE CAN AFFORD A CORVETTE THEN THIS SHOULD NOT BE AN ISSUE. I SAY IT IS A SERIOUS SAFETY ISSUE AND SHOULD NOT HAVE TO PAY OUT OF POCKET. AM ONLY AN EMPLOYEE AT A DAYCARE AND SAVED FOR YEARS TO PURCHASE THIS CAR. THE OTHER COMMON COMPLAINT IS THE FUEL GAUGE BUT UNDERSTAND THAT WITH COMPUTER BOARD REPLACED THIS WILL ELIMINATE PROBLEM. POP UP HEADLIGHT COST TO REPAIR $300.00. *TR