There are 6 stored owner reports matching the suspension leading-label group for the 2005 Chevrolet Corvette in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 6 of 6 matching reports.
Open the full vehicle complaint log (all categories)I purchased my 2005 Corvette C6 from a used car dealership on 4/30/2023. The car was fine for the first week. The second week I began getting a lot of error codes specifically: Service Active Handling System Service Traction Control Service ABS Shocks Inoperative Service Fuel System. At times it would go into limp mode. I would find a safe place to pull off. I would shut the car off and it would not restart. I would check the relays under the hood and the passenger floorboard. Eventually it would restart and drive again until the next time. I have replaced the following components: Battery cables with factory replacement New Battery, twice New high output alternator and a new belt. These items solved the many codes. Now I get Service Traction System, and the traction control shuts off. When this happened last, I got a P0101 MAF sensor error. Replaced the MAF Sensor 8/13. Has not happened as of yesterday. I have checked all of the grounds, added a new ground system called the Big Three. I should not have to put all this work into a well documented issue not only in the C6 but other models.
WHILE DRIVING 70+MPH ON AN INTERSTATE, "REDUCED POWER MODE" AND "SERVICE ACTIVE HANDLING" WARNINGS ILLUMINATED ON THE DIC AONG WITH THE CHECK ENGINE LIGHT. THE VEHICLE THEN COMPLETELY SHUT OFF MAKING IT EXTREMELY DANGEROUS TO GET SAFELY OUT OF THE PATHS OF OTHER VEHICLES. THIS HAS HAPPENED TO THE VEHICLE ABOUT 8 TIMES NOW IN VARYING CIRCUMSTANCES, MOSTLY WHILE IN MOTION. ERROR CODES TAKEN FROM HANDHELD PROGRAMMER INCLUDE: P1516, P2101, P2135
SERVICE ACTIVE HANDLING SYSTEM MESSAGE APPEARS INTERMITTINGLY, VEHICLE WAS IN MOTION. DIDN'T NOTICE ANY HANDLING ISSUE BUT I AM CONCERNED THAT THE CAR WILL BEHAVE IN AN UNSAFE MANOR.
BOTH REAR AXLES HAVE BROKE. ONE WAS FOUND BY A DEALERSHIP'S REPAIR SHOP WHEN THEY WERE LOOKING AT SOMETHING ELSE. THE SERVICE TECH SAID THAT THE LEFT REAR AXLE WAS CRACKED ALL THE WAY THROUGH AND THAT IT WAS A FACTORY DEFECT. THE OTHER REAR AXLE BROKE SEVERAL MONTHS LATER (ABOUT 2 MONTHS AGO) AS I WAS ACCELERATING INTO RUSH HOUR TRAFFIC. NOW I HAVE A PROBLEM IN THE FRONT. *TR
SERVICE ACTIVE HANDLING KEEPS COMING UP ON MY 2005 CORVETTE. THEY SAY THE WHEEL POSITIONING SENSOR IS BAD AND MUST BE REPLACED... *TR
DT: THE RIGHT REAR AXLE SNAPPED IN HALF. TOTAL LOSS OF ANY FORWARD MOVEMENT OR ACCELERATION. THE CAR STOPPED ON ITS ON. CAR WAS TAKEN BACK TO DEALER. THE CAR HAS NOT BEEN REPAIRED YET. DEALER SAID THERE WERE NO MANUFACTURING DEFECTS OR RECALLS. *AK
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.