There are 7 owner-reported visibility & wipers complaints for the 2005 Chevrolet Malibuin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED WHILE AT A COMPLETE STOP, SHE HEARD A LOUD BANG. THE CONTACT LATER DISCOVERED THAT THE SUNROOF GLASS HAD EXPLODED. THE SMALL PIECES OF GLASS SHATTERED INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
BLEND DOOR STUCK ON RECIRCULATE RESULTING IN INTERIOR MOISTURE AND FOGGING/ HEAVY ICING OF INTERIOR WINDOWS-NO VISIBLITY REQUIRING CONSTANT SCRAPING/WIPING. FRESH AIR AND RECIRC. LIGHTS DO WORK. LIGHTS ON BUT NO ONE HOME. *NOT AN ANTIFREEZE/ HEATER CORE LEAK. EXTERIOR VENTS BELOW WINDSHIELD ATOP FIREWALL DRAWING IN NO AIR. MECHANIC SAYS IT MIGHT BE HEATER CONTROL MODULE. BUT MIGHT MEANS AN EXPENSIVE FIX IF ITS THE PROBLEM. *TR
HEAT? AIR CONDITION FANS DO NOT BLOW ON #1-3. ONLY OPERATES ON LEVEL #4. *TR
I PUT DOWN THE BACK WINDOWS AND NOW THEY WON'T GO BACK UP. I HAVE AN '05 MALIBU AND RARELY USE THE WINDOWS. THE MOTOR SHOULD NOT HAVE WENT (IF THAT IS IN FACT THE PROBLEM). I WILL NOT BE ABLE TO PUT MY INFANT IN THE CAR IN THE WINTER IF THIS PROBLEM ISN'T FIXED? *TR
DT*: THE CONTACT STATED THE MOON ROOF VIBRATED VIOLENTLY ALONG WITH THE ENTIRE ROOF ANYTIME THE REAR WINDOWS WERE DOWN. THE PROBLEM IS MORE OBVIOUS AT SPEEDS OF 65-75MPH. THE VEHICLE WAS SEEN BY A SERVICE DEALER WHO DETERMINED IT WAS NORMAL FOR VIBRATION TO OCCUR WITH THE WINDOWS DOWN. THE MANUFACTURER WAS ALSO ALERTED OF THE POTENTIAL HAZARD. *AK
THE WINDSHIELD OF MY VEHICLE STARTED TO DEVELOP BUBBLES BENEATH THE SURFACE OF THE GLASS. I WAS INFORMED BY A GLASS REPAIR COMPANY THAT THIS IS A DEFECT IN THE GLASS(AT THE MANUFACTURING STAGE). I CANNOT SEEM TO GET ANY SATISFACTION FROM THE DEALER OR THE VEHICLE MANUFACTURER. *JB
DT*: THE CONTACT STATED THE DRIVER'S SIDE SUN VISOR DROPS UNEXPECTEDLY. THE LOCAL DEALERSHIP WAS MADE AWARE OF THE PROBLEM AND REPLACED THE ORIGINAL VISOR. HOWEVER, THE REPLACEMENT VISOR HAS THE SAME PROBLEM. THE VEHICLE HAS BEEN RETURNED TO THE DEALERSHIP FOR INSPECTION. UPDATED 2/21/2006 - THE DEALER REFUSED TO REPLACE THE VISOR AGAIN. THE MANUFACTURER WAS CONTACTED AND CLAIMED THAT THE WERE WORKING ON A FIX FOR THE PROBLEM. *NM
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 26, 2026