2008 Dodge Caliber Suspension Problems

I’ve only had the car since Aug. Im the second owner, it drove just fine. Then I got an oil change. Then the car began to rev down hill and struggled to make it uphill. Then my exhaust became excessively loud. Then the wheel became loose ,and started pulling ALOT. I was on my way to get an alignment this morning and the whole front end began to buckle not even a minute down the road. I tmade it in back the driveway before the front end collapsed completely

Rear subframe rusted right through control rods snapped rear end of car dropped down. Upon researching they know that this is bad and unsafe even gave a 10 year extended warranty for front and rear subframe so how long will and how many complaints before this is an actual recall. I see here in your complaints that there is a large number of complaints on this issue. How are they getting away with this and nothing being done. I will have photos also police had said if this happened while it was on interstate would have crashed and could have been fatal. The tire would have ripped right off. So not only was my safety but the safety of the others being jeopardized cause everyone just keeps looking away at this issue. I would love to know how many of these subframes have had to be replaced I bet if you do research there is not one of them out there that either should be replaced have been replaced or will need to be replaced. Stop allowing these car companies to use sub standard parts. I am sure this will fall to the wayside along with the other 100 complaints. I will try my hardest to make sure everyone knows this is a problem that the car company is fully aware of and nobody has done anything about and keep researching on how many more this has happened to and try to get everyone to file a complaint. There was NO WARNING SIGN just broke loose passenger side of car was practically on the ground the broken control arm is what held everything up. Please can we really check into this if there is a recall at least people will know the problem exist.

Rear crossmember/ subframe rusted thru and broke. Replaced front several years ago. Car has always been garaged.

The entire underneath of my car is rusted out. I was driving to work one day when someone pulled out in front of me and I had to hit the brakes. That resulted in the subframe and front drivers axel to break as I’m driving! The sunroof leaks when it rains and half the time the electricity doesn’t work on the sunroof button. My doors have completely stopped auto locking and my hazards will randomly start flashing without pushing the button. Steering is absolutely terrible, it feels like you’re skidding on ice or hydroplaning the entire drive.

2008 DODGE CALIBER SUB FRAME/K-FRAME FRONT END CROSSMEMBER COMPLETELY RUSTED THRU CAUSING THE DRIVER SIDE LOWER CONTROL ARM TO RIP FREE FROM FRAME (SEPERATING PART OF FRAME, WITH LOWER CONTROL ARM) FROM REST OF FRAME. THIS LEFT DRIVER WITH NO CONTROL OF AFFECTED WHEEL WHICH TURNING IT 90 DEGREES OUT FROM NORMAL OPERATING POSITION. LEFT OPERATOR WITH NO ABILITY TO STEER WHILE DRIVING ON MAIN PRIMARY (35 MPH SPEED LIMIT) TWO LANE ROAD. CAR SLID TO HALT IN MIDDLE OF ROAD. CAR NEEDED TO BE TOWED. DODGE/CHRYSLER APPARENTLY KNEW OF THIS PROBLEM AND NEVER NOTIFIED OWNER. PLEASE SEE ATTACHED NOTICE. FRONT AND REAR CROSSMEMBER CORROSION (X69 WARRANTY EXTENSION) - 2008-2012 DODGE CALIBER & JEEP COMPASS/PATRIOT OEMDTC JULY 17, 2017 15 COMMENTS NHTSA ID NUMBER: 10140027 MANUFACTURER COMMUNICATION NUMBER: 23-007-17 REV. B SUMMARY FRONT AND REAR CROSSMEMBER CORROSION (X69 WARRANTY EXTENSION) THE DRIVER OF THIS CAR COULD HAVE BEEN KILLED OR SERIOUSLY HURT. IT IS UNFATHOMABLE THAT DODGE CHRYSLER WAS ALLOWED TO GET AWAY WITH NOT NOTIFYING POTENTIAL CRASH VICTIMS

I HAVE HAD MY 2008 DODGE CALIBER SINCE 2009. SINCE THEN I HAVE REPLACED BOTH TIE RODS 4 TIMES. I JUST HAD THEM DONE AGAIN ABOUT 1 1/2 YEARS AGO AND THEY ARE BROKEN AGAIN. I HAVE CHANGED THE BALL JOINTS AS WELL.. THIS IS RIDICULOUS AND SHOULD HAVE BEEN RECALLED I READ A LOT OF FORUMS AND EVERYBODY COMPLAINS ABOUT THE SAME THING.

MY 2008 DODGE CALIBER CROSS-MEMBER BROKEN IN THE MIDST OF ME DRIVING

RECENTLY PURCHASED A 2008 DODGE CALIBER(OHIO). ON INITIAL DRIVE RETURNING WITH VEHICLE I NOTICED A VIBRATION COMING THROUGH STEERING WHEEL. UPON INSPECTION, WAS INFORMED THE TIE ROD ENDS AND CONTROL ARMS BOTH COULD USE REPLACEMENT, BUT COULD HAVE BEEN CAUSED BY THE MORE IMPORTANT BAD FRONT AND REAR CROSSMEMBERS AS WELL AS FRONT AND REAR CRASH BARS, BOTH HAVE SEVERE RUST DEVELOPMENT WITH METAL DETERIORATION WHICH COULD IMPOSE A SAFETY CONCERN DOWN THE ROAD. WAS ADVISE TO LOOK INTO REPLACEMENT. REACHED OUT TO ONE OF THE LOCAL DEALERSHIPS AND WAS INFORMED IT WAS A BULLETIN, HAD AN EXTENDED WARRANTY, BUT AM OUTSIDE OF 10 YEAR PERIOD. RUST FROM CROSSMEMBER IS NOW IN PROCESS OF TRANSFERRING TO ACTUAL FRAME AND COMING THROUGH AS HOLES IN ROCKERS NOW AS WELL. DEALERSHIP OFFERING NO HELP AFTER STATING THE ENHANCED SAFETY CONCERN. HARD TO BELIEVE AN 08 CAN DETERIORATE SO FAST. YOU WOULD THINK WITH THE COMPLAINTS AND T.S.B. AS WELL AS SAFETY CONCERNS, SEEING STILL ORIGINAL PARTS THAT HAVE BEEN WARRANTIED TO REPLACE BUT HAVE NOT ON THIS VIN, GETS NO HELP AT ALL. *TR

WHILE MY WIFE WAS DRIVING, THE FRONT SUBFRAME CROSSMEMBER RUSTED THROUGH, CAUSING HER TO LOSE CONTROL OF THE CAR AND SHE COULD NOT SAFELY OPERATE IT WITHOUT REPAIR. I MANAGED TO GET IT TO A FIRESTONE FOR THEM TO LOOK AT AND THEY REFERRED ME TO A DEALER AND TOLD ME NOT TO DRIVE IT ANYMORE BECAUSE IT IS UNSAFE. THIS IS A PROBLEM THAT DODGE KNEW ABOUT, BUT FAILED TO NOTIFY ME ABOUT. I ONLY FOUND OUT ABOUT THE PROBLEM FROM THE DEALERSHIP, WHO TOLD ME THAT THE EXTENDED WARRANTY THAT COVERS THIS PROBLEM HAD EXPIRED IN 2018 AND THAT I WOULD BE RESPONSIBLE FOR THE COST OF ANY REPAIRS. I OWNED THE CAR DURING THAT TIME AND I DID NOT KNOW OF THIS PROBLEM, SO I COULD NOT ACT ON GETTING IT REPAIRED. THIS NEVER SHOULD HAVE BEEN AN EXTENDED WARRANTY, THIS SHOULD HAVE BEEN A RECALL BECAUSE OF THE POTENTIAL TO KILL PEOPLE WHEN THE SUBFRAME RUSTS OUT. MY WIFE WAS DRIVING IN A PARKING LOT AT THE TIME AT A RELATIVELY LOW SPEED, BUT HAD THIS HAPPENED ON A HIGHWAY IT COULD HAVE KILLED HER AND MY SON, AS WELL AS OTHERS ON THE ROAD. NUMBER: 23-007-17 REV. B GROUP: BODY DATE: MARCH 10, 2017 *TR

TL* THE CONTACT OWNS A 2008 DODGE CALIBER. THE CONTACT TOOK THE VEHICLE TO A TIRE STORE BECAUSE SHE HEARD A GRINDING NOISE AND THOUGHT THERE WAS A BRAKE ISSUE. THE TIRE STORE REPRESENTATIVE DETERMINED THAT THE FRONT AND REAR CROSS MEMBERS WERE SEVERLY CORRODED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

THE FRONT CROSSMEMBER HAS RUSTED OUT SO MUCH THAT IT WILL NOT PASS A PA STATE INSPECTION AND IS UNSAFE TO DRIVE. AFTER HEARING THIS I FOUND OUT THAT IT IS NOT A MATTER "IF" IT WILL RUST OUT, JUST A MATTER OF "WHEN". I WAS NOT FORTUNATE ENOUGH TO HAVE THIS HAPPEN DURING THE WARRANTY EXTENSION AND FEEL THAT DODGE SHOULD HAVE NOTIFIED ME THAT THERE WAS AN EXTENSION.

NOTICED NOISE WHEN TURNING AND GOING OVER SMALL BUMPS IN ROAD .ON CITY STREETLOOKED UNDER IT SAW SUBFRAME IS RUSTED OUT WITH BIG RUST HOLES IN IT NOW PARKED NOT SAVE TO DRIVE

TL* THE CONTACT OWNS A 2008 DODGE CALIBER. WHILE DRIVING APPROXIMATELY 25 MPH, THE FRONT END OF THE VEHICLE STARTED TO SHAKE AND A LOUD SOUND EMERGED FROM THE WHEELS. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE IT WAS DETERMINED THAT THE CROSSMEMBERS ON THE FRONT OF THE VEHICLE WERE SEVERELY RUSTED AND NEEDED REPLACEMENT. THE VEHICLE WAS TAKEN TO KOLOSSO JEEP DODGE (2701 W COLLEGE AVE, APPLETON, WI 54914) WHERE IT WAS DIAGNOSED THAT THE FRONTAL CROSSMEMBERS WERE ALSO RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,200.

I PREVIOUSLY CALLED REGARDING ODI 11282835. THE FRONT AND REAR CROSS-MEMBERS WERE COMPLETELY RUSTED AWAY. THERE WAS AN EXTENDED WARRANTY AND THE ORIGINAL OWNER NEVER REPAIRED THE ISSUE THE WARRANTY EXPIRED 04/2018. CHRYSLER REFUSES TO FIX THE ISSUE. I PURCHASED THE VEHICLE 09/2019 AND DISCOVERED THE ENTIRE SUSPENSION HAD ROTTED OUT. THIS IS EXTREMELY DANGEROUS. IT IS PURSUANT TO THIS BULLETIN. CHRYSLER IS REFUSING TO REPAIR IT. SERVICE BULLETIN NUMBER: 23-012-14 GROUP: BODY DATE: MAY 19, 2014 THIS BULLETIN IS SUPPLIED AS TECHNICAL INFORMATION ONLY AND IS NOT AN AUTHORIZATION FOR REPAIR. NOTE: THIS ONLY APPLIES TO VEHICLES IN THE CANADIAN MARKET AND IN SALT BELT STATES WHICH INCLUDE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON, D.C., WEST VIRGINIA AND WISCONSIN. SUBJECT: FRONT AND REAR CROSSMEMBER CORROSION (X58 10 YEARS UNLIMITED MILEAGE) OVERVIEW: THIS BULLETIN INVOLVES INSPECTING THE FRONT AND REAR CROSSMEMBERS FOR PERFORATION / RUST THROUGH AND IF NECESSARY, REPLACE THE CROSSMEMBER(S). MODELS: 2007 PM CALIBER 2007 MK COMPASS, PATRIOT NOTE: THIS BULLETIN APPLIES TO VEHICLES BUILT ON OR AFTER AUGUST 26, 2005 (MDH 0826XX) AND ON OR BEFORE JULY 23, 2007 (MDH 0723XX). SYMPTOM/CONDITION: THE CUSTOMER MAY DESCRIBE A VIBRATION AT THE STEERING WHEEL OR MAY HAVE BEEN INFORMED BY A TECHNICIAN OR STATE VEHICLE INSPECTION THAT THE FRONT AND / OR REAR CROSS-MEMBER IS SEVERELY CORRODED. POLICY: WARRANTY PERIOD FOR CROSS-MEMBER PERFORATION / RUST THROUGH IS EXTENDED TO 10 YEARS. REIMBURSABLE WITHIN THE PROVISIONS OF THE WARRANTY.

TL* THE CONTACT OWNS A 2008 DODGE CALIBER. WHILE THE VEHICLE WAS AT AN INTERSECTION, THE VEHICLE SHOOK VIOLENTLY WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT MANAGED TO STEER THE VEHICLE HOME WHILE IT SHOOK. THE CONTACT LOOKED UNDER THE VEHICLE AND NOTICED THAT THE REAR SUBFRAME WAS FRACTURED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO FILE A COMPLAINT WITH NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 162,321. *BF CONSUMER STATED FRONT SUBFRAME RUSTED AND CORROSION, VIN IS XXXX. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

TL* THE CONTACT OWNS A 2008 DODGE CALIBER. WHILE DRIVING, THE CONTACT HEARD A LOUD NOISE. THE CONTACT LATER DISCOVERED THAT THE SUBFRAME WAS RUSTED THROUGH AND CAUSED THE FRONT DRIVER'S SIDE AXLE TO FRACTURE. ALSO, THE TOP OF THE DRIVER'S SIDE WHEEL WAS TILTED INWARD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THE AXLE, SUBFRAME, ONE OF THE BRAKES, AND THE TRANSMISSION FLUID LINE WERE REPLACED. THE DEALER WAS NOT CONTACTED. THE CONTACT CALLED THE MANUFACTURER AND WAS TRANSFERRED TO NHTSA. THE FAILURE MILEAGE WAS 112,850.

FRONT CROSS MEMBER COMPLETELY RUSTED THROUGH. THE CAR RUNS GREAT BUT IS UNSAFE TO DRIVE. I HAD TO PURCHASE A NEWER, SAFER CAR FOR MY FAMILY BECAUSE DODGE REFUSES TO FIX THEIR PROBLEM THAT IS WELL DOCUMENTED. THE CAR RATTLES VERY LOUDLY WHILE DRIVING.

LET ME START BY SAYING THAT I LOVE DRIVING MY 2008 DODGE CALIBER AND WISH THAT IT WAS WORTH REPAIRING ALL OF THE ISSUES THAT I AM RESEARCHING ARE COMMON PROBLEMS AMONG FELLOW OWNERS OF THIS YEAR, MAKE AND MODEL OF VEHICLE. AS A PERSON WHO PAYS CLOSE ATTENTION TO MY VEHICLE, REPAIR COSTS HAVE BEEN ADDING UP OVER THE PAST COUPLE OF YEARS. STARTING WITH A COMPLETE REPAIR RELATED TO THE SUSPENSION INCLUDING THE CONTROL ARMS/ BUSHINGS, SWAY BAR, BALL JOINTS, AND TIE RODS, WHICH HAS CAUSED MY 4 NEW TIRES TO EXPERIENCE A SHORTENED LIFESPAN DUE TO UNEVEN WEARING. RECENTLY, I HAD MY CAR IN THE SHOP TO ADDRESS A LOUD NOISE I WAS HEARING WHILE THE VEHICLE WAS IN MOTION. THE MECHANIC DIAGNOSED A LONG LIST OF ISSUES, INCLUDING RUSTING/CORROSION TO THE ENGINE CRADLE AND FURTHER PROBLEMS WITH THE SUSPENSION THAT IN THEIR PROFESSIONAL OPINION DETERMINED THE VEHICLE UNSAFE TO OPERATE. AT THIS POINT, THE MECHANIC INFORMED ME THAT THERE HAD BEEN RECALLS AND AN EXTENDED WARRANTY IMPLEMENTED TO ADDRESS THE RUSTING/CORROSION OF THE SUB FRAME, AS I WAS UNAWARE AND DID NOT RECEIVE ANY NOTICES FOR ANY OF THE LISTED RECALLS. TODAY, I FIND MYSELF RESEARCHING THE LIST OF PROBLEMS THAT THE MECHANIC INDICATED WITH THE SUSPENSION AND ROTTING ENGINE CRADLE AND WILL UNFORTUNATELY NOT BE WORTH PUTTING THOUSANDS OF DOLLARS INTO TO MAKE IT SAFE, AN ISSUE THAT SHOULD BE HONOURED BY THE MANUFACTURER. I WOULD LIKE TO TAKE THE PROPER STEPS TO ADDRESS THIS EXTREME SAFETY CONCERN THAT HAS BEEN AN OBVIOUS ISSUE FOR MANY OWNERS LIKE MYSELF. I WONDER HOW MANY OTHERS DID NOT RECEIVE THE RECALL NOTICE FOR THE ROTTING ENGINE CRADLE AND HAVE SPENT THOUSANDS IN REPAIRS ON THAT AND/OR SUSPENSION MALFUNCTIONS? THESE PROBLEMS ARE NOT MINOR AND NEED TO BE ADDRESSED, AS I AM SURE THERE ARE MANY OWNERS WHO HAVE NOT BEEN MADE AWARE OF THE RECALL AND SAFETY CONCERNS THIS POSES TO OPERATORS OR OTHERS IN THE VEHICLE PRESENCE.

DASH WARNING LIGHTS ALL COME ON, INTERIOR LIGHT COMES ON WHEN USING RIGHT TURN SIGNAL, LOSES POWER ONLY UP TO 40MPH , SOMETIMES WON'T START, ODOMETER GAUGE FLAPPING AROUND, WHICH ARE CURRENT PROBLEMS,HAVE REPLACED SUSPENSION THREE TIMES, AND REPLACED COMPUTER! WILL NEVER PURCHASE A DODGE AGAIN!

ONE HEADLIGHT DOESN'T,WORK SUB FRAME COMPLETELY RUSTED, DOORS LOCK AT DIFFERENT SPEEDS SHOCK AND STRUTS ARE HORRIBLE SQUEAKS AND MAKES REALLY BAD SOUNDING NOISES AT ANY SPEED EVEN BACKING OUT