2002 Dodge Grand Caravan Complaint Log

REPORTED AIRBAG LIGHT TO DEALER. SET UP APPOINTMENT. BROUGHT VEHICLE IN, WAS INFORMED THAT THE BODY CONTROLER NOT COMMUNICATING WITH AIRBAG MODUAL. WIRING OK, NEEDS AIRBAG MODULE OR BCM. WAS THEN INFORMED THAT IT IS NOT UNDER WARRANTY DUE TO MILEAGE. THE MILEAGE AT THE TIME OF CALL INTO DEALER WAS AROUND 34,000. BECAUSE OF THEIR BUSY SCHEDULE IT TOOK OVER A MONTH TO GET THE VEHICLE INTO THEM. BY THE TIME I DROVE OVER TO THE APPOINTMENT A MONTH LATER THE VEHICLE WAS "OUT OF WARRRANTY". PARTS ON BACK ORDER.

2002 DODGE GRAND CARAVAN VEHICLE DOES NOT MOVE WHEN SHIFTED INTO REVERSE. INTERMITTENT PROBLEM. DEALER UNABLE TO DUPLICATE PROBLEM AND REFUSED TO REPLACE TRANSMISSION UNLESS PROBLEM COULD BE DUPLICATED. SAFETY HAZARD: DRIVER MAY INADVERTENTLY EXIT VEHICLE WITH GEAR SELECTOR IN REVERSE POSITION. VEHICLE MAY SUDDENLY MOVE AND CAUSE INJURY OR DEATH. EVENTUALLY, TRANSMISSION ENGAGES IN REVERSE, TAKING BETWEEN 15 SECONDS TO ONE MINUTE. CYCLING GEAR SELECTOR AND CHANGING ENGINE RPM SEEM TO HAVE NO INFLUENCE ON WHEN TRANSMISSION MAY ENGAGE IN REVERSE. *NLM

I OWN A 2002 DODGE GRAND CARAVAN WITH APPROXIMATELY 11,000 MILES. THE AIR BAG LIGHT HAS BEEN ILLUMINATING INTERMITTENTLY WHILE DRIVING. THE CAR IS CURRENTLY AT THE DEALER FOR SERVICE AND THEY INDICATED IT WOULD TAKE SEVERAL DAYS TO CHECK OUT THE WIRING. AS AN ELECTRONIC ENGINEER I FIND THIS TO BE BIZARRE. THE CAR HAS LOW MILEAGE AND THE IMPLICATION OF THE DAYS TO CHECK RESPONSE IS THAT THERE IS A FRAYED WIRE SOMEWHERE AS THE CONNECTOR HAS CHECKED OUT ALL RIGHT. IF THE CAUSE IS A CHAFED WIRE THEN THERE IS A SERIOUS DESIGN FLAW COMPROMISING THE AIRBAG SAFETY FEATURE. *AK

THE POWER STEERING IS MAKING A SPORADIC WHINING NOISE ONLY IN THE FIRST FEW MILES OF DRIVING WHEN THE VEHICLE IS COLD. TRYING TO WORK WITH LOCAL DEALER TO REPLACE THE PUMP, HOWEVER, SINCE IT DOESN'T HAPPEN ALL THE TIME THEY CAN'T "FIX IT IF THEY DON'T HEAR IT" I DIDN'T CONSIDER THIS A SAFETY CONCERN UNTIL RECENTLY. IT'S HAPPENING SO OFTEN NOW THAT I FEAR THE POWER STEERING WILL FAIL. *LA

ON 4/17/02 I PURCHASED A NEW 2002 DODGE GRAND CARAVAN. THE SALESMAN SOLD THE VEHICLE TO ME WITH THE AIRBAG LIGHT ON, INFORMING ME THAT IT WAS SUPPOSED TO BE THAT WAY. IMMEDIATELY AFTER READING MY OWNERS MANUAL, I DISCOVERED THAT IT WAS NOT SUPPOSED TO BE THAT WAY. I MADE ARRANGEMENTS TO HAVE THE VAN CHECKED OUT AND SINCE THEN I HAVE HAD NOTHING BUT TROUBLE WITH THE AIRBAG LIGHT/SEAT BELTS/AUTOMATIC DOORS, ETC. THIS VAN HAS BEEN IN THE SHOP EIGHT TIMES FOR THE ABOVE REASONS. ON 7/24/03 THE ABS LIGHT ALONG WITH THE HYDRAULIC BRAKE LIGHT CAME ON. I TOOK THE VEHICLE TO THE DEALERSHIP AND IT IS STILL THERE AS OF TODAY'S DATE - 8/23/03. I CONTACTED CHRYSLER DIRECTLY ON 8/22/03 AND INFORMED THEM OF THE HAZARDOUS HISTORY OF THIS VEHICLE - THE AIRBAG MODULE HAS BEEN REPLACED SEVERAL TIMES, THE SEATBELT TENSIONERS REPLACED SEVERAL TIMES, AUTOMATIC DOORS REPROGRAMMED, ETC. I INFORMED THE CUSTOMER SERVICE REPRESENTATIVE, ARLENE, THAT I WAS AFRAID OF THE VEHICLE AND DID NOT WANT IT BACK. I WAS INFORMED BY "ARLENE" THAT THE VEHICLE PARTS HAD BEEN DELIVERED TO THE DEALERSHIP AND THAT THE VAN WOULD BE FIXED. I DON'T WANT THE VAN "FIXED". IT DOESN'T STAY "FIXED"!! IT IS A SAFETY HAZARD AND I DO NOT WANT TO BASE MY CHILDREN'S SAFETY ON THEIR IDEA OF A SITUATION BEING "FIXED" WHEN THEIR TRACK RECORD OBVIOUSLY STINKS. AM I GOING TO HAVE TO WAIT UNTIL AN ACCIDENT AND EITHER MYSELF OR, LORD FORBID, ONE OF MY CHILDREN ARE SENT AIRBORNE THROUGH THE WINDSHIELD? I WAS INFORMED BY "ARLENE" THAT SINCE THE VAN WAS NOT IN THE SHOP FOR THE "EXACT DEFECT" EVERY SINGLE TIME, THAT I WAS NOT ELIGIBLE FOR A NEW VAN. I WOULD THINK THAT THE FACT THAT THE AIRBAG SYSTEM HAS SHOWN IT HAS CONSISTENT PROBLEMS, THE SEATBELTS OBVIOUSLY HAVE CONSISTENT PROBLEMS AND NOW THE AIRBAG SYSTEM AND HYDRAULIC BRAKE SYSTEM LIGHTS ARE ON - ISN'T THAT ENOUGH???? OR DO I HAVE TO DIE IN AN ACCIDENT FOR MY FAMILY TO GET A SAFE VEHICLE?. *AK

IN 2002 I PURCHASED A NEW DODGE GRAND CARAVAN SPORT. THE VEHICLE HAS BEEN IN MY POSSESSION JUST UNDER A YEAR AND HAS APPROX. 20,800 MILES ON IT.THIS VEHICLE HAS ALREADY HAD 2 MAJOR REPAIRS TO SYSTEMS THAT AFFECT THE SAFETY OF THE VEHICLE. *AK 1. POWER STEERING HOSE RECALL 2. TRANSMISSION PUMP FAILURE. IN ADDITION TO THESE REPAIRS THERE WAS ALSO AN EXTENDED WARRANTY PLACED ON THE A/C UNIT BECAUSE IT IS EXPECTED TO FAIL, REPLACEMENT OF THE STEREO AND REPEATED REPAIRS TO THE FRONT CARPET PULLING OUT AT THE CORNERS. THE CARPET HAS BEEN "FIXED" HOWEVER NOW THE EMERGENCY BRAKE ASSEMBLY IS PROTRUDING ON THE DRIVER FLOORBOARD.

WHILE DRIVING AND BRAKES ARE DEPRESED THEY MAKE A LOUD NOISE ,LOCK UP AND HESTIATE TO STOP. DEALESHIP CONTACTED.*AK

I HAVE A 2002 DODGE GRAND CARAVAN WITH UNSAFE SEAT BELTS IN THE REAR. I WANT DAIMLER-CHRYSLER TO REPLACE THEM AT THEIR EXPENSE ASAP!*AK

2003 DODGE GRAND CARAVAN ES WITH MICHELIN MX4 P215/60R17 96S TIRES (DOT B9KX DVMX 1102). TWO TIRE HAVE HAD DAMAGED SIDEWALLS. ONE TIRE ON THE PASSENGER REAR RESULTED IN A SLOW LEAK. THE OTHER, ON THE PASSENGER FRONT, HAS A BULGE AFTER CONTACT WITH THE CURB. THE SENCOND TIRE WAS FINE FOR ONLY MINUTES EARLIER DURING AN OIL CHANGE AND RECALL WORK AT THE DEALERSHIP. NO ABNORMAL CONTACT WITH A ROAD HAZARD OCCURRED DURING THE TWO MILE DRIVE FROM THE DEALER TO HOME. *AK

THE TURN SIGNALS WILL INTERMITTENTLY WORK IN REVERSE. FOR EXAMPLE, IF I ENGAGE THE LEFT TURN SIGNAL, THE RIGHT DASH LIGHT WILL FLASH ALONG WITH THE RIGHT TURN SIGNAL LIGHTS. THIS REVERSE PROCESS ALSO HAPPENS SOMETIMES WHEN I ENGAGE THE RIGHT TURN SIGNAL. *NLM

MY VAN WAS BOUGHT NEW AND IS JUST ABOUT 1 YEAR OLD. I HAVE BEEN HAVING MANY PROBLEMS WITH THIS VEHICLE. THE VEHICLE WOULD GO 30 MPH BY ITSELF ALTHOUGH I WAS PRESSING THE BRAKE. THIS EVEN HAPPENED WHILE I WAS DRIVING ON AN ICY ROAD. THE DEALER SAID THAT THIS IS NORMAL. ALL THE VEHICLE'S LOCKS WOULD LOCK AND UNLOCK BY THEMSELVES, SOMETIMES LOCKING MY KEYS IN IT BEFORE I CAN GET THEM OUT. THREE MONTHS AFTER THE VEHICLE WAS PURCHASED IT WAS RETURNED TO THE DEALER BECAUSE THE HEATER AND AIR DID NOT WORK PROPERLY. A FIRE BURNED THE DRIVER'S DOOR, SEAT, FLOOR RUGS AND WINDOW. THE FIREMAN SAID IT WAS AN ELECTRICAL FIRE, WHICH STARTED IN THE DRIVER'S DOOR BY THE WIRES. THE FIRE HAPPENED ON THE WEEKEND THEREFORE THE DEALER IS NOT AWARE OF THE FIRE YET. I PLAN TO GO TO THE DEALER ON MONDAY TO SEE WHAT CAN BE DONE. THE VEHICLE CANNOT BE DRIVEN AND THE SMELL INSIDE THE VEHICLE IS OVERWHELMING. EVERYTHING ON DRIVERS SIDE IS BURNED. I WILL ASK FOR A NEW REPLACEMENT VEHICLE. *NM

VEHICLE EXPERIENCED ABS FAILURE CAUSED BY THE ROTORS DELAMINATING. *AK

AIRBAG SENSOR LIGHT CONTINUES TO STAY ON. DEALER NOTIFIED. *AK

ON 6/11/03 VEHICLE WAS MAKING POWER STEERING NOISES & AUTO DR LOCKS WOULDN'T LOCK AT 15 MPH. REPLACED POWER HOSE, HOSE CLAMP & OIL TRANS. INFORMED I NEEDED NEW BRAKES (22, 153 MILES & DIDN'T REQ THAT THEY DO THIS WHEN I ARRIVED AT SHOP). 7/2/03 TOOK VAN IN 'CAUSE LEFT REAR (DRIVER SIDE) SPEAKER CAUGHT ON FIRE WHILE AT A GAS PUMP. WHILE AT GAS PUMP W/2 OF OUR 4 KIDS IN THE CAR. BRAKES THAT WERE JUST REPLACED PREV MONTH WERE SQUEAKING AS WELL AS THE STEERING AGAIN. (DEALER-BRAKES SQUEAK 'CAUSE THEY ARE METAL & THERE IS AIR IN THE STEERING LINE). 9/23/03 VAN BATTERY BLEW UP WHEN STARTED. REPLACED BATTERY. 12/3/03 STEERING MAKING NOISE DURING TURNS. REPLACED BOTH SWAY BARS LINKS. 12/29/03 STEERING IS VERY TIGHT & SHUDDERING AGAIN & AUTO LOCK BUTTON ON KEY CHAIN WON'T WORK. ORDERED NEW POWER STEERING RACK & RESEVOIR. THEN ON 1/6/04 TACH SPIKED AT 4K, VEHICLE LOST POWER & ENGINE LIGHT CAME ON WHILE ON EXPRESSWAY W/MY BABY IN THE CAR. DETERMINATION WAS THE TRANSMISSION SOLENOID ASSY FAILURE & REPLACED THE SAME. THIS COST ME $107 (WOULD HAVE COST MORE IF I WASN'T GIVEN AN EXTENDED WARRANTY FOR FIRE I HAD). 1/19/04 VAN WAS GIVING A BURN SMELL FROM UNDER THE HOOD ALONG WITH SMOKE. THEY FOUND A/C COMPRESSOR CLUTCH SHORTING IN COIL. A/C COMPRESSOR REPLACED & RECHARGED. 2/5/04 VEHICLE TAKEN FOR THE LAST TIME FOR LOUD POPPING SOUND UNDER THE DR'S FT AREA WHEN TURNING LEFT. ALL SUSPENSION PARTS TIGHTENED. NEXT VISIT IS REQ'D BY THE FL LEMON LAW TO GIVE THEM 1 MORE CHANCE BEFORE PAPERWORK CAN BE FILED. DONE ON 3/8/04 FOR STEERING NOISE WHEN STOPPED & JUST TURNING WHEEL. REPLACED PT THAT WAS REPLACED BEFORE: POWER STEERING PUMP RESEVOIR. PAPERWORK FILED FOR FLORIDA LEMON LAW ON 4/5/04,UNSAVE VEHICLE & FEAR FOR SAFETY OF FAMILY. *JB

MY SEVEN YEAR OLD DAUGHTER WAS EXITING OUR 2002 DODGE GRAND CARAVAN WHEN HER FOOT SLIPPED THROUGH THE SAFETY BELT STRAP. THE STRAP WAS LOCATED NEXT TO THE SLIDING DOOR OF THE PASSENGER SIDE OF THE CAR. THE STRAP WAS IN IT'S STORAGE POSITION, BUT WAS CLEARLY STILL IN THE WAY OF HER STEPPING PAST THE MIDDLE PASSENGER SEAT AS SHE EXITED FROM THE REAR SEAT OF THE VEHICLE. SINCE THE STRAP "LOOPED" AROUND HER FOOT, SHE THEN TRIPPED AND TUMBLED OUT OF THE SLIDING DOOR SIDE OF THE VEHICLE. I WITNESSED EVERYTHING--ANY TALLER: SHE WOULD HAVE STRUCK HER HEAD ON THE DOOR OF THE CAR. SHE ACTUALLY FELL OUT THE SLIDING DOOR AREA AND SCRAPED HER ARMS PRETTY GOOD. I WAS SURE SHE MUST HAVE BROKE BOTH ARMS THE WAY THAT SHE FELL. BUT, WE WERE LUCKY THIS TIME. THERE MUST BE A BETTER WAY TO MOUNT THOSE SAFETY STRAPS TO AVOID THIS TYPE OF THING. WHEN THE PASSENGER IN THE MIDDLE SEAT IS STRAPPED IN, IT IS EVEN WORSE AS EACH PASSENGER PASSING TO THE REAR SEATS MUST WALK OVER OR UNDER THE STRAPS AS WELL. IN THIS CASE, HOWEVER, SHE WAS THE ONLY PASSENGER AND THE "RESTING" STRAP STILL CAUGHT HER LEG AS SHE EXITED THE VEHICLE. CLEARLY NOT SAFE IN MY OPINION. JUST THOUGHT I'D PASS THIS ALONG. *JB

THE REAR SEATBELTS ON THE REAR BENCH OF OUR 2002 DODGE GRAND CARAVAN DO NOT STAY LATCHED ON OUR CARSEATS. IN JUNE OF 2003 I NOTIFIED DODGE AND THEY STATED THEY HAD NOT RECEIVED ANY COMPLAINTS REGARDING THIS ISSUE. THEY NOW HAVE MY COMPLAINT - REFERRAL #11380233. THE REAR BENCH IS ALSO NOT LATCH EQUIPPED BUT DOES HAVE ONE REAR TOP TETHER ANCHOR PLACED IN THE MIDDLE. I HAVE 3 (SOON TO BE 4) CHILDREN IN CARSEATS. I WAS UNDER THE IMPRESSION THAT ALL SEATS WERE TO BE LATCH COMPATIBLE IN ALL POSITIONS. AS FOR THE SEATBELT ISSUE, THE DEALER CLAIMED IGNORANCE TO THE INTERNET SO I HAVE PRINTED OFF THE STORIES ON UNSAFEBELTS.COM TO TAKE TO THEM TODAY WHEN I GO TO PICK IT UP. THEY CLAIM THEY HAVE NOT BEEN ABLE TO TRIGGER THE RESPONSE - BUT THEN THEY DIDN'T TRY TO BUCKLE IN ONE OF MY MANY CARSEATS EITHER SO THEY WILL BE DOING THAT TODAY.*AK

WE'VE EXPERIENCED PROBLEMS WITH THE MIDDLE ROW INTEGRATED CHILD SAFETY SEATS. SEVERAL TIMES, THE TENSIONER ON THE SEAT WOULD NOT WORK, AND I HAD TO POP THE END OF THE SEAT BACK COVER OFF TO ACCESS THE MECHANISM TO FREE WHAT THE BELT WAS CAUGHT ON. I DIDN'T COMPLETELY REMOVE THE COVER SO I COULD SEE EXACTLY WHAT WAS HAPPENING. ALSO, SOMETIMES THE BUCKLE WILL NOT SECURE THE BELT PLATE. IT WILL SECURE AFTER SEVERAL ATTEMPTS, AND WE'VE RECENTLY NOTICED THAT IT WORKS BETTER IF WE LATCH A PARTICULAR SIDE FIRST, THEN THE OTHER SIDE (5 POINT HARNESS). I DON'T KNOW IF THE MECHANISM STICKS OR IF FOOD OR SOMETHING GOT FORCED INSIDE. THESE HAVE BOTH BEEN RECURRING PROBLEMS SINCE WE PURCHASED THE VEHICLE.*JB

I RECENTLY PURCHASED A 2002 DODGE GRAND CARAVAN SPORT 3.3 LITER,18,000 MILES ON ODOMETER WHEN PURCHASED,VEHICLE WANTS TO PULL TO RIGHT, AND BRAKES PULSATE WHEN APPLIED. NOTIFIED DODGE DEALERSHIP WHERE PURCHASED, (LEE DODGE,WEST BROOK,MAINE) BROUGHT VEHICLE BACK FOR SERVICE AND WAS TOLD "THEY" COULD NOT DUPLICATE PROBLEM????? I TOLD THEM I FELT VEHICLE WAS OUT OF ALIGNMENT,THEY SUPPOSEDLY DID THE ALIGNMENT,AND VEHICLE STILL PULLS TO RIGHT! AT THIS POINT THEY HAD A TECH. GO WITH ME,THE TECH EXPLAINED THAT HE FELT IT WAS THE CROWN OF THE ROAD, I HAVE DRIVEN PLENTY OF VEHICLES OVER THE COURSE OF MY LIFE AND I AM AWARE OF A ROAD CROWN, BUT THIS IS COMPLETELY UNACCEPTABLE, SOMETHING IS WRONG WITH THIS MINI VAN, AND ALL THE DEALERSHIP WANTS TO DO IS PATRONIZE ME!!! I HAVE MADE ANOTHER CALL TO LEE DODGE AND TOLD THEM THAT I WILL BE BRINGING THIS BACK TO THEM AND THEY HAD BETTER GET IT RIGHT THIS TIME! PS AND SINCE MY PREVIOUS VISIT I NOW HAVE A VIBRATION IN MY STEERING WHEEL UPON SLOW MOVING TURNING,THEY SAY THEY WILL ALSO LOOK INTO THIS.....................IS ANY ONE ELSE EXPERIENCING THESE TYPES OF PROBLEMS??? PLEASE HELP, I JUST BOUGHT THIS VEHICLE FOR MY WIFE AND 3 KIDS, AND I SURE DO WANT TO BE CERTAIN ITS A SAFE VEHICLE! I HAVE ONLY HAD THIS VEHICLE 10 DAYS!! PURCHASED ON 5-28-03 DEALER WAS NOTIFIED 1 AND A HALF DAYS LATER OF THESE PROBLEMS..............*JB

THE VEHICLES SLIDING DOORS DID NOT WORK PROPERLY. THE DEALER HAS INSPECTED IT THREE TIMES BUT COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *NLM

POWER STEERING FLUID LEAKING ON GARAGE FLOOR. DEALER SAID IT WAS THE POWER STEERING RACK AND THAT IT NEEDED TO BE REPLACED. CHYRSLER AGREED TO PAY FOR HALF OF THE REPAIR. 18 MONTHS LATER THE SYSTEM IS LOSING POWER STEERING FLUID. THE DEALER IS AGAIN SAYING THAT IT IS THE POWER STEERING RACK AND THAT IT NEEDS REPLACED YET AGAIN. CHRYSLER WILL NOT ASSIST IN ANY WAY ON THE $1,100.00 REPAIR. *JB

THE AIR BAG ON THE PASSENGER SIDE WAS INOPERATIVE. THE AIR BAG HAD TO BE REPLACED. *NLM *CB *NLM

I PURCHASED A NEW 2002 DODGE GRAND CARAVAN ON 4/17/02. SINCE THEN, THIS VEHICLE HAS BEEN IN THE SHOP FOR MULTIPLE PROBLEMS WITH THE AIRBAG LIGHT/SEATBELT TENSIONERS AND MALFUNCTIONING AUTOMATIC DOORS. THIS TIME THE VAN WAS IN THE DEALERSHIP FOR THE AIRBAG LIGHT AGAIN. PER THE DEALERSHIP THE AIRBAG MODULE WAS REPLACED AGAIN AND TENSIONER OVERLAY HARNESS COMPLETED AS PER STAR. THE REAR AUTOMATIC DOOR WOULDN'T OPEN AGAIN, HAD ALREADY BEEN REPROGRAMMED AND THIS TIME THE LIFTGATE LATCH WAS REPLACED. THIS VEHICLE IS A SAFETY HAZARD!!!!*AK

I HAVE A 2002 GRAND CARAVAN WITH DUAL SLIDING DOORS. SOMETIMES, THE DOORS DO NOT DETECT AN OBSTRUCTION AND ATTEMPT TO CLOSE ANYWAY. YESTERDAY, MY 3 YEAR OLD DAUGHTER RECEIVED MINOR BRUISING TO HER WAIST AFTER CLIMBING OUT OF THE VAN WHILE THE DOOR WAS IN MOTION. THE DOOR DID NOT RETRACT UNTIL I FORCIBLY PUSHED THE DOOR AFTER SEEING HER IN DISTRESS. IT DID NOT RETRACT AFTER SENSING HER TORSO IN THE PATH. SHE WAS OK BUT RECEIVED A BRUISE ON EACH SIDE OF HER WAIST (DOOR AND VAN BODY CONTACT). I HAD TO USE UNNECESSARY FORCE TO FORCE THE DOOR OPEN AND DOING SO DISENGAGED THE AUTOMATIC CLOSING MECHANISM WHICH REQUIRED A MANUAL CLOSING AFTERWARDS. THIS HAS HAPPENED NUMEROUS TIMES BUT HAS NEVER RESULTED IN AN INJURY UNTIL NOW. THE DEALER SAYS THAT A CERTAIN AMOUNT OF RESISTANCE IS REQUIRED FOR THE AUTOREVERSAL TO ACTIVATE. EVIDENTLY IT REQUIRES MORE FORCE THAN MY CHILD'S BODY. THIS IS UNACCEPTABLE. *NLM

POWER STEERING SYSTEM IS MAKING EXTREME AMOUNTS OF NOISE. THERE IS A HIGH PROBABILITY OF PREMATURE FAILURE CAUSING LOSS OF VEHICLE CONTROL IF IT HAPPENS DURING A CORNERING MANEUVER. DEALER(S) ACKNOWLEDGE THIS IS A DEFECT ON THIS MODEL AND GET MANY COMPLAINTS FROM CUSTOMERS. MANUFACTURER HAS BEEN CONTACTED AND REFUSES TO REPAIR THE DEFECTIVE COMPONENTS.*AK

ON 4/17/02 I PURCHASED A NEW 2002 DODGE GRAND CARAVAN. THIS VEHICLE HAD BEEN IN THE SHOP SEVERAL TIMES SINCE THE TIME OF PURCHASE. THIS TIME IT WAS THE AIRBAG LIGHT AGAIN. ACCORDING TO THE DEALERSHIP, AIRBAG DIAGNOSTIC TESTS WERE PERFORMED AND THE LEFT FRONT SEATBELT TENSIONER CIRCUIT WAS REPROGRAMMED. I INFORMED THE MECHANIC THAT THE SECOND ROW SEATBELTS WOULD NOT "LOCK" WHEN YOU JERKED ON THEM, BUT ACCORDING TO THE MECHANIC THEY WERE "OPERATING NORMALLY AT THIS TIME". I ALSO HAD TO HAVE THEM LOOK AT THE REAR LIFTGATE AGAIN. PER THE DEALERSHIP, THE CODES WERE REPROGRAMMED AGAIN. *AK

THE VEHICLE'S AIRBAG SENSOR LIGHT CAME ON INTERMITTENTLY. DEALER NOTIFIED. *NLM

POWER STEERING FAILED. HEARD A WHINING SOUND WHILE AT A STOP LIGHT, A SHORT TIME LATER I WAS ALMOST UNABLE TO MAKE A TURN INTO A PARK, BECAUSE THE POWER STEERING WAS GONE. *JB

I PURCHASED A NEW 2002 DODGE GRAND CARAVAN ON 4/17/02. ON 2/21/03 THE VAN WAS IN THE DEALERSHIP WITH THE AIRBAG LIGHT ON AGAIN! THIS WAS THE THIRD TIME SINCE I PURCHASED THE VEHICLE THAT THE AIRBAG LIGHT HAD COME ON. THIS TIME THE DEALER SAID THE LEFT FRONT SEATBELT TENSIONER SHORTED AND HAD TO BE REPLACED.*AK

THREE TIRE FAILURES WITHIN 12 MONTHS DUE TO "ROAD HAZARDS". THE TIRES ARE MICHELIN 215/60R17. ONE WAS A SLOW LEAK THE DISCOUNT TIRE REP SAID WAS DUE TO ROAD DAMAGE, THE SECOND WAS A HOLE IN THE SIDE WALL AFTER HITTING A CURB WHILE PARKING, AND THE THIRD WAS A SIDEWALL BUBBLE DISCOVERED WHEN THE SECOND TIRE WAS REPLACED DURING A COURTESY TIRE ROTATION. *NLM

NAR 05/21/2003 *MR MICHELIN MX4 P215/60R17 TIRES. 3 TIRE FAILURES WITHIN 12 MONTHS DUE TO ROAD HAZARDS. *CB

POWER STEERING, DEFECTIVE HOSE. HAVE HAD TWO POWER STEERING HOSES REPLACED WITHIN 3 WEEKS. DEALER HAS REPLACED WITH EXACT SAME HOSE, SAYS THAT IS WHAT CHRYSLER TELLS THEM TO REPLACE IT WITH. DEALER ADMITS THERE IS ABOUT 30 HOSES REPLACED EACH WEEK IN COLD WEATHER. ALSO STATED THAT ALL THAT MAY BE NEEDED IS A STRONGER/BETTER HOSE. NO RECALL HAS BEEN MADE. I HAVE THREE YOUNG CHILDREN THAT I TRANSPORT DAILY. AND I AM CONCERNED FOR THEIR WELFARE. I ALSO TRAVEL OVER 60 MILES TO WORK EACH DAY ON THE INTERSTATE. IF THE POWER STEERING GOES WHILE I AM ON THE INTERSTATE IT COULD CAUSE A HORRIFIC ACCIDENT EVEN RESULTING IN DEATH. IT SHOULDN'T TAKE THAT TYPE OF SITUATION BEFORE A RECALL IS MADE. IF THE HOSE GOES AGAIN, I WILL BE GOING THROUGH LEMON LAW PROCEEDINGS.*JB

BRAKES WOREOUT AROUND 23,000 OR 21,000 I PURCHASED THE VEHICLE USED IT HAD 15,000 MILES ALREADY ON IT. THE BRAKES WERE WEARING OUT FASTER AND FASTER EVEN THOUGH I PUT NEW ROUTERS ON THEM. MY MECHANIC SAYS THE CALIPERS ARE DEFECTIVE. I THINK THE DISTRIBUTION OF THE BRAKES IS NOT EVENLY HANDLE BY THE FRONT AND THE BACK. THE FRONT HANDLES TO MUCH OF THFE WORK AND THERE IS TOO MUCH WEIGHT IN THE FRONT OF THE VEHICLE. *AK

ON FEB 16 MY WIFE LOST THE POWER STEARING ON OUR 2002 DODGE GRAND CARRIVAN [MINNI-VAN] ON 17 FEB 03 I CALLED THE GARAGE THAT SOLD US THE VAN AND DISCRIBED THE PROBLEM. THEY { SERVICE MANG.] TOLD ME ON THE PHONE THAT I PROBLEY HAD A BROKEN POWER STEARING HOSE. I HAD THE VAN TOWED TO THE GARAGE AND THEY MADE MORE STATEMENTS OF A LARGE NUMBER OF THESE HOSES BRAKEING IN THE COLD WEATHER. IT HAS BEEN EXTREAMLY COLD IN MAINE THE PAST WEEK OR SO -20 TO -30 DEGREES. THE SERVICE MANAGER STATED THAT THERE WAS NO RECALL ON THIS. I CAN NOT BELIVE THAT CHREYSLER HAS NOT PUT OUT A RECALL ON THIS. NUMBER ONE THIS IS A SUDDEN LOSS OF POWER STEARING WITCH COULD PUT ME IN DANGER OF HAVEING A ACCIDENT. HOW ABOUT THE 97 POUND WEEKLN WHO COULD NOT CONTROL A MINI VAN WITH ON PWOERSTEARING!! THERE IS ALSO A DANGER OF FIRE IF THE POWER STEARING FLUID IS IN CONTACT WITH THE EXHAUST. AS FAR AS I KNOW THE REPALCEMENT HOSE IS OF THE SAME MATAREAL AS THE OLD HOSE AND IS JUST A LITTLE LONGER. WILL SOME ONE FROM YOUR OFFICE BE IN CONTACT WITH ME ? I WOULS LIKE TO KNOW WHAT THE GREAT WHITE FARTHER IN WASHINGTON IS DOING TO PROTECT ME FROM THE MONEY HUNGRY CORPS. THAT PRAY ON MY TRUST. THANK YOU

TL*THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. WHILE DRIVING BETWEEN 10-20 MPH, THE BRAKES SQUEALED AND MADE A GRINDING NOISE WHEN APPLIED. HOWEVER, THE VEHICLE STILL STOPPED NORMALLY. A POLICE REPORT WAS FILED. THE FRONT BRAKES WERE REPLACED, THE FRONT ROTORS WERE CUT, AND THE REAR DRUMS WERE CUT AND ADJUSTED AT 9,000, 22,000, 33,000, 45,000, AND 61,000 MILES. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE BRAKES HAVING A LOT OF WEIGHT ON THE FRONT END. THE FAILURE MILEAGE WAS 9,000 AND CURRENT MILEAGE WAS 67,000. THE DEALER STATED POWER STEERING NOISE, VEHICLE REVVING ON HILLS. UPDATED 11/14/07 *TR

AIR BAG CLOCKSPRING HAS BEEN REPLACED 6 TIMES. *MR THERE WAS A LEAK INSIDE THE VEHICLE ON THE PASSENGER'S SIDE, A BROKEN CHAIN ON THE DRIVER'S SLIDER DOOR, A HESITATION UPON ACCELERATION AND A STALLING PROBLEM (POSSIBLE FUEL FILTER PROBLEM), AND A GRINDING NOISE DUE TO THE IDLER PULLEY BEING FAULTY. THE CONSUMER REQUEST COMPENSATION. *SC *JB

I HAVE HAD NUMEROUS PROBLEMS WITH THE VEH SINCE IT WAS PURCHASED NEW , MAY 2002. VEH HAS A ROUGH IDLE WHILE STOPPED IN GEAR, DEALER STATES THEY ARE WAITING FOR A COMPUTER UPDATE. TO DATE STILL HAVE PROBLEM. PROBLEM WITH STARTER , SAME GRINDS ON FIRST START IN EXTREME COLD WEATHER. DEALER REPLACED 2 STARTERS AND FLYWHEEL. PROBLEM WITH TRANS, HARD BANG FELT WHEN SLOWING UP BETWEEN 8-5 MPH. SAID PROBLEM IS INTERMITTENT AND DEALER HAS NOT DRIVEN VEH LONG ENOUGH TO GET CONDITION. DEALER HAS REPLACED NUMEROUS PARTS OF TRANS, PROBLEM STILL EXIST. CAR HAS BEEN IN SEVERAL TIMES FOR POWER STEERING LEAK AND VIBRATION. NUMEROUS PARTS REPLACED. I HAVE CONTACTED CHRYSLER AND SPOKE WITH THE DISTRICT MANAGER AND ADVISED HIM OF ALL THE COMPLAINTS WITH VEH AND PROBLEMS THAT STILL EXIST. I TOLD HIM I DID NOT WANT THE VEH . HE ADVISED ME HE WOULD LOOK INTO MY FILE AND CALL ME BACK.ITS BEEN TWO MONTHS AND I HAVE LEFT HIM SEVERAL MESSAGES AND HE STILL HAS NOT RETURNED MY CALLS. HIS NAME IS [XXX]. CHRYSLER HAS LEFT ME NO CHOICE BUT TO FILE THE LEMON LAW. AS OF TODAY I AM WAITING FOR A HEARING DATE TOO BE SET. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

CONSUMER STATES THAT ALL 5 REAR SEAT BELT ASSEMBLIES UNLATCH EASILY. THE DRIVER AND PASSENGER SEAT BELTS ARE UNAFFECTED. THE CONSUMER PERFORMED THAT STEEL BALL TEST SEEN ON TELEVISION. BALL WAS ROLLED OVER BUCKLE RELEASE BUTTONS AND THEY CAME UNDONE EASILY. TS

I PURCHASED A NEW DODGE GRAND CARAVAN ON 4/17/02. ON 11/20/02 (FOR THE SECOND TIME SINCE PURCHASE - FIRST TIME WAS 5/08/02), I HAD TO TAKE THE VAN TO THE DEALERSHIP BECAUSE THE AUTOMATIC TAILGATE AND SLIDING DOORS WERE MALFUNCTIONING. ACCORDING TO THE DEALERSHIP, IT WAS REPROGRAMMED PLM AS PER BULL.*AK

THE PROBLEM I AM HAVING IS THAT THE GAS MILEAGE IS WAY OFF. I AM ONLY 12 MILES TO A GALLON AND SHOULD GET ALEAST 18. I HAVE HAD IN FOR REPAIRS NUMEROUS TIMES AND ON SOME OCCASSIONS THEY WILL REPLACE A SENSOR OR A HOSE.WITHIN A COUPLE OF WEEKS IT IS BACK TO THE SAME OLD PROBLEM AGAIN. SOMETIMES THEY SAY THEY CAN FIND NO PROBLEM. WHAT DO I DO?

DRIVING HOME AT NIGHT WHEN THE HEADLIGHTS FLICKERED ON AND OFF. TURNED ON THE HIGH BEAMS IN ORDER TO GET HOME. DEALER REPLACED THE FRONT CONTROL MODULE. *NM

CONSUMER STATES THAT VEHICLE'S GAS GAUGE READS INCORRECTLY WHICH CAUSES VEHICLE TO RUN OUT OF GAS WHILE DRIVING. DEALER CONTACTED. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

WHILE DRIVING THE VEHICLE'S AIR BAG LIGHT ILLUMINATED INDICATING THERE WAS A PROBLEM WITH THE AIR BAG. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE AIR BAGS MAY NOT DEPLOY IN AN ACCIDENT. *TS

WHERE TO START, SINCE THE DAU WE BOUGHT IT IN 7/02, WE HAVE BROUGHT IT IN 3 TIMES FOR FAULTY WINDSHIELD WIPER PROBLEMS, WE LOST POWERING STEERING (THANK GOD MY WIFE WAS NOT DRIVING IT WITH OUR TWO SMALL KIDS), THE REAR HATCH DIDN'T WORK AND IT TOOK 3 MONTHS FOR US TO FINALLY GET IT FIXED, WE HAVE TO REPLACE THE BRAKE PADS AT 14,000 MILES, AND JUST RECENTLY THE ALTERNATOR HAD TO BE REPLACED. NOW THERE IS A PROBLEM WITH THE BRAKES THEY MAKE A HORRIBLE SOUND WHEN PRESSING ON THEM AND IS GOING INTO THE DEALER AGAIN NEXT WEEK. MY WIPER REFUSES TO DRIVE THE CARAVAN THAT WE BOUGHT SO IT WOULD BE EASIER FOR HER WITH THE KIDS, BUT SHE FEELS THAT SOMETHING ELSE IS GONNA GO WRONG. WE WROTE A LETTER TO CHRYSLER AND THEY RESPONDED "WE'RE SORRY FOR THE INCONVENIENCE". (THE DATE OF THE FIRST INCIDENT LISTED BELOW MAY NOT BE EXACTLY WHEN IT HAPPENED, THE PAPERWORK IS AT HOME.) *LA

THE VEHICLE HAS BEEN DROPPING OUT OF GEAR FROM DRIVE TO NEUTRAL INTERMITTANTLY SINCE I BOUGHT IT. THIS HAPPENS DURING DRIVING AND TURNING, BUT IT IS INTERMITTANT SO CHRYSLER AND DODGE SERVICE HAVE NOT BEEN ABLE TO DUPLICATE, THEREFORE WILL NOT FIX THE PROBLEM. THE FIRST TIMES I CALLED MY OWN DEALERSHIP IN DAPHNE, I WAS TOLD THEY DON'T HAVE A TRANSMISSION PERSON & TO TAKE IT TO MOBILE OR PENSACOLA TO BE REPAIRED. I TOOK IT TO MOBILE FINALLY IN JAN. '03, BUT THEY COULD NOT DUPLICATE PROBLEM. THEY KEPT THE VEHICLE FOR 2 WEEKS & LEFT ME WITH NOTHING TO DRIVE. THEY WOULD NOT EVEN GIVE ME A LOANER. NEXT I APPROACHED MY OWN DEALERSHIP IN DAPHNE AGAIN & REQUESTED A MEETING WITH THE DISTRICT MANAGER. THEY INSISTED ON CHECKING IT THEMSELVES BEFORE THEY WOULD TALK TO THE DISTRICT MANAGER, EVEN THOUGH THEY DIDN'T HAVE A TRANSMISSION PERSON. THEY CHECKED IT AND FOUND NOTHING AGAIN, AND FAXED THE INFORMATION TO STAR CENTER. I STILL HAVE NOT HAD THE PROBLEM FIXED NOR HEARD A WORD FROM THE DISTRICT MANAGER. ALL THE SERVICE MANAGER DOES IT ARGUE AND SMILE WITH MY COMPLAINTS. BOTH SERVICE MANAGERS FROM MOBIEL AND DAPHNE STATE THAT CHRYSLER WILL NOT REPLACE AND CANNOT REPAIR THE TRANSMISSION.

THE AIR BAGS INADVERTENTLY DEPLOYED WHILE DRIVING CAUSING MINOR INJURY TO THE DRIVER AND PASSENGER. THE DEALER HAS REPAIRED THE VEHICLE. PLEASE PROVIDE ADDITIONAL INFORMATION.*JB

WHILE DRIVING CONSUMER DODGE GRAND CARAVAN WILL GO INTO NEUTRAL. *TS THE CONSUMER STATED ON ONE OCCASION, THE VEHICLE WAS IN DRIVE, BUT IT WOULD NOT MOVE. THE CONSUMER HAD TO MOVE THE LEVER A FEW TIMES IN ORDER FOR THE VEHICLE TO MOVE. THE CONSUMER WAS TOLD THE PROBLEM SHE WAS EXPERIENCING COULD NOT BE DUPLICATED IN THE 2 WEEKS THE MECHANIC HAD THE VEHICLE. THE STEERING WHEEL PULLED TO ONE SIDE AND VIBRATED WHEN SLOWING DOWN. THE ROTORS NEEDED TO BE RESURFACED. THE EMISSION HOSE AND GAS CAP WERE REPLACED. THE PASSENGER SIDE DOOR HAS TO BE OPENED AND CLOSED SEVERAL TIMES BEFORE STAYING SHUT. THE OIL PAN GASKET AND AXLE SEAL WERE LEAKING. *JB

FIRST INCIDENT WAS THE AIRBAG LIGHT CAME ON INTERMITTENTLY. THE DEALER REPAIRED IT LAST WEEK. TODAY, THE ENTIRE INSTRUMENT PANEL FUNCTIONED INTERMITTENTLY. DEALER WAS CALLED AND ANOTHER REPAIR DATE WAS SET.*AK

ON JULY 4, 2002 MY 2002 DODGE GRAND CARAVAN WAS INVOLVED IN A LOW SPEED ROLLOVER IN WHICH THE VEHICLE CAME TO REST UPSIDE DOWN. IN THE MINUTES FOLLOWING THE ROLLOVER THE VEHICLE CAUGHT ON FIRE AND BURNED COMPLETELY UP. MY WIFE AND 3 CHILDREN WERE TRAVELING IN THE VEHICLE WHEN THIS HAPPENED AND ALL 3 BY THE GRACE OF GOD WERE PULLED TO SAFETY BY PERSONS NEAR THE ACCIDENT. TWO MONTHS LATER I RECEIVED A RECALL ON THE VAN FROM THE DEALER INDICATING THERE WAS A RECALL ON THE FUEL SYSTEM TO REPLACE A PART THAT MAY CAUSE A FIRE IN THE EVENT OF A ROLLOVER. *NM

THE AIR BAG LIGHT WENT ON/OFF INTERMITTENTLY. THE VAN HAD 40K HIGHWAY MILES; THIS IS JUST A FEW K MILES SHY OF THE WARRANTY. AFTER CHECKING THIS WEBSITE I SEE THIS IS AN ON-GOING PROBLEM. WHAT DOES IT TAKE TO GET A RECALL HERE? REMEMBER THESE VANS ARE USED TO TRANSPORT CHILDREN AND AN EARLY OR LATE FAILURE OF THESE AIR BAGS COULD BE DISASTEROUS. MY FAMILY WILL GET THE $200 BACK IT COST TO REPLACE THE "CLOCKSPRING" BUT I HOPE IT DOES NOT TAKE A DEATH OR FIVE.*AK

RECALL REPLACEMENT OF GAS TANK THAT MIGHT HAS SOMETHING TO DO WITH MY ENGINE LIGHT TURNING ON NOW I FOUND OUT THAT THE PROBLEM IS COMING THROUGH THE EMISSION CONTROL SYSTEM PURGE (GROSS) LEAK ENGINE CODE P0455 GIVEN TO ME BY THE CAR ITSELF, MY CAR WILL BE TAKEN TO DEALER ON THIS CONDITION MONDAY JUNE 16,2003 AND I THINK THIS HAS SOMETHING TO DO WITH THE REPAIR OF THE RECALL. MY MAIN COMPLAINT IS THAT I'VE BIN AT THIS DEALER THREE TIMES WITH REPAIR DONE OR CHECK DONE ON PROBLEMS TO MY VEHICLE AND THREE TIMES I GET NO PROOF THAT THE VEHICLE WAS SERVICE THERE EVEN WHEN THE RECALL WAS DONE ALL I HAVE IS THE TAG # WHICH IS ONLY FOR THERE PURPOSE. I DO ASK FOR IT EVEN THOUGH I THINK I SHOULDN'T AND THEY STATE THAT JOB IS DONE AND I DON'T NEED ANYTHING CAUSE IT WAS DONE. *NLM