2005 Dodge Grand Caravan Body & Structure Problems

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHILE DRIVING 25 MPH, THE PASSENGER SIDE SLIDING DOOR OPENED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND ATTEMPTED TO CLOSE THE DOOR AUTOMATICALLY BY DEPRESSING THE SLIDING DOOR BUTTON; HOWEVER, IT FAILED TO CLOSE THE DOOR. THE CONTACT HAD TO CLOSE THE DOOR MANUALLY. THE VEHICLE WAS TAKEN TO TITUSVILLE CHRYSLER JEEP DODGE (5600 U.S. 1, TITUSVILLE, FL 32780, (321) 268-8970) WHERE IT WAS DIAGNOSED THAT THE MOTOR SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000. THE VIN WAS NOT AVAILABLE.

MY CAR IS 2005 DODGE GRAND CARAVAN IT HAS RUST IN THE BACK FENDER TWO SIDE DRIVER AND PASSENGER BED REST MAYBE IN THE FRAME AND I AM NOT ONLY ONE HAS THIS PROBLEM THIS PROBLEM IS VERY DANGEROUS BECAUSE THE FRAME CAN BE BREAK ANYTIME

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHEN THE CONTACT ATTEMPTED TO UNLOCK THE DRIVER AND PASSENGER SIDE DOORS WITH THE KEY FOB, THEY WOULD NOT UNLOCK. THE ONLY WAY TO UNLOCK THE DOORS WAS MANUALLY WITH THE KEY. THE CONTACT REPLACED THE BATTERIES IN THE FOB, BUT THAT DID NOT WORK. THE CONTACT ALSO STATED THAT THE REAR SLIDING DOOR DID NOT OPEN, EVEN MANUALLY WITH A KEY. THE VEHICLE WAS DRIVEN TO THE DEALER BUT THERE WAS A FEE FOR THE DIAGNOSTIC TEST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 205,000.

SIGNIFICANT RUSTING HAS SPREAD ON THE DRIVER SIDE REAR WHEEL CORNER PANEL AND BENEATH THE SLIDING DOOR ROCKER PANEL, LEAVING LARGE AREAS OF VISIBLE RUST AND MISSING PAINT, AS WELL AS REVEALING ERODED/CHIPPED CHUNKS OF METAL OF THE UNDERCARRIAGE. MULTIPLE BODY SHOP EXAMS HAVE SHOWN THAT THIS PROBLEM HAS ORIGINATED FROM THE INSIDE OUT, LEAVING LITTLE TO NO EASY FIX. THERE IS ALSO MINOR RUSTING OF THE SAME SORT ON THE PASSENGER SIDE OF THE VAN AS WELL. EXPERT CONSULTANTS HAVE DETERMINED THAT THIS DAMAGE MAY RESULT IN SERIOUS HAZARD IF/WHEN THE ROCKER OR PANEL PORTIONS OF THE AFFECTED AREAS DROP FROM THE VEHICLE AND DAMAGE EITHER OF THE REAR TIRES. THIS ALSO POSES A RISK TO ANY TRAFFIC THAT MAY BE TRAILING THE VEHICLE AT THE TIME PARTS SEPARATING DUE TO RUST. INDEPENDENT RESEARCH HAS SHOWN THAT CHRYSLER HAS REMOVED CRITICAL REQUIREMENTS, SUCH AS GALVANIZATION, AS DESIGN-TO-COST MEASURES THAT HAVE CONTRIBUTED TO THE INCREASE IN THESE PROBLEMS IN THE FIELD. CHRYSLER SHOULD RECALL, AND IF NOT, THEN A CLASS ACTION SUIT SHOULD BE PURSUED TO HOLD CHRYSLER RESPONSIBLE FOR THESE WELL KNOWN DESIGN DEFICIENCIES.

CLEAR COAT AND PAINT IS PEELING OFF LEAVING RUST ON THIS VAN IT SHOULD NOT BE DOING THIS WE HAVE OLDER CARS NOT DOING THIS AT ALL , I SEE A LOT OF DODGER VANS DOING THIS VERY SAME THING.

THE POWER FUNCTION TO BOTH REAR SLIDING DOORS FAILED WITHIN THE PAST 18 MONTHS, THE RIGHT REAR SLIDING DOOR WILL NOT OPEN MANUALLY NOW. IT WILL MOVE APPROXIMATELY 2 INCHES, THEN STOP AND NO MATTER HOW MUCH PHYSICAL FORCE YOU APPLY, THE DOOR REMAINS IN THAT POSITION. SHOULD SOMEONE NEED TO MAKE AN EMERGENCY EGRESS FROM THE VEHICLE THEY COULD NOT USING THIS DOOR. *TR

TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE PASSENGER'S SLIDING DOOR ERRONEOUSLY OPENED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 158,700.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DOOR LOCK SYSTEM FAILED. THE TWO SLIDING DOORS, THE DRIVER AND THE PASSENGER'S SIDE DOOR WOULD NOT OPEN ELECTRONICALLY AND COULD ONLY BE OPENED MANUALLY. THE CONTACT RESET THE DOOR LOCK SYSTEM HIMSELF HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 104,000.

MY DAUGHTER 8 CAN NOT OPEN THE SLIDING DOORS IN THE BACK BECAUSE THE BUTTON IS TO HARD TO PUSH ALSO ON ONE SIDE YOU CAN NOT OPEN IT FROM THE INSIDE AND I THINK THIS SHOULD BE CHECKED ON IT IS A SAFETY HAZARD. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE PASSENGER SIDE SLIDING DOOR COULD NOT BE LOCKED OR UNLOCKED AUTOMATICALLY. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE THE DOOR INSPECTED. THE DEALER DID NOT PROVIDE THE INSPECTION REPORT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 84,950.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE LOCKS ON THE DOORS EITHER COULD NOT LOCKED AUTOMATICALLY WHEN DRIVING OR THE LOCKS WOULD ENGAGE INDEPENDENTLY. THE FAILURE WOULD RECUR WHETHER THE CONTACT USED THE AUTOMATIC KEY FOB OR THE KEY MANUALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR A MECHANIC FOR DIAGNOSTICS OR REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE HOWEVER NO ASSISTANCE WAS PROVIDED. THE CURRENT MILEAGE WAS 140,000. THE FAILURE MILEAGE WAS 138,000.

LETTER FROM SENATOR COLLINS ON BEHALF OF CONSTITUENT, RE THE FRAME OF HER 2005 DODGE GRAND CARAVAN SXT *TGW THE CONSUMER STATED THE FRAME ON THE VEHICLE HAS EXTENSIVE RUST, WELL BEYOND WHAT SHOULD BE EXPECTED. THE CONSUMER WAS INFORMED THE VEHICLE WAS NOT SAFE TO DRIVE, BECAUSE THE OF THE EXTENSIVE RUST ON THE SUPPORT FRAME. *JB

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THE VEHICLE DOORS FAILED TO OPEN AND CLOSE WITH THE AUTOMATIC SYSTEM. THE DOOR CAN ONLY BE OPENED AND CLOSED MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE DOORS BODY CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS NOT REPAIRED. THE VIN INFORMATION WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 145,000 AND THE CURRENT MILEAGE WAS 146,000.

I PURCHASED A DODGE GRAND CARAVAN NEW IN 2005. YESTERDAY I HAD A FLAT TIRE AND TRIED TO ACCESS THE SPARE TIRE. IT WAS IMPOSSIBLE AS IT WAS FROZEN IN PLACE. I CALLED MY LOCAL DEALERSHIP AND THEY SUGGESTED I USE A PRY BAR TO FREE IT. I BELIEVE THIS IS A DESIGN FLAW AND THAT MANY PEOPLE ARE DRIVING AROUND BELIEVING THEY HAVE A SPARE TIRE WHILE IN REALITY, THE SPARE IS INACCESSIBLE. I COULD HAVE BEEN STRANDED OR IN AN UNSAFE AREA. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE ATTEMPTED TO LOCK THE DOORS USING THE KEY FOB AND THE DOORS WOULD NOT LOCK. THE CONTACT WAS ABLE TO SUCCESSFULLY LOCK THE DOORS MANUALLY. THE CONTACT REPLACED THE FUSES FOR THE DOOR LOCKS, BUT THE FAILURE RECURRED AFTER A FEW WEEKS. THE CONTACT AGAIN REPLACED THE FUSES, BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.

AUTOMATIC DOOR LOCKS HAVE FAILED, AND THE AUTOMATIC SLIDING DOORS HAVE FAILED. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THE SLIDE ELECTRIC DOOR DOES NOT OPEN ELECTRONICALLY OR MANUALLY. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE CONTACT STATED THAT CHILDREN CAN NOT EXIT THE VEHICLE ON THE PASSENGER SIDE. THE CHILDREN HAVE TO EXIT ON THE DRIVER SIDE WHICH EXITS INTO TO ONGOING TRAFFIC AND IT A SERIOUS SAFETY ISSUE. THE FAILURE MILEAGE WAS 55,970.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR DRIVER SIDE AUTOMATIC SLIDING DOOR WOULD NOT UNLOCK OR OPEN. THE CONTACT ATTEMPTED TO USE DIFFERENT METHODS TO OPEN THE SLIDING DOOR BUT IT WOULD NOT OPEN AUTOMATICALLY OR MANUALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 159,426.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE REAR AUTOMATIC SLIDING DOOR ON THE DRIVER'S SIDE BEGAN TO SLIDE OPEN. THE FAILURE RECURRED ON AN INTERMITTENT BASIS. THE CONTACT ALSO STATED THAT THE SLIDING DOOR NO LONGER FUNCTIONED AUTOMATICALLY AND HE HAD TO OPEN AND CLOSE THE DOOR MANUALLY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.

POWER SLIDING DOOR MOTOR FAILURE AND MALFUNCTION. *TR