There are 50 owner-reported electrical system complaints for the 2016 Dodge Grand Caravanin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2016 Dodge Grand Caravan. The contact stated that on several occasions, while inserting the key into the ignition, the vehicle failed to start. Additionally, on several occasions while driving at various speeds, the vehicle stalled. The contact stated that during each failure, the key was wiggled in the ignition for approximately 20-30 minutes each time, and the vehicle was able to be restarted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 52,000.
My 2016 dodge grand caravan has all of a sudden lost power on half the fuse box making it so the key (fob) says iuyts A bad key a total of 3 times so far as well as this time will not turn over at all, also the last time I went to put fuel in it half the gas was on the ground due to a faulty gas line on the fuel neck. It also has a fluctuateing rpm at stop lights. And might turn off and be hard to restart in the middle of an intersection.I would hope to have these things fixed in a recall soon.
Odometer Fraud. The contact purchased a 2016 Dodge Grand Caravan. The contact discovered a mileage discrepancy after purchasing the vehicle. The vehicle was a dealer sale. At the time of purchase, the mileage was approximately 116,000. The contact stated that a month after the vehicle was purchased, the transmission failed. The vehicle was taken to the dealer for repair, and it was discovered that the mileage was 131,000. The contact was unable to use the warranty due to the mileage discrepancy.
Door buzzing noise when unlocking...sliding door will not unlock from inside the vehicle. Safety hazard for the passengers.
My wife was stopped at a drive through window in DRIVE when the engine stalled. It wouldn’t crank over and needed to be pushed out of the way and towed. The TIPM failed and needed to be replaced. The repair was done at a Chrysler dealer and they took the faulty part after repair. Safety was at risk because if this had happened in the middle of the road it could have caused an accident. My wife was lucky it happened at the drive through. Vehicle not inspected by police or insurance. No warning lights or other symptoms, just engine stalled
Right side passenger sliding door makes a loud buzzing noise when it locks.
Looks like there's a design or defective part on the driver side (Left) window. It is unable to open. This is the second time that the window unable to open, the first time happened in around late 2019 early 2020. It was the window power switch issue and I had it replaced. Recently the window stopped working again. This can be a potential safety issue if the car is drove into a river or in a high water area and the window cannot be opened for driver to escape.
DRIVER SIDE SLIDING DOOR STUCK LOCKED. NOT ABLE TO OPEN THE DOOR. EXTREME SAFETY ISSUE. PASSENGER IS NOT ABLE TO EXIT THE CAR IN EMERGENCY SITUATION
Both back doors have failed lock actuators. I’ve gotten a repair quote of over $1400 per door to get fixed. Both doors buzz and one has actually locked shut. Extremely inconvenient with children.
Doors buzzing when you turn off car n open door.
The rear passenger sliding door is making a buzzing noise when unlocking. I have had it lock up a few times where I can't open the door and this is a big safety hazard. I have kids and if something was to happen and I couldn't open the door. I see there is an extended warranty for this problem. I called the dealership and they looked up my vin # and said I was not covered. The door lock actuator needs to be replaced.
Every time I lock right rear slider with power lock loud buzz is heard.
The actuator on the left passenger side sliding door is buzzing every time the doors are opened.
The side door actuator is malfunctioning. There is a loud buzzing noise that comes from the drivers side, side sliding door when locking and unlocking the van. Sometimes the door will not open at all and just keeps buzzing, I have also had issues unlocking the door as a result of the malfunctioning actuator. This is a HUGE safety concern as the door may or may not open and if it does this during an accident or other kind of emergency, the results could be catastrophic.
The sliding doors does not unlock on its own. Needs to be manually unlocked and makes a buzzing sound when pushing the lock button.
my passenger side, sliding door lock is making a loud buzzing noise when unlocking.
Loud buzzing noise when locking door. Seat position control buttons and mirror positioning control buttons stopped working. Had fixed and within a month, they stopped working again. The buzzing issue has been going on for years now. The issues with the seat/mirror controls started about three months ago.
The sliding door on the passenger side buzzes when the electronic locks are locked or unlocked. This is a shock to the driver as the locks engage while driving away from parked.
Unknown- was not in a accident but sliding door just all of a sudden will not open unlatch or anything it’s stuck shut will not even make an unlocking noise when attempting to open
My left sliding door has now locked shut after making noises that the other side had before it got fixed a year ago. And I can not open it at all.
Showing 1–20 of 50 complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 26, 2026