There are 18 stored owner reports matching the engine leading-label group for the 2005 Ford E-350 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 18 of 18 matching reports.
Open the full vehicle complaint log (all categories)WHILE DRIVE ON HIGHWAY,VEHICLE BEGAN TO LOSE POWER WHEN I ENCOUNTERED A HILL. IT BOGGED DOWN AND STRUGGLED TO MAKE IT TO TOP OF HILL AND LOST SPEED DOWN TO 30 MPH OR LESS AND THEN DIED. IT WOULD NOT START RIGHT AWAY, BUT AFTER LETTING IT SIT FOR 15 MINUTES, IT STARTED AND HAD REGAINED POWER AND I DROVE IT TILL I GOT TO THE NEST HILL AND DID THE SAME THING SEVERAL TIMES TILL I MADE IT HOME 3 HOURS LATER FOR A 10 MILE TRIP. I CHECKED ONLINE ON THE VEHICLE FOR FORD OWNERS FORUM AND SAW THAT SEVERAL PEOPLE ENCOUNTERED THIS PROBLEM BEFORE AND DESCRIBED IT AS BOGGING DOWN AND LOSING POWER. SOME ONE SUGGESTED CHANGING THE EGR VALVE WHICH I HAD DONE, AND THE FUEL FILTERS AS WELL AS AIR FILTER. WHEN I REMOVED THE BOTTOM FUEL FILTER UNDER THE VAN, I CAPTURED THE FUEL IN THE FILTER AND LINE AND IT HAD WHAT LOOKED LIKE SILVER PAINT. I KEPT THE SAMPLE AND IT IS SOFT AND PLIABLE. I ASSUMED IT WAS A PROTECTIVE COATING LINING THE FUEL TANK. I DON'T BELIEVE THIS SHOULD BE HAPPENING,BECAUSE IT COULD DO DAMAGE TO THE INJECTORS AND OTHER THINGS. *TR
TL* THE CONTACT OWNS A 2005 FORD E-350. WHILE DRIVING 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER REPEATED ATTEMPTS. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
TL* THE CONTACT OWNS A 2005 FORD E-350. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE IT WAS INSPECTED BY AN AUTHORIZED MECHANIC. THE MECHANIC ADVISED THE CONTACT THAT THE FILTER AT THE BOTTOM OF THE ENGINE HAD BECOME CLOGGED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.
TL* THE CONTACT OWNS A 2005 FORD E350 SUPER DUTY. THE CONTACT STATED THAT HE WOULD HAVE TO WAIT HOURS FOR THE ENGINE TO COOL DOWN BEFORE THE VEHICLE COULD BE STARTED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE ENGINE OIL COOLER, INJECTORS AND THE EGR COOLER WOULD ALL NEED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 79,000. UPDATED 1/7/13 *CN THE CONSUMER STATED THE DEALER REBUILT THE ENGINE, POSSIBLY DUE TO DETERIORATION OF THE FUEL TANK LINER. UPDATED 01/09/13
TL* THE CONTACT OWNS A 2005 FORD E-350 DIESEL. WHILE DRIVING APPROXIMATELY 35 MPH AND EXITING THE HIGHWAY, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE AS IT COASTED OFF THE RAMP AND ONTO A SECOND HIGHWAY WHERE THE VEHICLE WAS MANEUVERED TO THE SHOULDER. THE CONTACT WAS ABLE TO RESTART THE VEHICLE YET IT CONTINUED TO STALL REPEATEDLY. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED THAT THE INJECTION PUMP AND INJECTION CONTROL SENSOR WAS DEFECTIVE AND WOULD NEED TO BE REPLACED. IN ADDITION, THE MECHANIC ADVISED THAT THE HIGH PRESSURE OIL PUMP WAS DAMAGED AND THE HOUSING WHICH WOULD ALSO NEED REPLACING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 67,294 AND THE CURRENT MILEAGE WAS 67,310.
TL*THE CONTACT OWNS A 2005 FORD ECONOLINE E350. WHILE DRIVING 60 MPH, THE VEHICLE SHUT OFF COMPLETELY AND LOST POWER STEERING ABILITY. THE FORD DEALER AND MANUFACTURER OFFERED NO ASSISTANCE. THE VEHICLE WAS TOWED AND IT WAS DISCOVERED THAT THE INTERIOR OF THE FUEL TANK HAD DELAMINATED AND CAUSED THE ENGINE TO LOSE POWER. THE DEALER WOULD NOT REPAIR THE VEHICLE UNDER THE THREE YEAR, 36,000 MILE WARRANTY OR UNDER A RECALL. THE CONTACT WAS NOT INFORMED IF HIS VEHICLE WAS INCLUDED IN ANY RECALLS. THE FAILURE AND CURRENT MILEAGES WERE 35,000.
2005 FORD E-350 HAD ALTERNATOR PROBLEMS, THE A/C COMPRESSOR HAS BEEN REPLACED TWICE, THE ENGINE WAS REBUILT AND CHECK ENGINE LIGHT ILLUMINATED. *KB *NM
2005 FORD E-350'S A/C COMPRESSOR FAILED AND CHECK ENGINE LIGHT ILLUMINATED. *KB *NM
2005 FORD E-350 VALVE ASSEMBLY MODULATOR PROBLEMS, CHECK ENGINE LIGHT ILLUMINATED. *KB *JB
2005 FORD E-350 TURBO CHARGER PROBLEMS, EGR VALVE PROBLEMS. *KB *JB
2005 FORD E-350 HAD ALTERNATOR PROBLEMS, A SHORT IN THE DASHBOARD WIRING AND CHECK ENGINE LIGHT ILLUMINATED. *KB *NM
2005 FORD E-350 HAD A WIRING HARNESS DEFECT WHICH CAUSED THE VEHICLE TO RUN TROUGH. THE SERPENTINE BELT WAS REPLACED, THE CHECK ENGINE LIGHT ILLUMINATED AND THE ENGINE HAD TO BE REBUILT. *KB *NM
2005 FORD E-350 AMBULANCE WAS DRIVING WITH LIGHTS AND SIRENS TO A 911 CALL WHEN THE ENGINE DIED. THE CREW WAS BARELY ABLE TO CONTROL THE VEHICLE TO A STOP. THIS HAS HAPPENED 2 TIMES BEFORE, BOTH TIMES THE VEHICLE WAS SENT TO A FORD DEALERSHIP SERVICE CENTER AND THEY HAVE BEEN UNABLE TO FIND A SOLUTION TO THE PROBLEM. THEY ARE UNWILLING TO REPLACE THE ENGINE AND ALL DRIVETRAIN SYSTEMS. *NM
2005 FORD E-350 AMBULANCE HAD A TOTAL ENGINE FAILURE WHILE DRIVING TO A 911 CALL. THE FORD DEALERSHIP SERVICE CENTER DIAGNOSED AN OIL PUMP FAILURE AS THE CAUSE AND REPLACED IT UNDER WARRANTY. THIS IS COMPLIANT #2 OF 6. ALL OF THE 2005 FORD AMBULANCES WE PURCHASED HAVE SUFFERED TOTAL ENGINE FAILURES FROM EITHER THE OIL PUMPS OR THE WIRING HARNESS SYSTEMS. FORD IS UNWILLING TO REPLACE THESE PARTS ON THE OTHER UNITS UNTIL THEY FAIL. THEY ARE PLACING NUMEROUS LIVES IN EXTREME JEOPARDY AND REFUSE TO ADMIT THERE ARE MAJOR PROBLEMS WITH THE 6.0 L DIESEL ENGINE IN THE 2005 SERIES AMBULANCE CHASSIS. *NM
2005 FORD E-350 AMBULANCE HAD A TOTAL AC SYSTEM FAILURE THE FORD DEALERSHIP SERVICE CENTER DIAGNOSED THE CAUSE AND REPLACED IT UNDER WARRANTY. THIS IS COMPLIANT #3 OF 6. ALL OF THE 2005 FORD AMBULANCES WE PURCHASED HAVE SUFFERED MAJOR SYSTEM FAILURES FROM EITHER THE OIL PUMPS OR THE WIRING HARNESS SYSTEMS, AND SEVERAL HAVE HAD AC PROBLEMS AS WELL. FORD IS UNWILLING TO REPLACE THESE PARTS ON THE OTHER UNITS UNTIL THEY FAIL. THEY ARE PLACING NUMEROUS LIVES IN EXTREME JEOPARDY AND REFUSE TO ADMIT THERE ARE MAJOR PROBLEMS WITH THE 6.0 L DIESEL ENGINE IN THE 2005 SERIES AMBULANCE CHASSIS. *NM
2005 FORD E-350 AMBULANCE HAD A TOTAL ENGINE FAILURE WHILE DRIVING TO A 911 CALL. THE FORD DEALERSHIP SERVICE CENTER DIAGNOSED AN OIL PUMP FAILURE AS THE CAUSE AND REPLACED IT UNDER WARRANTY. THIS IS COMPLIANT #5 OF 6. ALL OF THE 2005 FORD AMBULANCES WE PURCHASED HAVE SUFFERED TOTAL ENGINE FAILURES FROM EITHER THE OIL PUMPS OR THE WIRING HARNESS SYSTEMS. IN ADDITION 3 OF 6 HAVE NEEDED NEW AC SYSTEMS AS WELL. FORD IS UNWILLING TO REPLACE THESE PARTS ON THE OTHER UNITS UNTIL THEY FAIL. THEY ARE PLACING NUMEROUS LIVES IN EXTREME JEOPARDY AND REFUSE TO ADMIT THERE ARE MAJOR PROBLEMS WITH THE 6.0 L DIESEL ENGINE IN THE 2005 SERIES AMBULANCE CHASSIS. *NM
2005 FORD E-350 AMBULANCE HAD A TOTAL ENGINE FAILURE WHILE DRIVING. THE FORD DEALERSHIP SERVICE CENTER DIAGNOSED AN OIL PUMP FAILURE AS THE CAUSE AND REPLACED IT UNDER WARRANTY. THIS VEHICLE ALSO SUFFERED A TOTAL AC SYSTEM FAILURE THAT WAS REPLACED UNDER WARRANTY. THIS IS COMPLIANT #6 OF 6. ALL OF THE 2005 FORD AMBULANCES WE PURCHASED HAVE SUFFERED TOTAL ENGINE FAILURES FROM EITHER THE OIL PUMPS OR THE WIRING HARNESS SYSTEMS. IN ADDITION 3 OF 6 HAVE NEEDED NEW AC SYSTEMS AS WELL. FORD IS UNWILLING TO REPLACE THESE PARTS ON THE OTHER UNITS UNTIL THEY FAIL. THEY ARE PLACING NUMEROUS LIVES IN EXTREME JEOPARDY AND REFUSE TO ADMIT THERE ARE MAJOR PROBLEMS WITH THE 6.0 L DIESEL ENGINE IN THE 2005 SERIES AMBULANCE CHASSIS. *NM
THE AGENCY FOR COMMUNITY TRANSIT PROVIDES SERVICES FOR MADISON COUNTY MASS TRANSIT DISTRICT WHO IS RESPONSIBLE FOR PUBLIC TRANSPORTATION SERVICES IN THE MADISON COUNTY, ILLINOIS AND METROPOLITAN ST. LOUIS, MO. AREA. WE HAVE APPROXIMATELY 48 FORD E450 VAN CUTAWAY CHASSIS EQUIPPED WITH TURTLE TOP BUS BODIES, ALL EQUIPPED WITH 6.0L DIESEL ENGINES. BUSES ARE 2004 & 2005 MODEL YEARS. COKING (UN-COMBUSTION) DEPOSITS FORM ON THE EGR VALVE CAUSING DRIVABILITY ISSUES SUCH AS LACK OF POWER, SURGES, AND STALLING. THIS CONDITION IS ESPECIALLY DANGEROUS WHEN THE BUS DEVELOPS THIS CONDITION WHEN CROSSING INTERSECTIONS, RAILROAD TRACKS ETC AND IS TRANSPORTING PASSENGERS BOTH MOBILE AND HANDICAPPED. DRIVERS HAVE VOICED THEIR CONCERN OVER THIS CONDITION AS THEY BELIEVE IT IS UNSAFE FOR THEM AND THEIR PASSENGERS. FORD MOTOR COMPANY HAS REPLACED EGR VALVES (APPROX. 36-40) OR RECOMMENDS A FUEL ADDITIVE TO TRY TO TAKE CARE OF THE PROBLEM BUT IT DOES NOT REPAIR THE PROBLEM AS IT EVENTUALLY RETURNS ONCE THE REPLACEMENT EGR BUILDS UP COKING DEPOSITS. WE HAVE BEEN IN CONTACT WITH FORD BUT HAVE BEEN INFORMED THERE ARE NO CURRENT PLANS TO PERMANENTLY CORRECT THE PROBLEM. WE HAVE BEEN IN TOUCH WITH FORD FIELD SERVICE ENGINEERS AND ENGINEERS IN MICHIGAN BUT TO NO AVAIL. PREVIOUSLY WE HAD SIMILAR FORD VEHICLES WITH 7.3L DIESEL ENGINES OPERATING UNDER IDENTICAL CONDITIONS WITH NO PROBLEMS. THESE PROBLEMS OCCURRED WHEN THE 6.0L DIESEL WAS INTRODUCED INTO THE FLEET AS THE 7.3L PREVIOUSLY USED WAS DISCONTINUED. *JB
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: May 4, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.