2004 Ford Escape Complaint Log

MY HUSBAND WAS DRIVING HOME WITH OUR SON AND STARTED TO HEAR A LOUD NOISE. TOOK IT TO OUR REPAIR GUY WHO STATED THE FRAME WAS COMPLETELY RUSTED THROUGH AND WAS NO LONGER SAFE TO DRIVE. WE THEN TOOK IT FOR A 2ND LOOK AND WAS TOLD THE SAME THING AND THAT ITS NOT FIXABLESO WE'LL HAVE TO BUY A NEW CAR. WE'VE ONLY HAD THIS CAR FOR 6 YEARS AND I BOUGHT IT FROM OUR LOCAL FORD DEALERSHIP WHO WHEN CONTACTED SAID THEY COULDN'T DO ANYTHING TO HELP BECAUSE THERE ARE NO RECALLS ON THE VEHICLE FOR THIS PROBLEM. WE HAVE 2 SMALL CHILDREN AND I'M VERY LUCKY THAT SOMETHING DIDN'T HAPPEN TO THEM. WHAT IS A RECALL GOING TO TAKE? SOMEONE GETTING HURT OR WORSE?? THIS IS A MAJOR SAFETY ISSUE AND FORD NEEDS TO BE RESPONSIBLE CLEARLY ITS A MANUFACTURING PROBLEM WHEN THERE'S 1000'S OF CUSTOMERS WITH THE SAME PROBLEM!!!! *TR

AIRBAG SENSOR DISPLAYED ON DASH. WILL NOT GO OFF. SCHEDULING DIAGNOSTIC TEST ON FRIDAY 2/21/2014. RESEARCHED PROBLEM ON INTERNET, APPARENTLY THIS IS HAPPENING MUCH TO OFTEN FOR IT TO BE A INDIVIDUAL PROBLEM. MY MECHANIC STATED IT HAS BECOME A COMMON PROBLEM WITH FORD ESCAPES. THE COST TO REPAIR IS NOT CHEAP. I CANNOT BELIEVE THAT THE GOVERNMENT HAS NOT INTERVENED AND ALERTED THE PUBLIC OR AT THE VERY LEAST FORD ESCAPE OWNERS. I AM DISABLED AND HAVE NO INCOME AT THIS TIME. I TRULY HOPE THAT THE GOVERNMENT WILL HOLD FORD MOTOR COMPANY TO THIS ISSUE BEFORE SOMEONE GETS SERIOUS HURT OR WORSE KILLED. *TR

WHILE DRIVING, THE THROTTLE STUCK. APPLIED THE BRAKES, BUT VEHICLE WAS DIFFICULT TO SLOW AND TACHOMETER INDICATED HIGH ENGINE SPEED. SHIFTING TO NEUTRAL, THE ENGINE RPMS PUT THE NEEDLE IN THE RED BEYOND THE GAUGE. AFTER SHUTTING OFF THE VEHICLE, AND OPENING THE HOOD THE PROBLEM DID NOT PERSIST, BUT RETURNED AFTER DRIVING AGAIN. *TR

WELL, MY FORD ESCAPE 2004 LTD EDITION HAD ISSUES SLOWING DOWN. I HAD USED THE CRUISE CONTROL INTERMITTENTLY AND NOTICED THAT THE VEHICLE CONTINUED AS IF CRUISE CONTROL WAS ON EVEN AFTER I BRAKED HARD AND CANCELLED THE CRUISE CONTROL. I SHUT THE VEHICLE OFF AND TRIED TURNING IT BACK ON. WHEN IT STARTED BACK UP, THE VEHICLE REVVED TO 5,000 RPM IN UNDER 5 SECONDS. I DID THIS TWICE WITH THE SAME EFFECT. I BROUGHT IT IN TO MY FORD DEALERSHIP. THEY SAID THERE WAS NO RECALL (ALTHOUGH NOW I SEE THEM ALL OVER THE INTERNET). I GOT A CALL BACK AFTER THIS WHOLE ORDEAL THAT THE RIGHT REAR WHEEL WELL HAD COMPLETELY RUSTED THROUGH AND THAT THE SHOCK WAS NOT ATTACHED TO ANYTHING. THIS SEEMS TO BE A COMMON TREND WITH THESE VEHICLES, BUT THERE ARE NO RECALLS. MY DEALERSHIP IS BRINGING IT TO AN AUTO BODY SHOP TODAY. I AM EXPECTING A $3,000 REPAIR NOW. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A HESITATION WHEN DEPRESSING THE ACCELERATOR PEDAL AND THE ENGINE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC WAS UNABLE DETERMINE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

THE RIGHT REAR FENDER WELL HAS RUSTED OUT AROUND THE SHOCK MOUNT CAUSING THE SHOCK MOUNT TO SEPARATE FROM THE BODY OF THE VEHICLE. *TR

STEERING FAILURE.

PASSENGER REAR WHEEL WELL HAS COMPLETELY RUSTED OUT AND SHOCK AND MOUNT HAVE RUSTED OFF OF FRAME. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE CRUISE CONTROL WOULD NOT DISENGAGE WHEN APPLYING THE BRAKES, CAUSING THE VEHICLE TO ACCELERATE TO 85 MPH INDEPENDENTLY. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL AND WAS ABLE TO SLOW THE VEHICLE DOWN. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS ADVISED THAT THE CRUISE CONTROL MALFUNCTIONED DUE TO EXTREME COLD WEATHER. THE CONTACT STATED THE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN I.D. NUMBER: 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 80,000.

WHILE DRIVING AT ABOUT 45 MILES PER HOUR MY CAR STARTS TO SPIT, SPUTTER AND RUN ROUGH, THERE IS A NOTICEABLE LOSS OF POWER AND MY GAUGES FIRST TOP OUT THEN THEY BOTTOM OUT THEN THEY GO BACK TO NORMAL. FORD CAN'T FIND THE PROBLEM BECAUSE IT DOESN'T CODE FOR THEM. *TR

THESE WAS A LOUD BANG WHEN DRIVING OVER SMALL BUMPS IN THE REAR PASSENGER SIDE WHEEL. WHEN I WAS HOME I CHECKED THE WHEEL WELL AND THE TOP SHOCK MOUNT WAS TOTALLY ROTTED THROUGH TO THE TRUCK AREA. THE MOUNT HOUSE IN THE BODY HAD BROKEN OFF AND DESTROYED THE INNER WHEEL WELL. *TR

DRIVING DOWN ROAD AND THE RPMS ON MY 2004 ESCAPE JUMP UP. SO I TRY TO SLOW DOWN AND CAR KEEPS ACCELERATING. THROW CAR INTO PARK BECAUSE BRAKES WOULDN'T SLOW IT DOWN. EVER SITE I READ SAYS IT IS THE ACCELERATOR CABLE. SUPPOSEDLY THIS WAS REPLACED BY DEALER WHILE IN FOR AIR BAG INDICATOR LIGHT REPAIR IN DECEMBER 2012. UNDER RECALL. NOW WHEN I START VEHICLE RPMS JUMP, AND GET BURNING SMELL FROM MOTOR. CARS RPMS JUMP WHILE DRIVING DOWN ROAD ALSO. BATTERY AND ALTERNATOR WERE REPLACED IN MAY 2013 BUT SINCE THEY WERE REPLACED BATTERY INDICATOR LIGHT IS DIMLY LITE UPON ACCELERATING. I HAVE SPENT A FORTUNE ON THIS VEHICLE AND EVERY TIME I TURN AROUND IT NEEDS MORE WORK. I ALSO AFTER GETTING BATTERY AND ALTERNATOR REPLACED HAD TO PUT A NEW THROTTLE BODY COMPONENT IN BECAUSE MOTOR WAS RACING TO 3000 RPMS WHILE IN PARK OR WHILE FOOT WAS ON BREAK. PLEASE HELP. I AM SCARED TO DEATH TO DRIVE THIS VEHICLE LIKE IT IS. CAN NOT AFFORD TO PUT ANYMORE MONEY INTO IT EITHER. *TR

WHEN DRIVING HOME ON 12/30/14, I HEARD A LOUD RATTLE COMING FROM THE RIGHT REAR OF THE VEHICLE. I LOOKED IN THE REAR PASSENGER WHEEL WELL AND NOTICED THAT THERE WAS A LOT OF RUST. I DID NOT DRIVE IT AGAIN UNTIL I TOOK IT TO MY MECHANIC TO HAVE IT INSPECTED ON 1/6/15. HE INFORMED ME THAT THE WHEEL WELL WAS RUSTED AND THE STRUT COULD BREAK LOOSE. HE ALSO INFORMED ME THAT HE HAD NEVER SEEN A VEHICLE DO THIS. I WAS ALSO INFORMED THAT IT IS A SAFETY ISSUE AND I SHOULD NOT DRIVE THE VEHICLE UNTIL IT IS FIXED. HE ALSO CHECKED TO SEE IF ANYONE IN THE AREA WOULD BE ABLE TO FIX IT SINCE HE IS NOT EQUIPPED TO DO SO. NO LUCK WITH THAT. AFTER SEEING HOW MANY PEOPLE ARE HAVING THIS SAME ISSUE WITH THEIR FORD ESCAPE, I WOULD EXPECT THAT THE FORD COMPANY WOULD DO THE RIGHT THING, TAKE RESPONSIBILITY FOR THE DEFECT AND MAKE IT RIGHT. I AM PREPARED TO FOLLOW THROUGH TO HAVE THIS MATTER TAKEN CARE OF, EVEN IF I HAVE TO TAKE IT TO LANSING AND WASHINGTON. *TR

THE RIGHT REAR WHEEL HOUSING WAS TOTALLY CORRODED AWAY. AFTER RESEARCHING ONLINE FOUND MANY WITH THE SAME PROBLEM. THE OTHER THREE WHEEL HOUSINGS WERE IN GOOD CONDITION WITHOUT RUST. I TOOK SUV TO WOLTZ & WIND FORD IN HEIDELBURG, PA WHERE THEY TOLD ME THAT THEIR SUPPLY OF THIS PART WAS USED UP AND FORD WAS NOT MAKING ANY AT THAT TIME. THE REAR HOUSINGS SUPPORT THE REAR SHOCKS AND "COULD HAVE" CAUSED A SEVERE ACCIDENT. IT TOOK 3 1/2 MONTHS BEFORE PART WAS REPLACED. OF COURSE FORD DOWN PLAYS THE SEVERITY OF THE PROBLEM AND I WAS GIVEN A TOTAL RUN-A-ROUND BY THE DEALERSHIP AND WITH FORDS CUSTOMER SERVICE. I AM 78 YEARS OLD WIDOW WHO DREADS TO THINK WHAT "COULD HAVE" HAPPENED. PLEASE DO NOT WAIT UNTIL SOMEONE GETS KILLS TO MAKE THIS A PRIORITY. YOU MAY SPEAK TO MYSELF OR MY SON-IN-LAW [XXX] WHO HAS BEEN HELPING WITH THIS MESS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WAS DRIVING ON THE HIGHWAY AND NOTICED A LOUD NOISE COMING FROM THE REAR OF MY VEHICLE AND NOTICED THE NOISE WAS GETTING LOUDER. I TOOK MY VEHICLE TO MY MECHANIC THINKING I NEEDED SHOCKS. MY MECHANIC STATED TO ME THAT I COULD NOT PUT NEW SHOCKS ON MY ESCAPE BECAUSE MY INNER FENDER WELL WAS RUSTED OUT AND MY SHOCK WAS NO LONGER BOLTED TO THE FRAME. I THEN HAD TO TAKE IT TO A BODY SHOP TO BE REPAIRED. MY SHOCK WAS JUST BOUNCING AROUND AND COULD HAVE BROKEN THROUGH THE BACK SEAT OR BROKEN OFF ALL TOGETHER. ONCE I TOOK IT TO THE BODY SHOP I WAS TOLD I WOULD ALSO HAVE TO REPLACE THE SHOCKS BECAUSE MY RIGHT PASSENGER SIDE SHOCK WAS CRACKED IN HALF. I JUST PURCHASED THIS "USED" VEHICLE IN NOVEMBER AND MY HUSBAND REALLY LIKES FORD PRODUCTS BUT AFTER THIS HAPPENING TO US AND FINDING OUT THAT FORD HASN'T DONE ANYTHING ABOUT THIS PROBLEM FOR ANYBODY WHO HAS HAD THE SAME ISSUE IT IS VERY DISAPPOINTING. LUCKILY NOBODY IN MY FAMILY WAS INJURED DUE TO THIS PROBLEM. I REALIZE THIS PROBLEM HAS HAPPENED TO MOST VEHICLES WHERE THERE IS SNOW AND ICE HAS TO BE USED ON THE ROADS, I FEEL FORD SHOULD ISSUE A RECALL FOR THE VEHICLES THAT HAVE HAD THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED WHILE TRAVELING APPROXIMATELY 80 MPH, THE VEHICLE CONTINUED TO ACCELERATE ALTHOUGH THE ACCELERATOR PEDAL WAS NOT DEPRESSED. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN NUMBER 12V353000 (ENGINE AND ENGINE COOLING , VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 140,000. THE VIN WAS UNAVAILABLE.

AT APPROXIMATELY 65 MPH ON A CROWDED INTERSTATE HIGHWAY, THE VEHICLE LOST POWER AND THE "CHECK ENGINE" LIGHT ILLUMINATED THE VEHICLE SLOWED AND I WAS ABLE TO PULL OFF THE HIGHWAY. AFTER SWITCHING THE ENGINE OFF AND WAITING A FEW MINUTES, I WAS ABLE TO START THE CAR AND MOVE FORWARD FOR ABOUT A MILE WHEN THE SAME THING HAPPENED. AFTER THE THIRD TIME THIS HAPPENED, I DECIDED THE CAR WAS TOO DANGEROUS TO DRIVE IN TRAFFIC AND PULLED OVER TO CALL A TOW TRUCK. THE CAR HAS LESS THAN 20,000 MILES ON IT. THE LOCAL FORD DEALER INDICATES NO RECALL HAS BEEN ISSUED FOR THIS SPECIFIC PROBLEM. LOSING SPEED IN FAST-MOVING HIGHWAY TRAFFIC IS EXTREMELY DANGEROUS; THANKFULLY THERE WAS NO ACCIDENT OR INJURY IN THIS CASE. *TR

RATTLING NOISE COMING FROM THE REAR OF THE VEHICLE. DAUGHTER TOOK ME FOR A RIDE AND I SAT IN THE REAR OF THE VEHICLE TO TRY AND FIND THE SOURCE OF THE RATTLING. CHECKED THE STORAGE COMPARTMENT FOR THE SPARE, ALL OTHER PARTS AND COULD NOT DETERMINE THE SOURCE. THE NEXT DAY THE NOISE WAS MUCH MORE PRONOUNCED. TOOK IT TO A BODY SHOP AND THEY IMMEDIATELY FOUND THE SOURCE OF THE PROBLEM, THAT BEING A TOTALLY RUSTED OUT SHOCK/STRUT TOWER. THE BODY SHOP MANAGER SAID HE HAS SEEN THIS ON MULTIPLE ESCAPES. HE REFUSED TO QUOTE THE JOB AS HE DID NOT WANT TO BE LIABLE IN CASE IT DID NOT WORK OUT. *TR

2004 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO VEHICLE ACCIDENT AND SAFETY RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE WAS TOTALED. SHE BELIEVED THE ACCIDENT, WAS DUE TO THE SAFETY RECALL.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, A LOUD NOISE WAS HEARD FROM OUTSIDE THE REAR PASSENGER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THAT THE SHOCKS AND STRUT MOUNT WERE COMPLETELY CORRODED. THE VEHICLE WAS SCHEDULED FOR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. UPDATED 12/4/13*CN THE CONSUMER STATED THE RIGHT REAR SIDE OF THE SHOCK STRUT MOUNT RUSTED AWAY. UPDATED 12/12/13

RIGHT SIDE SHOCK TOWER RUSTED OUT . CAR IS UNSAFE TO DRIVE. *TR

TL* THE CONTACTS OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR END OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS ADVISED THAT THERE WAS A HOLE ABOVE THE PASSENGER'S SIDE REAR BODY PANEL AND AS A RESULT, THE REAR PASSENGER'S SIDE STRUCTURE OF THE UNIBODY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 112,000.

I HIT A BUMP AND THE BACK OF MY VEHICLE STARTED MAKING A BANGING NOISE AFTERWARD ANY TIME I WENT OVER THE SLIGHTEST BUMP. I TOOK IT TO THE GARAGE AND THE MECHANIC WOULDN'T EVEN TOUCH IT. THE REAR SHOCK MOUNT PLATE IS RUSTED OUT AND HE SAID THE WHEEL WELL IS BREAKING RIGHT OFF THE FRAME. THERE IS NOTHING LEFT AROUND IT - THE METAL WAS ONLY HELD TOGETHER BY UNDERCOATING IN SOME PLACES. HE SAID IT WAS PUSHING DOWN ON THE BRAKE LINE, TOO. I HAVE SEEN SEVERAL INCIDENTS WITH THIS MAKE/MODEL/YEAR AND THE 2005 AS WELL. THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS KILLED. MY CHILDREN WERE IN THAT VEHICLE! *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THE SEAT BELT WOULD NOT COMMUNICATE TO THE AIR BAG TO ACTIVATE WHILE ENGAGED. THE AIR BAG LIGHT WAS ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE DEALER STATED THAT THE WIRING SYSTEM TO THE SEAT BELT NEEDED TO BE REPLACED. THE DEALER DID NOT REPLACE THE WIRING SYSTEM. THE DEALER STATED THAT IN THE EVENT OF A CRASH, THE AIR BAGS POSSIBLY WOULD NOT DEPLOY. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, SHE HEARD AN ABNORMAL NOISE AND UPON FURTHER INVESTIGATION, SHE FOUND THAT THE REAR WHEEL WELL SUFFERED FROM SEVERE CORROSION. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.

NOTICED A LOUD NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. AFTER ARRIVING HOME I CHECKED THE MUFFLER AREA THINKING IT WAS LOOSE WHICH IT WAS NOT. I THEN CHECKED INSIDE OF THE PASSENGER SIDE REAR WHEEL WELL AND FOUND THAT THE SHOCK THAT WAS ATTACHED TO THE FRAME OF THE VEHICLE HAD TOTALLY RUSTED OUT LEAVING A HUGE HOLE IN THE FRAME. THE HOLE NOW LEAVES THE VEHICLE UNSTABLE AND EXPOSED TO ALL ELEMENTS OF THE WEATHER. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SUB FRAME WAS COMPLETELY RUSTED AND HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE FRONT SUB FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 40,000. UPDATED 11/19/13*LJ UPDATED 11/29/2013 *JS

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SUB FRAME WAS COMPLETELY RUSTED AND HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 143,000.

THE RIGHT FRONT WHEEL BEGAN PULLING TO THE RIGHT. UPON INSPECTION WE FOUND THE SUB-FRAME UNDER THE RIGHT FRONT WAS RUSTED AND WAS SAGGING. I WAS ADVISED NOT TO DRIVE THE VEHICLE BECAUSE THE FRAME COULD COLLAPSE AND CONTROL OF THE VEHICLE WOULD BE LOST. UPON FURTHER INSPECTION IT WAS NOTICED THAT ONLY FRAME RUSTED OUT WHERE THE AIR CONDITIONER WAS DRIPPING CONDENSATION. THE DEALER SAID IT WAS THE ROAD SALT USED IN WINTER. IF THAT WAS THE CASE WHY WASN'T THE WHOLE SUB-FRAME ROTTED AND NOT JUST THE SECTION WHERE THE AIR CONDITIONER WAS DRIPPING? I DON'T THINK A 10 YEAR OLD VEHICLE SHOULD HAVE THE FRAME DISINTEGRATE LIKE THIS. *JB

I WAS DRIVING HOME FROM THE STORE AND STARTED HEARING A LOUD BANGING NOISE COMING FROM THE REAR OF THE TRUCK. UPON INVESTIGATION I DISCOVERED WHAT I BELIEVE TO BE A MAJOR SAFETY CONCERN IN MY 2004 FORD ESCAPE. THE REAR PASSENGER SIDE WHEEL WELL OVER THE SHOCK TOWER COMPLETELY RUSTED OUT AND SEPARATED OVER THE SHOCK. I HAVE BEEN TOLD AND SEEN THAT THIS SEEMS TO BE A COMMON PROBLEM WITH MY VEHICLE AND OTHER YEARS OF ESCAPES. AFTER SPEAKING WITH AN INDEPENDENT BODY SHOP IN MY AREA THEY INFORMED ME THIS WAS A COMMON PROBLEM THEY HAVE SEEN SEVERAL TIMES BEFORE. BUT WHEN I CONTACTED 3 LOCAL FORD DEALERS THEY ALL CLAIMED TO HAVE NEVER SEEN IT BEFORE. AND WANTED TO CHARGE ME A HUNDRED DOLLARS JUST TO LOOK AT IT. I AM TOLD THE VEHICLE IS UNDRIVEABLE IN THIS CONDITION. AND THAT IN MOST CASES CAN NOT BE REPAIRED. AFTER DOING MUCH RESEARCH ONLINE I FOUND HUNDREDS OF OTHER PEOPLE WITH THE SAME EXACT PROBLEM. I HAVE ALSO CONTACTED FORD AND AM AWAITING A RESPONSE. I WOULD LIKE TO SEE A RECALL MADE ON THIS AS I CAN SEE THIS BEING A MAJOR PROBLEM THAT COULD HAVE CAUSED AN ACCIDENT. AND IS GOING TO BE A VERY EXPENSIVE REPAIR JOB IF IT IS EVEN REPAIRABLE. I HAVE PHOTOS BUT AM NOT SURE HOW TO ATTACH THEM. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE STEERING WHEEL SEIZED AND THE BRAKE AND ACCELERATOR PEDALS WOULD NOT RESPOND TO PRESSURE. THE CONTACT WAS ABLE TO MOVE THE STEERING WHEEL AFTER MUCH EFFORT BUT SHORTLY AFTER, CRASHED INTO A UTILITY BOX. THE CONTACT WAS NOT INJURED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 90,000. UPDATED 04/22/14 MA WHEN THE CONSUMERS DAUGHTER CRASHED INTO THE ELECTRICAL BOX, IT CAUGHT ON FIRE, AND SPREAD TO THE VEHICLE. UPDATED 04/24/14

THE RIGHT REAR WHEEL WELL THAT SUPPORTS THE SHOCK TOWER HAS COMPLETELY RUST OUT,THIS IS COMMON IN THE 2004-2006 ESCAPES. *TR

THE RIGHT REAR INNER WHEEL HOUSING HAS ALMOST COMPLETELY RUSTED AWAY CAUSING THE RIGHT REAR SHOCK ABSORBER TO BREAK AWAY FROM ITS TOP MOUNTING AND CAUSE SEVERE VEHICLE BOUNCING AND SWAYING WHILE DRIVING MAKING IT ALMOST IMPOSSIBLE TO DRIVE THE VEHICLE.MANY OTHER ESCAPE OWNERS I HAVE SPOKEN TO ARE HAVING THE SAME PROBLEM AND AN INTERNET SEARCH OF THIS PROBLEM CONFIRMS MY FINDINGS. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 50 MPH, THE ACCELERATOR PEDAL BECAME STUCK AND THE VEHICLE FAILED TO SLOW DOWN. THE ACCELERATOR PEDAL WAS APPLIED REPEATEDLY AND THE FRONT END OF THE VEHICLE BEGAN TO VIBRATE. THE VEHICLE VEERED OFF THE ROAD TO AVOID CRASHING INTO ANOTHER VEHICLE INTO A DITCH. THE VEHICLE CONTINUED TO TRAVEL AND CRASHED INTO A CONCRETE BARRIER AND THEN A FENCE. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER WAS 12V353000 (ENGINE AND ENGINE COOLING , VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED AND INFORMED HIM THAT THE VIN WAS INCLUDED. THE EXTERIOR DAMAGES HAD NOT BEEN DETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 192,000. UPDATED 9/5/13 *CN UPDATED 09/11/2013 *JS

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE RPMS INCREASED EXCESSIVELY AS THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT MENTIONED THAT THE THROTTLE CABLE WAS STUCK. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V574000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 176,000.

HEARD A RATTLE IN REAR OF CAR. THOUGHT IT WAS EXHAUST SYSTEM RELATED. UPON INSPECTION FOUND REAR PASSENGER UPPER SHOCK CONNECTION HAD ROTTED COMPLETED AND THE SHOCK WAS DISCONNECTED FROM THE CAR. SHOCK IS BARELY HANGING ON THE VEHICLE AND APPEARS INCREDIBLY DANGEROUS. VEHICLE HAS BEEN MAINTAINED AS PER FORD REQUIREMENTS AT THE DEALER WHERE IT WAS PURCHASED FROM. NO UNUSUAL DRIVING CONDITIONS. *TR

THE SHOCK MOUNT ON THE REAR PASSENGER WHEEL IS LOOSE BECAUSE THE METAL SUPPORTING IT IS RUSTING AWAY. WHENEVER A BUMP IS HIT THERE IS A LOUD NOISE AND SHARP JOLT. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, SHE WAS ADVISED THAT THE SUB FRAME WAS COMPLETELY COVERED WITH RUST AND HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE REAR SUB FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE CURRENT AND FAILURE MILEAGE WAS 180,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE PASSENGER REAR SHOCK MOUNT PENETRATED THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE SHOCK MOUNT HAD BECOME PERFORATED DUE TO RUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 197,000. THE VIN WAS NOT AVAILABLE.

I WANT TO BRING TO YOUR IMMEDIATE ATTENTION A SERIOUS SAFETY CONCERN I HAVE WITH MY 2004 FORD ESCAPE. WE HAVE OWNED THE CAR SINCE 2007 (MILEAGE 102,000) AND HAVE RECENTLY EXPERIENCED INTERMITTENT STALLING WHILE THE CAR IS IN MOTION. I HAVE HAD 4 EXPERIENCES WHERE THE CAR WOULD STALL WHILE IN MOTION. IT APPEARS TO OCCUR WHEN OUTSIDE TEMPERATURES ARE ABOVE 80 DEGREES AND I HAVE TRAVELED IN THE CAR FOR >30 MINUTES AND HAVE MADE A SHORT STOP (FOR GAS OR SHOPPING). AFTER CONTINUING MY DRIVE AFTER A SHORT STOP, THE CAR SUDDENLY SHUTS OFF AT SOME POINT ON THE WAY HOME WHILE THE VEHICLE IS IN MOTION, LOSING ALL POWER TO THE STEERING AND BREAKING SYSTEM. THE CAR WILL START UP AGAIN (WHILE COASTING) WITH NO ISSUE BUT STALL AGAIN AFTER A SHORT WHILE. THESE HAVE BEEN VERY HARROWING EXPERIENCES ON BUSY ROADS AND FORTUNATE THAT IT WAS ME AND NOT MY PREGNANT WIFE, AS I DON'T BELIEVE SHE WOULD HAVE HAD THE STRENGTH TO EXECUTE THESE EMERGENCY ACTIONS WITH NO POWER. THE CAR HAS BEEN AT THE FORD DEALERSHIP FOR >1 WEEK BUT THEY HAVE FAILED TO REPLICATE THE PROBLEM. THE CAR REMAINS AT THE FORD DEALERSHIP UNTIL THE CAUSE CAN BE DETERMINED. *TR

SON CAME HOME FROM COLLEGE. BANGING NOISE NOTICED WHEN SISTER RIDING WITH HIM COMING FROM RIGHT REAR OF VEHICLE. UPON INSPECTION AT OIL CHANGE GARAGE IT WAS NOTICED THAT RIGHT REAR SHOCK MOUNT HAD COMPLETELY CORRODED AND BROKEN OFF FROM THE WHEEL WELL SHEET METAL. VEHICLE NOT DRIVABLE IN THAT CONDITION AS WHEEL COULD POSSIBLY BREAK OFF OR AT THE LEAST POOR HANDLING OF VEHICLE. ONLINE SEARCH CAME UP WITH SIMILAR COMPLAINTS FOR 2003/2004/2005 ESCAPES. CALLED FORD BUT NO RECALL HAS BEEN ISSUED SO OWNERS OUT OF LUCK FOR VERY EXPENSIVE FIX. *TR

IT WAS LAST FRIDAY WHEN I ALMOST REAR ENDED SOMEONE. THE SPEED CONTROL RECALL IS NOT FIXED. I WENT TO KEITH HAWTHORN FORD ON SOUTH BLVD, HERE IN CHARLOTTE, LAST YEAR, AND WAS TOLD THAT THEY HAD TO ORDER A PART. I WAITED A FEW WEEKS, THEN I CALLED THEM AGAIN, AND WAS TOLD THAT THE PART WAS IN, I TOOK MY CAR IN, AND IT DID NOT TAKE 40 MINUTES THE CAR WAS READY. I DON'T KNOW WHAT THEY DID BUT I AM STILL HAVING ISSUES WITH SPEED. IT IS VERY SCARY. THIS IS ALL THE TIME, NOT JUST LAST FRIDAY. *TR

THE CAR STALLS AFTER PUTTING IT IN GEAR / *TR

MY DAUGHTER NOTICED HER ESCAPE WASN'T DRIVING RIGHT IT WAS TRAVELING SIDEWAY`S DOWN THE HIGHWAY, I NOTICED HER FRONT TIRE`S WERE WORN, ESPECIALLY THE PASSENGER`S FRONT, IT WAS WORN ON THE OUTSIDE. I SPOKE WITH A FORD MECHANIC THAT SUGGESTED NEW TIRE`S AND A FRONT END ALIGNMENT, SHE HAD THAT SERVICE DONE, WHICH DID NOT MAKE THE VEHICLE DRIVE ANY DIFFERENTLY. SHE THEN TOOK THE VEHICLE BACK IN FOR SERVICE IN WHICH NOW THE VEHICLE WAS DOG TRACKING WHEN DRIVING AND WAS THEN INFORMED THAT THE WHEEL WELL`S WERE TOTALLY RUSTED THROUGH AND THAT THEY WOULD NOT REPLACE THE REAR SHOCKS BECAUSE OF IT. THERE ARE SEVERAL HUNDREDS OF OTHER FORD ESCAPE OWNERS WHOM HAVE EXPRESSED THE SAME CONCERN. THE WHOLE REAR END HAS APPARENTLY SHIFTED OUT OF LINE, BECAUSE OF THE RUSTED OUT WHEEL WELL`S THAT ATTACH TO THE SHOCK`S TO HOLD THE REAR END IN ALIGNMENT. THIS IS A HUGE SAFETY ISSUE, AND FORD IS NOT DOING ANYTHING ABOUT IT. THIS ISSUE DOE`S NOT JUST INCLUDE 2004 MODEL`S , IT HAS ALSO BEEN BROUGHT TO MY ATTENTION, THAT EVEN A NEW 2013 MODEL HAS THE SAME PROBLEM. PLEASE HAVE THIS ISSUE INVESTIGATED IT IS A SERIOUS SAFETY ISSUE. *TR

AS I WAS SITTING IN MY CAR WITH MY 9 YEAR OLD IN THE BACKSEAT, IN PARK, WITH THE ENGINE ON, WAITING FOR MY OLDER SON, WE HEARD A LOUD EXPLOSION AND THE BACK WINDSHIELD HAD SHATTERED INTO A MILLION PIECES. I THOUGHT SOMEONE HAD SHOT OR THROWN SOMETHING AT THE CAR BUT ONCE I GOT OUTSIDE AND LOOKED AT IT I COULD TELL BY THE WAY THE GLASS HAD BLOWN OUTWARD (FOR THE MOST PART) THAT SOMETHING THAT I COULD NOT EXPLAIN MUST HAVE HAPPENED/MALFUNCTIONED WITH THE WINDSHIELD. IT WAS VERY SCARY AND, AS I WAS A HALF HOUR FROM HOME AND IT WAS RAINING, PRETTY INCONVENIENT. THE EXPLOSION WAS SO FORCEFUL THAT IT DAMAGED BOTH THE REAR WIPER SYSTEM AND THE HYDRAULIC ARM WHICH LIFTS THE REAR WINDOW. I AM GLAD MY DOG WAS NOT TRAVELING IN THE BACK OF THE CAR AS PLENTY OF GLASS ENDED UP IN THE BACK OF THE CAR. ALSO, NOW I HAVE TO PAY FOR ALL OF THIS TO GET FIXED? THIS IS A PROBLEM. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT AFTER DRIVING THE VEHICLE A SMALL DISTANCE, SHE SMELLED A BURNING ODOR FROM UNDER THE HOOD. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 129,790. THE VIN WAS NOT AVAILABLE.

CAR'S ENGINE VIBRATED VIOLENTLY AND COMPLETELY STALLED GOING 45 MPH DOWN A HIGHWAY, ACCIDENT AVOIDED AS CAR BEHIND ME SLAMMED ON THE BRAKES. CAR WOULD NOT START, CHECK ENGINE LIGHT ON. TOWED VEHICLE TO FORD DEALERSHIP WHO FOND TWO ENGINE COILS DEFECTIVE AND ALL SPARK PLUGS REPLACED. THIS VEHICLE HAS REPEATED ISSUES WITH DEFECTIVE COILS AND DANGEROUS TO TRAVEL ON A HIGHWAY WHEN ENGINE ABRUPTLY STOPS. THIS IS POOR ENGINEERING ON FORD'S PART AND DEMAND THE US GOVERNMENT FORCE A RECALL! *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL KNOCKING NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THAT THEY COULD NOT PROVIDE ANY ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS 98,000.

I WAS DRIVING ON THE EXPRESSWAY. THE ROADS WERE CLEAR, FLAT, AND SMOOTH. OUTSIDE TEMP WAS IN THE 20'S. I HAVE BEEN DRIVING FOR ABOUT 30 MINUTES, AFTER LETTING THE VEHICLE WARM UP FOR 15 MINUTES, WHEN THE REAR WINDOW EXPLODED FOR NO REASON ON THE EXPRESS WAY. THERE WERE NO BRIDGES OR OVERPASSES FOR ANYTHING TO FALL ON IT. THE REAR WINDOW DEFOGGER HAD BEEN ON FOR ABOUT 15 MINUTES PRIOR. I RECENTLY PURCHASED THE VEHICLE USED FROM A PRIVATE PARTY. I HAD DRIVEN IT LESS THAN 200 MILES SINCE MY PURCHASE. APPROXIMATE TIME OF INCIDENT 16:36. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR CONSTANTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE SEAT BELT PRE-TENSIONER CONNECTORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 74,000. UPDATED 3/14/13 *CN