2011 Ford Escape Fuel System Problems

The fuel pump was replaced and a new one was installed and now the engine is misfiring really hard and when the vehicle is placed in drive or reverse the engine tries to stall. The mechanic is saying that I will have to purchase a fuel rail pressure sensor that controls the fuel to each fuel injector. If this item or the whole fuel system is on a Recall List. Then I shouldn't have to pay anything to have it repaired and replaced by the Dealership. I do need to be notified about this issue immediately. This is a 2011 Ford Escape XLT AWD 4dr SUV with 3.0 V6 Flex Fuel system.

Leaking gas from gas tank where the fuel delivery pipe enters the tank

The contact owns a 2011 Ford Escape. The contact stated that the fuel tank was leaking and there was an abnormally strong fuel odor inside and outside the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who confirmed the fuel leak. The mechanic applied epoxy to the leak, but the failure recurred. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 138,000.

The contact owns a 2011 Ford Escape. The contact stated that upon approaching the vehicle, the contact observed gasoline leaking underneath the fuel tank. The contact became aware of a crack in the gasoline tank seal. The contact stated that there was a constant odor of gasoline on the interior of the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 240,000.

I TRIED TO GET FUEL LATE AT NIGHT IN WINTER WARNING AFTER WORK AND UPON DOING SO, THE NOZZLE AT THE GAS STATION WOULD NOT FIT PROPERLY TO FUEL THE TANK. GAS BEGAN TO LEAK OUT AS I WAS FUELING THE VEHICLE, SQUIRTING UP ONTO MY BODY AND CLOTHING. I DID NOT UNDERSTAND WHY THE NOZZLE DID NOT FIT, HOWEVER I NEEDED DESPERATELY TO GET GAS SO THAT I COULD RETURN HOME IN A MOUNTAINOUS AREA WHERE I LIVE. I TRIED FILLING THE GAS TANK SLOWLY TO NO AVAIL. THEN I PROCEEDED TO ANOTHER GAS STATION AS THERE ARE NOT MANY AROUND, AND AGAIN NOZZLE WOULD NOT ENTER THE TANK. THIS TIME I COULDN'T EVEN TURN ON THE PUMP. AFTER INSPECTING THE SITUATION, I COULD SEE THAT THE FUEL TANK AREA LOOKED AS THOUGH THE HOLE FOR THE TANK NO LONGER ACCEPTED NOZZLES, THE FUEL FILLER AREA SEEMED TO HAVE SLIPPED AND I NOW I AM UNABLE TO GET GAS AT ALL. THERE WAS NO WARNING- THIS JUST HAPPENED SUDDENLY, PUTTING ME IN A DANGEROUS SITUATION, WITH GASOLINE ON MY CLOTHING, FREEZING TEMPERATURES AND NEARLY STRANDED. LUCKILY I HAD ENOUGH GAS TO GET HOME, HOWEVER I CAN NOT FUEL MY TANK AND THIS COULD HAVE BEEN A DIRE STRAIGHTS EMERGENCY.

I HAVE CALLED FORD MANY TIMES, AS I HAVE THE SAME PROBLEM ALL THE TIME, IT SHOWS THAT MY CAR HAS AN EVAPORATIVE EMISSION SYSTEM LEAK CODE P0457. THIS IS THE 4TH TIME THAT SHOWS THE SAME PROBLEM EVEN AFTER 'FIXING'. FORD ESCAPE HAD THIS RECALL IN 2016 BUT FOR SOME REASON I WAS NOT SENT A NOTICE.

THE GAS TANK IS FAULTY. SUDDENLY, IT WILL NOT HOLD GAS. GAS BEGAN TO POUR OUT AFTER I HAD FILLED THE TANK JUST A FEW MINUTES BEFOREHAND. I NOTICED THE GAS POURING OUT WHEN THE VEHICLE WAS STATIONARY AND PARKED IN OUR GARAGE. THERE HAS BEEN NO ACCIDENT OR EXTERNAL DAMAGE TO THE CAR TO CAUSE THIS ISSUE. I READ THAT SOME 2011 FORD ESCAPES WERE RECALLED FOR THIS VERY ISSUE, BUT MY VIN DOES NOT APPEAR IN THE DATABASE AND CUSTOMER SERVICE ADVISED THAT I FILL OUT THIS FORM.

THIS VEHICLE HAD A RECALL REGARDING THE FUEL DELIVERY MODULE REPAIRED IN MAY 2019 (BY CHAPMAN FORD IN HORSHAM, PA), JUST BEFORE I BOUGHT THE CAR IN JUNE. IN LATE AUGUST 2019, THE CAR WAS HAVING DIFFICULTY STARTING. I BROUGHT IT TO MY LOCAL FORD DEALERSHIP (FULLERTON FORD IN SOMERVILLE, NJ). THEY INSISTED CHAPMAN FORD DID A POOR JOB WITH THE RECALL REPAIR (SPECIFICALLY CONNECTING THE FUEL PUMP) AND FORD CORPORATE AUTHORIZED FULLERTON TO FIX CHAPMAN'S POOR WORK (FREE OF CHARGE FOR ME). A FEW DAYS AGO, THE VEHICLE FAILED TO START EVEN WHEN JUMP STARTED. THE LOCAL FORD DEALERSHIPS (MALOUF FORD IN NORTH BRUNSWICK, NJ AND FULLERTON FORD) SAID THEY DIDN'T HAVE AN OPENING TO WORK ON THE CAR FOR 3 WEEKS. I WANTED TO TAKE THIS VEHICLE TO A FORD DEALERSHIP BUT I CAN'T AFFORD TO BE OUT OF A VEHICLE FOR 3 WEEKS SO I TOOK THE CAR TO A PRIVATE SHOP (QUALITY AUTO CENTER IN FRANKLIN PARK, NJ) . THE PRIVATE SHOP DIAGNOSTICALLY PROVED THE FUEL PUMP NO LONGER WORKS. THE PRIVATE SHOP REPLACED THE FUEL PUMP AND THE VEHICLE NOW WORKS AGAIN. THIS IS INDEED AN OLDER VEHICLE, BUT I THINK THE TIMING IS ESPECIALLY SUSPICIOUS THAT THE FUEL PUMP FAILS SHORTLY AFTER IT HAS BEEN HANDLED MULTIPLE TIMES FOR RECALL REPAIR. FURTHERMORE, CHAPMAN FORD WAS DEEMED BY FORD CORPORATE TO DO A SUBPAR RECALL REPAIR. I CALLED FULLERTON FORD AND FORD CORPORATE ABOUT POTENTIAL LIABILITY BUT THEY DIDN'T SEEM INTERESTED TO ENTERTAIN BECAUSE I WASN'T ABLE TO BRING MY CAR TO THE DEALERSHIP FOR INSPECTION.

The contact owns a 2011 Ford Escape. The contact stated that while operating the vehicle, the odor of fuel was present inside the cabin of the vehicle. Upon inspection, the contact discovered a crack in the fuel tank which caused the fuel leak. The cause of the failure was not yet determined, and the vehicle was not repaired. The local dealer was not contacted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 220,000.

RECEIVED NOTICE OF RECALL IN DEC 2017, CALLED KENDAL FORD IN ANCHORAGE FOR SCHEDULING OF REPAIR. THE SERVICE DEPARTMENT STATED THAT THEY DID NOT HAVE THE PART NEEDED AND WOULD CALL WHEN IT CAME IN. OCTOBER 2018, CALLED KENDALL AFTER RECEIVING SECOND NOTICE. THE SERVICE DEPT. SAID THEY'D CALL WHEN IT CAME IN. KENDALL FORD SERVICE DEPT. 866-957-4040. THIRD NOTICE RCVD 7/12/2019. CALLED AGAIN AND, TERESA, STATED THEY'D CALL WHEN THE PART CAME IN. THREE YEARS TO GET A PART IS OUTRAGEOUS. THE FORD DEALER HAS DEMONSTRATED BEYOND ANY DOUBT THAT THEY DON'T CARE ABOUT RECALLS, UNABLE TO BE TRUTHFUL, AND HAVE NO CONCERN ABOUT ANYTHING BUT MONEY.

I HAVE HAD ISSUES WITH A CHECK ENGINE LIGHT THAT LIGHTS UP ALL THE TIME ON THE CAR. IT WILL ALSO SAY "CHECK FUEL FILL INLET" WHEN I PUMP GAS. THE CODE READS P0455 WHICH MEANS THE ENGINE COMPUTER RECOGNIZES A LARGE LEAK IN THE EVAPORATIVE EMISSION CONTROL SYSTEM (EVAP). THE VEHICLE'S EVAP SYSTEM IS SEALED, IT'S MAIN PURPOSE IS TO PREVENT GASOLINE VAPORS IN THE FUEL TANK FROM ESCAPING INTO THE ATMOSPHERE. I AM NOT SURE IF ONE OF THE RECALLS PERTAINS TO THIS, BUT THIS IS AN ONGOING PROBLEM FOR ME. SO MUCH SO, THAT I HAVE STOPPED DRIVING THE CAR IN FEAR FOR MY SAFETY AND MY FAMILY.

EXPERIENCE SURGING AND STUMBLING UNDER THROTTLE UP

TL* THE CONTACT OWNS A 2011 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V777000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PHIL LONG FORD OF MOTOR CITY, 1212 MOTOR CITY DR, COLORADO SPRINGS, CO 80905, (719) 694-3487) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *TT *JS

TL* THE CONTACT OWNS A 2011 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V777000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (COURTESY FORD, 3921 W RIVER DR., DAVENPORT, IA 52802, (563) 326-4011) STATED THAT THE PART WAS NOT AVAILABLE FOR THE RECALL REMEDY AND DID NOT KNOW WHEN IT WOULD ARRIVE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

2011 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO FUEL PROBLEMS. *LD THE CONSUMER STATED THE PARTS WERE NOT AVAILABLE TO COMPLETE RECALL REPAIR. *JS

I RECEIVED A RECALL NOTICE FROM FORD DEC 2016 REFERENCING NHTSA SAFETY RECALL 16V-777. AUG 2017 I STILL HADN'T HEARD ANYTHING SO I ASKED FORD WHAT WAS GOING ON USING FORD WEBSITE LIVE CHAT. EBONEE SAID PARTS STILL NOT AVAILABLE. JAN 2018 GOT ANOTHER LETTER SAYING PARTS NOW AVAILABLE. CALLED DEALERSHIP THEN AND AGAIN TODAY 4/11/18 & THEY SAID STILL NOT AVAILABLE. VERY FRUSTRATED AND CONCERNED ABOUT WHAT MIGHT HAPPEN DUE TO POSSIBLE FUEL LEAK. WE WANT THIS FIXED BUT NO ONE SEEMS TO BE ABLE TO HELP.

I RECEIVED A RECALL ON MY 2011 ESCAPE IN LATE 2016 INFORMING ME ABOUT AN ISSUE WITH THE FUEL DELIVERY MODULE. I TOOK IT TO THE DEALERSHIP AT THE TIME, INFORMING THEM THAT I HAD BEEN NOTICING FUEL SMELLS, BUT THEY WERE UNABLE TO REMEDY THE ISSUE, OR PERFORM THE RECALL. IN JANUARY OF 2018 I RECEIVED ANOTHER LETTER SAYING THAT PARTS ARE NOW AVAILABLE TO REPAIR MY VEHICLE, BUT AS OF APRIL, TWO LOCAL DEALERSHIPS STILL SAY THEY HAVE NOT RECEIVED THE NECESSARY PARTS FOR THE REPAIR. THE SAFETY RECALL IS 16S41/NHTSA RECALL 16V-777. BASED ON THE SAFETY IMPLICATIONS OF THIS RECALL, IT SEEMS THAT FORD IS BEING VERY SLOW IN DELIVERING PARTS TO THE DEALERSHIPS TO MAKE THIS REPAIR.

TL* THE CONTACT OWNS A 2011 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V777000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR AS THE RECALL NOTICE WAS RECEIVED OVER A YEAR AGO. THE DEALER SMITH CAIRNS FORD LINCOLN (900 CENTRAL PARK AVE, YONKERS, NY 10704) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS CONTACTED SEVERAL TIMES AND WAS UNABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *TT

I RECEIVED A RECALL NOTICE IN JANUARY 2018. I CONTACTED MY LOCAL DEALER IN DANBURY, CT TO REPAIR MY VEHICLE. THEY ADVISED THEY DO NOT HAVE THE PART AND ARE WAITING. I CONTACTED THEM AGAIN 3/23/18 AND AM TOLD THEY STILL HAVE NOT RECEIVED THE PARTS NEEDED. THE NHTSA WEBSITE INDICATES THE PARTS ARE AVAILABLE BUT I AM TOLD I HAVE TO WAIT.

TL* THE CONTACT OWNS A 2011 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V777000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS FOR THE RECALL REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT NOTICED FUEL FUMES COMING FROM THE VEHICLE. THE DEALER (LUTHER NORTH COUNTRY FORD, 10401 WOODCREST DRIVE NW, COON RAPIDS, MN 55433, 612-424-7648) SCHEDULED AN APPOINTMENT TWICE; HOWEVER, WHEN THE CONTACT ATTEMPTED TO CONFIRM THE APPOINTMENTS, THEY WERE MOVED FURTHER BACK. THE LAST TIME THE CONTACT ATTEMPTED TO SCHEDULE AN APPOINTMENT, THE DEALER WAS UNABLE TO PROVIDE ANOTHER DATE FOR THE REPAIR BECAUSE THE MANUFACTURER WAS NOT PROVIDING PARTS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. PARTS DISTRIBUTION DISCONNECT.