2000 Ford Expedition Complaint Log

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN PARK, THE VEHICLE STARTED TO ROLL AWAY IN REVERSE. THE CONTACT WAS ABLE TO JUMP BACK INTO THE VEHICLE AND APPLY THE EMERGENCY BRAKE. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR LOCAL MECHANIC FOR A DIAGNOSTIC TEST. THE CONTACT STATED IT WAS DIFFICULT TO SHIFT THE VEHICLE INTO PARK. THE FAILURE MILEAGE WAS 162,835.

WHILE VEHICLE IS OFF THE HEATER BLOWERS WILL TURN ON AND RUN BATTERY DOWN. WHILE DRIVING 4X4, WASHER LIGHTS, POWER WINDOWS, RADIO, INTERIOR LIGHTS ALL TURN OFF AND ON. RADIO WORKS WHILE IN PARK BUT, POWERS DOWN WHEN VEHICLE IS PUT IN GEAR. HAVE HAD ISSUES WITH WATER GETTING IN AND RUNNING DOWN DRIVERS SIDE. APPEARS ALOT OF PEOPLE ARE HAVING THE SAME ISSUE. BOUGHT THE VEHICLE IN 2001 JUST STARTED HAVING THESE ISSUES WITHIN THE PAST YEAR STARTED OUT SLOW BUT ARE GETTING WORST AND MORE FREQUENT. *TR

VEHICLE SITTING IN DRIVEWAY AFTER 2 DAYS OF RAIN. WENT TO START UP VEHICLE AND BATTERY DEAD. TOOK BATTERY OUT TO BE TESTED AND TESTED FINE. SPENT $165 ON ALTERNATOR REPLACEMENT. VEHICLE DEAD AGAIN NEXT MORNING. CHARGED BATTERY STARTED VEHICLE UP. NOTICED WATER IN FLOORBOARDS AND HEADLINER. WHEN KEY WAS REMOVED FROM IGNITION, RADIO WAS STILL ON AND DOOR WOULD STILL DING AS IF KEY IN IGNITION. BATTERY DEAD AGAIN SEVERAL HOURS LATER. AFTER DOING RESEARCH, WAS EXTREMELY FRUSTRATED TO LEARN THE ISSUE IS VERY WELL DOCUMENTED WITH IMPROPERLY SEALED WINDSHIELDS. RATHER THAN FORD PAYING TO RESEAL OR INFORM CONSUMERS TO FIX OUT OF THEIR OWN POCKETS, THEY ALLOWED CONSUMERS TO EXPERIENCE DREADFUL ELECTRICAL MALFUNCTIONS WITH VEHICLE. WITHOUT GOING TO MECHANIC, I REMOVED BOTH THE GEM MODULE AND FUSE BOX. PUT FAX IN VEHICLE TO SPEED UP THE DRYING PROCESS. ALLOWED FUSE BOX TO SIT INSIDE FOR A WEEK AND ORDERED A GEM MODULE OFF THE INTERNET. CLEANED CORROSION FROM FUSE BOX/GEM CONNECTORS AND REPLACED GEM MODULE. VEHICLE PERFORMS MUCH BETTER. THINGS THAT HAVEN'T WORKED IN YEARS (AUTO LOCKS) NOW WORK. HOWEVER, RADIO LOSES POWER INTERMITTENTLY WHICH IS FRUSTRATING. I OWN 2 FORDS AND AM A VERY VERY DISAPPOINTED CONSUMER THAT SOMETHING THAT COULD HAVE BEEN FIXED FOR $100 HAVE COST LOYAL CONSUMERS THOUSANDS. *TR

WHILE PICKING UP SPEED FROM A STOP LIGHT MY TRUCK WENT INTO 4X4 BY ITSELF AND LOCKED UP MY TIRES. I WAS ABLE TO GET IT OFF THE ROAD AND CALLED TRIPLE A FOR A TOW. WE UNHOOKED THE BATTERY AND IT SEEMS TO BE WORKING NOW. ALSO HAVE ELECTRICAL PROBLEMS AS WELL. MY ODOMETER SOMETIMES WORKS SOMETIMES DOESN'T, MY RADIO VOLUME GOES UP WHEN YOU TURN IT DOWN. *TR

MY 2000 FORD EXPEDITION WILL NOT STAY IN PARK. AND WHEN IT IS IN PARK AFTER A COUPLE MINUTES IT WILL JUST GO BACKWARDS. MY FORD HAS ALREADY HIT A PARKED VEHICLE. I WAS WARMING HER UP. I GOT OUT TO SHUT MY BACK HATCH IT JUST TOOK OFF BACKWARDS WHILE STILL IN PARK AND HIT ANOTHER VEHICLE. I TRIED JUMPING IN THE MY TRUCK PUT WAS DRAGGED AND UNABLE TO STOP IT. I DON'T FEEL SAFE BUT HAVE NO CHOICE BUT TO DEAL WITH THIS ISSUE. MANY MECHANICS LOOKED AT IT SAID THEY DON'T KNOW WHAT'S CAUSING THE PROBLEM. *TR

EXPEDITION CAUGHT ON FIRE IN MY MOM'S DRIVEWAY ABOUT 8:30 P.M. IT HAD BEEN PARKED FOR ABOUT 3 HOURS AND FLAMES BEGAN COMING FROM THE VEHICLE. MY MOMS NEIGHBOR THAT LIVES IN THE NEXT BLOCK SAW THE FLAMES AND CAME TO TELL US THAT MY VEHICLE WAS ON FIRE. I CALLED 911. THE POLICE DEPARTMENT BLOCKED THE STREET FOR THE FIRE DEPARTMENT. THE FIRE DEPARTMENT GOT HERE AND EXTINGUISHED THE FLAMES. *TR

INTERIOR LIGHTS AND DIGITAL ODOMETER LIGHT GOES OUT AND THEN COME BACK ON EVERY NOW AND THEN. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN A RESIDENTIAL DRIVEWAY. AS HE STARTED THE ENGINE, HE NOTICED BLACK SMOKE AND THEN FLAMES COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE SPEED CONTROL LIGHT WAS ILLUMINATED AT THE TIME OF THE FAILURE. THE CONTACT ATTEMPTED TO RAPIDLY EXIT THE VEHICLE AND FELL, INJURING HIS BACK, LEG AND FOOT. THE FIRE DEPARTMENT WAS NOTIFIED WHO ARRIVED TO EXTINGUISH THE FIRE. A FIRE REPORT WAS NOT AVAILABLE. THE VEHICLE WAS DESTROYED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACTS VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT WAS TAKEN TO THE HOSPITAL. THE CONTACT SUSTAINED BACK AND NECK INJURIES. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. PAM...UPDATED 07/02/14 *BF NO AMENDED TEXT. 07.03.14

AS I WAS SLOWING TO STOP AT A STOP SIGN THE ENGINE MADE AN EXTREMELY LOUD NOISE. AFTER INVESTIGATING WE FOUND A SPARK PLUG LOOSE UNDER THE HOOD. THE SPARK PLUG BLEW OUT OF THE HEAD AND STRIPPED OUT THE THREADS. AFTER LOOKING THIS UP ON THE INTERNET I FOUND IT HAPPENS OFTEN BUT THAT THERE HAS BEEN NO RECALLS. MY EXPEDITION HAS A TRITON 5.4 ENGINE. *TR

WE ARE THE LIEN HOLDER ON A 2000 FORD EXPEDITION. OUT CUSTOMER SAID THAT HIS VEHICLE EXPLODED BESIDE HIS MOBILE HOME AFTER SITTING THERE FOR 2 DAYS. THE MOBILE HOME RECEIVED BURN DAMAGES BUT WAS NOT A TOTAL LOSS. THE CAR WAS A TOTAL LOSS AND BURNED ALL OF THE CAR. OUR CUSTOMER SAID THAT THE VEHICLE HAD TWO MORE EXPLOSION AFTER THE FIRST ONE. ALL THE EXPLOSION WERE IN THE ENGINE COMPARTMENT. THE SHERIFF''S DEPARTMENT LISTED THE INCIDENT STATUS AS UNFOUNDED. NO ONE WAS INJURED. *TR

WHEN MAKING A RIGHT TURN ONTO A HIGH-TRAFFIC, FOUR-LANE SURFACE STREET, BOTH REAR LOWER CONTROL ARMS FAILED UNDER ACCELERATION. THIS FAILURE CAUSED THE REAR AXLE TO TWIST, THE REAR DIFFERENTIAL TO SHIFT POSITION, AND FOR THE DRIVE SHAFT U-JOINTS TO BIND. THE RESULT WAS AN EFFECTIVE LOSS OF POWER AND AN IN INABILITY TO ACCELERATE TO MATCH TRAFFIC FLOW. SEVERAL VEHICLES HAD TO BRAKE HARD OR SWERVE INTO THE ADJACENT LANE TO AVOID THE OBSTRUCTION MY VEHICLE CREATED. *TR

EXHAUST MANIFOLDS LEAKING AND FUMES ENTERING VEHICLE. *TR

CAR CAUGHT ON FIRE IN THE MIDDLE OF THE NIGHT, REASON UNKNOWN BUT APPARENTLY IT HAD TO DO WITH A RECALL ON THE CRUISE CONTROL SWITCH . WE NEVER RECEIVED ANY LETTER'S OR NOTICES OF THE FOLLOWING RECALL. VEHICHLE WAS DESTROYED AND WE ALSO HAD PROPERTY DAMAGE TO CARPORT AND HOUSE TOTALLING $40,000. *TT

I HAVE HAD NO PROBLEMS WITH MY 2000 FORD EXPEDITION UNTIL MAY 25, 2012. I HAD TAKEN MY HUSBAND AND DAUGHTER TO MY PARENT'S HOUSE AND WAS GOING TO GO INTO TOWN. I WAS ABOUT 50 FEET FROM THE STOP SIGN WHEN I SUDDENLY HEARD A LOUD BANG AND MY VEHICLE STARTED SOUNDING LIKE A LAWNMOWER! I WAS NOT SURE WHAT HAD HAPPENED AND WAS AFRAID IF I TURNED OFF THE VEHICLE IT WOULD NOT RESTART, YET I DIDN'T WANT TO LEAVE IT TO CONTINUE TO RUN BECAUSE I DID NOT WANT TO FURTHER DAMAGE THE MOTOR. LUCKILY, SINCE I WAS ONLY A BLOCK AWAY, I JUST DECIDED TO DRIVE IT RIGHT BACK TO MY PARENT'S HOUSE; WHERE I HAD TO HAVE AAA COME AND TOW IT BACK TO MY TOWN TO THE SHOP. COME TO FIND OUT, I BLEW THE #3 SPARK PLUG. I WAS NOT AWARE OF THIS EVER HAPPENING; BUT I AM NOW. I DRIVE MY CHILDREN TO AND FROM SCHOOL EVERY DAY IN THIS VEHICLE. NOW I AM AFRAID TO DRIVE IT BECAUSE I AM AFRAID IT WILL HAPPEN AGAIN, AND I AM NOT IN A POSITION TO BUY A NEW VEHICLE. FORD SHOULD OWN UP TO THIS DESIGN FLAW IN THEIR MOTORS. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT THE AIR CONDITIONING FAILED. THE CONTACT HAD THE COMPRESSOR AND ALL OF THE AIR CONDITIONING UNIT COMPONENTS REPLACED, BUT TO NO AVAIL. THE MECHANIC THAT PERFORMED THE REPAIRS STATED THAT A RELAY CAUSED THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 196,000. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION XLT. THE CONTACT WAS TRAVELING 35 MPH WHEN SMOKE WAS SEEN COMING FROM THE VENTS AND NEAR THE ACCELERATOR. THE CONTACT PULLED OVER IN A NEARBY PARKING LOT AND EXITED THE VEHICLE. THE VEHICLE THEN BURST INTO FLAMES. THERE WERE NO INJURIES. A POLICE AND FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE YARD. THE FAILURE MILEAGE WAS 100,000.

THE 2000 EXPEDITION EDDIE BAUER WAS PURCHASED WITH 117,208 MILES FROM RON MARHAUFER AUTOMALL INC IN THE YEAR 2011. IN THE LAST SIX MONTHS I HAVE EXPERIENCED NUMEROUS ELECTRICAL ISSUES WITH THIS VEHICLE. I HAVE SPENT OVER $1000.00 DOLLARS REPLACING NUMEROUS PARTS EX: TWO ELECTRICAL COILS AND A ALTERNATOR. THE VEHICLE WILL RUN OK, I NOTICED THAT IF I DRIVE AND STOP AND PARK TWO TOO THREE TIMES, THE AUTO WILL NOT START RIGHT AWAY. I HAVE TO CONTINUALLY TAKE THE CAR OUT OF GEAR AND RETURN THE GEAR SHIFTER TO PARK. THE AUTO WILL THEN START. I ALSO NOTICED THAT THE DASH LIGHTS WILL ILLUMINATE TO BRIGHT ON THEIR OWN WHILE DRIVING. I AM CONCERNED THAT THE FORD MOTOR COMPANY IS AWARE OF THESE ISSUES AND HAVE FAILED TO RECALL ALL AFFECTED VEHICLES. I HAVE SEEN MANY COMPLAINTS FRO THE SAME REASON. WHAT IS THE SOLUTION? *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THE VEHICLE CAUGHT FIRE WHILE IT WAS PARKED. THE FIRE CAUSED DAMAGE TO THE CONTACTS HOME. THE FIRE DEPARTMENT WAS PRESENT, AND STATED THE FIRE ORIGINATED IN THE ENGINE AREA. THE VEHICLE WAS TOWED FOR FURTHER INVESTIGATION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE HE NOTICED A LOUD NOISE AND FOUND THAT THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE CAUSED DAMAGE TO THE RESIDENTIAL GARAGE, A NEIGHBORING HOME AND ANOTHER VEHICLE. THE POLICE AND THE FIRE DEPARTMENT WERE CONTACTED AND A REPORT WAS FILED. THE FIRE DEPARTMENT WAS UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC PENDING AN INVESTIGATION. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 165,000.

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DETECTED THAT THE REAR LOWER CONTROL ARMS WERE COMPLETELY RUSTED AND CORRODED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER, WHERE THE REAR LOWER CONTROL ARMS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT EXPRESSED CONCERN OF THE POTENTIAL SAFETY HAZARD. THE APPROXIMATE FAILURE MILEAGE WAS 290,000.

I BEGAN NOTICING ELECTRICAL PROBLEMS WITH THE LIGHTS GOING ON AND OFF, DASH GAUGES GOING ON AND OFF, RADIO GOING ON AND OFF, HEATER GOING ON AND OFF, DOOR ALARM STAYING ON WHEN DRIVER'S DOOR IS OPEN, BUT NO KEY IN IGNITION OR LIGHTS ON, DOOR LOCKS NOT WORKING PROPERLY, 4WD ENGAGING AUTOMATICALLY, CD PLAYER GOING OFF AND ON, WINDSHIELD WIPERS GOING ON AND OFF, AND WATER ON DRIVER'S SIDE FLOOR AFTER RAINS. IT HAS BECOME MORE OF A PROBLEM. I DID NOT KNOW WHAT WAS CAUSING THE PROBLEMS UNTIL I BEGAN REPLACING PARTS AND FOUND ON THE INTERNET THAT THIS HAS BEEN A KNOWN PROBLEM WITH THE EXPEDITION AND FORD BEING AWARE OF THE PROBLEM FOR MANY YEARS. I JUST WROTE THE FORD COMPANY AND THEY TOLD ME THEY KNEW NOTHING ABOUT SUCH PROBLEMS!!! REFERENCE NUMBER IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DURING RAINY PERIODS THE STEREO AND WINDHSHIELD WIPERS WILL TURN OFF AND ON BY THEMSELVES. IF THE TRUCK IS TURNED OFF THE STEREO AND AC WILL STAY ON AND LOCKS WILL LOCK AND UNLOCK BY THEMSELVES. SMOKE COMES UP FROM THE STEERING WHEEL. THE TURN SIGNALS WILL BLINK A FEW TIMES THEN STOP BLINKIN BUT THE LIGHT WILL STAY ON. *JS

THE FORD EXPEDITION MODEL YEAR 2000 WAS PARKED IN THE GARAGE FOR APPROXIMATELY 3 HOURS ON THE EVENING OF FEBRUARY 13,2012. THE FAMILY WENT TO BED AND WAS AWAKENED AROUND 8:30PM BY A POLICE OFFICER WHO HAD KICKED THE FRONT DOOR OF THE RESIDENCE IN TO INFORM US OUR GARAGE WAS ON FIRE. THE SMOKE HAD NOT YET ENTERED THE HOME BUT SOME FUMES WERE THOUGHT TO BE COMING THROUGH THE DUCT SYSTEM CAUSING US TO SLEEP MORE DEEPLY. WE GOT OUT OF THE HOUSE AND CROSSED THE STREET BY THAT TIME THE GARAGE WAS FULLY ENGAGED IN FLAMES. THE METAL GARAGE DOORS MELTED WITH THE HEAT. LATER WHEN THE FIRE WAS PUT OUT THE FIRE CHIEF DID AN INVESTIGATION TO SAY THE FIRE ORIGINATED IN THE FORD BEHIND THE LOCATION OF THE BATTERY. THE INSURANCE COMPANY SENT OUT SPECIALISTS WHO SAID IT WAS THE SPEED CONTROL MODULE THAT WAS THE CAUSE OF THE FIRE. MY FAMILY HAS BEEN DISPLACED FOR 3-6 MONTHS WHILE REPAIRS ARE DONE TO THE HOUSE. BOTH OF OUR VEHICLES WERE IN THE GARAGE AND WERE A TOTAL LOSS FROM THE FIRE. THE OWNER OF THE VEHICLE WAS A CARPENTER AND LOST ALL OF HIS TOOLS FROM THE FIRE. *TR

AFTER A MODERATE RAIN, WHILE DRIVING ON THE HIGHWAY, THE WIPERS, DEFROSTER AND WINDOWS STOPPED WORKING AND THE RADIO BEGAN BLINKING IN AND OUT. SINCE THIS INCIDENT, IT SEEMS THAT AFTER ANY RAIN, THE ELECTRICAL SYSTEM GOES CRAZY, I HEAR RELAYS CLICKING UNDER THE DASH, THINGS DON'T WORK WHEN TURNED ON, OR DO WORK WITH THEM TURNED OFF. SEVERAL TIMES THE BLOWER FOR THE HEAT WOULD KEEP OR TURN ON AFTER I SHUT THE TRUCK OFF. ABSOLUTELY A SAFETY HAZARD THAT SHOULD BE RECALLED IF THIS IS THAT COMMON A PROBLEM. > ALSO MY MECHANIC SAID IT WILL COST UPWARDS OF $1000 TO FIX THIS PROBLEM AND NOT GUARANTEED NOT TO HAPPEN AGAIN. *TR

MY HUSBAND WAS INVOLVED IN A ROLLOVER ACCIDENT ON HIS WAY TO WORK. HIS AIR BAGS DID NOT GO OFF. THANK GOD NO ONE ELSE WAS INJURED OR KILLED. HE HAS BRUISED RIBS, A HEAD INJURY, CONCUSSION AND ABRASIONS ON HIS HEAD. HE HAD BRUISES AND SCRATCHES ON HIS NECK. HE HAD BRACED HIMSELF ON THE STEERING WHEEL, HOPING THE AIR BAG WOULD GO OFF AND NEVER DID. FORD TOOK THE CLAIM BUT HAVE NOT HEARD FROM THEM THUS FAR. WE HAVE HEARD THIS IS NOT THE FIRST TIME AIR BAGS HAVE NOT GONE OFF. HE IS LUCKY TO BE ALIVE. THE VEHICLE IS TOTALED. *TR

I HAVE A 2000 FORD EXPEDITION THE PAST 3 DAYS WE HAVE HAD HARD RAINS. I WENT OUT TO MY CAR AND FOUND THAT THE FLOOR ON BOTH THE DRIVERS SIDES AND PASSENGER SIDE OF THE SUV WAS FLOODED. MY RADIO WAS ON THE CAR WAS NOT. THE DASH LIGHT WERE GOING CRAZY. I STARTED THE CAR TO MOVE IT SO THAT I COULD GET IT NEAR AN OUTLET TO USE THE WET VAC TO REMOVE THE WATER AND THE WIPERS WOULD NOT WORK. I REMOVED THE WATER FROM THE FLOORS AND WHEN I WENT TO MOVE MY EXPEDITION IT WOULD NOT START IT SEEMS THAT IT IS LEAKING FROM THE WINDSHIELD. I NOTICED THAT THERE ARE ALOT OF COMPLAINTS ON WATER LEAKAGE ON EXPEDITIONS. NOW I AM WORRIED THAT THE WATER MAY HAVE SHORTED OUT THE ELECTRICAL SYSTEM. *KB

I THOUGHT WHEN I BOUGHT THIS CAR THAT I WOULD HAVE A VEHICLE TO TAKE MY SON TO GET HIS CHEMOTHERAPY BUT I THOUGHT WRONG! IT STARTED WITH THE AIR SUSPENSION THAT DROPPED TO THE GROUND WHEN MY SHOCKS GAVE OUT AND THE REAR AIRBAGS COULDN'T HOLD THE WEIGHT OF THE VEHICLE BUT I WAS SITTING IN THE CAR RIDER LINE AT MY SON'S SCHOOL AT A DEAD STOP WHEN THEY DECIDED TO GO. (SO MUCH EASIER TO LOOK THE FOOL) WE THEN FOUND HOSES THAT HAD CORRODED APART THAT WERE VACUUM HOSES AND THINKING THAT WAS THE PROBLEM WE FIXED THEM. IT WASN'T THE PROBLEM. I DIDN'T KNOW THEN THAT MY SHOCKS WERE COMPLETELY GONE UNTIL WE WERE JACKING UP THE CAR AND REMOVING THE BACK TIRES TO INSPECT THE AIRBAGS BETTER WHEN WE SAW THAT THE RUST HAD COMPLETELY TAKEN OVER THE WHOLE UNDER CARRIAGE. NOW I HAVE FRONT & REAR TRAILING ARMS THAT HAVE NUMEROUS HOLES FROM THE RUST EATING THROUGH THEM, ALONG WITH THE FUEL TANK STRAPS THAT HAVE ALMOST ROTTED THEMSELVES LOOSE, AND ALMOST COMPLETELY BROKEN BALL JOINTS. I WANT TO KNOW WHO IS COMING TO TAKE MY SON TO GET HIS CHEMO SINCE I DON'T HAVE THE MONEY TO RUN OUT AND BUY A NEW CAR? I GIVE MY CASH TO FORD TO KEEP MY CAR AFLOAT. I HAVE HAD THIS CAR FOR 10 MONTHS AND I OWE $2800 BUT THE THING IS THAT IT COST MORE FOR ME TO FIX EVERYTHING AND REPLACE ALL DRY ROTTED LINES, RUST, ECT AND BUY COIL SPRINGS WHICH I HEAR NOW HAVE AS MANY PROBLEMS. IS FORD GOING TO PAY FOR MY SON A NEW CAR SINCE IT IS LIKE THIS ONE WOULD BE TOTALED SINCE IT COST MORE TO FIX THAN IT'S WORTH? NO, THEY DON'T CARE AND I HOPE WHEN THEY GO HOME AFTER READING THIS THEY CAN LOOK THEIR OWN CHILD IN THE FACE KNOWING THAT MY SON DOESN'T HAVE A RIDE TO CHEMO 30 MILES AWAY! I GUESS IT WILL TAKE WRECKING MY CAR ACCIDENTALLY AND KILLING THE CHILD I FOUGHT FOR 10 YRS TO KEEP ALIVE FOR INSURANCE TO PAY FOR IT OR IS FORD GOING TO HAVE HEART DOING THE RIGHT THING BY RECALLING THE THINGS THEY KNOW IS THEIR FAULTS? *TR

WE HAVE A 2000 FORD EDDIE BAUER EXPEDITION WITH 111,000 MILES. WE PURCHASED NEW &IT HAS BEEN GARAGED KEPT & ALWAYS WASHED AT THE CAR WASH AFTER A SNOW STORM. TOOK THE TRUCK FOR INSPECTION ON 8/15/11 AND WAS TOLD BY THE MECHANIC TO STOP DRIVING THE VEHICLE IMMEDIATELY DUE TO FAILURE OF THE LOWER CONTROL ARMS. WE WHERE ADVISED IF THE CONTROL ARMS BROKE A SERIOUS ACCIDENT COULD OCCUR, ESPECIALLY @ HIGHWAY SPEEDS. THE UPPER CONTROL ARMS ARE BEGINNING TO SHOW SIGNS OF CHIPPING OF THE POWDER COATING WHICH WILL MORE THAN LIKELY LEAD TO PREMATURE FAILURE. WE HAVE RESEARCHED THIS ISSUE ON LINE & FOUND THAT THERE ARE OTHERS WHO ARE ALSO EXPERIENCING THE SAME ISSUE WITH THE RUSTING OF THE LOWER CONTROL ARMS. THE TRUCK IS NOW SITTING IN OUR GARAGE & WE ARE WAITING FOR DELIVERY OF THE BOTH THE LOWER & UPPER CONTROL ARMS. SEEMS LIKE THERE IS SOME SORT OF RUST ISSUES W/ THEM FOR THOSE OF US WHO LIVE IN THE SNOW BELT REGION. *TR

BRAKE LINES FAILED AND LOST 90% OF BRAKE POWER.

I WENT APPROX. 3 MILES WHEN SMOKE STARTED TO COME OUT OF THE HEATING VENTS IN MY 2000 FORD EXPEDITION. A FEW SEC. AFTER THE TRUCK BEGAN TO SMOKE FLAMES WERE STARTING TO COME OUT OF THE AREA BY THE DRIVERS SIDE FEET. UNDER THE DASH. MY HUSBAND PUT OUT THE FIRE AND SUSTAINED SEVERE 2ND DEGREE BURNS ON HIS FORE ARM HAND WRIST AND CHIN. HE WAS ABLE TO SEE THE FIRE STARTED BY CORRODED WIRES UNDER THE KICK PLATE. ALL THE WIRES HAVE MELTED AND NOW 4X4 ISN'T WORKING WINDOWS ARE NOT WORKING LIGHTS INSIDE OF TRUCK STAY ON HEADLIGHTS STAY ON NO TAIL LIGHTS NO DASH LIGHTS POWER WINDOWS AND DOOR LOCKS NO LONGER WORK, SPEAKER ON DRIVER SIDE DOES NOT WORK. HAZARD LIGHTS DO NOT BLINK THEY JUST STAY ON. TEMP IN THE TRUCK READS 140 DEG. F. WE HAVE NOT YET HAD THIS LOOKED AT. I HAVE AN APPT WITH A FORD GARAGE ON MONDAY TO SEE IF THIS WAS A RECALL ISSUE. *TR

WELL FIRST IT WAS THE HORN THAT HAS BEEN REPLACED SEVERAL TIMES AND NOW ALL OF THE SUDDEN CRUISE CONTROL DOESN'T WORK. I WAS ANNOYED ABOUT THE HORN, BUT NOW THE CRUISE CONTROL... SEEMS LIKE SOMETHING IS WRONG WITH THAT HORN AND CRUISE CONTROL SET UP.... AND I WAS WONDERING ABOUT THE PAINT BECAUSE IT IS ALSO PEALING LIKE CRAZY... *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION EQUIPPED WITH GOOD YEAR TRACKER2 TIRES, SIZE: P265-70-R17 (SERIAL NUMBER: 48570555000). THE CONTACT STATED THAT ALL FOUR TIRES WOULD CONSTANTLY LOSE AIR, CAUSING THE TIRES TO BECOMES FLAT WITHOUT WARNING. THE TIRES WERE REPLACEMENT TIRES. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE TWO TIRES WERE REPLACED, HOWEVER THE FAILURE ALSO OCCURRED WITH THE REPLACEMENT TIRES. THE TIRE FAILURE MILEAGE WAS 11,000 AND THE VEHICLE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 165,713. UPDATED 8/15/13 *CN THE CONSUMER STATED HE HAD TO REPLACE THE TIRES AFTER 1 1.2 YEARS. DURING THAT TIME PERIOD, SHE EXPERIENCED TEN TIRE INCIDENTS.

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION EDDIE BAUER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND SITTING IDLE WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE AND ADVISED THAT THE ORIGIN WAS AT THE ENGINE. A FIRE REPORT WAS AVAILABLE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) AND SHOULD HAVE BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

DRIVE A 2000 FORD EXPEDITION WITH YOKOHAMA GEOLANDER H/T S P265/70R17 AND HAD BLOWOUT OF ONE TIRE ON THE INSIDE SIDEWALL. EXTENDED OVER 15 INCHES AND WAS CLOSE TO THE RIM AS EVIDENCED IN MOST BLOWOUTS. THE CAR WAS PARKED FOR ABOUT 2 HOURS AFTER A TIRE ROTATION WHEN IT RUPTURED ABRUPTLY. RESULTED IN A TEAR OF ABOUT 12 INCHES AND THEN ENDED IN AN EXTENSION TO THE TREAD. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE OPERATING THE PASSENGER SIDE SEAT BELTS ON THE SECOND AND THIRD ROW SEATING, THE CONTACT NOTICED THE SEAT BELT RETENTION SYSTEMS WERE NOT FUNCTIONING. THE SEAT BELTS WOULD NOT TIGHTEN AND HOLD IN PLACE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 102,000.

WHILE DRIVING VEHICLE AT 15 MPH HEARD A CLUNK UNDER THE VEHICLE. STOPPED AND WHEN TRYING TO MOVE HEARD A LOUD POPPING/GRINDING SOUND. VEHICLE WAS TOWED TO FORD REPAIR SHOP. MECHANIC DOCUMENTED THAT BOTH REAR LOWER TRAILING ARMS HAD RUSTED ALL THE WAY THROUGH AND WERE BROKEN. MECHANIC ALSO NOTED THAT BOTH REAR UPPER TRAILING ARMS WERE VERY RUSTY. BOTH UPPER AND LOWER REAR TRAILING ARMS WERE REPLACED. OLD PARTS ARE AVAILABLE. *TR

SYMPTOM WAS A DEAD BATTERY. COURTESY LIGHTS WOULD NOT GO OFF. HARD FAILURE. ROOT CAUSE WAS LEAKING WINDSHIELD SEAL WHICH CORRODED ELECTRONICS. ACCORDING TO THE FORD SERVICE BULLETIN THIS WAS FIRST DISCOVERED WELL WITHIN THE FACTORY WARRANTY PERIOD OF THE VEHICLE. AN ONLINE SEARCH FOUND NUMEROUS SIMILAR COMPLAINTS ALONG WITH A FORD SERVICE BULLETIN FORD SPECIAL MESSAGE #15773. REPAIRS TO MY VEHICLE INCLUDED REMOVING AND REPLACING GEM AND CJB ALONG WITH RESEALING THE WINDSHIELD. I PURCHASED THE VEHICLE NEW IN APRIL 2000 AND IT HAS NEVER BEEN IN AN ACCIDENT. REPAIR COST WAS OVER $1400 FOR A LATENT DEFECT THAT HAS BEEN IN THE VEHICLE SINCE IT WAS BUILT. *TR

THE LOWER CONTROL ARMS ON THE REAR SUSPENSION HAVE EXCESSIVE RUST AND THEY BREAK OFF WITH ENGINE TORQUE OR THROTTLE. THE DRIVE SHAFT BREAKS OFF WHEN THE REAR AXLE ROTATES AND THIS LOCKS UP THE REAR AXLE, AND ALSO SNAPS THE EMERGENCY BRAKE CABLE. THE DAMAGES ARE UP TO 3500.00 DOLLARS AND CLIMBING. THIS IS HAPPENING ON ALL VEHICLES WHERE THE NEW ROAD SALT IS USED IN EXCESS. THIS SHOULD BE A MAJOR RECALL. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT WAS SHIFTING THE VEHICLE INTO REVERSE WHEN A SCREW DETACHED FROM THE STEERING COLUMN AND THE VEHICLE WOULD NOT MOVE IN REVERSE. THE VEHICLE WAS THEN SHIFTED INTO PARK BUT CONTINUED TO MOVE FORWARD. THE DRIVER ENGAGED THE PARKING BRAKE AND SHUT THE VEHICLE OFF. HE THEN ATTEMPTED TO RESTART THE VEHICLE BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED NOR REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 215,000.

I OWN A 2000 FORD EXPEDITION WITH A 5.4 LITER TRITON ENGINE WHICH EXPERIENCED A SPARK PLUG BLOW OUT. SO FAR, NHTSA HAS NOT REQUIRED FORD TO ISSUE A RECALL FOR A PROBLEM THAT MANY OTHERS HAVE HAD WITH THE SAME TYPE OF ENGINE. FORD DOES NOT ACCEPT RESPONSIBILITY FOR A DEFECTIVE DESIGN OF THIS ENGINE. I AM NOW FORCED TO PAY $3,000 TO FIX THE PROBLEM BEFORE I CAN EVEN CONSIDER TRADING IT IN OR TRYING TO SELL IT. *TR

2000 FORD EXPEDITION WAS TOTALED DUE TO A FAULTY CRUISE CONTROL SWITCH. *TR

MULTIPLE INSTANCES FOLLOWING RAIN OF: VEHICLE TURNS OVER BUT WILL NOT START. REMOVING THE KEY ANY OF THE FOLLOWING WILL OCCUR- HEATER FAN BLOWER COMES ON AND WILL ONLY GO OFF WITH THE KEY IN AND IN THE ON POSITION. LIGHTS MAY OR MAY NOT COME ON. RADIO MAY OR MAY NOT COME ON. ALL THIS WITH KEY OUT, VEHICLE EMPTY AND CLOSED. SOMETIMES BLOWER WILL COME ON IN EMPTY VEHICLE. IF THE CAR STARTS SOMETIMES THE WIPERS WILL NOT WORK, THE HORN WILL NOT WORK, RADIO WILL NOT WORK, LIGHTS WILL NOT WORK OR BLINKERS GO ON. ANY OR ALL OF THIS MAY OCCUR. SOMETIMES AND ODER LIKE BURNING OR SOUR GAS WILL OCCUR. IF THE RAIN QUITS AND THE VEHICLE SITS FOR MINUTES TO HOURS ALL THESE SYMPTOMS GO AWAY. I HAVE PULLED THE LOWER KICKER PANEL ON THE DRIVERS SIDE AND FOUND EVIDENCE OF WATER BELOW THE GEM NEAR THE EDGE OF THE CARPET. I BELIEVE THIS TO BE THE PROBLEM REPORTED BY MANY AS THE WATER ENTERING FROM THE WINDSHIELD AND SHORTING AT THE GEM FUSE CONNECTION. I AM CONTACTING THE DEALER, IF THEY WILL NOT TAKE CARE OF IT I WILL HAVE A WINDSHIELD REPLACEMENT COMPANY TRY TO RESEAL AND EXAMINE FOR LEAKS. THIS APPEARS TO BE POTENIALLY DANGEROUS IF ENGINE WOULD DIE WHILE DRIVING, LIGHT GO OUT OR WIPERS STOP WORKING. *TR

WE BOUGHT THIS VEHICLE IN FEBRUARY 2010 IT RAN PERFECTLY UNTIL WE GOT THE FIRST SNOW OF THE YEAR AND THEN WE STARTED HAVING MAJOR ELECTRICAL PROBLEMS. IT STARTED OUT JUST THE WARNING LIGHTS WOULD BLINK, THEN THE RADIO WOULD SHUT OFF IN DRIVE BUT COME BACK ON IN PARK. THEN THE WIPERS WOULD NO LONGER WORK OR THE HEADLIGHTS! SO WE PARKED IT FOR ABOUT A MONTH, THE SECOND DAY THE RADIO AND HEATER CAME ON WITHOUT THE KEYS EVEN BEING IN THE VEHICLE SO WE HAD TO DISCONNECT THE BATTERY! WE LET IT SIT WITH THE BATTERY DISCONNECTED FOR AWHILE THEN TRIED IT AGAIN. THE SUV RAN GREAT FOR ABOUT 8 WEEKS THEN IT SNOWED AGAIN AND IT SUDDENLY STARTED TRYING TO START ITSELF AND WE DO NOT HAVE REMOTE START!!! NOW IT DOES IT EVERY TIME YOU SHIFT, START IT, OR WHENEVER IT IS PARKED IT JUST STARTS CRANKING AWAY!! I NOW HAVE SMOKE COMING FROM SOMEWHERE BEHIND THE FUSE BOX! THE FUSES ARE ALL GOOD AND I CAN'T SEE ANY PROBLEM WITH THE WIRING... I HAVE TALKED TO SEVERAL PEOPLE WHO HAVE HAD THESE EXACT SAME ISSUES WITH THIS MODEL OF EXPEDITION AND NONE OF THEM HAVE BEEN ABLE TO FIGURE OUT WHAT THE PROBLEM IS EVEN AFTER SPENDING THOUSANDS OF DOLLARS... AND FORD IS REFUSING TO ISSUE A RECALL... SO WHAT ARE WE TO DO AS CONSUMERS WHEN WE ARE ASSURED THE VEHICLES WE BUY ARE SAFE AND THEY TURN OUT TO BE THE EXACT OPPOSITE!!!!

DRIVER SIDE CURTAIN AIR BAG DEPLOYED. AFTER RETURNING TO THE PARKED VEHICLE, I SHUT THE DRIVER'S SIDE DOOR, INSERTED THE KEY TO START THE VEHICLE AND THE INSTANT I TURNED THE KEY THE DRIVER'S SIDE CURTAIN AIR BAG WENT OFF, CAUSING A MASSIVE ABRASION ON THE TOP SURFACE OF MY LEFT ARM. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED IN A GARAGE, THE ENGINE CAUGHT FIRE. A FIRE INCIDENT REPORT WAS FILED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE VEHICLE WAS INCLUDED IN RECALL 05V388000 (VEHICLE SPEED CONTROL) AND SOMEONE WOULD CONTACT HIM IN REGARDS TO THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 142,000.

2000 FORD EXPEDITION CAUGHT ON FIRE SEPT 24 2010. MECHANIC SAID IT WAS DUE TO CRUISE CONTROL DEVICE THAT I NEVER RECEIVED A RECALL FOR. MASTER SOLENOID AND PLASTIC COATING UNDER HOOD ARE ALL MELTED, SUV IS TOTALED. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE TRAVELING 55 MPH THE CONTACT HEARD A LOUD POPPING SOUND COMING FROM THE REAR OF THE VEHICLE, AFTER EXAMINING THE VEHICLE THE CONTACT NOTICED THAT A PART OF THE VEHICLE HAD BROKEN OFF THE REAR END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE TRAILING ARM WAS REPLACED. PRIOR TO THE FAILURE THE CONTACT HEARD A CLANKING SOUND COMING FROM THE REAR OF THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 103000.

THE TRAILING ARMS/LOWER CONTROL ARMS ON MY 2000 FORD EXPEDITION HAD RUSTED THROUGH & HAD TO BE REPLACED. I COULD NOT WAIT FOR THEM TO FAIL GIVEN THE HAZARDOUS NATURE OF THIS DEFECT. THESE PARTS SHOULD NOT HAVE BEEN MADE SO POORLY. *TR

BRAKE FAILURE DUE TO BRAKE LINE RUST. *TR