There are 53 stored owner reports matching the suspension leading-label group for the 1992 Ford Explorer in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 50 of 53 matching reports. This is a limited sample of up to 50 reports, ordered by incident date when available, not the complete group. The list controls page through the loaded reports only.
Open the full vehicle complaint log (all categories)I JUST WANT TO FILE A COMPLAINT IN REGARDS TO THE 4WD ON THE 1992 FORD EXPLORER. THE PROBLEM IS THAT IT WILL NOT DISENGAGE FROM 4WD TO 2WD. I FEEL THAT BECAUSE OF THIS IS THE REASON FOR ALL THE NOISE I HEAR COMING FROM THE FRONT END. I HAVE NOT REPLACED IT BECAUSE IT WILL COST ME BETWEEN $300-$800 DEPENDING ON WHAT I PUT ON IT. I WOULD LIKE TO KNOW WHAT I NEED TO GET THIS REPLACED? I HAVE TWO SMSLL CHILDREN THAT ARE IN THE VEHICLE WITH ME MOST OF THE TIME AND DON'T WANT ANYTHING TO GO WRONG WITH THIS THAT WILL CAUSE ME TO HAVE AN ACCIDENT. *NM
THE FAULTY ENGINE MOUNT AND REAR AXLE SHOCK ABSORBER CAUSE EXTREME VIBRATION IN THE ENTIRE VEHICLE WHILE DRIVING, THE ENGINE IS NOT HARMONICALLY BALANCED AND SETS UP A VIBRATION THAT EXTENDS TO THE FRAME AND THE REAR SHOCK ABSORBERS. *YH . CONSUMER STATES THAT THIS PROBLEM IS A MANUFACTURER DEFECT, BUT MANUFACTURER IS N OT WILLING TO TAKE ANY RESPONSIBILITY, CONSUMER WAS ADVISED BECAUSE OF THE AGE AND THE MILEAGE IT WOULD BE THE CONSUMER'S RESPONSIBILITY,*JB
IT IS OBVIOUS THAT WHEN FRONT SUSPENSION COMPRESSES STEERING LINKAGE OR TIE ROD HITS THE RUBBER BRAKE LINE. BRAKES FAILED WHILE DRIVING! *AK
DURING HARD BRAKING IN VEHICLE CHASSIS FEELS LIKE IT IS STOPPING, BUT CAB OF VEHICLE FEELS LIKE IT CONTINUES TO MOVE FORWARD EXCESSIVELY. DEALERSHIP HAS EXAMINED VEHICLE AND REPLACED "RADIUS CONTROL ARM BUSHING" BECAUSE THIS COMPONENT WAS DETERMINED TO BE BAD. HOWEVER, PROBLEM HAS NOT BEEN CORRECTED. *AK CONSUMER STATES WHILE BRAKING, VEHICLE DOES NOT RESPOND VERY WELL, IN REVERSE AND WHILE TURNING, VEHICLE WILL THUMP AND POP UNDER PASSENGER SIDE. *SLC
WHILE DRIVING, CONSUMER HEARD A LOUD NOISE AND THEN LOST TEMPORARY CONTROL OF THE STEERING WHEEL, VEHICLE HIT THE BRIDGE AND FROM THE RIGHT FRONT OF THE VEHICLE, THEN SLIDE SIDEWAYS, CONSUMER SAYS IT WAS NOT A FAULTY TIRE. *SLC
MY 16-YEAR-OLD SON, FROM THE HIGHWAY PATROL'S INVESTIGATION, WAS EITHER DISTRACTED OR FELL ASLEEP AT THE WHEEL AND GENTLY EDGED OFF THE ROAD; HE DIDN'T SWERVE. TIRE TRACKS SHOW THAT AS HE CAME BACK ONTO THE ROAD, HE LOST CONTROL, THE CAR FLIPPED, AND HE WAS THROWN FROM THE VEHICLE AND DIED AS A RESULT OF SEVERE HEAD INJURIES. HE WAS NOT WEARING A SEAT BELT. WE DIDN'T KNOW THAT SUV'S TEND TO FLIP WHEN CONTROL IS LOST. I SAW THE REPORT ON STUDYING LATER MODELS FOR FRONT STABILIZER BAR LINKS AND THOUGHT YOU MIGHT WANT TO LOOK FURTHER BACK TO 1992.
REPLACEMENT TIRES WERE SAME AS FACTORY ORIGINAL, RATED AT 50,000 MILES. AT 40,000 MILES, BEGAN TO EXPERIENCE VIBRATION, THE SOURCE OF WHICH COULD NOT ACCURATELY BE IDENTIFED BY MECHANIC. (U-JOINT AND SEVERAL BEARINGS REPLACED TO NO EFFECT). DURING DRIVING TRIP TO LITTLE ROCK FOR THANKSGIVING, VIBRATION WORSENED, WHICH I ATTRIBUTED TO BAD ROAD SURFACE CONDITIONS IN MO AND AR. DURING RETURN TRIP TO KANSAS CITY FROM LITTLE ROCK, APPROX. 100 MILES WEST OF LITTLE ROCK ON WB I-40, RIGHT REAR TIRE TREAD FAILED, DELAMINATING COMPLETELY FROM TIRE CORE AT 70 MPH. LOST CONTROL OF VEHICLE AND TRAVELED DOWN GRASS EMBANKMENT OF CENTER MEDIAN, HIT CONCRETE DRAINAGE WAY AT CENTER, AND CONTINUED UP THE OPPOSITE EMBANKMENT TOWARD ONCOMING EB TRAFFIC. REGAINED PARTIAL CONTROL AS VEHICLE SLOWED UP THE EMBANKMENT, AND WAS ABLE TO STEER VEHICLE TO REST BACK AT THE BOTTOM OF THE MEDIAN. PASSING MOTORISTS ASSISTED IN RETURNING VEHICLE TO THE HIGHWAY, AND I PUT ON THE FULL-SIZE SPARE. PASSING ARKANSAS STATE TROOPER STOPPED AND ASCERTAINED THAT THERE WERE NO INJURIES NOR COLLISIONS WITH OTHER VEHICLES. NO REPORT WAS FILED. CONTINUED TO KANSAS CITY ON SPARE TIRE; NO FURTHER VIBRATION NOTICED. APPROXIMATELY 5000 MILES LATER REPLACED ALL FOUR TIRES WITH SAME BRAND, FIRESTONE ATX. THESE TIRES NOW HAVE APPROXIMATELY 8000 MILES. NO FURTHER INCIDENTS TO REPORT. ORIGINALLY THOUGHT TO BE ISOLATED INCIDENT, AND SO DID NOT REPORT TO NHTSA UNTIL I HEARD NEWS REPORTS ABOUT YOUR INVESTIGATIONS ON THIS TIRE. NTB SALESMAN NOTED THAT THEY WERE FAMILIAR WITH FAILURE PROBLEMS ON THIS TIRE AT THE TIME THAT I BOUGHT THE LAST SET. I WENT AHEAD AND BOUGHT THEM BECAUSE ORIGINAL SET PERFORMED OK, AND THEY WERE MOST ECONOMICAL PRODUCT FOR MY BUDGET. *AK( DOT NUMBER: TIRE SIZE: P235/75R14 )
COMING BACK FROM A TRIP ON THE INTERSTATE AT 65MPH VEHICLE STARTED TO VIBRATE. COULD FEEL IT IN THE STEERING. HEARD A LOUD BANG AS IF VEHICLE HAD BEEN REARENDED. TIRE STAYED INFLATED. DIDN'T CONTACT DEALER OR MANUFACTURER. PURCHASED ANOTHER TIRE. *AK
RADIUS ARM BUSHING TOTALLY CRUMBLED ,FELL APART, CAUSING A LOSS OF VEHICLE CONTROL AND BRAKES. *AK
HAS LATERAL VIBRATION IN VEHICLE WHEN DRIVING AT VARIOUS SPEEDS. THE PROBLEM IS INTERMITTENT. THE DEALER CANNOT LOCATE THE VIBRATION PROBLEM. CONTROLLING THE VEHICLE IS NO PROBLEM. *AK
DP98001 HEAVY LATERAL VIBRATION; WHILE DRIVING DRIVER FEELS A VIBRATION IN THE VEHICLE. THE VIBRATION IS FELT MORE WHEN THE VEHICLE IS DRIVEN UNDER 50 MPH. PLEASE DESCRIBE DETAILS. *AK
CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH FRONT END SUSPENSION. ALSO, THERE IS A BANGING SOUND WHEN APPLYING BRAKES. THE MANUFACTURER HAS BEEN CONTACTED. *AK
WHILE DRIVING ABOUT 5 OR 10 MPH THE LEAF SPRING ON THE DRIVER'S SIDE BROKE. THE DEALER IS AWARE OF THE PROBLEM. THE PROBLEM HAS NOT BEEN CORRECTED. *AK
SLOWING DOWN FOR A STOP SIGN GOING ABOUT 20MPH, SUDDENLY VEHICLE SLAMMED INTO CURB. RIGHT SIDE TIRES EXPLODED/RIMS/FRONT SUSPENSION/RIGHT SIDE FENDER TORE UP. VEHICLE TOWED TO DEALER. SVC MANAGER NOTICED SUSPENSION STABLIZER BAR PIN WAS CUT.BEFORE ACCIDENT. VEHICLE WOULD ALSO VIBRATE. *AK
THE FRONT RADIUS ARM BUSHINGS HAVE FAILED TWICE, I-BEAM BUSHING FAILED ONCE. THRUST BEARINGS ALSO FAILED, RELATED TO A-ARM BUSHINGS. *AK
VEHICLE EXPERIENCES SEVERE VIBRATION. DEALER ATTEMPTED TO FIX IT SEVERAL TIMES, BUT PROBLEM CONTINUES. ALSO, BRACKETS THAT CONNECT THE HYDRAULIC CYLINDERS TO REAR LIFTGATE TO PULLED AWAY FROM INSIDE OF THE LIFTGATE PRIOR TO RECALL (95V-164-001) *AK
WHEN DRIVING VEHICLE ABOVE (55) MPH THERE IS EXTREME VIBRATION COMING FROM THE FRONT END OF VEHICLE. VEHCLE HAS NOT BEEN REPAIRED. *AK
WHEN DRIVING AT 55 MPH THE WHOLE VEHICLE SHAKES. OWNER TOOK VEHICLE TO GOODYEAR AND THEY SAID THAT IT WAS AN ALIGNMENT PROBEM, BUT CANNOT BE FIXED BECAUSE OF THE WAY THE FRAME IS MADE. *AK THE VEHICLE CAN NOT BE PROPERLY ALIGNED AND VIBRATES AFTER 50 MPH. *YH
VIBRATION IN THE STEERING WHEEL AND THE BODY OF THE VEHICLE. PLEASE DESCRIBE. *AK
FRONT END RADIUS ARM BUSHING DETERIORATED, CAUSING FRONT END NOISE AND STEERING PROBLEMS. *DH
Showing 1-20 of 50 loaded complaints
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: May 4, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.