There are 10 stored owner reports matching the fuel system leading-label group for the 1996 Ford Explorer in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 10 of 10 matching reports.
Open the full vehicle complaint log (all categories)TL* THE CONTACT OWNS A 1996 FORD RANGER. THE CONTACT STATED THE STRAPS TO THE GAS TANK RUSTED AND BROKE CAUSING THE GAS TANK TO DROP TANK DROPPED ONTO DRIVESHAFT CAUSING FUEL LEAKAGE. THE VEHICLE HAD NOT BEEN INSPECTED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 194,000. UPDATED 09/29/2011 *LN *TR
TL*THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTACT STATED THAT DASHBOARD LIGHTS WERE TOO DIM. THE GAS CAP WAS NOT SECURE ON THE TANK AND DID SHE WAS UNABLE TO REPLACE THE GAS CAP ON TIGHT. THE DEALER ADVISED HER THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED BECAUSE IT ADDED TO THE POLLUTION. SHE RECEIVED RECALL NOTICE 09V399000,VEHICLE SPEED CONTROL AND THE DEALER REPLACED THE CATALYTIC CONVERTER INSTEAD OF THE SPEED CONTROL DEACTIVATION SWITCH. SHE CALLED THE DEALER AND THE MANUFACTURER BUT RECEIVED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 157,000.
FUEL PUMP WAS BEING REPLACED. TOWNSEND FORD PERFORMED THE JOB. TECH BROKE CHEAP PLASTIC CLIP REQUIRING FUEL FILLER NECK TO BE REPLACED. IT'S DEFECTIVE. WILL NOT SEAL. GAS VAPOR LEAK. CHECK ENGINE STAYS ON. FORD HAS PROBLEM WITH SUPPLIER. NONE IN COUNTRY TOLD TO ME ABOUT A COUPLE MONTHS AGO. STILL NONE NOW. GAS VAPOR LEAK IS HEALTH HAZARD AND UNSAFE IN MY OPINION. THEY KEEP BLOWING ME OFF ON RESOLUTION. CAN YOU HELP? -THANKS-*AK
A STRONG SMELL OF FUEL INSIDE OF VEHICLE. DRIVER HAS TO ROLL DOWN WINDOWSBECAUSE FUMES MAKE CONSUMER SICK. *AK
FUEL PUMP BROKE. THERE WAS A RECALL FOR THIS PROBLEM, BUT THIS VEHICLE WAS NOT AFFECTED BY RECALL ALTHOUGH IT HAS SAME PROBLEM. *AK WITH CRUISE CONTROL ENGAGED, VEHICLE WON'T STOP UNLESS CONSUMER STOMPED ON GAS PEDAL SEVERAL TIMES, CONSUMER STATES THE GAS PEDAL SEEMED STUCK AND ACCELERATION WOULDN'T STOP. *SLC
VEHICLE WAS DRIVEN AND PARKED ON THE CARPORT, UNDER THE HOOD COMPARTMENT FIRE, CAUSING THE VEHICLE/CARPORT TO COMPLETELY BURN. ALSO, SMOKE DAMAGES, FIR EWAS CAUDED BY FAULTY FUEL INJECTORS. *AK
WATER SPLASHED UP INTO THE AIR INTAKE PORT, CAUSING ENGINE TO SEIZE.
FUEL VENT TUBE FAILED, FUEL SPRAYED OUT OF THE FUEL TANK WHEN FILLING THE TANK. *AK
A SPLINTERED TWO BY FOUR PIERCED THE GAS TANK. TT
I HAD THIS SAME PROBLEM WITH MYH 1994 EXPLORER. WHEN THE TEMPERATURE IS OVER 85 DEGREES OUTSIDE AND THE AIR CONDITIONER IS ON, WE GET AN EXTREMELY STRONG ODOR OF RAW GASOLINE INSIDE THE CAR. IT MAKES US NAUCEOUS. THIS HAPPENS ESPECIALLY WITH IN-TOWN STOP AND GO DRIVING. *AK
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: May 4, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.