2006 Ford Explorer Engine Problems

The contact owns a 2006 Ford Explorer. The contact stated while driving at an undisclosed speed, the engine seized. The vehicle was driven to the shoulder of the road. The contact parked the vehicle and allowed the vehicle to set for a while. The vehicle was started. The contact stated that the vehicle was driven 100 yards before the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

RADIATOR FLUID EXPLODED ALL OVER ENGINE AND FLOOR MASSIVE LEAK . SEARCHED IT UP ON INTERNET AND SEEMS THIS IS A COMMON PROBLEM WITH THIS VEHICLE . I STARTED VEHICLE AND FLUID STARTED GOING EVERYWHERE .I DROVE MAYBE 10 FEET AND SHUT THE CAR OFF IMMEDIATELY . *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED TWO MORE TIMES. THE VEHICLE WAS TAKEN TO TRI STAR FORD (930 OLD US HWY 22, BLAIRSVILLE, PA 15717), BUT THE DEALER WAS UNABLE TO DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO ANOTHER DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 37,500. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. IN ADDITION, THE CONTACT NOTICED STEAM COMING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COMPRESSOR FAILED AND THE CHECK ENGINE INDICATOR WAS DISABLED. AS A RESULT, THE ELECTRONIC CONTROL MODULE CAUSED THE VEHICLE TO MALFUNCTION. THE COMPRESSOR WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THEENGINESTALLED WITHOUTWARNING. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED.THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE.THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.

FIRST PROBLEM STARTED WITH THE BRAIN IN THE TRANSMISSION AREA. HESITATING, LUNGING FORWARD AND TACHOMETER JUMPING WHEN TAKING OFF AND DURING DRIVING DOWN THE ROADS/HIGHWAYS. HAD DIAGNOSTICS TESTS DONE (MARCH 3, 2016.) REPLACED BRAIN AND IT STOPPED THE HESITATION, LUNGING AND TACHOMETER JUMPING=$2700.00. NEXT PROBLEM CAME ALONG WHEN WE STARTED HEARING A TICKING SOUND WHEN IT WAS STARTED IN THE DRIVEWAY(MAY 16, 2016.) COME TO FIND OUT THE ENGINE WAS BLOWN WHICH IS NOW GOING TO COST $6700.00. WE HAVE ALWAYS MAINTAINED OUR VEHICLES WITH PROPER CARE AND ATTENTION, BUT HOW CAN ALL THESE MAJOR THINGS GO WRONG AT ONLY 108000 MILES???

MY CAR SLOWED DOWN TO A CRAW IN THE HIGHWAY AND HAD TO LIMP HOME AT VERY LOW SPEED ALMOST CAUSED A CRASH.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED TEN TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR WAS LEAKING FLUID. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

DOES THE CLASS ACTION LAWSUIT CONCERNING SPARK PLUGS INCLUDE THIS MODEL OF EXPLORERS? THE V8 4.6L EDDIE BAUER EDITION-IF NOT, IT SHOULD, AS WE WERE TOLD THE SAME INFO ON SPARKS PLUGS BREAKING OFF IF NOT DONE WITH A SPECIAL EXTRACTION TOOL. WE HAD DIAGNOSTICS DONE AND DEPENDING ON WHAT HAPPENED WHEN REMOVED AND CHANGED COULD COST ANYWHERE BETWEEN $600-$1500. SPECIFICALLY TOLD "DO NOT ATTEMPT YOURSELF." SERVICE WAS PERFORMED JUNE 19, 2014 BY A LOCAL FORD DEALER.

THE RADIATOR IN THE 2006 FORD EXPLORER LEAKS, AND A RECALL IS MANDATORY. I BOUGHT THIS VEHICLE IN 2007, USED, AND I AM NOW FACED WITH REPLACING THE RADIATOR FOR THE 4TH TIME IN 7 YEARS. IT IS A KNOWN ISSUE THAT THIS RADIATOR IS FAULTY AND STILL THERE IS NO RESOLVE. PLEASE OPEN AN INVESTIGATION AND READ ALL THE COMPLAINTS REGARDING THE RADIATOR FOR THIS VEHICLE. *TR

I WAS DRIVING 25 MPH AND TURNING LEFT TO A SMALL STREET. I SAW AN ENGINE LIGHT SHOW ON, AND THEN THE ENGINE STOP. AT THAT POINT, I COULDN'T TURN THE WHEEL, AND ALSO IT WAS SO DIFFICULT FOR ME TO STOP THE VEHICLE. I HAD MENTION THIS PROBLEM AT THE FORD DEALER IN GREENFIELD, MA WHO FIXED MY ABS BREAK ABOUT TWO WEEKS AGO. A PERSON AT THE SERVICE RESPONDED, " THAT'S NORMAL. OUR COMPUTER DOES NOT SEE OTHER ISSUE BESIDE THE ABS." I SPEND $85 FOR DIAGNOSIS THE ABS BREAK PROBLEM AND SPEND ALMOST $500.00 TO FIX THE BREAK. I TOOK MY VEHICLE TO A SMALL BODY SHOP IN MY AREA. THIS PERSON RAN THE COMPUTER THROUGH THE VEHICLE SYSTEM, AND THE COMPUTER DID NOT SHOWN ANY PROBLEMS. THEN, I CALLED FORD CORPORATE AND TRIED TO GET SOME ADVICE FROM THE COMPANY. THE COMPANY SAID I SHOULD TAKE THE VEHICLE TO A DIFFERENT DEALER TO GET OTHER OPINION. MEANING THAT I HAVE TO PAY ANOTHER $85.00 AGAIN, AND I STILL DO NOT KNOW I WILL GET AN ANSWER OR NOT. MY CONCERN, I DO NOT WANT TO CAUSE AN ACCIDENT. *TR

FROM JULY 5TH TO PRESENT MY 2006 FORD EXPLORER TRUCK WAS TOED TO THE DEALERSHIP 3 TIMES. EACH TIME IT WAS FOR THE SAME PROBLEM OVERHEATING. THIS HAS BEEN A CONSTANT PROBLEM WITH THIS CAR SINCE IT WAS PURCHASED IN DECEMBER 2005. THE RADIATOR HAS BEEN REPLACE TWICE, THE TRANSMISSION ONCE, THE THROTTLE , ETC. I HAVE BEEN TOLD THAT NOW AFTER THE RADIATOR WAS A REPLACED AND THE THROTTLE, ETC. AT A COST OF $2300.00.THE CAR NOW NEEDS A NEW ENGINE AND /OR GASKETS THAT NEED REPLACING. I CANNOT UNDERSTAND WHY A CAR WITH NORMAL MILEAGE, WHICH WAS ONLY INVOLVED IN ONE MINOR FENDER BENDER.CAN NEED SO MUCH MAJOR WORK. *TR

VEHICLE WAS JUST AT THE FORD DEALERSHIP FOR OVER A WEEK IN MARCH FOR TRANSMISSION RELATED ISSUES, NEW RADIATOR, ETC. JUST FOUR MONTHS LATER, I AM HAVING THE SAME ISSUES THAT MANY OTHERS ARE WRITING ABOUT; HARD SHIFT INTO REVERSE, VEHICLE IS JUMPING/JOLTING FORWARD FROM A STOP, RPM FLUCTUATION WHILE IDLING. *TR

TL* THE CONTACT OWNS 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 50 MPH THE TEMPERATURE GAUGE STARTED TO RISE. A FEW MILES DOWN THE HIGHWAY HE SAW A LARGE CLOUD OF SMOKE COMING FROM HIS ENGINE. THE CONTACT WAS ABLE TO MERGED TO THE SIDE OF THE ROAD AND HAVE THE VEHICLE TOWED. AFTER DIAGNOSIS FROM THE DEALER THEY ADVISED HIM THAT THE RADIATOR FRACTURED AND STARTED TO LEAK ONTO THE ENGINE. AS A RESULT, THE ENGINE AND RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 83,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT THE VEHICLE HESITATED TO ACCELERATE. THE VEHICLE THEN RAPIDLY ACCELERATED TO APPROXIMATELY 60 MPH AND BEGAN TO DECELERATE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REBUILT OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,000. UPDATED 02/20/13*LJ THE CONSUMER STATED THERE WAS AN EMMISSION ISSUE AND THE RADIATOR WAS LEAKING. UPDATED 02/20/2013 *JS

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THE VEHICLE HESITATED. THE CONTACT WAS ABLE TO ACCELERATE INTO TRAFFIC HOWEVER WITHIN MOMENTS, FIRE EMITTED FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND ADVISED THAT THE FIRE ORIGINATED FROM THE RIGHT SIDE OF THE ENGINE BAY AREA. THE FIRE HAD SPREAD TO THE WINDSHIELD AND DASHBOARD AS WELL. THE VEHICLE WAS TOWED TO THE DEALER WHO DID NOT ADVISE THE CONTACT ON THE CAUSE OF THE ENGINE FAILURE THAT COULD HAVE LED TO THE FIRE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

ENGINE LOST POWER AND BEGAN VIBRATING. ENGINE DRIVEN TO DEALERSHIP AND ENGINE LIGHT CAME ON. DEALERSHIP STATES "SEIZED" SPARK PLUG BUT BECAUSE PART IS DEFECTIVE WANTS TO REPLACE ALL EIGHT PLUGS. UNABLE TO QUOTE COST AS PLUGS ARE KNOWN TO BREAK OFF DURING REMOVAL. PLUG REPLACEMENT RECOMMENDED ORGINALLY TO BE 100000 NOW DROPPED TO 60,000. SERVICE WRITER STATED "YOU MUST HAVE HAD SOMEONE MESSING WITH YOUR SPARK PLUGS". TOLD HIM NO ONE HAS SERVICED MY CAR BUT HIS DEALERSHIP. SPECIAL TOOL DESIGNED BY FORD TO REMOVE THESE PLUGS. COST CANNOT BE QUOTED ($946 FOR ONE PLUG CHANGEOUT PLUS FULL SERVICE FUEL SERVICE PRIOR TO REMOVAL TO "LOOSEN" UP CARBON BUILDUP WHICH THEY SAY CAUSES THE PROBLEM WITH PLUG BREAKAGE) BUT COST RUNS INTO THOUSANDS OF DOLLARS AND SHAVINGS FROM REBORING THE PLUGS FOR REPLACEMENT OF DIFFERENT DESIGN PLUG CAN CAUSE ENGINE TO BE DAMAGED. CAR PURCHASED NEW IN 2006. ONLY DRIVER. ONLY DEALER SERVICED. THIS IS A TERRIBLE PROBLEM.

THE RADIATOR LEAKS ON ALMOST ALL 2006 MODELS FROM THE FACTORY. FORD ACKNOWLEDGES THE ISSUE WAS FROM OVERTIGHTENING, YET DOES NOT ISSUE A RECALL. *TR