2018 Ford Explorer Complaint Log

The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 50 MPH, the front driver’s side A-pillar trim was suddenly ejected from the vehicle. The local dealer was notified of the failure. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V031000(STRUCTURE), which was related to the failure, but parts needed to repair the vehicle were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that later the front passenger’s side A-pillar trim experienced the same failure. The manufacturer was not made aware of the failure. The failure mileage was unknown

In 2025 the dashboard leather on our 2018 Ford Explorer Platinum began to come unglued and rolled apart creating a very distracting white strip. This is very distracting and reflects into our line of sight. We have taken to the Ford dealership for repair. And the only answer from them is Go to an upholstery shop or replace the full dashboard… Very expensive!! We have researched and discovered that this is a regularly reported problem on Reddit and other sites for Ford Explorers and Expeditions from 2018-2020. These SUVs are not cheap! We paid a lot of money for a luxury SUV and this is not acceptable. But Ford isn’t interested because they don't see it as the safety danger it really is. The exposure of the white matting underneath the leather creates a vision safety problem looking out the windshield. Pictures attached. We are asking for assistance in getting Ford to address and repair this problem. At the very least it is a quality control problem on their luxury SUVs that Ford should be fixing.

Traveling 50mph, noticed smoke rolling from under the dash. Got to the side of the road. The entire dash was engulfed in fire. I had to fight my way out of the car after the doors locked. After I got out of the vehicle I called 911. Fire department came. It has been ruled as electrical. I am not sure whom I need to reach out to yet in regards to this matter and a total loss.

1 year ago, the exterior pillar trim detached on the 202 Highway in Mesa, Arizona while I was drivign 65 MPH. It cracked another windshield. I received the recall and went in to Robert Horne Ford Dealership. They informed me those pieces are on recall. I told them to notify me when they became available. It has been 1 1/2 years and still nothing. This week, the other side pillar trim came off, again while I was on the highway. This is dangerous. Now I feel like my windshield is not secure, as it is shaking while I am driving. The recall was announced in January of 2024. It is October of 2025. How can a company ignor the recall and simply not address explicit safety violations? NHTSA # 24V031

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

This recall has been 1.5 years and still does t have a remedy by Ford? Part was checked by Ford dealership, they advised yep it qualifies but we don't have parts then left. That was 1 year ago.

See attached document for complaint. I am writing to express my concern with the February 2024 recall from Ford (Safety Recall Notice 24S02/NHTSA Recall 24V031. This has been a known safety issue from Ford since February 2024. The recall letter (attached) advised that parts were expected later half of 2024. To date, no parts or further communication has been sent from Ford. I was driving my daughter and a friend home. While traveling on 196, the passenger side A-pillar applique trim clip attachment became detached from vehicle, hitting my windshield and then flying backwards on the expressway toward other vehicles. On this particular Sunday, 196 was rather busy. I was able to safely check my rear-view mirrors to ensure that other vehicles traveling behind me were not impacted by the detached trim. I am grateful that this incident occurred without any harm to any individual. I have no idea if the trim caused any damage to the vehicles traveling behind me. I am finding it unacceptable that Ford has sent out zero communication on this safety recall. My husband took my 2018 Ford Explorer to Tony Betten Ford & Sons to inquire about the missing trim and how we go about it getting repaired. He was simply told that Ford has not communicated any ETA for delivery of such parts and as far as they know, Ford is not making enough to meet the recall demand. It is now approximately 18 months since the initial recall notice and Ford has yet to send out any repaired parts. This is unacceptable and dangerous for those driving these recalled vehicles.

See attached document for complaint.

The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving 65 MPH, the passenger’s side A-pillar trim detached from the vehicle. No warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The failure mileage was unknown.

The internal water pump system on the EcoBoost engine in the 2018 Ford Explorer failed after 7 years and only 63,880 miles. The vehicle was taken into the shop multiple times when the check engine light came on and the defect was not located until the vehicle failed. Due to the design, it is not easily fixed and cost an outrageous amount of money to fix for a vehicle with less than 100,000 miles. This is a safety risk because if this is a common issue, which it is, and the engine fails while driving it, the driver is not able to get to a safe area to address damages and is left stranded. There are numerous complaints regarding the design flaw of having the water pump inside the engine. The manufacturer refuses to address the flaw. The check engine light came on and was taken in and wrongly diagnosed each time until the engine failed.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Prior to the failure, when the vehicle was started, there was an abnormal sound coming from the engine. After several minutes, the sound ceased. The vehicle was taken to an independent mechanic who diagnosed the vehicle with a misfire in cylinder #3. The contact was informed that the spark plug was stuck, and the independent mechanic was unable to remove the spark plug. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken back to the independent mechanic. The vehicle was diagnosed with a misfire in cylinder #3, and the spark plug and ignition coil were replaced. The contact was unsure if the stuck spark plug was removed the second time the vehicle was repaired. Most recently, the contact noticed that while the vehicle was in park(P) and left running, the vehicle was idling roughly. The message "Engine Coolant Over Temperature" was intermittently displayed. The contact pulled over to the side of the road, left the vehicle running, exited the vehicle, opened the hood, and there was no smoke or steam present. The contact returned to the vehicle and noticed that the temperature gauge was indicating that the engine was HOT. The contact drove back to the residence. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion in cylinders #1, #2, and #4. The contact was informed that the coolant reservoir was empty, that the spark plug in cylinder #3 was stuck, and that the engine needed to be replaced. The vehicle was not repaired. The contact took the vehicle to an independent mechanic for a second opinion, who diagnosed coolant intrusion in cylinders #1, #2, and #4, and that the spark plug was stuck in cylinder #3. The vehicle was not repaired due to the cost. The dealer notified the manufacturer of the failure. The failure mileage was approximately 118,000.

The plastic covers on the roof rails are both loose and constantly pop out. I'm nervous that they are going to fly off when driving, causing an issue for other drivers.

The vinyl on the top part of the dash has completely seperated which is causing a major white reflection on my window and rendering the car unsafe to drive. Ford refuses to address the issue. I also suspect if my air bags deployed this could impact how they deploy or cause additional vinyl shrapnel hitting an occupant in the face in the event of a crash.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that while operating the vehicle, the engine overheated, and the vehicle stalled. The contact inspected the vehicle and discovered that the serpentine belt had failed. The contact replaced the serpentine belt, and the vehicle was repaired. Later, while operating the vehicle, several electrical warning lights were displayed. The battery was replaced, but the failure persisted. The contact replaced the alternator; however, after replacing the alternator, the transmission remained stuck in park(P), rendering the vehicle undrivable. The cause of the failures was not yet determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 155,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, front driver’s side and passenger’s side A-pillar trims loosened and vibrated in the wind. Several local dealers were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 105,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the roof rail covers separated from the vehicle and flew off on several occasions. The vehicle was taken to the dealer, where the roof rail covers molding was replaced; however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 86,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the driver’s and passenger’s side A-Pillar trim pieces were loose. The failure mileage was unknown. VIN tool confirms parts not available.

The cover on my dashboard has lifted/rolled up and revealed a white material underneath, and as such, this has caused a glare onto the windshield in my field of vision, making it harder for me to see while driving. I feel that this is a safety concern. I have taken it to a Ford dealership to have it looked at, and they claim that there is nothing that can be done except for the entire dashboard to be replaced which would be thousands of dollars. I have researched this issue and it seems to be a common issue among my make and model year of the vehicle.

I previously reported a battery 'explosion' in this 2018 Ford Explorer with ODI 11678705 due to my concern for a potentially highly dangerous situation for my grandchildren who were riding with me. And myself. An unpleasant smell intermittently followed this car that morning July 10 Upon opening the hood it was evident that battery acid had leaked out of the battery and 'exploded' covering most visible engine parts. Entire time of drive there was no 'alert' showing up on my dashboard July 11 car would not start to take to Ford dealership. AAA towed car with AAA driver remarking 'looks like your battery exploded!' Engine compartment cleaned by service, battery replaced July 12 July 18 engine light came on. Ford dealership contacted, no service appointment available until Aug 20. Advised by Ford service to take short trips only, and stop driving if engine light started flashing. I restricted my driving. July 27 started car for trip to church. Loud banging coming from under hood. Stopped driving. Car towed July 28 to Ford dealership repair. Car was not into service dept until Aug. 5. Aug 6, Ford service decided to get input from a more experienced technician to diagnose the problem with 2018 Ford explorer Aug 7, Ford service escalated case to Ford corporate for engineering help with identifying 'electrical' problem with my car. Ford service rep stated 'you car is throwing a code not typically seen with explorers) How can be safe if these my car had a battery issues mechanics freely admit they have not seen before. And now trained Ford mechanics cannot even find or fix the broken link that truly may be responsible for back to back engine failures? Dealer has finally been able to provide a rental. This car has been maintained according to factory recommendations at Sunset Ford and Bommarito Ford St. Loui

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was being serviced at a local car wash, the exterior roof rail rack detached. Upon further inspection, the front driver’s side A-pillar trim fractured, and water was leaking onto the interior, causing damage to the rear mirror power module. The contact stated that the front driver’s side mirror failed to adjust as intended when the control module was in use. The local dealer was contacted; however, parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim on the passenger’s side windshield started to detach. The contact received notification of NHTSA Campaign Numbers: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer sent a technician to the contact's residence and the vehicle was diagnosed and it was determined that the A-pillar trim retention clips had failed and needed to be replaced. The vehicle was not repaired. The dealer confirmed that parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 75,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that occasionally while shifted into reverse(R), the rearview camera failed to properly display the image behind the vehicle. There was no warning light illuminated. Additionally, the contact stated that the failure had progressed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,265.

Screen blacks out and unable to connect handsfree, control rear ac or anything else that requires use of screen

The contact owns a 2018 Ford Explorer. While the contact's son was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. The vehicle was driven to the shoulder of the roadway. The contact stated another driver with a tow truck assisted and towed the vehicle off the highway to a safe location. The contact stated after the vehicle sat for three hours, the vehicle was restarted, and driven to the contact's residence. The contact stated that the failure had occurred twice within one week. The contact stated that after the vehicle sat for a while, the vehicle independently reset and the vehicle could be driven for a while; however, the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall; however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 60,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the front passenger side A-pillar trims detached. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 98,000.

2018 Leather on dashboard shrinks pulled away from the glue. Causes a safety hazard while driving.

The displayed view by the back up camera flickers, or shows a blue screen when the car is placed in reverse. This places the safety of pedestrians at risk of being hit by the vehicle when backing up. This places the safety of other drivers and myself at risk of collision when backing up. The component (back up camera) was inspected by a Ford dealer (Sunrise Ford in Fort Pierce Fl.). I was charged $199 to run diagnostics on the camera. They found that the camera had an internal fault, vision blurry and suggest replacing camera at a charge of $1145. I was told that the existing recalls do not cover my VIN. I contacted Ford customer care to see if my VIN was covered under the announced 15 year warranty for backup camera replacement. Although 2016 - 2025 Ford explorers was listed as being eligible for replacement, I was told my VIN was not included. Ford customer care opened up case number CXH-06550938-R6D9Q3 to investigate the problem. The problem started about 6 months ago and only happened once in a while then the camera would work as intended. Now the problem occurs 90% of the time the car is placed in reverse.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at highway speeds, the front passenger’s side A-pillar trim detached. Despite the failure, the contact was able to put the part back in place. The local dealer was contacted about the failure, and the contact was informed that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was approximately 44,000.

Rear view camera not functioning since March 2025

On Thursday, June 14, 2025, the check engine light illuminated on my 2018 Ford Explorer, which has fewer than 75,000 miles. I promptly contacted my trusted local mechanic, Bananno Automotive, to schedule an oil change and requested that they also inspect and diagnose the cause of the warning light. During their inspection, they performed a diagnostic scan and identified stored engine code P0430 – Catalyst System Efficiency Below Threshold (Bank 2), which corresponds to the catalytic converter on the left side of the radiator. Concerned that delaying the repair could lead to increased emissions and potential damage to the engine, I authorized the necessary repairs. All work was completed by June 23, 2025. It was only after the repairs were finalized that I reviewed the Ford Warranty Guide and discovered that this issue is, in fact, covered under warranty. Unfortunately, Ford has denied reimbursement solely because the repairs were not performed at a Ford dealership. This is deeply disappointing, especially considering the repair cost exceeded $1,800, and no alternative solution or support has been offered. My intention in sharing this is to ensure that other Ford owners are not similarly affected by this type of parts failure and warranty denial.

I am writing to formally report a significant mechanical issue involving the water pump in my 2018 Ford Explorer with the 3.5L V6 engine. This vehicle recently experienced a sudden failure of the internal water pump, a problem I have since learned is common across this model and others using the same engine design. In my case, the water pump failure occurred just outside of the vehicle’s extended warranty coverage, leading to engine overheating and a substantial repair cost. What makes this issue particularly concerning is the design flaw in which the water pump is located internally, driven by the timing chain. When the pump fails, it can leak coolant internally, potentially leading to catastrophic engine failure without warning. This design not only makes the part extremely costly to repair (often $2,000–$4,000 or more), but it also introduces a serious safety risk—drivers may experience engine overheating or seizure while on the road, with minimal to no warning. This poses a clear hazard, especially at highway speeds or in high-traffic situations. I understand that many other Ford owners have reported similar failures, yet no recall or Customer Satisfaction Program (CSP) has been issued to address the problem. Given the frequency of these incidents and the potential danger involved, I respectfully request that NHTSA investigate whether this condition qualifies as a safety-related defect. I have included my vehicle details below for your reference: Make/Model/Year: 2018 Ford Explorer Engine: 3.5L V6 (non-EcoBoost) Mileage at Failure: 101345 Failure Description: Internal water pump failure leading to coolant leak and overheating Repair Estimate: $4511.19

The radio flickers on & off when started for about 10 minutes. It’s very distracting. The windshield makes a whistling noise when going above 50mph

The dash cover came unglued and is rolling up exposing a white cloth that reflects on the windshield makingit hard to see

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the repair was not yet available. No further information was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated that while operating the vehicle, there was an abnormal acidic odor inside the cabin of the vehicle. Upon raising the hood and inspecting the vehicle, the contact became aware that the battery cap was unsecured, and the battery acid had covered the interior of the engine compartment. The vehicle was towed to the local dealer, where the engine compartment was cleaned, and the battery was replaced. The vehicle was repaired. The contact stated that the battery was previously replaced at a different dealer. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 73,000.

The contact owns a 2018 Ford Explorer. The contact stated that while attempting to start the vehicle, there was an abnormal clicking sound coming from the vehicle and the vehicle failed to start. The contact stated that the clicking sound was the doors locking and unlocking continuously. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the keyless entry keypad on the driver's side door, resulting in battery drainage. The contact was informed that the keypad needed to be reprogrammed. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2018 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side A-Pillar trim detached and flew off the vehicle. The contact stated that the failure almost caused a crash. Additionally, the contact later discovered that the passenger’s side A-Pillar trim had also detached and flew off the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

Engine light turning off and on. Engine overheating light on. Told by Ford dealership that I need engine replacement.

The dashboard is string to come up the glue is no longer holding and it cause the leather to shrink and come up cause a white glare on the windshield and making it hard to see

I can hear air coming from the windshield on the drivers side at the top

B pillar trim behind passenger door (vertical pillar) is peeling from the top. May fly off and cause a safety issue on roadway if unaddressed. Similar to existing recall of A pillar trim for same year and model as well as an existing recall for 2011-2017 B pillar trim (same issue as mine, but adjacent model years).

As you drive you can hear air coming from around the windshield on the drivers side.

The contact owns a 2018 Ford Explorer. The contact stated that the tailgate had failed to open. The vehicle was taken to a local dealer, where it was diagnosed that the tailgate latch had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

My rear view camera goes to a dark blue or gray s screen with the words “check surroundings for safety” & “Camera is unavailable” and it does not work. This is the same recall issue that is on 1,900+ plus vehicles from a recall. I have called and filled a complain with Ford and have visited 3 dealers in our area and that is what they tell me. I have photos and I need this repair done ASAP because I travel with an [XXX] I’ve called Ford four different times since July and I keep getting the run around and visit different t dealers that tell me that it is the same problem as the recall but the explorers are not yet part of the recall. I NEED YOUR HELP PLEASE THANK YOU [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at 50 MPH, the passenger's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The contact stated that on a separate occasion, the passenger's side A-pillar trim was loose. The local dealer was not contacted. The vehicle was not repaired for the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 75,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, the A-pillar trims on the front passenger’s side and the front driver's side became loosened. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while driving at 70 MPH, the hood unexpectedly opened. The contact stated that the hood was slightly ajar. The message "Hood Ajar" was displayed. The contact pulled over to the shoulder of the roadway and pushed the hood down. The contact continued driving. Most recently, while driving 70 MPH, the failure reoccurred with the message "Hood Ajar" displayed. The contact pulled over to the side of the shoulder and pushed down and closed the hood. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The contact owns a 2018 Ford Explorer. The contact stated while driving 80 MPH, the front windshield trim on the passenger's side detached and flew off the vehicle. The vehicle was taken to the dealer where it was diagnosed with a fractured exterior front windshield trim. The contact was informed that the repair was not covered under recall. The contact was informed that the front exterior windshield trim needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under the recall repair. In addition, the contact was informed that because the entire windshield exterior trim did not detach, the repair was not covered under the recall. The manufacturer was made aware of the failure. The contact received NHTSA Campaign Number: 24V031000 (Structure), however the contact was informed that the repair was not covered under the recall. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 92,500. The VIN was not available.

I believe I am getting the Cam Phaser Rattle sound in my 2018 Ford Explorer Platinum with the 3.5L EcoBoost Engine. Through research I have seen that this is a common problem among other 3.5L EcoBoost Engines like the F-150, Expedition, and Navigator. This happens at Cold Start ups I noticed. I have tried calling my dealership and Ford Corporate about this issue and they say that they can't cover this at all. My vehicle is at 65k miles (just outside the warranty).