2005 Ford F-150 Complaint Log

SPARK PLUG BLEW OUT OF HEAD. CALLED FORD NO RECALL. CAN SEE WHY SO MANY SUV, TRUCKS,ECT. HAVE THIS PROBLEM. FORD SHOULD HAVE PAID. WENT TRUCK SHOPPING GOT A NEW DODGE. *TR

WOULD NOT START BROKE DOWN HAD TO TOW RUSTED FUEL PUMP MODULE. *TR

BOUGHT THIS FORD F150 USED WITH 95,000 MILES. I WAS TOLD THE PLUGS AND FUEL FILTER NEEDED REPLACED BY THE 100,000 RANGE. MY LOCAL GARAGE SPENT HOURS REPLACING ONE PLUG AND WHEN THEY CHECKED WITH THE LOCAL FORD DEALER ABOUT THE PROBLEM THEY WERE TOLD IT WAS A LONG ON GOING PROBLEM. THE DEALER SAID, THEY COULD REMOVE THE PLUGS BUT IT WOULD BE $500.00 DOLLARS TO START AND IF THE PLUGS BROKE OFF IN THE HEADS THE COST COULD BE AS MUCH AS $3,000.00 IF THEY HAD TO REMOVE THE HEADS. RESEARCH SHOWS ME THIS HAS BEEN GOING ON FOR EVER AND FORD REFUSES TO REPAIR OR RECALL THE F150 5.4 3V SPARK PLUG PROBLEM. BUILD UP AROUND THE BASE OF THE PLUGS FROM POOR HEAD DESIGN IS COSTING US CONSUMERS THOUSANDS. PEOPLE ARE GETTING HURT JUST TRYING TO REMOVE THESE PLUGS. I FEEL FORD SHOULD RECALL THE F150 WITH THIS ENGINE AND REPAIR OR REPLACE THE ENGINE HEADS WITH A PLUG THAT CAN BE REPLACED AT A FAIR PRICE NOT THIS STUPID THOUSANDS PEOPLE ARE SPENDING. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT HE SHIFTED INTO PARK AND EXITED THE VEHICLE HOWEVER, IT BEGAN TO ROLL AWAY IN REVERSE. THE CONTACT JUMPED BACK IN THE VEHICLE AND APPLIED THE PARKING BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 115,000.

WHEN ACCELERATING SLOWLY FROM A STOP LIGHT, THE DRIVERS SIDE WINDOW FELL DOWN INTO THE DOOR. APPARENTLY THE WINDOW REGULATOR BROKE, AN ISSUE WHICH IS DOCUMENTED ON NUMEROUS INTERNET SITES. THE WINDOW DROPPING INTO THE DOOR CREATED A VERY DISTRACTING DRIVING SITUATION, NOT TO MENTION VISUAL SAFETY HAZARDS AS IN TODAY DURING RAINY, FOGGY, HUMID CONDITIONS AFFECTING THE VISIBILITY THROUGH THE REMAINING GLASS IN THE VEHICLE. *TR

MICHELIN LTX AT2 TIRES. EXCESSIVE CRACKING. TIRES WITH 30,000 MILES ON THEM AND WELL OVER ONE-HALF TREAD REMAINING HAVE DEVELOPED WIDESPREAD SIDEWALL CRACKS. CRACKS ARE MORE THAN COSMETIC, YOU CAN ACTUALLY FEEL RAISED BUMPS IF YOU RUN YOUR HAND OVER THEM. THE CRACKS SEEM SEVERE ENOUGH THAT I AM CONCERNED ABOUT TIRE FAILURES, PARTICULARLY AT HIGHWAY SPEEDS. INTERNET SEARCH SHOWS MANY SIMILAR COMPLAINTS, AND EVIDENCE THAT MICHELIN HAS BEEN QUIETLY OFFERING DISCOUNTED REPLACEMENTS TO THOSE WHO COMPLAIN DIRECTLY TO THEM. I RECENTLY FILED A COMPLAINT ON THEIR WEBSITE BUT HAVE NOT HEARD BACK. THIS PROBLEM IS WIDESPREAD ENOUGH THAT A MORE FORMAL PROGRAM ON MICHELIN'S PART SEEMS WARRANTED. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH CONTINENTAL CONTITRAC BSW TIRES, SIZE: LT245 75 R17. THE CONTACT STATED THAT ALL FOUR TIRES WERE CRACKED ON THE SIDEWALL. THE CONTACT TOOK THE VEHICLE TO A MECHANIC TO HAVE THE BRAKES CHANGED AND WAS INFORMED OF THE FAILURE. THE CONTACT SPOKE TO THE MANUFACTURER IN REGARD TO NHTSA CAMPAIGN ID NUMBER: 05T022000 (TIRES: TREAD/BELT), BUT WAS TOLD THAT THE TIRE SIZE WAS NOT INCLUDED. THE FAILURE AND THE CURRENT MILEAGES WERE 37,125....UPDATED 02-13-13 *BF UPDATED 02-19-2013 *JS

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE DRIVER'S SIDE AIR BAG ERRONEOUSLY DEPLOYED WITHOUT THE VEHICLE BEING INVOLVED IN A CRASH. THE DRIVER SUSTAINED FIRST DEGREE BURNS TO THE RIGHT WRIST. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE DEALER DID NOT PROVIDE ANY ASSISTANCE SINCE THEY WOULD HAVE TO WAIT FOR THE LEGAL DEPARTMENT TO AUTHORIZE ANY REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 219,671.

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT END OF THE CONTACT'S VEHICLE. THE VEHICLE WAS DESTROYED. THE AIR BAGS FAILED TO DEPLOY AND THE CONTACT SUSTAINED INJURIES TO THE NECK AND BACK. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND ADVISED THAT THE AIR BAG SENSORS WERE NOT FUNCTIONING. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE GEAR WAS SHIFTED INTO DRIVE AS THE BRAKES WERE DEPRESSED WHEN THE VEHICLE LUNGED FORWARD ABNORMALLY. IN ADDITION, THE ENGINE RPMS INCREASED EXCESSIVELY AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE CONTACT WAS ADVISED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 106,000.

FRONT PASSENGER WINDOW FELL TO BOTTOM OF DOOR. *TRW

MY FUEL CONTROL MODULE SHORTED OUT WHICH CAUSED MY PCM TO BE ERASED. IT SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING IT, BUT NO RECALL HAS BEEN ISSUED. MY PREGNANT WIFE WAS DRIVING MY TRUCK AND LOST ALL POWER. THIS RESULTED IN A NEAR ACCIDENT DUE TO HAVING NO POWER STEERING AND LESS BRAKE CONTROL. IF THIS IS SUCH A COMMON PROBLEM WITH THE PLACEMENT OF THE CONTROL MODULE WHY HAS THIS NOT BEEN RECALLED. $1000 LATER I HOPE THIS DOESN'T HAPPEN AGAIN. *TR

AFTER THE TRUCK PASSED 76000 I STARTED TO NOTICE A TICK/KNOCK IN THE ENGINE. I BROUGHT IT TO FORD AND THEY TOLD ME THIS WAS NORMAL NOISE FOR THESE ENGINES, TO ME THIS WAS NO NORMAL. NOW THE TICK/KNOCK/RATTLE HAS BECOME WORSE AND I HAVE BEEN TOLD BY FORD I WOULD NEED A NEW ENGINE. THIS IS A VERY VERY COMMON SITUATION WITH THE 2004-2008 5.4L 3V ENGINES. WHAT US FORD OWNERS WOULD LIKE IS A RECALL ON THE CAM PHASERS AND VCT SOLENOIDS. FORD HAS REDESIGNED BOTH OF THESE PARTS SO THEY KNOW THIS WAS CAUSING BIG ISSUES WITH OWNERS OF THE MENTIONED MAKE/MODEL/YEAR FORDS. I DO NOT KNOW HOW A COMPANY, AN AMERICAN COMPANY, CAN GET AWAY WITH SELLING VEHICLES WHERE THE INTERNAL PARTS OF THE ENGINE, AND AMERICAN MADE ENGINE, GO FAULTY BEFORE THE ODOMETER HIT'S 100,000 MILES. THERE ARE NORMAL WEAR AND TEAR REPLACEABLE PARTS ON EVERY CAR, BUT WHEN INTERNAL ENGINE COMPONENTS FAIL WITH A VEHICLE THAT IS JUST 7 YEARS OLD THAT IS NOT ACCEPTABLE! *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH THE VEHICLE BEGAN TO SPILL FUEL INTO THE STREET. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE JOINT ON THE TANK HAD BECOME DELAMINATED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 52,300. UPDATED 01/09/13*LJ UPDATED 1/11/2013 *JS

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT IN AN ATTEMPT TO AVOID CRASHING INTO A DEER, THE CONTACT CRASHED INTO A DITCH AND THE DRIVER'S SIDE SEAT BELT FAILED TO RESTRAIN THE CONTACT. THE CONTACT SUFFERED A BROKEN LEG AND WRIST. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A LOUD KNOCKING SOUND COMING FROM THE MOTOR. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 215,000. UPDATED 1/14/14*CN

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH MICHELIN LTX/MS 2 TIRES, SIZE: P275/65/R18. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR DRIVER'S SIDE TIRE EXPLODED. THE CONTACT NOTICED THAT THE SIDE WALL WAS SEPARATED FROM THE TREAD. THE TIRE WAS TAKEN TO AN INDEPENDENT TIRE SHOP WHERE THEY STATED THAT THE TIRE WERE DEFECTIVE. THE TIRE WAS THEN TAKEN TO A MICHELIN DEALER WHERE THE CONTACT WAS ADVISED THAT THE BLOWOUT WAS CAUSED BY A SCREW. THE VEHICLE FAILURE MILEAGE WAS 61,000 AND THE CURRENT MILEAGE WAS 61,863. THE TIRE FAILURE MILEAGE WAS 25,581. ..UPDATED 11/14/12 *BF THE CONSUMER STATED A SECOND TIRE HAD TO REPLACED BECAUSE THE TREAD DEPTH CANNOT BE MORE THAN 4/32 ON SAME AXLE ON A 4 WHEEL DRIVE. UPDATED 11/19/2012 *JS

THE STEERING WHEEL ON THIS 2005 IS EXTREMELY LOOSE AT THE TOP OF THE WHEEL AND FEELS VERY UNSECURED AS FAR AS IT BEING CONNECTED OR SECURED UNDERNEATH. IT IS ALSO DETERIORATING GREATLY IN THAT SAME AREA AT THE TOP OF THE WHEEL AND NEVER HAVE SEEN THIS BEFORE. THE REASON I AM SO CONCERNED ABOUT THE SAFETY OF ME AND ESPECIALLY MY FAMILY WHERE WE HAD A HEAD-ON COLLISION AND WERE VERY LUCKY TO BE ALIVE. MY WIFE HAS NEVER FULLY RECUPERATED FROM THAT HORRIBLE NIGHT. FOR HER TO DRIVE MY PICKUP AND FEEL UNSAFE BECAUSE OF A DEFECT THAT THE FORD MOTOR COMPANY OBVIOUSLY OVERLOOKED OR IS NEGLECTING IS UNTHINKABLE. I CANNOT EMPHASIZE THIS ENOUGH DUE TO A FRIEND OF MINE WHICH WAS KILLED IN ONE OF YOUR FORD EXPLORERS MANY YEARS AGO DUE TO DEFECTIVE TIRES FROM FIRESTONE. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE HEADLIGHTS BECAME INOPERABLE WHILE DRIVING 55 MPH. THE CONTACT STATED THAT HE WAS DRIVING WITH THE LOW BEAMS ACTIVATED WHEN THEY FAILED AND NEVER RE-ILLUMINATED. THE DEALER WAS NOTIFIED WHO ADVISED THAT WITHER THE MULTI-SWITCH OR THE MODULE UNDER THE DASHBOARD WOULD NEED REPLACING. THERE WERE NO RECALLS FOR THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 164,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD AND THEN RESUMED DRIVING. THE VEHICLE WAS INSPECTED UPON ARRIVING TO THE RESIDENCE. THE CONTACT DETECTED THE NUMBER SEVEN SPARK PLUG DISLODGED FROM THE ENGINE CYLINDER HEAD. THE DEALER WAS CONTACT WHO INFORMED HIM THAT THERE WAS NO RECALLS PERTAINING TO THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED WHILE TRAVELING 30 MPH, THE REAR DRIVER SIDE WINDOW COLLAPSED INTO THE DOOR PANEL. THE CONTACT MERGED TO THE SIDE OF THE ROAD AND THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE WINDOW REGULATOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE LATER RECURRED WITH ANOTHER WINDOW. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 66,000. ..UPDATED 09-28-12 *BF THE CONSUMER STATED TWO OF THE WINDOWS FAILED WITHIN TWO DAYS OF EACH OTHER. THE FIRST FAILURE HAPPENED AT 30 MPH AND THE SECOND INCIDENT HAPPENED AT 65 MPH, WHILE HIS WIFE WAS DRIVING ON THE FREEWAY. THE CONSUMER'S WIFE ALMOST LOST CONTROL OF THE VEHICLE, BECAUSE SHE THOUGHT IT WAS A GUN SHOT. THE WINDOW DROPPED INSIDE THE DOOR, LEAVING THE INABILITY TO ROLL UP THE WINDOW. UPDATED 10/01/12

I HAVE POWERED WINDOWS ON MY TRUCK. TODAY WHILE DRIVING TO WORK AND GETTING ON THE HIGHWAY GOING SOUTH ON I-35 IN OKC, OK. I HAD THE DRIVER SIDE WINDOW PARTIALLY ROLLED DOWN AND ONCE I WAS AT HIGHWAY SPEEDS I DECIDED TO ROLL THE WINDOW UP, AS I USUALLY HAVE ALWAYS DONE BEFORE. AFTER THE WINDOW REACHED THE CLOSED POSITION, I HEARD A LOUD POP AS IF A ROCK HIT THE WINDOW AND IMMEDIATELY AFTER THAT, THE WINDOW FELL DOWN AND SLAMMED INTO THE BOTTOM WELL OF THE DOOR PANEL. TO MY AMAZEMENT AND NOT UNDERSTANDING WHAT JUST OCCURRED, I TRIED TO RE-RAISE THE WINDOW BACK UP UNSUCCESSFULLY. SO FAR ITS SITTING IN THE PARKING LOT, TAPED UP WITH PLASTIC OVER IT SINCE ITS ABOUT TO RAIN UNTIL I CAN GET IT TAKEN CARE OF. ON ANOTHER NOTE THE OTHER REAR BACK PASSENGERS WINDOWS SQUEAK WHEN THEY ARE RAISED OR LOWERED. WHAT NEXT!! PROBABLY MORE OF THE SAME. SWEET!! *TR

WHILE APPROACHING A STOP DURING A HEAVY RAIN SHOWER I BROUGHT THE VEHICLE TO A COMPLETE STOP ABOUT 10 FEET FROM THE VEHICLE IN FRONT OF ME. SUDDENLY, THE VEHICLE ACCELERATED FORWARD. I PRESSED HARDER ON THE BRAKE AND THE VEHICLE JERKED AND SHUDDERED VIOLENTLY. MY FIRST THOUGHT WAS THAT I WAS STRUCK FROM BEHIND BY ANOTHER VEHICLE. I WAS ISSUED A VIOLATION FROM LOUISIANA STATE POLICE FOR FOLLOWING TOO CLOSELY. MY BELIEF IS THAT THE SHUDDERING WAS THE EFFECT OF THE ANTI LOCK BRAKES ACTIVATING. THE DAMAGE TO BOTH VEHICLES WAS RELATIVELY MINOR. THE VEHICLE WAS CHECKED FOR A DEFECT BUT NONE COULD BE FOUND.

THE TRUCK LOSES ITS POWER STEERING CAPABILITY AFTER ABOUT 10-15MIN OF DRIVING DOWN THE ROAD. IF A TURN NEEDS TO BE MADE,THE STEERING WHEEL FREEZES WITHOUT NOTICE, WHICH CAUSES PANIC; ADDITIONALLY, IT RATTLES AND CLUNKS AS IT IS MANUALLY MANEUVERED. IT BECOMES NECESSARY TO QUICKLY STRONG-ARM THE STEERING WHEEL, IN HOPES OF FORCIBLY COMPLETING THE TURN SO THAT IT DOESN'T GO OFF THE PATH POSSIBLY CRASHING INTO SOMETHING OR SOMEONE. FORD HAS ISSUED A TSB #05-9-23 PERTAINING TO THIS ISSUE. WHY IS A MECHANICAL PROBLEM THAT CAN BE SO DANGEROUS TO THE DRIVER, PASSENGERS AND OTHERS NOT IDENTIFIED AS A RECALL VS. A TSB? *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE PARKED, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER SIDE COIL SPRING WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE FRONT PASSENGER SIDE COIL SPRING WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE DRIVER STARTED THE VEHICLE AND HEARD A POPPING NOISE. THERE WAS SMOKE SEEN RISING FROM UNDER THE HOOD. THE CONTACT APPEARED ON THE SCENE TO EXAMINE THE VEHICLE AND NOTICED THAT THE POWER ASSIST FEATURE ON THE BRAKES WAS NO LONGER FUNCTIONING. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT VARIOUS HOSES FOR THE BRAKING SYSTEM FAILED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS). THE MANUFACTURER WOULD NOT HONOR THE RECALL A SECOND TIME. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 95,173.

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED AT THE OWNER'S EXPENSE, EVEN THOUGH THERE WAS A RECALL ISSUED FOR THE SIMILAR DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 11V107000 (AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE). THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. IN ADDITION, THE STEERING WHEEL WOULD EMIT A LOUD CLUNKING AND RATTLING NOISE WHEN THE VEHICLE WAS IN OPERATION. THE STEERING WHEEL WOULD ALSO LOCK WHENEVER THE VEHICLE WAS BEING DRIVEN FOR OVER A PERIOD OF TWENTY MINUTES AND EVENTUALLY UNLOCK WHEN THE ENGINE WAS SHUT OFF. THERE WAS A TECHNICAL SERVICE BULLETIN PERTAINING TO THE NHTSA ITEM NUMBER 10014252 (STEERING). THE STEERING WHEEL WAS REPAIRED BY THE DEALER AND THE PROBLEM CONTINUED TO OCCUR. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH HANKOOK SNM TIRES, SIZE: P235 70 R17. THE CONTACT STATED THAT WHILE TRAVELING 55 MPH, THE REAR DRIVER SIDE TIRE BLEW. THE CONTACT STATED THAT TWO WEEKS PRIOR TO THE FAILURE, THE VEHICLE PASSED STATE INSPECTION WITH NO INDICATION OF A FAILURE. THE CONTACT STATED THAT THE TIRE TREAD SEPARATED AND CAUSED THE FAILURE. THE CONTACT WAS TOLD THE TIRES WERE IMPORTED FROM KOREA AND THAT THE RUBBER DID NOT WEAR EVENLY. THE FAILURE AND THE CURRENT MILEAGE WAS 30,000. .. UPDATED 08-30-12 *BF UPDATED 08/31/2012 *JS

PARKING MY TRUCK IN MY GARAGE, STOPPED, PUT TRANSMISSION IN PARK, CLOSED DRIVERS DOOR POWER WINDOW, HEARD LOUD POP, SOUNDED AS IF GLASS BROKE, BUT IT DID NOT. WINDOW FELL DOWN INTO DOOR, WOULD NOT RAISE UP. PRESSING POWER BUTTON, I COULD HEAR MOTOR RUNNING, BUT WINDOW WOULD NOT MOVE. *JS

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SHIFTER CABLE DETACHED FROM THE CONNECTION IN THE TRANSMISSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE MECHANIC REPLACED THE SHIFTER CABLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

WHILE SITTING AT REST, THE LEFT FRONT COIL SPRING BROKE AT THE BOTTOM RUNG. THE ENGINE WAS NOT RUNNING AND THE TRUCK WAS UNLOADED. I HEARD A LOUD SNAP AND THE TRUCK SHOOK. NO PARTS OR FRAGMENTS WERE RELEASED AND THE BREAK WAS CLEAN AND RATHER EVEN ACROSS THE BODY OF THE SPRING. THE STANCE OF THE TRUCK HAS BEEN ALTERED ALTHOUGH NO CHANGE IN DRIVABLILITY TO DATE (NEXT DAY). *TR

JUNE 24, 2012 DEAR FORD MOTOR COMPANY, I OWN A 2005 FORD F150 4X4 CREW CAB TRUCK, WHICH I HAVE HAD SINCE 2005, AND WHICH YOU HAVE EXCLUDED FROM YOUR PRESENT RECALL OF 2005-2006 FORD F150'S. HOWEVER, IT HAS PRESENTED AN ILLUMINATED AIR BAG LIGHT EVERY TIME IT HAS BEEN STARTED NOW FOR OVER 2 YEARS.THIS I HAVE LEARNED IS THE SINGLE WARNING SIGN CAPABLE OF WARNING OF ITS FAULTY AIR BAG SYSTEM. I AM AWARE THAT NHTSA WANTED FORD TO RECALL 1.2+ MILLION TRUCKS AND THAT FORD HAS AVOIDED SUCH A WIDE-SPREAD RECALL SAYING THEY HAD MADE PRODUCTION CHANGES THAT MINIMIZED THE NUMBER OF AFFECTED TRUCKS, AND THAT NHTSA SENT ANOTHER LETTER WARNING FORD THAT IF THEY DIDN'T AGREE TO A COMPLETE RECALL, THE AGENCY COULD CONVENE A FORMAL PUBLIC HEARING TO COMPEL A RECALL, AND THAT NOW FORD HAS AGREED TO RECALL 2004 THROUGH 2006 F-150 VEHICLES, APPROXIMATELY 1.2 MILLION MORE TRUCKS. YET STILL MY TRUCK IS A 2005, THE VERY YEAR MODEL INCLUDED IN YOUR ORIGINAL RECALL, YET FOR WHATEVER REASON MY 2005 FORD F150 IS EXCLUDED, LEAVING ME TO CHANCE THE SAFETY OF MY FAMILY'S LIFE EVERY TIME ANY OF US GET IN MY TRUCK (WHICH ONLY LIKES 2 PAYMENTS BEING PAID FOR). BY THE WAY, I AM A MOTHER OF 3, DAUGHTER OF 2, SISTER TO 1 AND THE GIRLFRIEND OF A MEAN BIKER, SHOULD I PARISH MY CHILDREN WOULD BE ORPHANS, BUT MORE IMPORTANTLY TO FORD MOTOR COMPANY, SHOULD ANY OF MY CHILDREN BE SO MUCH AS HARMED DUE TO THIS WELL DEPICTED ISSUE, FORD MOTOR COMPANY IS GOING TO WISH MY CHILDREN WERE ORPHANED! [XXX] P.S. I ALSO COME FROM A FAMILY OF FORD ENTHUSIASTS, THUS I HAVE GREAT FAITH IN YOUR LOYALTY AND THEREFORE WILL ALLOW YOU A MINIMAL AMOUNT OF TIME TO INCLUDE MY 2005 FORD F-150 IN YOUR RECALL (AND NOTIFY ME OF IT), BEFORE I FORWARD THIS CORRESPONDENCE TO THE NHTSA AND EVERYWHERE ELSE ADDITIONAL RESEARCH INSTRUCTS ME TO. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH GOODYEAR WRANGLER TIRES, SIZE 235/70/R17. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE FRONT DRIVER'S TIRE BLEW OUT. THE ROAD CONDITIONS WERE CLEAR. THE CONTACT STATED THAT THE TREAD AROUND THE TIRE SEPARATED COMPLETELY FROM THE REST OF TIRE. THE LEFT AND RIGHT SIDES ATTACHED TO THE RIM REMAINED INTACT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIR SHOP TO GET THE TIRES INSPECTED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 115,000. THE FAILURE AND CURRENT MILEAGE OF THE TIRE WAS 1,000.

DRIVING OUT OF A PARKING LOT, ONLY 10 MPH OR SO, LOUD POP ON PASSENGER SIDE DOOR. STOPPED THE VEHICLE, AND PASSENGER WINDOW DROPPED DOWN INTO THE DOOR. GRATEFUL I WAS NOT GOING FAST AND HAD THE ABILITY TO STOP QUICKLY, OTHERWISE POTENTIAL ACCIDENT. LOOKING ONLINE, CAN SEE THIS IS A FREQUENT PROBLEM WITH THIS YEAR, MAKE, MODEL TRUCK. A MATTER OF TIME BEFORE SOMEONE GETS HURT FROM THIS. *JS

THIS 5.4 LITER V8 MOTOR REQUIRED REPLACEMENT OF SPARK PLUGS (CHECK ENGINE MESSAGE FLASHED ON THE DASHBOARD). THE SPARK PLUGS HAD WELDED THEMSELVES TO THE ENGINE HEAD, ULTIMATELY REQUIRING THE REMOVEL OF THE ENGINE HEAD TO EXTRACT SPARK PLUG-COST $2,000 IN ADDITIONAL COST TO CONSUMER. INTERNET IS FULL OF SIMILAR REPORTS. MECHANICS AT FORD DEALERSHIP AND MIDAS REPORT FREQUENT ENCOUNTER WITH THIS ISSUE WITH SIMILAR RESULT. I HAVE CONTACTED FORD AND THEY CLAIM NO LIABILITY, STATING NHTSA HASN'T REQUIRED THEM TO DO A RECALL. *TR

AFTER THE RECALL TO PREVENT A SHORT BETWEEN HORN AND AIR BAG WAS COMPLETED IN 2011 A SHORT TIME THEREAFTER IN THE MIDDLE OF THE NIGHT THE HORN CAME ON BY ITSELF IN THE LOCKED VEHICLE WITH NO ONE IN IT. AFTER TRYING EVERYTHING I COULD THINK OF LIKE STARTING THE ENGINE AND PUSHING THE HORN BUTTON NUMEROUS TIMES. I WAS ABOUT READY TO DISCONNECT THE BATTERY WHEN IN ANGER I HIT THE CENTER OF THE STEERING WHEEL VERY HARD WITH MY HAND AND THE HORN STOPPED BLOWING. FROM THAT DAY ON THE AIRBAG WARNING LIGHT STAYS ON WHEN THE ENGINE RUNS. AND THE HORN BLOWS HALF AS LOUD AS IT ORIGINALLY DID WHEN ACTIVATED. FORD SAYS ITS MY PROBLEM BECAUSE THE RECALL WAS ALREADY COMPLETED. ONLY PROBLEM HERE IS THAT THEIR WAS NO PROBLEM AT ALL UNTIL AFTER THE RECALL WORK. *TR

I WAS LEAVING AN ATM (IT WAS RAINING), I ROLLED UP THE DRIVERS WINDOW. WHEN THE WINDOW REACHED THE TOP THE WINDOW FELL (FREE FALL WAS MORE LIKE IT) IN TO THE DOOR. ONCE I REMOVED THE DOOR PANEL AND INSPECTED THE WINDOW PARTS I FOUND THE REGULATOR FAILED/BROKE. WE ARE THANKFUL THE WINDOW DID NOT BREAK AND INJURE US. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS BEING EXAMINED FOR ROUTINE MAINTENANCE WHEN HE WAS INFORMED THAT FOUR SPARK PLUGS WERE FRACTURED. THE CONTACT ALSO STATED THAT THE SPARK PLUGS WERE SUPPOSED TO LAST FOR APPROXIMATELY 100,000 MILES BEFORE BEING REPLACED. THE DEALER STATED THAT A CARBON BUILD UP ON THE TIPS OF THE PLUGS CAUSED THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 81,000.

THE TRUCK HAS BEEN BACK TO FORD MANY TIMES FOR DRAINING THE BATTERY. IF IT IS PARKED FOR 2 TO 3 DAYS I WOULD HAVE TO JUMP START IT. THE DEALERS COULD NOT FIND THE PROBLEM AND KEEP REPLACING THE BATTERY. AFTER IT WAS OUT OF WARRANTY PAID OUT OF MY OWN POCKET TO FIND THE PROBLEM STILL COULD NOT FIND. I HAVE A VIDEO OF THE TRUCK IN12/11 OF THE HEATER/DEFROSTER RUNNING AFTER THE TRUCK WAS PARKED FOR 3 HOURS WITH NO KEYS IN THE TRUCK. ON 5/16/2012 THE TRUCK WAS PARKED IN MY DRIVEWAY AND CAUGHT FIRE UNDER THE DASH. *TR

DRIVING MY SON HOME FROM SCHOOL, HEARD A LOUD POP IN THE DRIVER'S SIDE DOOR, WHICH MADE ME JERK THE WHEEL (GLAD I WASN'T GOING VERY FAST), THEN THE DRIVER'S SIDE WINDOW FELL INTO THE FRAME. DEALERSHIP CLAIMS BROKEN WINDOW REGULATOR. WENT ONLINE AND FOUND HUNDREDS OF COMPLAINTS OF THE SAME. CALLED FORD COMPLAINT NUMBER; THEY VERY KINDLY TOLD ME THERE WAS NOTHING THEY COULD DO AT THIS TIME. TOO MANY COMPLAINTS OF THE SAME ISSUE TO NOT BE ON RECALL LIST. *TR

DRIVING TO CHURCH ON MAY 6TH, 2012 @ 0900 A.M. ON THE INTERSTATE TRAVELING @ 70 MPH. I LOWERED THE WINDOW ABOUT AN INCH. WHEN I PRESSED THE BUTTON TO RAISE THE WINDOW A LOUD POP OCCURRED AND THE WINDOW DROPPED INTO THE DOOR-WELL. IT SCARED EVERYONE IN THE TRUCK. IT WAS A SUNNY DAY. POTENTIAL FOR LOSS OF LIFE IS PRESENT WITH THIS ISSUE. INCLEMENT WEATHER OR BLINDING DEBRIS WITHIN THE CAB COULD RAISE THE POTENTIAL FOR LOSS OF LIFE. PLEASE PETITION FORD MOTOR COMPANY FOR A RECALL ON THIS POTENTIALLY LIFE THREATENING ISSUE. *TR

SITTING IN PARK AS I HAD JUST STARTED THE VEHICLE WHEN THE AIRBAG DEPLOYED. *TR

CROSS-REFERENCE FORD TSB 07-13-5: WATER LEAK FROM AC HAS FLOODED THE PASSENGER FLOOR PAN AND ALL ASSOCIATED CARPETING AND PADDING. SIGNIFICANT HEALTH HAZARD EXISTS IN WARM CLIMATES DUE TO THE PROLIFERATION OF RESPIRATORY HAZARDS INCLUDING BUT NOT LIMITED TO LEGIONNAIRE'S DISEASE. THE ITEM SHOULD BE A RECALL FOR THIS REASON. I HAVE LOST USE OF MY TRUCK DUE TO THE INABILITY TO SUFFICIENTLY DRY THE PADDING - I HAVE HAD THE VEHICLE DRYING FOR ONE WEEK IN HOT FLORIDA SUN TO NO AVAIL. *TR

FOR THE THIRD TIME, I HAVE HAD A DOOR WINDOW DROP FROM A FULLY CLOSED POSITION TO A FULLY OPEN POSITION. IN DOING RESEACH ON THE ISSUE, I FIND THAT THIS IS A COMMON PROBLEM WITH 2004 - 2005 MODEL YEAR F150 CREW CABS. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH HE NOTICED THAT THE ENGINE MISFIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE MECHANIC STATED THAT THE REVERSE SPARK PLUGS WELDED THEMSELVES TO THE ENGINE HEAD. THE MECHANIC PERFORMED A TUNE UP AND REPLACED THE SPARK PLUGS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000. THE VIN WAS UNAVAILABLE. UPDATED 06/05/12*LJ THE CUSTOMER STATED FORD REPLACEDTHE FAULTY FUEL INJECTORS. UPDATED 06/06/12 *JS

I WAS DRIVING ON A RESIDENTIAL STREET (GRAY ST. )APPROACHING A BUSY TWO LANE STREET THAT WAS ONE WAY HEADING SOUTH (ARMENIA AVENUE) IN TAMPA, FLORIDA. AS I WAS APPROACHING THE STOP SIGN, MY FOOT WAS ON THE BRAKE. PREPARING TO STOP, BUT INSTEAD OF STOPPING THE ENGINE REVVED AND ACCELERATED INTO THE LANES OF TRAFFIC TRAVELING SOUTH. I WAS STANDING ON THE BRAKE SO HARD THAT MY LEG WAS SHAKING WHEN I FINALLY STOPPED. I STOPPED THE VEHICLE BY DEPRESSING THE EMERGENCY BRAKE AND THE RPM'S FINALLY CAME DOWN AND THE ENGINE RETURNED TO NORMAL. I WAS SO NERVOUS BECAUSE IF THERE HAD BEEN CARS COMING I WOULD HAVE BEEN HIT ON THE DRIVER'S SIDE. THE STREET IS USUALLY VERY HEAVY WITH TRAFFIC. I WAS VERY LUCKY THAT THERE WAS NO ONE CLOSE OR I MAY NOT BE WRITING THIS TODAY. A FEW DAYS LATER I CAME TO THE SAME CORNER AND A BICYCLIST CROSSED RIGHT IN FRONT OF ME. IF THIS HAD HAPPENED ON APRIL 12TH, I WOULD HAVE RUN OVER THE BICYCLIST. I DROVE AROUND THE BLOCK VERY SLOWLY CONTINUING TO STOP AND RPM'S WERE NORMAL. I REALLY THOUGHT EVERYONE WOULD THINK I WAS CRAZY FOR WHAT HAD JUST HAPPENED. WHEN THE FORD DEALERSHIP FOUND THE PROBLEM ON THE COMPUTER I WAS RELIEVED TO KNOW THAT THERE WAS A PROBLEM THAT COULD BE FIXED. IT WAS THE THROTTLE BODY. A MONTH LATER OUR OTHER FORD F-150, A 2007, HAD THE SAME PROBLEM AND THIS TIME MY HUSBAND WAS DRIVING IT. THERE WAS A REPORT ON THIS VEHICLE ALSO. FORD IS NOT RECOGNIZING THAT THERE IS A PROBLEM AND OTHER VEHICLES ARE BEING BROUGHT IN FOR THE SAME ISSUES WHICH COULD RESULT IN SERIOUS INJURY OR FATALITIES TO INNOCENT PARTIES DUE TO SOME DEFECT IN THE THROTTLE BODY'S ON THE F-150'S. MY REPORT NUMBER ON OUR 2007 F-150 IS 10459967. *TR

ON THREE SEPARATE OCCASIONS, MY FORD 2005 F150 KING RANCH SUPERCREW 4X4 ENGINE SUDDENLY DIED WHILE DRIVING AT APPROXIMATELY 55-60MPH. ON ALL THREE OCCASIONS, I FORTUNATELY WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD WITH THE ENGINE DIED AND NO POWER STEERING. IF I HAD NOT BEEN IN THE RIGHT HAND LANE AND ABLE TO PULL OFF OF THE ROAD, THEN AN REAR ENGINE COLLISION WOULD MORE THAN LIKELY OCCURRED IF I WOULD HAVE BEEN IN AN OUTER LANE OF A MULTIPLE LANE HIGHWAY. AFTER THE THIRD OCCASION THIS PAST WEEK, I TOOK THE VEHICLE TO THE FORD DEALERSHIP IN ROCKWALL, TEXAS WHERE IT COST ME $700.00 TO HAVE THROTTLE BODY/MOTOR ASSEMBLY REPLACED. MY OBD READINGS AT HOME WERE P2104 AND P2112. IF NOT ALREADY, THIS ISSUE IS A FATALLY WAITING TO HAPPEN. LOTS OF CHATTER ON INTERNET OF SIMILAR ISSUES. *TR

ENGINE STARTED TICKING ENDED UP BEING CAM PHASERS AND NEEDED NEW MOTOR FORD KNOWS ITS A WELL KNOWN PROBLEM BUT REFUSES TO STAND BEHIND THEIR PRODUCTS.WAS TOLD IT WAS NORMAL ENGINE WEAR WHICH I FIND HARD TO BELIEVE AT 100,000MILES WITH RECOMMENDED MAINTENANCE DONE TO VEHICLE CLASS ACTION LAWSUIT WOULD BE THE BEST FOR ALL INVOLVED WHEN IT COMES TO THIS PRODUCT 7000 DOLLARS TO REPLACE MOTOR.

#3 SPARK PLUG BLEW OUT WHILE TRAVELING AWAY FROM HOME IN ANOTHER STATE. IN DRIVING TWO MILES BACK TO MY SON'S HOUSE, I HAD TWO EXPLOSIONS FROM EXCESS GASOLINE AND SPARK PLUG FIRING. THE SPARK PLUGS WERE ORIGINAL AND BLEW OUT BECAUSE OF THE FINE THREADS AND ALUMINUM CYLINDER HEADS. THIS IS A DESIGN DEFECT AND SAFETY PROBLEM KNOWN TO FORD. TOWING AND INSERT INSTALLATION BY A FORD DEALER WAS $950. THE ENGINE IS A 4.6 V-8 UPDATED 05/17/12 *BF

THE HOSES FROM THE WINDOW WASHER PUMP TO THE SPRAYERS HAVE DETERIORATED