2008 Ford F-150 Complaint Log

WHILE MAKING LEFT OR RIGHT TURNS THE STEERING GETS HARD TO STEER THEN IT LOOSENS UP MAKING IT OVER STEER. I BELIEVE IT IS IN THE STEERING SHAFT U-JOINT BECAUSE IT IS ALL RUSTED.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING, THE ENGINE MADE AN ABNORMAL NOISE AND THE CHECK ENGINE LIGHT ILLUMINATED. IN ADDITION, THE OIL PRESSURE WAS LOW AND THE VEHICLE SHOOK VIOLENTLY. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE TECHNICIAN INFORMED THE CONTACT THAT THERE WAS A TSB FOR THE FAILURE (14-0114). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE TURNING LEFT OR RIGHT, THE STEERING WHEEL STIFFENED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE POWER STEERING WAS LEAKING AND THE RACK AND PINION AND HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.

AIRBAG STAYS ON ALL THE TIME DO NOT MATTER WHAT YOU DO IT HAS A CODE OF 1869

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOST OIL PRESSURE AND STALLED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND WAS ABLE TO RESTART AND RESUME DRIVING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE LOW OIL PRESSURE CAUSED THE ENGINE TO FAIL. THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFTING CABLE BURNED THROUGH OR FRACTURED DUE TO THE CABLE RESTING ON THE EXHAUST MANIFOLD. THE DEALER REPLACED THE TRANSMISSION SHIFTING CABLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,172. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE SHIFTING CABLE HAD BURNT THRU OR FRACTURED DUE TO THE CABLE RESTING ON THE EXHAUST MANIFOLD AND CORROSION. THE DEALER REPLACED THE TRANSMISSION SHIFTING CABLE AND REPAIRED THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,172.

TIRE TREAD SEPARATION ON FRONT DRIVE SIDE TIRE. I WAS ABLE TO CATCH IN TIME AND HAD TIRE REPLACED BUT WOULD LIKE COMPANY TO REIMBURSE ME BECAUSE THIS BRAND OF TIRE WAS RECALLED LAST YEAR FOR THE SAME REASON BUT DID NOT INCLUDE THE P265/70R17. THE BRAND OF TIRE IS CAPITAL PRECISION TRAC II, THE TIRE SHOP THAT REPLACE THE TIRE TOLD ME I WAS LUCKY THAT IT DID NOT BLOW ON THE HIGHWAY. *TR

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT UPON REMOVING THE KEY AND RE-ENTERING THE KEY TO START THE VEHICLE, THE IGNITION SWITCH CYLINDER FRACTURED. THE CONTACT MADE SEVERAL ATTEMPTS AND WAS ABLE TO MANEUVER THE SWITCH BACK INTO PLACE, BUT IT WAS NOT SECURELY CONNECTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR FURTHER INSPECTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 4/7/15*CN UPDATED 04/14/15

2008 FORD F150 TIRES, WITHIN THREE MONTHS AND 283 MILES ALL FOUR OF THE TIRES HAD TREAD SEPARATION AND WERE REPLACED. ..UPDATED 02/12/15*BF THE CONSUMER STATED THE TREAD SEPARATED ON THE REPLACEMENT TIRES, AS WELL. *JB

I WAS DRIVING MY 2008 FORD F150 WHEN THE ENGINE SUDDENLY STARTED SEVERE JERKING/MISSING AND LOSS OF POWER. IT CONTINUED TO GET WORSE WHILE VEHICLE WAS UNDER LOAD THEN EVENTUALLY THE ENGINE STOPPED WORKING AND WOULD NOT START. I WAS ABLE TO DETERMINE THE ISSUE WAS A LOSS OF FUEL PRESSURE CAUSED BY A DEFECTIVE FUEL PUMP DRIVER LOCATED ABOVE THE SPARE TIRE ON A STEEL CROSS MEMBER. THIS PART WAS SEVERELY CORRODED DUE TO AN ENGINEERING FLAW REPORTED BY HUNDREDS OF F150 OWNERS PRIOR TO THIS INCIDENT. THIS ISSUE NEEDS TO BE ADDRESSED BY NHTSA WITH FORD AND A RECALL INITIATED TO REPLACE THIS COMPONENT WITH THE IMPROVED PART DESIGN NOW AVAILABLE. *TR

FUEL PUMP DRIVER CORROSION CAUSE TRUCK TO STALL AND NOT RESTART LUCKY I WAS IN SAFE LOCATION OR COULD HAVE BEEN A BAD SCEAN FORD SHOULD RECALL THIS PART CAUSE IN STATES THAT USE SALT CAUSES THIS PROBLEM DOES SOMEONE HAVE TO DIE BEFORE IT GETS FIXED CAUSE NEW ONES HAVE A SPACERS SO THEY DON'T RUST IM SURE THIS HAS BEEN BROUGHT UP MANY TIMES THANK YOU *TR

TL*THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THERE WAS A STRONG ODOR OF FUEL EMITTING THROUGH THE VENTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000. ...UPDATED 03/31/15 *BF THE CONSUMER STATED THE MANUFACTURER REFUSED TO OFFER ANY ASSISTANCE DUE TO THE VEHICLE BEING OUT OF WARRANTY. UPDATED 10/21/2015*JS

THE ENGINE 5.4 TRITON MAKES A SOUND THAT RESEMBLES A DIESEL AND SOUNDS LIKE THE PISTON IS ABOUT READY TO COME THROUGH THE BLOCK. I FIRST EXPERIENCED THIS APPROX. 3 YEARS AGO WHILE AT A DRIVE THROUGH FAST FOOD RESTAURANT. I IMMEDIATELY TURNED OFF THE ENGINE. I THEN RESTARTED AND THE NOISE HAD STOPPED. THE MOTOR NOW STILL HAS THE SAME ISSUE, AND AFTER READING MANY FORUMS STATING THE SAME CONDITIONS, DECIDED TO CALL FORD DIRECTLY. THE RESPONSE FROM FORD WAS THEY KNOW ABOUT THE ISSUE ON THESE TYPES OF MOTORS, BUT ARE NOT ISSUING A RECALL FOR THE FIX. THE ISSUE IS APPARENTLY RELATED TO A KNOW CAM, TIMING CHAIN ISSUE THAT HAS TO HAVE THE GEARS AND TIMING CHAIN REPLACED. AT THE OWNERS EXPENSE OF APPROX. 800-1200M DOLLARS PER SIDE ON THIS TYPE OF V8 MOTOR. I RECOMMEND THAT FORD NEEDS TO DO A RECALL ON THESE, AND FIX THE KNOWN ISSUE, THUS CREATING FURTHER PURCHASES FROM CONSUMERS FOR FUTURE PURCHASES OF THEIR PRODUCT. IF YOU ARE IN DOUBT OF THIS ISSUE, JUST TYPE IN YOUR SEARCH ENGINE, 2008 FORD F150 LOUD KNOCKING NOISE WHILE IDLING, AND SIT BACK AND READ UNTIL YOU ARE TIRED OF READING. PLEASE FEEL FREE TO CONTACT ME WITH ANY QUESTIONS. THANK YOU.

ON SUNDAY 12/14/14 AT 7PM MY 2008 FORD F-150 SHUT OFF WHEN I WAS GOING 65 MPH DOWN THE NEW YORK STATE THRUWAY. I WAS STUCK ON THE SIDE OF THE ROAD FOR HOURS WAITING FOR IT TO BE TOWED. TURNS OUT THE FUEL PRESSURE MODULE (FPM) THAT IS MOUNTED IN THE BACK OF THE TRUCK ON A CROSSMEBER OF THE FRAME UP ABOVE THE SPARE TIRE WAS THE CAUSE. FORD NEEDS TO RECALL THESE 2004-2008 FORD F-150 THAT USE THIS FPM BEFORE SOMEONE GETS KILLED ON THE SIDE OF THE ROAD! *TR

REAR END DOES A SKIDDING WHEN COMING FROM A COMPLETE STOP TO MOVING. LOOKS AS THOUGH THE BRAKES ARE NOT RELEASING LIKE THEY SHOULD, BUT SOUNDS LIKE THERE IS GRINDING FROM THE REAR DIFFERENTIAL. WHEN CALLING AUTO PART STORES ABOUT GETTING A REPLACEMENT, THEY HAVE ALL ADVISED THAT THIS YEARS (2008) FORD F-150S ALL HAVE THIS SAME PROBLEM. ALL STORES SAY IT IS THE DIFFERENTIAL CLUTCH PACKS IN THESE 2008 FORD F-150S BUT FORD WILL NOT TAKE RESPONSIBILITY OF THE MALFUNCTION OF THIS PART. *TR

I WAS DRIVING MY TRUCK HOME ON THANKSGIVING AND IT BLEW OUT A SPARK PLUG (SECOND INCIDENT, DIFFERENT CYLINDER). I WAS LATER TOLD THAT AN ENGINE FIRE COULD OCCUR FROM THE FUEL/FUMES COMING FROM THE OPEN CYLINDER HEAD. *JS

MOTOR EJECTED SPARK PLUG PASSENGER SIDE THIRD ONE BACK. SHOULD BE A RECALL BECAUSE IT IS A FAULTY DESIGN. *TR

TL* THE CONTACT OWNS A 2008 FORD F 150. AFTER STARTING THE VEHICLE, EXHAUST FUMES EMITTED INSIDE THE VEHICLE, BUT THE FAILURE RECURRED DAILY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE EXHAUST MANIFOLD KIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

TL*THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, AN ABNORMAL NOISE EMITTED FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER MECHANIC, WHO DIAGNOSED THAT THE TIMING CHAIN, TIMING CHAIN SLIDE, TIMING CHAIN TENSIONER AND CAM PHASERS NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WATER LEAKED INTO THE THIRD BRAKE LIGHT AND ONTO THE REAR SEATS OF THE VEHICLE. AS A RESULT, THE CONTACT STATED THAT THE LOWER REAR CAB CORNERS BECAME RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

THE CLEAR COAT PAINT IS PEALING OFF THE FRONT TRUCKER AROUND THE HEADLIGHT AND FRONT BUMPER. *TR

STARTED VEHICLE WITH NO ISSUES, DROVE FROM HOME TO LOCATION APPROXIMATELY 30 MILES AWAY. DURING THE DRIVE, I COULD FEEL A "HESITATION" DURING THE AUTOMATIC SHIFTING OF GEARS. HESITATION SEEMED TO PROGRESS DURING DRIVE TO LOCATION. ARRIVED AT LOCATION WITH NO FURTHER ISSUES. 3 HOURS LATER I LEFT LOCATION, IN ROUTE BACK TO MY HOME, AND NOTICED SAME HESITATION. ON THE WAY HOME THE "TRANS FAULT" CODE CAME ON AND THE "O/D OFF" INDICATOR LIGHT BEGAN BLINKING ON AND OFF. I ARRIVED AT MY HOME WITH NO FURTHER ISSUES. WHILE AT HOME, I ATTEMPTED TO PLACE THE VEHICLE IN REVERSE AND IT DID NOT SHIFT FOR ALMOST 3-5 SECONDS, THEN THE TRANSMISSION SEEMED TO ABRUPTLY SHIFT INTO REVERSE. AT THIS POINT MY VEHICLE IS NOT OPERABLE FOR FEAR OF CAUSING FURTHER DAMAGE. *TR

VEHICLE WOULD STALL AT SLOW SPEED AND SEVERE RATTLING AND LOSS OF POWER TO VEHICLE WHICH COULD EASILY RESULT IN ACCIDENT. FORD SERVICE INDICATED THAT IT WAS CAM PHASING OR OTHERWISE KNOWN AS INTAKE CAMSHAFT POSITION TIMING OVER RETARDED PROBLEM. VERY DANGEROUS CONDITION WHICH SHOULD BE ADDRESSED VIA RECALL. *TR

STEERING STICKS. *TR

MY TRUCK HAS 81K MILES ON IT AND THE TORQUE CONVERTER HAS GONE BAD. I HAVE NEVER IN THE PAST HEARD OF A BAD TORQUE CONVERTER FROM NORMAL WEAR AND TEAR. THE TOP OF MY STEERING WHEEL IS SHOWING MAJOR WEAR. MY WIFE'S 2000 MINI VAN HAS NO WEAR ON IT. WHY WOULD THE TOP OF MY STEERING WHEEL BE FALLING APART? *TR

WHILE MAKING A LEFT HAND TURN, NOTICED STEERING BECAME VERY TIGHT. HAD TO FORCE IT THEN IT "RELEASED" RESULTING IN AN OVER STEER AND ALMOST VEERING TO ONCOMING TRAFFIC. CENTERING THE WHEEL ALSO BECAME DIFFICULT AND RESULTING IN OVERSTEER THE OPPOSITE WAY. SAME PROBLEM - RIGHT OR LEFT HAND TURN. WAS INTERMITTENT BUT HAS BECOME CHRONIC NOW AND GETTING WORSE. HAVE NOT HAD IT IN THE SHOP YET. *TR

WHEN I WAS MAKING A LEFT TURN OFF A HIGHWAY RAMP, THE STEERING WHEEL LOCKED UP & THEN SNAPPED BACK & SPRAINED MY WRIST. I DON'T CARE ABOUT MY WRIST,BUT I DO CARE ABOUT THE DEFECTIVE LOWER STEERING SHAFT THAT WAS ENGINEERED WRONG TO START WITH & YOU MADE FORD ISSUE A RECALL (BECAUSE OF THE DEFECT)IN ALL THERE MID SIZED & HIGHEND CARS ALONG WITH LINCOLN & MERCURY MODELS BECAUSE IT'S A MAJOR SAFETY PROBLEM. WHAT YOU DIDN'T DO IS, ORDER A RECALL FOR ALL FORDS THAT HAS THE SAME LOWER STEERING SHAFT! WHY? YOU SAY IT'S NOT A SAFETY PROBLEM IN THE F-150, WHY? JUST BECAUSE IT'S A TRUCK OR FORD PAID YOU OFF NOT TO ISSUE THE RECALL FOR THE F-150'S?? IF IT'S A DEFECTED PART IN THERE CARS,IT'S THE SAME PART PUT IN F-150'S,MADE BY THE SAME CO.. I PD $38,000 FOR A TRUCK THAT HAS THE SAME DEFECTED PART YOU MADE THEM ISSUE A RECALL. SOME LINCOLNS & MERCURY CARS RECALLED ARE HEAVIER THAN MY F-150,BUT THAT DOESN'T MATTER TO YOU. I ALMOST CRASHED THREW THE GUARD RAIL & IF I DID, I WOULD BE DEAD!! I WANT TO KNOW HOW YOUR AGENCY EXCLUDED THE F-150 IN THE RECALL?? ARE YOU PEOPLE ENGINEERS? HOW IN THE WORLD COULD YOU EXCLUDE ANY VEHICLE IN THE RECALL THAT HAS THE SAME DEFECTED PART IN IT? PLEASE E-MAIL ME THE REASON WHY A DEFECTED PART FORD MADE,IS ONLY A SAFETY ISSUE IN CARS, BUT NOT THE F-150"S THAT HAS THE SAME LOWER STEERING SHAFT'S. I REALLY WANT TO KNOW. THINK OF THIS, A MERCURY SABLE HAD THE SAME PROBLEM I HAD WHILE MAKING A LEFT TURN, THE MERCURY WOULD HIT THE GUARD RAIL & STOP, MY F-150 WOULD OF WENT UP & OVER THE GUARD RAIL & FALL TO MY DEATH!! A DEFECTED PART IS A DEFECTED PART,NO MATTER WHAT VEHICLE IT'S IN. I WANT TO KNOW WHY YOU THINK IT'S OK FOR MILLIONS OF F-150'S TO HAVE DEFECTED LOWER STEERING SHAFT'S?? GOD FOR BID MY CHILDREN EVER GOT HURT BECAUSE YOU IDIOT'S SAID A DEFECTED PART IS OK ON F-150'S!! *TR

DRIVERS SIDE SEAT BELT TAKES A FEW TRIES TO GET IT TO CLICK AND SOMETIMES IT DOESN'T ENGAGE ALL THE WAY AND THE LATCH COMES OUT. A MISFIRE IN CYLINDER 1 LEAD THE DISCOVERY OF KNOWN ISSUES WITH SPARK PLUGS AND REMOVAL. 3 OF THE PLUGS WERE LOOSE. *TR

STARTED SHAKING AND SPUTTERING IN REVERSE AT LOW RPM. TWO TRANSMISSION SHOPS SAID IT WAS THE REVERSE BAND IN TRANSMISSION AND NEEDED REBUILD. HAD TRANS REBUILT (AT COST OF 2390.00). AFTER REBUILD, MECHANIC WAS DRIVING AND IT STILL HAD PROBLEM. AFTER RESEARCHING, HE THINKS IT IS THE CAM PHASERS CAUSING PROBLEM. HE HAD REPLACED MY PLUGS BEFORE TRANSMISSION WORK TO RULE THAT OUT (ALL 8 OF THE PLUGS BROKE WHILE TAKING THEM OUT, HE HAD NEVER SEEN ALL BREAK ON A F150 BEFORE). THIS ENGINE/TRANSMISSION IS A BAD DESIGN ALL AROUND AND FORD NEEDS TO STEP UP, ADMIT IT AND FIX AND OR REIMBURSE CUSTOMERS FOR REPAIRS. YOU CAN SPEND THOUSANDS CHASING PROBLEMS IN THIS POWER TRAIN! EVEN THOUGH THE TRANSMISSION REBUILD DID NOT FIX THE INITIAL PROBLEM, THE REAR BAND WAS WORN, AND THE PLATE IN THE TRANSMISSION HAD A SMALL DENT AND HAIR LINE CRACKS, SO IT WAS GOING TO FAIL EVENTUALLY! THE TRANSMISSION SHOP SAID THIS IS COMMON IN THESE. I WANT SOMETHING DONE! *TR

TL-THE CONTACT OWNS A 2008 FORD F150. THE CONTACT STATED THAT THE WINDSHIELD RUBBER COVER MOLDING WAS DEFECTIVE. THE RUBBER MOLDING FRACTURED AND CAUSED THE RUBBER TO BECOME TRAPPED IN THE WINDSHIELD DOCK AREA AND CAN BE RELEASED WHILE DRIVING AND CAUSED A CRASH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE VEHICLE WAS NOT REPAIRED THE FAILURE AND CURRENT MILEAGE 36,000. LI

TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED WAS DRIVING 35 MPH AND NOTICED THAT THE ENGINE RPMS INCREASED AS SMOKE BILLOWED FROM THE EXHAUST. AFTER THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN, IT WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEALS WERE LEAKING TO THE BEARINGS AND THE TURBO OF THE EMISSIONS SYSTEM HAD FAILED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

STEERING IS TIGHT AND HARD TO STEER ESPECIALLY WHILE DRIVING AROUND CURVES AND WHEN TURNING THE STEERING IS TIGHT AND THEN LOOSENS UP AND JERKS SUDDENLY . FOUND THE STEERING COLUMN KNUCKLES SCOLDED AND NO WAY TO LUBRICATE. *TR

VEHICLE HAD INTERMITTENT STARTING ISSUE AND HAS LEFT ME STRANDED. AFTER RUNNING A DIAGNOSTIC CHECK WITH A SCANNER RECEIVED A P1233 CODE WHICH IS THE FUEL PUMP DRIVER MODULE OFFLINE. COMPONENT LOCATED UNDERNEATH BOLTED TO THE FRAME.CALLED AND EMAILED SPITZER FORD,LOCAL DEALER, AND THEY'RE UNSURE OR ACTED LIKE THE NEVER HEARD OF THE PROBLEM. WHY IS IT THAT FORD NORTH AMERICA IS SHORT HANDED OF THE FPDM?

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE HEADLIGHTS FAILED, THE AIR BAG ACTIVATED INDEPENDENTLY AND THE AIR BAGS DEPLOYED ERRONEOUSLY. ADDITIONALLY, SMOKE BILLOWED FROM UNDER THE DASHBOARD AREA AS THE FLOORBOARD BECAME ENGULFED IN FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE OR POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS FOUND THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 111,383.

DROVE TRUCK THROUGH CARWASH PULL ON TO ROAD QUIT RUNNING TRIED TO START AND DID ENOUGH TO GET OFF ROAD THEN QUIT AGAIN AND WOULD NOT START AT ALL. TOWED TO FORD GARAGE MODULE RUSTED OFF FRAME. THIS IS A KNOWN PROBLEM WITH FORD BECAUSE PART IS MADE OF POT METAL AND BOLTED TO STEEL CROSS MEMBER. *TR

MALFUNCTION INDICATOR LAMPS, SPEDOMETER, TEMP GAUGE AUDIO BEEPER RANDOMLY GO ON AND OFF. SPEEDOMETER GOES TO ZERO, MILEAGE GOES TO DASHED LINES OR "CHECK GAUGES".

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. WHEN THE BRAKE PEDAL WAS ENGAGED, THE ABS ACTIVATED AND CAUSED THE VEHICLE TO PULSATE AND THE CONTACT TO LOSE CONTROL. THE DEALER REPLACED THE FRONT ROTORS, BUT THE FAILURE RECURRED. THE CONTACT INSPECTED THE VEHICLE AND DRAINED THE FRONT BRAKES; HOWEVER, THE BRAKE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

FUEL PUMP CONTROL MODULE FAILED WITHOUT NOTICE, STOPPING VEHICLE. DISSIMILAR METALS IN CONTACT CAUSED CORROSION OF ELECTRONIC COMPONENT. A KNOWN PROBLEM WITH EVERY ENGINEER AND MECHANIC. *TR

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE JERKED FORWARD WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE ENGINE TEMPERATURE GAUGE REACHED HIGH LEVELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

FRONT FUEL TANK STRAP FAILED WHILE TRAVELING 55 MILES AN HOUR CAUSING FRONT EDGE OF THE FUEL TANK TO HIT THE PAVEMENT AND BE DRUG SEVERAL HUNDRED FEET UNTIL THE VEHICLE WAS ABLE TO GET OFF THE ROADWAY. UPON FAILURE OF THE STRAP, THE METAL HOOK DUG A GROOVE INTO THE DRIVESHAFT. *TR

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE SUN ROOF BECAME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER BUT THE CONTACT WAS ADVISED THAT THEY COULD NOT REPAIR THE FAILURE BECAUSE IT WAS AN AFTER MARKET SUN ROOF. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

I HAD PROBLEMS WITH THE THROTTLE STICKING AND I PUT MY OB11 ON AND ISAID CODE P2104 AND P2111 .SO ICALLED AND THEY SAY ITS A WELL KNOW PROBLEM.IF YOU DON'T KNOW WHAT TO DO I CAN SEE SOME ONE GET HURT SO I THINK IT SHOULD BE A RECALL. *TR

THIS HAS HAPPENED NUMEROUS TIMES WHEN BRAKING THE ACCELERATOR IS ALSO DEPRESSED AT THE SAME TIME. CAUSING THE VEHICLE TO CONTINUE TO MOVE UNEXPECTEDLY. TODAY WHILE PULLING INTO OUR DRIVEWAY THIS HAPPENED AGAIN AND THE VEHICLE WENT THROUGH THE HOUSE PUSHING IT OFF THE FOUNDATION AND CAUSING DAMAGE TO THE VEHICLE. THIS IS A DESIGN FLAW THE GAS AND BRAKE PEDAL ARE TO CLOSE TOGETHER. THIS HAS ALSO HAPPENED TO MY WIFE AND SHE WEARS A SIZE 6 SHOE. ARE THERE ANY RECALLS OR CLASS ACTION SUITS THAT ANY ONE IS AWARE OF. OR DOES SOMEONE HAVE TO DIE BEFORE IT MATTERS. I HAVE BEEN ON OTHER WEB SITES AND FIND MANY OWNERS OF AND \08 F150 HAVE THE SAME COMPLAINTS. *TR

FUEL PUMP DRIVER MODULE - FAULTY DESIGN IN THE MOUNTING OF THE DRIVER MODULE CAUSING PARTS TO FAIL AND CAUSING NO STARTS/LOSS OF POWER(STALES). *TR

THE SEATBELT RECEIVER/LOCKING MECHANISM TO CLASP SEAT BELT ACROSS BODY DID NOT ENGAGE AND SEIZE CLASP. THE RECEIVER DID NOT ENGAGE AND GRASP THE SEATBELT HOOK ON DRIVER SIDE. FAILURE THOUGHT ISOLATED BUT PASSENGER SIDE EXPERIENCED ISSUE AT SAME TIME. EXAMINED RECEIVER, NO GROSS BUILD UP OR EXTERNAL STRUCTURAL DEFORMITIES.. "PUMPING" ACTION REQUIRED TO GET RECEIVER TO ENGAGE. REPEATED INSERTION OF CLASP INTO RECEIVER APPEARS TO HAVE NO EFFECT. BACK SEATBELTS APPEAR UNAFFECTED AT THIS TIME. PROBLEM IS NOW INTERMITTENT. HAS NOT RELEASED CLASP SPONTANEOUSLY YET ONCE ENGAGED UNLESS BUTTON USED. *TR

I HAVE A 2008 FORD F-150 KING RANCH WITH A 5.4 L ENGINE. EXHAUST STUDS HAVE SNAPPED OFF CAUSING A LEAK FROM THE EXHAUST MANIFOLD AND CARBON MONOXIDE FILLS THE CAB OF THIS VEHICLE SETTING AT IDLE. FORD HAS A PROBLEM WITH THIS ENGINE FOR USING A NON CONFORMING GRADE OF STUD. ACCORDING TO FORUMS THAT I HAVE RESEARCHED SHOWED THAT FORD HAS CHANGED THE STUDS. THEY ARE NOW USING STAINLESS STEEL STUDS. IS THERE A POSSIBILITY OF A RECALL ON THIS VEHICLES ENGINE FOR A REPAIR TO CHANGE ALL STUDS TO STAINLESS STEEL. I PURCHASED THIS VEHICLE USED AND NOTICED THE PROBLEM AFTER THE 30 DAY WARRANTY HAD EXPIRED. BUYER BEWARE! PROTECT YOUR FAMILY FROM THIS PROBLEM. *TR

MY SON WAS HAVING TROUBLE WITH ENGINE BEING SLUGGISH FOR A WEEK OR SO AND TRIED TO PASS SOMEONE AND ENGINE CUT OUT AND HE WAS ALMOST RAN OVER BY ONCOMING TRAFFIC. WE TOOK TO FORD DEALER AND THEY HAD A BULLETIN FROM FORD ABOUT FAULTY ENGINES IN 2008 F 150'S AND SAID FORD WOULD REPLACE THE ENGINE. THEY CALLED BACK NOW AND SAID THEY FOUND SOME SLUDGE IN BOTTOM OF ENGINE WHICH ONLY HAS 41,000 MILES ON IT AND SAID FORD WILL NOT COVER IT. THIS IS A FORD DEFAULT AND THEIR LIABILITY. READY TO JOIN THE CLASS ACTION AGAINST THEM ON THIS ISSUE. *TR