2008 Ford F-150 Engine Problems

See attached document for complaint.

The contact owns a 2008 Ford F-150. The contact stated that while driving at an undisclosed speed, the engine seized. The contact stated that the starter and the computer were replaced; however, the failure persisted. The vehicle was towed to the dealer where it was diagnosed as a possible liquid propane injection system failure. The contact stated that after researching, the failure was like the failure described in NHTSA Campaign Number: 08V523000 (Engine and Engine Cooling). The contact was informed that the VIN was not included. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 155,000.

My F150 will run great until it warms up and then it will run rough, shows low oil pressure, and stalls at stops and while driving at low speeds. I have taken it to two mechanics and have spent thousands of dollars without fixing this problem. This has been an ongoing issue and started in Sept. 2022

The contact owns a 2008 Ford F-150. The contact stated while driving at approximately 40 MPH and rounding a right-hand bend, the steering wheel veered to the left direction. The contact stated the "tire pressure" warning light was illuminated. The contact stated the vehicle crashed into a guard rail on the driver's side and flipped over the rail and landed on the driver's side. The contact said that there was damage to the front fender, driver's and passenger door, and rear quarter panel. The contact said he had received medical attention on-site for minor lacerations to his left hand and bruising on his left shoulder. The police wrote an incident report. The vehicle was towed to an impound lot. The contact said that a day prior to the crash he had smelled a burning smell coming from the engine compartment. The vehicle had not been diagnosed by a dealer or independent mechanic. The vehicle was not repaired. The contact had researched online and related the failure to NHTSA Campaign: 08V523000 (Engine and Engine Cooling). The manufacturer had not been informed of the failure. The failure mileage was approximately 167,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS RESTARTED AFTER SEVERAL ATTEMPTS. ON SOME OCCASIONS, THE VEHICLE HESITATED TO START. THE CONTACT BELIEVED THE FAILURE WAS DUE TO ROUSH TRANSITION TO PROPANE ON THE FORD F-150. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE AND OFFERED NO ASSISTANCE. THE CONTACT REFERENCED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 08V523000 (ENGINE AND ENGINE COOLING) HOWEVER VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE THE CONTACT WAS STOPPED AT A TRAFFIC LIGHT, HE SMELLED EXHAUST FUMES INSIDE THE CABIN OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO CAUSEWAY FORD LINCOLN (LOCATED AT 375 NJ-72, STAFFORD TOWNSHIP, NJ 08050, (609) 597-8083), WHERE IT WAS DIAGNOSED THAT BOTH EXHAUST MANIFOLDS, GASKET, AND HARDWARE BOLTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 70,000. *CW CONSUMER STATED HE HAS SOLD THE VEHICLE.*JB

MY TRUCK TIMING BELTS HAVE BIN REPLACED 4 TIMES IN THE LAS 3 YRS. IT STARTS BY MAKING THE ENGINE JUMP THE RPM GO BELOW 300 AND IT SHUTS OFF AS I APPROACH A STOP SIGN OR A LIGHT. THE CHECK ENGINE LIGHT NEVER COMES ON IT JUST SHUTS OFF AND IT WONT DRIVE. *TR

2008 FORD F-150. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. *LD THE CONSUMER STATED THE VEHICLE ENGINE WOULD MISFIRE AND LACKED POWER. THE ENGINE ASSEMBLY WAS REPLACED.*JS

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING 50 MPH, THE ENGINE FAILED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A LOCAL DEALER (AUTO NATION OF PANAMA CITY, 1730 W 15TH ST, PANAMA CITY, FL 32401) AND WAS INFORMED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 180,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE OPERATING THE VEHICLE, THE ODOR OF EXHAUST FUMES WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. ALSO, WHILE IDLING, THE VEHICLE SHOOK AND RATTLED. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DISCOVERED A CRACK IN THE EXHAUST MANIFOLD. THE CAUSE OF THE CRACK WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. JOE MACHENS FORD (807 SOUTHWEST BLVD, JEFFERSON CITY, MO) WAS INFORMED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

ENGINE STUMBLES AND LOSES OF POWER ON SLIGHT INCLINE.

PLASTIC TIMING GUIDES ARE RIPPED FROM MOUNTING LOCATION BY TIMING CHAINS AND DROP INTO THE OIL SYSTEM, USUALLY CAUSING LOSS OF OIL PRESSURE, CONTAMINATED OIL, TRASH-FILLED MOTOR, AND ACCELERATED WEAR OF THE TIMING CHAINS, RESULTING IN ENGINE DAMAGE. USUALLY THE GUIDES BREAK OFF AT OR BEFORE 100,000 MILES AND THE CHAINS NEED REPLACING BETWEEN 120,000 AND 200,000 MILES, DEPENDING ON HOW THE TRUCK IS DRIVEN. METAL REPLACEMENT GUIDES ARE AVAILABLE AT MOST SHOPS AND ONLINE PARTS STORES.PRICES RANGE BETWEEN $10 AND $40. OCCURS IN 4.6L AND 5.4L V8 ENGINES.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING 60 MPH, THE VEHICLE SHOOK WITHOUT WARNING. THE VEHICLE WAS TOWED TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE SPARKS PLUGS WERE FRACTURED AT THE BOTTOM TIP AND WENT THROUGH THE ENGINE. THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS AND ADVISED THE CONTACT TO CALL NHTSA. THE FAILURE MILEAGE WAS 140,000. UPDATED 08/29/17*LJ *CN

WHEN THE TRUCK IS UNDER 1000RPM AND AT NORMAL OPERATING TEMPERATURE, IT BEGINS TO KNOCK LIKE A DIESEL AND SHAKE VIOLENTLY. THIS IS ONLY REMEDIED BY TURNING THE TRUCK OFF OR REVING THE ENGINE OVER 2000 RPM. THE CHECK ENGIN LIGHT NEVER COMES ON AND AT ALL OTHER TIMES THE TRUCK DRIVES NORMALLY. THIS HAD BEGUN TO HAPPEN MORE FREQUENTLY, INCLUDING AT RED LIGHTS, MY TRUCK HAS ONLY 78,000 MILES

BOUGHT MY TRUCK WITHOUT KNOWING THAT IT HAS A COMMON IS WITH THE EXHAUST MANIFOLD LEAK. IT IS REAL BAD WHERE THE FUMES GET IN THE CAB OF TRUCK WHEN IT FIRST STARTS UP THIS ISSUE HAS LEAD TO OTHER HEALTH ISSUES FOR ME

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT HEARD A LOUD NOISE COMING FROM THE MOTOR AND THE SPARK PLUG SUDDENLY BLEW OUT. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT THE FAILURE OCCURRED DUE TO THE ALUMINUM HEADS AND THE THREADS WERE WORN AND FRACTURED, WHICH CAUSED THEM TO DETACH. THE CONTACT HAD THE VEHICLE'S HEATING COILS THREADED IN THE HEAD COVER; HOWEVER, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AGAIN WHO STATED THAT THE HEATING COIL BLEW OUT AND DAMAGED THE HEAD COVER. THE MECHANIC STATED THAT THE HEAD COVER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 12284440. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE COMING TO A STOP, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT PHASER FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

RADIATOR AND THERMOSTAT - I HAVE HAD TO REPLACE 4 RADIATORS IN MY FORD F250 TRUCK AND THE VEHICLE ONLY HAS 125,000 MILES. THIS IS A KNOWN DEFECT FROM FORD AND THEY HAVE DONE NOTHING TO PROTECT THEIR CUSTOMERS. I HAVE BEEN STRANDED 3 TIMES AS A RESULT OF THIS DEFECT WITH MY CHILDREN IN THE CAR.

I HAVE BEEN ADVISED BY THE LOCAL PHIL LONG FORD DEALERSHIP SERVICE DEPARTMENT THAT MY TRUCK NEEDS THE CAM PHASERS REPLACED TO FIX THE PROBLEMS I AM EXPERIENCING. I HAVE SEEN THAT THIS IS A "VERY" COMMON PROBLEM WITH THE 5.4 ENGINE AND FORD HAS RETIRED THIS ENGINE FROM THEIR VEHICLES DO TO THE FAILURES AND IT HAS BEEN KNOWN BY FORD SINCE THE 2003 MODELS AND YET THEY CONTINUED TO SELL A KNOWN FAULTY ENGINE. THEY SHOULD PAY TO HAVE THESE ENGINES REPAIRED AND NOT THE CONSUMERS. THIS IS IN COLORADO SPRINGS, CO AND THE PROBLEMS IS STILL INTERMITTENT AT THIS TIME.

SPARK PLUG BLEW OUT IN A CROWDED STORE PARKING LOT,' BRAKING THE COIL. A FIRE COULD HAVE RESULTED IF COIL HAD NOT BROKE. THE GAS FUMES WERE STRONG. I THOUGHT IT WAS GASKET PROBLEM AND CONTINUED TO DRIVE TO MY MECHANIC'S SHOP.