2003 Ford F-250 Complaint Log

The customer purchased a vehicle from Metro Motors on May 8, 2026, after visiting the dealership three times and speaking with multiple sales representatives. During each visit, the customer specifically stated that the vehicle would be used to tow a trailer and repeatedly asked whether it was safe and suitable for towing. The sales staff consistently represented that the vehicle was in good working condition, had low mileage, showed no significant issues on the Carfax report, and would be an excellent vehicle for towing. The customer was discouraged from test driving the vehicle because it was low on fuel, and sales staff stated that the only reason it had not sold was the snowplow attached to the front. Immediately after taking possession of the vehicle on May 8, the customer experienced a serious issue with the electronic parking brake repeatedly engaging while driving. The customer contacted Metro Motors on the next business day and was instructed by the manager, Nate, to bring the vehicle back. Metro Motors later determined that the parking brake cable was broken and that the brakes were in poor condition. After discussions, the dealership agreed to perform repairs if the customer paid for the parts. After the repairs were completed, the customer noticed smoke coming from the wheels and immediately returned the vehicle to Metro Motors. The dealership retained the vehicle but failed to communicate the nature of the problem or any repair costs until notifying the customer that the vehicle was ready for pickup on June 6, 2026. Before taking possession of the vehicle again, the customer arranged for an independent mechanic to inspect it. Although the dealership manager was initially hesitant to allow the inspection, he ultimately permitted it. The mechanic determined that the vehicle's frame was broken and that it was unsafe to operate, particularly for towing, which was the purpose repeatedly disclosed to Metro Motors before purchase.

Truck had no check engine light then caught on fire going down the road and burned to ground within seconds Incident report 46-24-05039 08_30-74 US-30 - PA 74 30 W

Speed control sensor allows brake fluid leak through the plug connector and run down the wiring harness, allowing brake fluid to splash on the exhaust manifold and cause a fire.

The contact owns a 2003 Ford F-250. The contact stated that both turn signals and the windshield wipers would intermittently fail to operate as needed. Over time, the failure worsened and the components failed to operate. The dealer and the manufacturer were notified of the failure and informed him that there were no recalls on the vehicle. the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 140,000.

Fuel tank straps corrode causing fuel tank to fall off A recall was issued for other similar ford trucks, but this model was not included

When the truck accelerates and reaches about 40-5mph the truck begins to wobble sideways. This wobbling sensation shakes the steering wheel violently and as the speed increases so does the shake. I have not had the truck over 65mph as it becomes unmanageable and is very hard to keep in its lane. The tyres are wearing funny as a result. All 4 wheels are wearing a band around both the inside and outside of the tyres.

DIRECTIONAL SIGNALS DO NOT WORK

I HAVE PAID OVER $6.000 DOLLARS TO MY LOCAL FORD DEALER TO FIX MY TRUCK JUST TO HAVE THEM TELL ME THERE IS NO WAY TO FIX THE PROBLEM, ITS A DESIGN FLAW FROM FORD THAT CAN NOT BE FIXED. I HAVE BEEN BACK AND FORTH WITH FORD MOTOR COMPANY, I HAVE BEEN LIED TO, STRONG ALONG, CALLS NOT RETURNED AND SO ON. THE DESIGN FLAW HAS TO DO WITH THE EGR. AND TODAY ITS SEEMS THE 3RD NEW TURBO STOPPED WORKING AND THE MOTOR HAS STARTED TO HAVE A BAD VIBRATION. THIS HAS BEEN A NIGHTMARE AND EVEN THOUGH FORD KEPT TELLING ME THEY WILL TAKE CARE OF ME, NOTHING HAS HAPPENED. WHEN THE TURBO FAILED AS I WAS TRYING TO GET ONTO THE FREEWAY I HAD NO POWER AND NEARLY WAS REAR ENDED BY AN 18 WHEELER WHO WAS EXTREMELY ANGRY. I HAD TO STAY OFF THE FREEWAY ON OTHER ROADS TILL I COULD GET HOME. THE TRUCK DEVELOPED A BAD VIBRATION AND I WAS NOT SURE I WOULD GET IT HOME. IF I WOULD HAD BEEN TOLD BY FORD THE FIRST TIME I TOOK IT IN OF THE DESIGN FLAW AND THERE IS NO WAY TO FIX IT, I WOULD HAVE NEVER POURED SO MUCH MONEY INTO IT. IT IS A LEMON AND SHOULD HAVE BEEN RECALLED. I HAVE TALKED TO MANY PEOPLE AND RESEARCHED THIS TRUCK. I FOUND OUT FORD NEW OF THIS DESIGN FLAW AND THAT THEIR CUSTOMERS WOULD HAVE THESE PROBLEMS BUT RELEASED THE TRUCK TO US ANYWAY. I NOW CAN'T AFFORD TO PUT ANY MORE MONEY INTO THIS TRUCK, I CAN'T FIX IT, I CAN'T SELL IT, AND FORD WILL NOT DO ANYTHING TO HELP ME. WHEN I FOUND OUT I WAS LIED TO AND CAUGHT THEM AND SAID, I NOW YOU HAVE BEEN LYING TO ME AND I DO NOT TRUST YOU, I WAS LABELED A HOSTEL CUSTOMER. I ASK YOU, WHO LIKES TO BE LIED TO? THIS HAS BEEN GOING ON INTO 2 YEARS NOW. NOW I HAVE NO TRUCK. I AM INTERNING WHERE IT ASKS "WHEN THIS HAPPENED" TODAY'S DATE. PLEASE HELP. THANK YOU.

TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TURBO NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO PENSKE FORD (LOCATED AT 8970 LA MESA BLVD, LA MESA, CA 91942, (619) 464-7777), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE FUEL TANK WAS HANGING DOWN. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND SAW THAT THE FUEL TANK STRAP WAS FRACTURED AND THE FUEL GAUGE WAS DAMAGED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 49,000.

BRAKE LINES COMPLETELY RUSTED THROUGH CAUSING BRAKE FAILURE WHILE DRIVING. THIS IS THE SECONDED TIME.

THE REAR FUEL TANK STRAP FAILED WHILE TRAVELING ON A STATE HIGHWAY.

TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING 3 MPH, THE CONTACT HEARD A DRAGGING NOISE. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE FUEL TANK WAS LEANING TO THE GROUND. IN ADDITION, THE CONTACT NOTICED THAT THE FUEL TANK STRAPS WERE RUSTED. THE CONTACT CALLED OLIVER FORD-LINCOLN (1001 E JEFFERSON ST, PLYMOUTH, IN 46563, (800) 448-8292) AND WAS INFORMED THAT THE FAILURE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000.

THE CHECK ENGINE LIGHT CAME ON AND WE PULLED OVER THEN WHEN I PUT THE TRUCK INTO DRIVE TO PULL OUT IT BARELY MOVED. WE WERE ALMOST HIT BC THE TRUCK WOULDN'T MOVE SO I PUT IN IN REVERSE TO GET OUT OF THE ROAD AND IT DID FINE. SO I TRIED TO PULL OUT AGAIN N DRIVE AND AGAIN IT WOULDN'T GO NO MATTER HOW MUCH GAS I GAVE IT. IT SOUNDS LIKE SOMETHING IS DROWNDING OUT OR IT ISN'T GETTING GAS. BUT LIKE I SAID. IT WON'T GO FORWARD IN DRIVE OR 1ST OR 2ND. ONLY IN REVERSE WILL IT MOVE NORMALLY. THIS IS MAJOR!!! I CAN'T HAVE MY KIDS AT RISK BC THERE'S SOMETHING WRONG WITH THE TRUCK. I HAVE ONLY HAD THE TRUCK ABOUT 3 WEEKS SO IT'S VERY FRUSTRATING.

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THAT THERE WAS RUST ASSOCIATED WITH THE FUEL STRAPS, WHICH FRACTURED AND CAUSED THE FUEL TANK TO HANG. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN THE MANUFACTURER RECALL CAMPAIGN NUMBER: 11S21, ALTHOUGH THE FAILURE WAS IDENTICAL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

FAILED SMOG AND EVERY TIME SENSORS ARE REPLACED FAILURE HAPPENS AGAIN.

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH FEDERAL COURAGIA A/T TIRES, SIZE 285/75/R16 (NA). THE CONTACT STATED THAT THE TIRES WERE WEARING OUT FASTER THAN NORMAL. THE DEALER WAS NOT CONTACTED. THE TIRE MANUFACTURER WAS NOTIFIED, BUT DID NOT RETURN THE CONTACT'S CALL. THE VIN AND DOT NUMBER WERE UNKNOWN. THE VEHICLE FAILURE MILEAGE WAS 158,000 AND THE TIRE FAILURE MILEAGE WAS 6,000.

I have been trying to get the exhaust manifold bolts replaced by several machine shops and did my own checking on the Ford F-250 Web site and everyone tells me the same thing! Ford knows about the problem but is doing nothing to correct! I have finally found a shop that will fix the broken exhaust manifold blots ! But I would like to know what ford truly knows about this problem . To get it fixed they have to replace all the bolts do to the bolts being so rusted ! Now I only have 121, + miles on my2003 and with the bolts broken it starts admitting gas fumes into the cab . I did check your site and could only find but 1 complaint , so if this is an issue with the exhaust manifold bolts braking and all the ford forums are full of complaints where are they being filed at on your site ? And I do believe it is an issue because I have spoken to 5 different shoppes and 1 ford dealer , they all say the same thing SORRY but it is your problem ! ford knows but will not do anything about it ! I am having mine put in the shop for repairs on the week of 7 Feb 2022 , now that I found someone I could afford! I had quotes from I will not do the work because it is a V10 to $1000.00 per bolt please address this ! It won’t help me but maybe it will hold ford accountable for the product !

DRIVING 50-60 HIT A BUMP AND THE TRUCK GOES INTO A VIOLENT WOBBLE, UNABLE TO CONTROL THE BREAKS AND STEERING. THIS LAST TIME I WAS ON THE INTERSTATE AND IT CAUSED ME TO ENTER THE LANE NEXT TO ME NEARLY CAUSING AN ACCIDENT. THE OTHER DRIVER WAS ABLE TO AVOID ME. WHEN THE SHAKING STOPS, THE TRUCK RUNS SMOOTH WITHOUT ANY SIGN OF A PROBLEM. I AM AFRAID OF MY FAMILIES SAFETY!!!

I HAD PARKED MY TRUCK IN MY DRIVEWAY. I PUT IT IN PARK, SET THE PARKING BRAKE AND TURN OFF THE ENGINE. AS I STEPPED OUT OF THE TRUCK THE TRUCK ROLLED DOWN THE DRIVEWAY DRAGGING ME ABOUT 100 FT STIKING THE POWER POLE AT THE END OF THE DIVEWAY. THE POLE WAS ROTTED AND FELL ON THE TRUCK CRUSHING ME BETWEEN THE BODY AND THE DRIVER SIDE FRONT DOOR.

TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE ATTEMPTING TO DRIVE THE VEHICLE, IT FAILED TO START AND THE FUEL GAUGE FAILED TO PROVIDE AN ACCURATE READING. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT HE NEEDED TO TAKE THE VEHICLE BACK WHERE IT WAS PURCHASED. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.

MY FRONT END SHAKES IT'S NOT THE HIGH SPEED WOBBLE MY TRAILER BRAKES THEY DO NOT WORK I'M BLOWING FUSES IN MY FUSE BOX VIA TRAILER MY TRUCK MAKES A MOANING SOUND KIND OF SOUNDS LIKE A FOGHORN THIS IS WHEN I STARTED OR I COME TO A STOP AND WHEN IT'S IDLING DOESN'T DO IT ALL THE TIME MY SHIFTER ON MY COLUMN CAME LOOSE AND WON'T GO INTO PARK

TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED AND THE INSTRUMENT PANEL WARNING INDICATORS ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, TURNED OFF THE ENGINE, AND RESTARTED THE VEHICLE. THE DEALER REPLACED THE ENGINE HARNESS AND CAM SENSOR, BUT THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND WAS INFORMED THAT THE ALTERNATOR WAS OVERCHARGED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TIRE FAILURE

TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING 30 MPH, THE CONTACT CRASHED INTO THE DRIVER'S SIDE OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT INJURED HIS HEAD AND SHOULDER, BUT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE CONTACT DROVE 10 MPH TO HIS HOME. THE VEHICLE WAS TOWED THREE DAYS LATER TO VISELIA AUTO BODY FOR REPAIRS. THE CONTACT WENT TO MONARCH FORD (132 N D ST, EXETER, CA 93221, (559) 592-3800), BUT DID NOT RECEIVE ASSISTANCE. THE FAILURE MILEAGE WAS 345,555. *BF *TR

MY TRUCK SHUTS OFF WHILE DRIVING FOR NO REASON WHATSOEVER. THE LIGHTS COME AND IT THROWS NO CODES AT ALL. I HAVE EXPERIENCED THIS WHILE DRIVING DOWN THE ROAD AT SPEEDS OF 50 OR LESS. BUT IT DOESN'T MATTER IT STILL DIES JUST THE ENGINE. I HAVE NOT SEEN ONE INVESTIGATION BY THE GOVERNMENT AT ALL. AND AS I GO ONLINE MANY PEOPLE ARE SUFFERING THE SAME FATE TO WHERE PEOPLE HAVE GOTTEN INTO ACCIDENTS... I WANT ANSWERS!!! WE NEED ANSWERS AS THIS IS A SERIOUS PROBLEM. THE ENGINE JUST DIES BUT I DON'T LOSE ELECTRICAL POWER, BUT I DO LOSE STEERING AND IT'S VERY HARD TO CONTROL THE TRUCK AT THESE TIMES. FORD DENIES EVERYTHING AND WILL NOT HELP AT ALL WITHOUT MONEY IN HAND!!! THIS IS WRONG... WE NEED GOVERNMENT TO STEP IN AND HELP!!!

I HAVE AMERICAN EAGLE - 20 " EAGLE ALLOY WHEELS. THEY ARE APPROXIMATELY 24 MONTHS OLD. THIS SUMMER A SPOKE CRACKED ALL THE WAY THROUGH ON ONE WHEEL. THE DEALER WOULD NOT WARRANTY IT AND I HAD TO PURCHASE A REPLACEMENT. THIS WEEK I NOTICED ANOTHER OF THE WHEELS CRACKED ALL THE WAY THROUGH. I HAVE NOT HIT ANY MAJOR POT HOLES, CURBS OR ANYTHING ELSE. MY TRUCK IS NOT A WORK TRUCK OR USED FOR MUDDING OR OFF ROAD, IT IS A PAVEMENT PRINCESS DRIVEN BACK AND FORTH TO WORK. I AM WORRIED THERE IS A MANUFACTURER DEFECT AND THAT THE WHEELS ARE NOT SAFE.

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). WHILE DRIVING AT LOW SPEEDS, THE VEHICLE BECAME DIFFICULT TO STEER AND LOST BRAKING ABILITY. THE FAILURE OCCURRED AT LOW AND HIGH SPEEDS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH YOKOHAMA GEOLANDER TIRES, SIZE: LT285/7516 (NA). THE CONTACT STATED THAT THE TREAD WAS DISINTEGRATING COMPLETELY. THE VEHICLE COULD NOT BE DRIVEN. THE TIRES WERE NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DOT NUMBER WAS NOT AVAILABLE. THE VEHICLE FAILURE MILEAGE WAS 148,000 AND THE TIRE FAILURE MILEAGE WAS 15,000.

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THAT IN ORDER TO KEEP THE VEHICLE'S ENGINE ON, THE HAZARD LIGHTS AND HEADLIGHTS HAD TO BE ACTIVATED; HOWEVER, THE LIGHTS DID NOT ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

REPLACED 4 NEW TIRES ON MY FORD F-250 TRUCK 9/20/2013. YOKOHAMA GEOLANDAR H/T-S, LT235/85R16. ON APPROXIMATELY 5/10/2016, WHILE ON FREEWAY,BEGAN TO FEEL A VIBRATION WHILE DRIVING. FELT LIKE WHEEL OUT OF BALANCE. THE LEFT REAR TIRE TREAD CAME OFF THE TIRE CAUSING SEVERE DAMAGE TO THE TRUCK BED. APPROXIMATELY 28,500 MILES ON THE TIRES. TIRE REMAINED INFLATED. I CONTACTED YOKOHAMA TO OPEN A CASE FILE. I SENT THEM THE TIRE FOR EXAMINATION PER THEIR REQUEST. THEY SENT ME THE ANALYSIS BACK WITH A BUNCH OF PHOTOS BLAMING THE FAILURE ON ROAD DEBRIS. APPROXIMATELY 5 WEEKS LATER ON 7/2/2016 I EXPERIENCED THE SAME VIBRATION WHILE ON A TRIP OUT OF TOWN. THIS TIME THE RIGHT REAR TIRE TREAD CAME OFF THE TIRE CAUSING SEVERE DAMAGE TO THE RIGHT SIDE TRUCK BED. APPROXIMATELY 29,000 MILES ON THE SECOND TIRE. CONTACTED YOKOHAMA TO OPEN ANOTHER CASE FILE. CURRENTLY IN LITIGATION AS OF 3/3/2017 FOR $7,111 FOR VEHICLE DAMAGE AND 4 NEW TIRES. FORTUNATELY NOBODY WAS HURT BECAUSE OF THESE DEFECTIVE TIRES.

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH BF GOODRICH ALL TERRAIN KO-II TIRES, SIZE: 265/75/16. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE VIBRATED AND SHOOK. UPON INSPECTION, IT WAS DISCOVERED THAT THE FRONT PASSENGER AND DRIVER SIDE TIRES EXPERIENCED TREAD SEPARATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER (DISCOUNT TIRE, 11881 MAGNOLIAM AVE, RIVERSIDE, CA) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE DOT NUMBER, VIN, AND FAILURE MILEAGE WERE UNKNOWN.

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH BF GOODRICH ALL TERRAIN KO TIRES, SIZE: 265/75/16. WHILE DRIVING APPROXIMATELY 60 MPH, THE REAR DRIVER'S SIDE TIRE EXPERIENCED A BLOW OUT. THE TIRE WAS RETURNED TO THE MANUFACTURER WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE LOCAL DEALER (DISCOUNT TIRE, 11881 MAGNOLIAM AVE, RIVERSIDE, CA) WAS NOTIFIED OF THE FAILURE. THE VIN, DOT NUMBER, AND FAILURE MILEAGE WERE UNKNOWN.

TL* THE CONTACT OWNS A 2003 FORD F-250 SUPER DUTY. WHILE ATTEMPTING TO USE THE CRUISE CONTROL, THE VEHICLE SPEED FUNCTION WOULD NOT WORK. THE CONTACT STATED THAT THE SWITCH BECAME HOT AND FAILED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 85,000.

5.4 LITER MOTOR BLOWS SPARK PLUGS OUT OF THE ENGINE, BECAUSE SOME MORON AT FORD DESIGNED AN ENGINE WITH 2 OR 3 THREADS PER PLUG PORT ON ALUMINUM HEADS. FORD IS PAYING A CLASS-ACTION LAWSUIT FOR MODEL YEARS 2004 - 2008, BUT MINE IS A 2003. THANKS FOR THE SCREW-JOB, FORD.

TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE CLEANING THE VEHICLE, THE CONTACT NOTICED THAT ONE OF THE FUEL TANK STRAPS WAS FRACTURED AND THE OTHER ONE WAS ABOUT TO FRACTURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,715.

THE TRUCK HAD WHAT SOUNDED LIKE VALVE TAP GOING ON WHEN IT WAS STARTED. I THOUGHT NOTHING OF THIS SINCE TRUCK IS A 2003 BUT THIS WAS A CHANGE FROM EARLIER TRIP. I PROCEEDED TO DRIVE THE TRUCK SINCE NO WARNING LIGHTS WERE ON AND POWER SEEMED FINE. GOING 35-40 MPH ABOUT 1 MILE FROM HOME I HEARD WHAT SOUNDED LIKE A SHOTGUN GOING OFF AND THE TRUCK BEGAN TO RUN BADLY AND I LIMPED IT HOME WITH WINDOWS DOWN BECAUSE OF GAS SMELL. THE NEXT DAY I OPENED THE HOOD TO SEE WHAT WAS GOING ON AND I FOUND CYLINDER #2 HAD BLOWN APART THE COIL PACK AND HAD ALSO EJECTED THE SPARK PLUG FROM THE CYLINDER HEAD. FOLLOWING THAT I TOOK REMOVED ALL OTHER COILS AND PLUGS TO FIND THAT 5 OF THE 8 WERE LOOSE AND WORKING THEIR WAY OUT OF THE THREADS. I BELIEVE THAT THE ONLY THING THAT PREVENTED AN ENGINE FIRE WAS THE FACT THAT THE SPARK PLUG HAD SHORTED ITSELF OUT. THIS IS A SERIOUS PROBLEM. I HAVE SINCE FOUND THAT THE PROBLEM SEEMS TO BE ON MANY YEARS AND MODELS AND IS DUE TO FAULTY CYLINDER HEADS THAT WERE MADE OF ALUMINUM THAT WAS TO SOFT. THE SPARK PLUGS HAD BEEN REPLACED ONCE AND I CHECKED THEM AFTER I BOUGHT THE TRUCK USED, I TIGHTENED TO CORRECT SPECS WITH A TORQUE WRENCH.

CPSC: RECREATIONAL VEHICLES: CONSUMER STATED THE AXLE CAUSED DAMAGE TO THE BRAKE LINE, AND EMERGENCY CABLE. *SS

3RD SPARK PLUG ON PASSENGER SIDE BLEW OUT WITHOUT WARNING AND ALSO DESTROYED THE COIL. MY RESEARCH INDICATES THIS PROBLEM IS WELL KNOWN TO FORD, BUT NO RECALLS THAT I COULD FIND. *TR

I HAD LT265/75R16 BF GOODRICH TIRES ON MY TRUCK, WITH ONLY APPROX. 12,000 MILES ON THEM, THE TRUCK DOES NOT GET DRIVEN BUT ONCE A WEEK. TRAVELING ON THE INTERSTATE WHEN THE PASSENGER FRONT TIRE EXPLODED. I WAS ABLE TO CONTROL THE TRUCK AND GET IT OFF THE ROAD WITHOUT HITTING ANYONE. BUT MY TRUCK SUSTAINED $3800.00 IN DAMAGE. I FILED CLAIM WITH MICHELIN AND SENT THEM THE TIRE, THEY DENIED THE CLAIM THAT I MUST HAVE HIT SOMETHING VERY HARD AND THAT CAUSED THE TIRE TO SPLIT ON THE INSIDE LINING WHICH THEN CAUSED THE BLOW OUT. I HAVE NEVER HIT ANYTHING AND I TRAVEL THE SAME TWO ROADS ALL THE TIME WITH BOTH MY VEHICLES SO I KNOW I DID NOT HIT ANYTHING. SECONDLY THESE ARE "ROUGH TERRAIN" TIRES SO EVEN IF I DID HIT SOMETHING THEY SHOULD HAVE NOT SPLIT. MICHELIN IS VERY LUCKY THAT I HAD CONTROL OF THE TRUCK, THERE WERE CARS ON BOTH SIDES OF ME THAT WOULD HAVE RESULTED IN A LAWSUIT AGAINST THEM IF I HAD HIT THEM. I WAS AFRAID TO DRIVE THE TRUCK WITH THE OTHER 3 EXISTING TIRES SO I HAD ALL FOUR REPLACED AT TIRES PLUS. MA 10/5

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL NOISE AND STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHO REPLACED THE OIL PUMP. THE CONTACT ALSO INDICATED THAT THERE WERE MULTIPLE FAILURES WITH THE VEHICLE. AT LEAST TWELVE FUEL INJECTORS WERE REPLACED BY THE DEALER AT LEAST TWELVE TIMES; HOWEVER, THE MAIN FAILURE WAS THE TURBO BRACKET BEING UNSTABLE. THE DEALER DIAGNOSED THAT THE FOUR BOLTS WERE RUSTED WITH CORROSION AND THE BOLTS, WHICH WERE NOT IN PLACE AND THE J-TUBE INTERNALLY FRACTURED. THE DEALER REPLACED THE FOUR BOLTS AND THE J-TUBE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

ON MARCH 2ND 2015, MY 2003 FORD F-250 CAUGHT FIRE ON IT'S OWN. NO ONE WAS HOME AT THE TIME AND LUCKILY MY NEIGHBORS CALLED 911. THIS TRUCK WAS RECALLED FOR A FAULTY SPEED CONTROL SWITCH. THE ENTIRE ENGINE COMPARTMENT WAS TORCHED. THIS TRUCK IS NOT REPAIRABLE.

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE LOST POWER AS THE CONTACT ATTEMPTED TO ACCELERATE. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ACCELERATOR PEDAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 273,000.

ON 10/11/14 WE WERE TRAVELING FROM OUR HOME IN HAVELOCK, NC TO THE CHARLOTTE AREA. WITH ABOUT 20 MINUTES INTO THE TRIP WE FELT A VIOLENT VIBRATION AND THEN THE REAR PASSENGER TIRE BLEW! MIRACULOUSLY, MY HUSBAND WAS ABLE TO PULL HIS FORD F-250 PICKUP TO THE SIDE OF THE ROAD AND THANKFULLY NO ONE WAS HURT! THE TIRE WAS FLAT WITH MUCH OF THE TREAD SEPARATED FROM THE TIRE. ALSO, SIGNIFICANT DAMAGE WAS CAUSED TO THE WHEEL WELL OF THE TRUCK BECAUSE OF THE BLOWOUT. AFTER HAVING ALLSTATE MOTOR CLUB COME AND ASSIST US, AND REPLACE THE BLOWOUT, WE WERE ON OUR ROAD AGAIN. THREE DAYS LATER ON OCTOBER 14TH WE WERE HEADED BACK TO HAVELOCK WHEN ONCE AGAIN THE TRUCK BEGAN TO SHAKE VIOLENTLY. MY HUSBAND MADE IT TO MY BROTHER-IN-LAWS DRIVEWAY, GOT OUT AND NOTICED THE FRONT PASSENGERS TIRE HAD A MAJOR BUBBLE IN IT. WE ALMOST HAD A SECOND TIRE BLOWOUT! NOW WE WERE THINKING THERE MUST BE SOMETHING WRONG WITH THESE TIRES SINCE TWO OF THEM FAILED WITHIN 3 DAYS. THE TIRES ON OUR TRUCK ARE BF GOODRICH MUD TERRAIN T/A KM2 LT285/75R16 DOT # BFYUCF213810. THESE TIRES ON OUR PICKUP HAVE PLENTY OF TREAD LEFT ON THEM AND SHOULD NOT HAVE FAILED! I HAVE BEEN IN CONTACT WITH MICHELIN (THE PARENT COMPANY OF BF GOODRICH). THEY TOLD ME TO GO TO MY LOCAL FAMILY TIRE TO HAVE THEM INSPECT OUR TIRES AND THEN HAVE THEM CONTACT MICHELIN ON THEIR FINDINGS. THEY ALSO SAID I WOULD NEED THE BLOWN OUT TIRE, WHICH I NO LONGER HAVE, TO RECEIVE ANY COMPENSATION FOR THAT. I BELIEVE I AM IN FOR A "RUN AROUND" FROM MICHELIN BEFORE I RECEIVE (IF I DO RECEIVE) ANY KIND OF COMPENSATION. I'VE SEEN ONLINE TOO WHERE SEVERAL SIMILAR TIRES FROM BF GOODRICH HAVE BEEN RECALLED DUE TO TREAD SEPARATION. I DO BELIEVE THE TIRES MENTIONED ABOVE ARE UNSAFE AND COULD CAUSE LOSS OF LIFE! I ALSO BELIEVE MICHELIN IS PUTTING THE ALMIGHTY DOLLAR BEFORE HUMAN SAFETY! *TR

ON 10/11/14 WE WERE TRAVELING FROM OUR HOME IN HAVELOCK, NC TO THE CHARLOTTE AREA. WITH ABOUT 20 MINUTES INTO THE TRIP WE FELT A VIOLENT VIBRATION AND THEN THE REAR PASSENGER TIRE BLEW! MIRACULOUSLY, MY HUSBAND WAS ABLE TO PULL HIS FORD F-250 PICKUP TO THE SIDE OF THE ROAD AND THANKFULLY NO ONE WAS HURT! THE TIRE WAS FLAT WITH MUCH OF THE TREAD SEPARATED FROM THE TIRE. ALSO, SIGNIFICANT DAMAGE WAS CAUSED TO THE WHEEL WELL OF THE TRUCK BECAUSE OF THE BLOWOUT. AFTER HAVING ALLSTATE MOTOR CLUB COME AND ASSIST US, AND REPLACE THE BLOWOUT, WE WERE ON OUR ROAD AGAIN. THREE DAYS LATER ON OCTOBER 14TH WE WERE HEADED BACK TO HAVELOCK WHEN ONCE AGAIN THE TRUCK BEGAN TO SHAKE VIOLENTLY. MY HUSBAND MADE IT TO MY BROTHER-IN-LAWS DRIVEWAY, GOT OUT AND NOTICED THE FRONT PASSENGERS TIRE HAD A MAJOR BUBBLE IN IT. WE ALMOST HAD A SECOND TIRE BLOWOUT! NOW WE WERE THINKING THERE MUST BE SOMETHING WRONG WITH THESE TIRES SINCE TWO OF THEM FAILED WITHIN 3 DAYS. THE TIRES ON OUR TRUCK ARE BF GOODRICH MUD TERRAIN T/A KM2 LT285/75R16 DOT # BFYUCF213810. THESE TIRES ON OUR PICKUP HAVE PLENTY OF TREAD LEFT ON THEM AND SHOULD NOT HAVE FAILED! I HAVE BEEN IN CONTACT WITH MICHELIN (THE PARENT COMPANY OF BF GOODRICH). THEY TOLD ME TO GO TO MY LOCAL FAMILY TIRE TO HAVE THEM INSPECT OUR TIRES AND THEN HAVE THEM CONTACT MICHELIN ON THEIR FINDINGS. THEY ALSO SAID I WOULD NEED THE BLOWN OUT TIRE, WHICH I NO LONGER HAVE, TO RECEIVE ANY COMPENSATION FOR THAT. I BELIEVE I AM IN FOR A "RUN AROUND" FROM MICHELIN BEFORE I RECEIVE (IF I DO RECEIVE) ANY KIND OF COMPENSATION. I'VE SEEN ONLINE TOO WHERE SEVERAL SIMILAR TIRES FROM BF GOODRICH HAVE BEEN RECALLED DUE TO TREAD SEPARATION. I DO BELIEVE THE TIRES MENTIONED ABOVE ARE UNSAFE AND COULD CAUSE LOSS OF LIFE! I ALSO BELIEVE MICHELIN IS PUTTING THE ALMIGHTY DOLLAR BEFORE HUMAN SAFETY! I PREVIOUSLY FILED THIS COMPLAINT UNDER FORD MANUFACTURER BY MISTAKE. THIS IS A TIRE ISSUE. AFTER SEVERAL TIMES CALLING MICHELIN, THEY ARE WILLING TO DO NOTHING TO HELP. *TR

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE ENGINE WOULD SUDDENLY MALFUNCTION AND INTERMITTENTLY CUT IN AND OUT AND MISFIRE. AFTER INSPECTING THE VEHICLE THE CONTACT DISCOVERED THAT THE REAR FUEL TANK STRAP HAD RUSTED AND SEPARATED CAUSING THE FUEL TANK TO HANG FROM THE SUB FRAME OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

2003 FORD F-250. CONSUMER WRITES IN REGARDS TO SPEED CONTROL DEACTIVATION SWITCH FIRE. *SMD THE CONSUMER STATED THE VEHICLE WOULD OCCASIONALLY STALL AND RE-START, DUE TO VEHICLE MOMENTUM, BUT IT STALLED COMING TO A LOW RPM IDLE, OR STOP. WHEN IT STALLED, IT GAVE NO CODE WARNINGS OR DASH LIGHT INDICATOR. HE RESET THE IGNITION KEY AND RE-STARTED THE VEHICLE. THE LOCAL FORD DEALER COULD NOT FIND A PROBLEM. AFTER THE RECALL WAS PERFORMED, THE CONSUMER DID NOT EXPERIENCE ANY MORE PROBLEMS. *JB

TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH BF GOODRICH ULTRA ALL RANGE TIRES, LINE SIZE: P235/85/R16. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE REAR PASSENGER SIDE TIRE BLEW OUT. THE CONTACT MENTIONED THAT AFTER INSPECTING ALL THE TIRES, HE NOTICED THAT THE TIRE TREAD WAS WEARING PREMATURELY AND HAD STARTED SEPARATING. THE VEHICLE WAS TAKEN TO A TIRE SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRES WERE NOT REPLACED. THE TIRE FAILURE MILEAGE WAS 85,151. THE VEHICLE CURRENT MILEAGE WAS 86,000. UPDATED 03/17/15*LJ UPDATED 08/25/2017*CT

1 OF THE TANK STRAPS BUSTED OFF AND THE TANK BEGAN SAGGING AND ALMOST TOUCHING THE GROUND, THUS CAUSING A SEVERE FIRE HAZARD.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED SMOKE FROM THE REAR OF THE VEHICLE AND THERE WAS A LOUD POPPING NOISE. THE VEHICLE WAS COMPLETELY SURROUNDED BY SMOKE RESULTING IN A FIRE. THE VEHICLE STALLED. THE FIRE WAS EXTINGUISHED INDEPENDENTLY. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V553000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000. UPDATED 7/1/15*CN THE CONSUMER STATED THERE WAS NO FIRE, JUST EXCESSIVE PRESSURE IN THE CRANKCASE CAUSING THE ENGINE TO BLOW OIL OUT THE GLOW PLUG. UPDATED 03/31/16.*JB