2005 Ford F-250 Complaint Log

I RECENTLY PURCHASED A FORD 2005 F250 SUPER DUTY TRUCK. WHILE DRIVING ON THE HIGHWAY AT 70 MPH, I HIT AN UNEVEN SPOT ON THE ROAD THAT CAUSED THE FRONT END TO WOBBLE VIOLENTLY. I FELT I COULD NOT CONTROL THE TRUCK AND HAD TO APPLY THE BRAKES IMMEDIATELY. LUCKILY THERE WERE NO OTHER CARS NEARBY. WHEN THE TRUCK REACHED APPROXIMATELY 30 - 35 MPH, THE WOBBLE CEASED. ON MY WAY BACK HOME, THE WOBBLE OCCURRED AGAIN. THIS TIME I WAS TRAVELING AT 60 - 65 MPH AND HIT ANOTHER ROUGH SPOT ON THE ROAD. THIS IS A MAJOR SAFETY HAZARD THAT NEEDS TO BE RESOLVED BEFORE SOMEONE IS KILLED. I RESEARCHED THE PROBLEM ON THE INTERNET AND DISCOVERED THIS HAS BEEN ONGOING FOR A WHILE. THERE ARE NUMEROUS EXAMPLES FROM OTHER F250 AND F350 OWNERS WITH THE SAME PROBLEM THAT CAN BE FOUND ON THE INTERNET. THE FORD MOTOR COMPANY IS AWARE OF THE PROBLEM AND BLAMES THE WOBBLE ON UNDERFLATED TIRES. THE WOBBLE OCCURS ON PROPERLY INFLATED TIRES ALSO AS DETAILED BY OTHER TRUCK OWNERS. BUT EVEN IF THE TRUCK'S TIRES ARE UNDER INFLATED, A VIOLENT WOBBLE SHOULD NOT OCCUR. MANY OTHER VEHICLES ARE IN USE WITH UNDER INFLATED TIRES, YOU DON'T HEAR OF A VIOLENT WOBBLE AFTER ENCOUNTERING A POT HOLE OR AN UNEVEN ROAD SURFACE. *TR

I OWN A 2005 FORD F-250 4X4. AT SLOW SPEEDS AS TAKING OFF FROM A STOP THE FRONT END SHIFTS FROM LEFT TO RIGHT SO HARD I CANNOT STEER THE TRUCK. I MUST STOP AND MOVE THE STEERING WHEEL LEFT TO RIGHT A FEW TIMES BEFORE STARTING TO MOVE AGAIN. ITS LIKE THE STEERING PUMP IS PUSHING THE STEERING WHEEL LEFT TO RIGHT. *TR

FORD F-250 WITH THE 6.0L DIESEL MOTOR HAS A RECURRING ISSUE OF A FAILING EGR COOLER. THE FAILURE OF THEIR COOLER CAN RESULT IN COOLANT ENTERING THE ENGINE AND CREATING A MOTOR FAILURE. AT 99,000 MILES I HAD A EGR AND OIL COOLER REPLACED. AT 113,000 MILES I HAVE HAD ANOTHER FAILURE. THE COST TO THE CONSUMER TO REPAIR THIS PROBLEM IS AT A MINIMUM OF $2,500. FORD IS AWARE OF THIS PROBLEM (ASK ANY FORD SERVICE TECHNICIAN) AND REFUSES TO PROVIDE A PERMANENT RESOLUTION. *TR

TL* THE CONTACT OWNS A 2005 FORD F250 SD. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT ANTI-FREEZE WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE EGR COOLER FAILED AND WOULD NEED TO BE REPLACED. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 39,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.

WHILE DRIVING DOWN THE HIGHWAY AT 70 MPH, MY 2005 FORD F-250 DIESEL TRUCK ENGINE SUDDENLY DIED. I HAD TO WRESTLE WITH THE TRUCK TO GET IT STOPPED AND PULLED OVER TO THE SIDE OF THE ROAD. I HAD NO STEERING WHEN THE TRUCK ENGINE STALLED SUDDENLY AND HAD TROUBLE GETTING IT STOPPED. I WAS TOWED HOME AS THE TRUCK WOULD NOT RESTART. WE THEN TOWED IT TO THE DEALERSHIP FOR REPAIRS ON JULY 26TH, AND IT HAS BEEN THERE UNTIL TODAY, SATURDAY, AUGUST 7TH, 2010. THE DEALERSHIP REPLACED THE HIGH PRESSURE OIL PUMP AT OVER $1200.00. EVEN THOUGH THE TRUCK HAD 62,000 MILES, IT HAD JUST GONE OVER 5 YEARS OLD. WE WERE TOLD THIS IS A BIG PROBLEM WITH FORD DIESELS AND THE FORD ENGINEERS ARE TELLING CONSUMERS THAT THEY AREN'T CHANGING THE OIL ENOUGH. I CONSISTENTLY CHANGED THE OIL IN THAT TRUCK EVERY 5000 MILES WITH DELO 400 AS I WAS TOLD TO DO. THERE NEEDS TO BE AN INVESTIGATION OF FORDS HIGH PRESSURE PUMPS AND THE AMOUNT OF MONEY CONSUMERS ARE HAVING TO PAY FOR REPAIRS BECAUSE OF THIS DEFECTIVE PART. I ASKED TO HAVE THE HIGH PRESSURE PUMP THAT WAS REMOVED FROM MY TRUCK, AND I WAS TOLD THAT HE HAD TO SEND IT BACK TO FORD BECAUSE IT HAD A VERY EXPENSIVE CORE. I'M SURE THEY DID NOT WANT ME TO HAVE THE EVIDENCE. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE TOWING A TRAILER APPROXIMATELY 20 MPH THE VEHICLE STALLED. DURING THE FAILURE WHITE FUMES WERE SEEN COMING OUT OF THE EXHAUST. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE EGR COOLER WAS REPLACED. APPROXIMATELY ONE WEEK LATER THE FAILURE RECURRED. THE CONTACT WAS IN THE PROCESS OF REPLACING THE EGR COOLER. THE FAILURE MILEAGE WAS 73,000 AND THE CURRENT MILEAGE WAS 75,000.

2005 FORD F 250 CREWCAB 4X4 FRONT END SHAKES UNCONTROLLABLY AFTER HITTING A BUMP AT HIGHWAY SPEEDS. THE ENTIRE VEHICLE BOUNCES AROUND TO WHERE OTHER VEHICLE ON THE ROADWAY HAVE TO SWERVE TO GET OUT OF THE WAY. ONLY WAY TO STOP IT IS TO SLOW DOWN TO ABOUT 30 MPH. I JUST RECENTLY HAD THE STEERING STABILIZER, DRAG LINK BAR AND SHOCKS ON THE TRUCK REPLACED ALONG WITH TIGHTENING THE STEERING GEAR BOX AND IT STILL CONTINUES TO DO THE SAME THING. *TR

FRONT SHAKES VIOLENTLY AT TIMES ON MY 2005 FORD F-250. FEELS LIKE THE WHOLE FRONT END OF THE TRUCK IS SHAKING APART. THE ONLY WAY I HAVE FOUND TO STOP IT IS TO DRASTICALLY SLOW DOWN MY TRUCK, WHICH IS A HUGE SAFETY HAZARD WHEN OTHER VEHICLES ARE FOLLOWING BEHIND ME. I SOMETIMES HAVE TO SLOW FROM 55 MPH TO 35 MPH. UPDATED 07/08/10 *BF UPDATED 07/09/10.*JB *TR

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED WHILE DRIVING AT SPEEDS OF 20 TO 65MPH THE MOTOR WOULD STALL CAUSING HIM TO LOSE ALL POWER TO THE BRAKE AND STEERING. HE WOULD COAST THE VEHICLE TO THE SIDE OF THE ROAD AND WAIT ABOUT HALF HOUR BEFORE IT WOULD RESTART, ALTHOUGH THERE WERE TIMES THAT THE VEHICLE WOULD RESTART IMMEDIATELY. WHEN THE FAILURE OCCURRED THERE WERE NO WARNING LIGHTS ILLUMINATING ON THE DASHBOARD . THE DEALER WAS CALLED WHO STATED THAT THE CONTACT PURCHASED THE VEHICLE AS IS AND THEY WOULD NOT REPAIR IT. THE MANUFACTURER WAS CALLED AND THEY ADVISED HIM TO CONTACT NHTSA TO FILE A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000.

2005 FORD F-250. CONSUMER STATES ENGINE FAILURE *TGW THE CONSUMER STATED THE ENGINE FAILURE NEARLY CAUSED AN ACCIDENT, WHEN IT SHUT DOWN ON A MAJOR HIGHWAY. SUBSEQUENTLY, THE CONSUMER ALSO EXPERIENCED A FAILURE WITH THE FUEL INJECTION CONTROL MODULE. AFTER HAVING THE FUEL INJECTION CONTROL MODULE REPLACED, THE CHECK ENGINE LIGHT ILLUMINATED AFTER LEAVING THE DEALERSHIP. THE CHECK ENGINE LIGHT ILLUMINATED DUE TO A FAILED EGR VALVE. THE CONSUMER WAS ALSO INFORMED THE ALTERNATOR WAS SPIKING, AND NEEDED TO BE REPLACED AS WELL AS THE EGR COOLER AND HEAD GASKETS. *JB

THIS EVENT HAD NO WARNINGS LEADING UP TO THE FAILURE. THIS FAILURE OCCURRED ONCE AND WAS DEBILITATING. MY 2005 FORD F250 (6.0 DIESEL) SUFFERED A LEAK IN TWO ORINGS AND A CRACK IN AN OIL LINE IN THE HIGH PRESSURE OIL SYSTEM. THE RESULT WAS A VEHICLE THAT DIED AND WOULD NOT START. THIS VEHICLE ONLY HAS 40,000 ORIGINAL MILES ON IT. ONLINE RESEARCH HAS REVEALED THAT THIS IS A DESIGN FLAW IN THE 2004 & 2005 MODEL YEARS. FORD HAS ISSUED TSB'S ON THE PROBLEM HOWEVER NEVER NOTIFIED CONSUMERS OF THE DEFECT TO FOREWARN OR CORRECT THE AFFECTED MODEL YEARS. THE ENGINE HAS SENSORS THAT SHUT THE ENGINE DOWN AND PREVENT IT FROM STARTING WHEN OIL PRESSURE IS LOST FROM SUCH DEFECTS. MY VEHICLE WAS TOWED TO FORD, HOWEVER THE WARRANTY HAD EXPIRED IN DECEMBER 2009. I HAVE TRIED TO RESOLVE COST ISSUE WITH FORD TO NO AVAIL. I FEEL THIS DEFECT IN DESIGN WAS A KNOWN PROBLEM AND SHOULD HAVE BEEN ADDRESSED, ESPECIALLY WHILE THE VEHICLE WAS STILL UNDER WARRANTY. *TR

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE CONTACT DISCOVERED CRACKS ON BOTH THE FRONT PASSENGER AND REAR DRIVER'S SIDE WHEELS. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 90,000.

EXTREME FRONT END WOBBLE ON MY 2005 FORD F-250. FEELS LIKE THE FRONT END IS GOING TO TEAR ITSELF APART. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED AND THE CONTACT WAS UNABLE TO RESTART THE ENGINE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THE VEHICLE WOULD NEED A REPLACEMENT ENGINE. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC WHERE THEHEAD GASKET WAS REPLACED. THE FAILURE DID NOT RECUR. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 113,000.

THIS IS THE FIRST OF FOUR TIMES THAT I HAVE HAD TO HAVE BRAKE WORK DONE ON MY TRUCK. THREE OF THE TIMES I WAS TOLD THAT THE CALIPERS HAD FROZEN AND SO CALIPERS PADS AND (EXCEPT THIS LAST TIME) ROTORS HAD TO BE REPLACED. THIS IS ABSURD FOR A TRUCK WITH LESS THAN 45,000 MILES. UNDERSTAND THIS IS EXPENSIVE!! HAVE NEVER HAD ANYTHING LIKE THIS ON ANY OTHER VEHICLE. ALSO, I HAVE EXPERIENCED THE OFT TALKED ABOUT "DEATH WOBBLE" A FEW TIMES ON THE HIGHWAY. WAS REAR BRAKES IN 2010' FRONTS IN 2011' NOW REARS AGAIN IN 2013. *TR

UPON HITTING A BUMP AT 30 TO 40 MPH , STEERING VEERS FROM SIDE TO SIDE, ALSO KNOWN AS THE "DEATH WOBBLE"VERY UNSETTLING TO SAY THE LEAST,AFTER SOME RESEARCH ONLINE I WAS SHOCKED TO SEE THAT OTHER FORD 4X4 OWNERS HAVE THE SAME THING. I FOUND A COMPANY THAT SAYS THE STEERING GEOMETRY IS WRONG AND HAVE A FIX, WC MOTORSPORTS (508-203-9450)THIS SHOULD NOT BE HAPPENING , MY TRUCK HAS UNDER 40,000 MILES AND I AM AFRAID TO DRIVE IT. IT IS OBVIOUS THAT SOMETHING IS WRONG AND FORD HAS BEEN IGNORING FOR YEARS. WHAT DO I DO ?DO YOU WANT TO BUY IT? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE WINDSHIELD WIPERS ON A FORD F 250 SUPERDUTY TRUCK FAIL TO SHUT OFF. SAFETY ISSUE, THE DRIVER'S ATTENTION IS TAKEN AWAY FROM DRIVING TO MANIPULATING THE WINDSHIELD WIPER CONTROLS IN AN EFFORT TO TURN OFF THE WIPERS OR THE DRIVER WILL REMOVE THE FUSE AND THEN THERE ARE NO WIPERS WHEN NEEDED. THIS PROBLEM IS KNOWN TO OTHER FORD F250 DRIVERS SO IT IS NOT AN ISOLATED CASE. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE FRONT STARTED SHAKING BETWEEN 55 AND 65 MPH. THE VEHICLE WAS SHAKING EXCESSIVELY THEREFORE; THE SPEED WOULD NOT INCREASE. THE VEHICLE WAS NOT INSPECTED. THE VEHICLE WOULD ALSO SHAKE EXCESSIVELY WHILE DRIVING OVER A BUMP IN THE ROAD. THE DEALER STATED THAT THEY HAD NOT HEARD OF THE FAILURE AND THAT THE WARRANTY EXPIRED. THE FAILURE MILEAGE WAS 45000 AND THE CURRENT MILEAGE 50000.

ONGOING PROBLEM WITH THE 6.0 DIESEL IN THE 2005 FORD F250 SUPER DUTY TRUCKS. *TR

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE DRIVING VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. FERRARIO FORD LINCOLN (2472 CORNING RD, ELMIRA, NY) WAS CONTACTED AND DIAGNOSED THE FAILURE AS A HIGH PRESSURE OIL PUMP MALFUNCTION AND THE PART WOULD NEED TO BE REPLACED. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.

MY 2005 FORD F-250 6.0L DIESEL LOST ACCELERATION ONTO A HIGHWAY. IT STALLED AND STARTED BILLOWING WHITE SMOKE FROM THE EXHAUST. AFTER A FEW MOMENTS IT SLOWLY ACCELERATED, BUT NEARLY CAUSED AN ACCIDENT AS CARS RAN UP ONTO US. THE ENGINE WAS MISSING AND WE MADE IT TO AN INTERSECTION TO PULL OFF OF HIGHWAY. WE STOPPED AND RESTARTED THE ENGINE AND IT STARTED RUNNING NORMALLY. HOWEVER, IT HAPPENED AGAIN ONCE WE WERE ON THE ROAD. WE MADE IT TO THE DEALERSHIP WHERE THEY DIAGNOSED THE PROBLEM AS A FAILED "FICM FUEL INJECTOR CONTROL MODULE." THIS HAS BEEN REPORTED TO THEM MULTIPLE TIMES, BUT A RECALL HAS NOT BEEN ISSUED FOR THIS MODEL. I DID FIND REFERENCE TO A RECALL (FORD RECALL NO. 05S34) OF THE EXACT NATURE ON A DIFFERENT YEAR MODEL. I CALLED FORD AND THEY WOULD NOT REIMBURSE THE COST OF THE PART AND LABOR OF $1100. *TR

TRANSMISSION UPPER HOUSING CASE HAS DEVELOPED CRACK NOT NEAR BOLT FLANGES BUT ON TOP OF HOUSING..CAUSING FLUIDS TO LEAK ON EXHAUST SYSTEM...NOT DAMAGE TO BOTTOM OF HOUSING...NO ABUSE.. *TR

DRIVING AT HIGHWAY SPEEDS , THE TRUCK SHAKES VIOLENTLY AFTER HITTING A BUMP . THE ISSUE IS COMMONLY REFERRED TO AS A DEATH WOBBLE . YOU SLOW DOWN TO ABOUT 45 MPH OR SLOWER & IT STOPS . YOU CAN THEN RESUME YOUR TRIP . *TR

TL* THE CONTACT OWNS A 2005 FORD F250 SUPERDUTY. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH OVER A ROAD BUMP WHEN HE LOST CONTROL OF THE STEERING. THE CONTACT WAS ABLE TO GAIN CONTROL AND RETURNED TO NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THEY WERE UNABLE TO LOCATE THE PROBLEM. THERE WAS A TECHNICAL SERVICE BULLETIN NUMBER 42601 WHICH WAS RELATED TO THE STEERING. THE NHTSA ITEM NUMBER WAS 10018736. THE CONTACT EXPERIENCED THE SIMILAR DEFECT AS MENTIONED IN THE TECHNICAL SERVICE BULLETIN. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 60,000.

EXPERIENCED STEERING SHIMMY AT HIGHWAY DRIVING SPEEDS ON MULTIPLE OCCASIONS WHILE PULLING A TRAVEL TRAILER AND WHILE NOT PULLING A TRAILER. RESULTS IN VIOLENT VIBRATION OF THE ENTIRE VEHICLE TO THE POINT OF BEING DIFFICULT TO CONTROL. *TR

TL* THE CONTACT OWNS A 2005 FORD F-250 SUPER DUTY. THE CONTACT STATED WHEN DRIVING AT VARIOUS SPEEDS THE FRONT END WOULD SWAY FROM LEFT TO RIGHT. IN ADDITION, WHEN DRIVING AT SPEEDS OF AT LEAST 30 MPH, THERE WAS A SLIGHT LOSS OF POWER STEERING ASSIST CAUSING MINIMAL STEERING CONTROL. THE CONTACT WOULD SHUT OFF THE ENGINE AND WHEN RESTARTING, THE VEHICLE WOULD REGAIN POWER STEERING ASSIST. THE VEHICLE HAD NOT YET BEEN TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 119,091.

TL*THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED OVER 50 MPH, THE ENTIRE VEHICLE WOULD SHAKE VIOLENTLY FROM SIDE TO SIDE WHICH CAUSED CONTAINERS TO FALL OUT OF THE CUP HOLDER. WHENEVER THE CONTACT SHUT THE VEHICLE OFF AND BACK ON, IT BEGAN FUNCTIONING NORMALLY UNTIL HE DROVE OVER ANOTHER BUMP IN THE ROAD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE DEALER STATED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE CURRENT MILEAGE WAS APPROXIMATELY 66,500. UPDATED 11/03/10. *LJ

I WAS ON THE INTERSTATE DRIVING 70 MPH WHEN I HIT A SMALL BUMP IN THE ROAD WHICH CAUSED MY TRUCK TO SHAKE VIOLENTLY AND LOSE CONTROL OF STEERING WHICH TOOK ME OFF THE ROAD INTO THE CENTER MEDIAN. THIS COULD HAVE EASILY BEEN A HEAD ON COLLISION IN DIFFERENT CIRCUMSTANCES. *TR

2005 FORD F250 DIESEL. TRUCK ENGINE ALL OF A SUDDEN DIES LEAVING LITTLE CONTROL OF STEERING AND LESSER BRAKES. SOMETIMES WILL CRANK BACK AND SOMETIMES WONT. HAPPENED 3 TIMES WHILE UNDER WARRANTY AND NOW 2 TIMES OUT OF WARRANTY. 3 OF THE 5 TIMES ALMOST RESULTED IN AN ACCIDENT WITH OTHER TRAFFIC BECAUSE OF THE LOSS OF POWER AND LIMITED USE OF BRAKES AND STEERING. *TR

1) @50,000 MILES, NORMAL CITY DRIVING, SPEED LESS THAN 30 MPH. 2) LEFT TIEROD BROKE WITHOUT WARNING. THE TIE ROD DROPPED TO THE GROUND AND THE LEFT FRONT WHEEL NO LONGER HAD STEERING CONTROL. THE TIE ROD LOOKS LIKE THE CASTELLATED NUT WAS OVER TORQUED CAUSING THE STUD TO BREAK OFF AND THE TAPERED SHAFT TO FALL OUT OF THE SPINDLE. THIS IS NOT A CASE OF THE BALL JOINT IN THE TIE ROD WEARING OUT. I'M LUCKY IN THIS CASE IT HAPPENED AT A SLOW SPEED AND NO TRAILER IN TOW. IF I WAS MOVING FASTER WITH A TRAILER, IT COULD HAVE BEEN A DISASTER TO LOSE STEERING CONTROL OF THE LEFT FRONT TIRE. THE RIGHT SIDE TIRE WAS STILL ABLE TO STEER. THE TRUCK SWERVED OUT OF THE LANE MOMENTARILY WHILE I REGAINED SOME CONTROL. IN THE ACT OF DROPPING DOWN, THE TIE ROD MADE CONTACT WITH THE BEAD AREA OF THE FRONT RIM. AS A RESULT THE WHEEL RIM WAS ALSO RUINED. IT WAS INTERESTING THAT THE TOW TRUCK DRIVER AND THE SERVICE MANAGER BOTH MENTIONED THAT THEY HAVE SEEN THIS KIND OF PROBLEM BEFORE. 3) THE TRUCK WAS FLATBEDDED TO THE DEALERSHIP FOR REPAIR. THE TIE ROD END WAS REPLACED AT MY EXPENSE FOR ~$750, NOT INCLUDING THE DAMAGED WHEEL. I HAVE THE OLD PART AND CAN SUPPLY PICTURES IF NEEDED. *TR

BETWEEN SPEEDS OF 40-65MPH TRUCK WILL GO INTO "DEATH WOBBLE" AFTER HITTING A POTHOLE, ROUGH SPOT IN ROAD, OR DIPS ( EX. OVER PASSES, BRIDGES). TRUCK WILL SHAKE VIOLENTLY TO THE LEFT AND RIGHT ALMOST CAUSING A WRECK. ONCE THIS HAPPENS I HAVE TO LET OFF GAS APPLY BRAKE SLOWLY TILL TRUCK STOPS THE SHAKING. TRAFFIC BEHIND ME HAS TO BRAKE, ALMOST CAUSING ACCIDENTS, NOT TO MENTION HOW HARD IT IS TO CONTROL THE TRUCK WHEN THIS HAPPENS. I HAVE ALMOST HAD A WRECK EVERY TIME THIS HAD OCCURRED. FIRST STARTED WHEN I BOUGHT THE TRUCK IN FEB. 2010 WITH 52,500 MILES. STILL HAPPENS TO THIS DAY AFTER REPLACING FRONT END PARTS, TRUCK NOW HAS 68K MILES. I'VE RESEARCHED ONLINE AND THIS SEEMS TO BE AN ISSUE LOTS OF PEOPLE ARE HAVING, NOT TO MENTION IT IS ONGOING. *TR

I HAVE A FORD F250 SUPER DUTY. AFTER HITTING A SMALL DIP IN THE ROAD, MY STEERING COLUMN SHOOK VIOLENTLY, BACK AND FORTH. I WAS TRAVELING ONLY 30 MI PER HOUR. TOOK TO MY DEALER AND THEY SAID NOTHING WAS WRONG. PROBABLY COULD BE MY TIRES. BOUGHT NEW TIRES AND A COUPLE OF WEEKS LATER,, THE SAME THING HAPPENED AGAIN. IF I WAS TRAVELING ANY FASTER, I TRULY BELIEVE I WOULD HAVE LOST CONTROL. I HAVE BEEN DRIVING FIRE APPARATUS FOR OVER 29 YEARS. AND I KNOW SOMETHING IS WRONG HERE. PLEASE DO SOMETHING BEFORE SOMEONE IS SERIOUSLY HURT OR KILLED. I DO NOT TRUST FORD. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE TRAVELING 65 MPH OVER A BUMP OR CRACK IN THE SURFACE OF THE ROAD THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PERFORMING NORMALLY. THERE WERE NO PRIOR WARNINGS. THE FAILURE MILEAGE WAS 26000 AND THE CURRENT MILEAGE WAS 28000. UPDATED 01/11/2011*LJ UPDATED 04/07/11

OWN A 2005 FORD F250 WITH A 6.0 DIESEL ENGINE. THE 6.0 DIESEL HAS A FACTORY DEFECT WITH THE EGR VALUE COOLER INSIDE THE ENGINE RUPTURING SENDING COOLANT INTO THE ENGINE AND THRU THE EXHAUST INTO THE ATMOSPHERE. THIS SHOULD BE A RECALL DUE TO A FACTORY DEFECT. FORD IS REPAIRING THIS PROBLEM IF IT OCCURS WHEN THE VEHICLE IS STILL UNDER WARRANTY BUT ALLOWING THE CONSUMER TO BURDEN THE EXPENSE IF THEIR WARRANTIES HAVE EXPIRED. THE ESTIMATED COST IS $2600.00 TO $3300.00. FORD HAS REDESIGNED THE EGR VALUE & COOLER TO HANDLE THE PRESSURE BETTER WITH THICKER WALLS. THE FORD DEALERSHIP HAS ADVISED THAT THIS IS A PROBLEM THAT WILL HAPPEN DUE TO THE COOLER WALLS BEING TO THIN AND RUPTURING UNDER PRESSURE. THE END RESULT IS A SUDDEN LOST OF POWER WITH POSSIBLE STEERING & BRAKE ISSUES IN CONTROLLING THE VEHICLE. IN OUR FAMILY WE HAVE PURCHASED 4 OF THE F250'S. I HAVE PICTURES OF THE EVENT AS IT HAPPENS AND A COPY OF THE REPAIRS NEEDED TO FIX THIS PROBLEM. I HAVE SPOKE WITH KRISTIN BERRY WITH YOUR AGENCY AND RECEIVE AN E MAIL OF MY COMPLAINT BUT I COULD NOT MAKE THE NECESSARY CHANGES TO THE FORM AND RESENT IT. THE REFERENCE # 10305746. *TR

2005 FORD F-250 CREW CAB 4X4, V-10, 56000 MILES. FRONT SUSPENSION WOBBLES AND STEERING WHEEL SHAKES WHEN HITTING POTHOLES OR ANY SORT OF GOOD BUMP AT SPEEDS 30 MPH AND ABOVE. NEW LARGER TIRES, 265/75/17 ONLY AMPLIFIES THIS PROBLEM TO AN UNCONTROLLABLE STATE AT HIGHWAY SPEEDS OF 65+. WHEN THE PROBLEM OCCURS, IT FEELS LIKE I AM DRIVING DOWN A WASHBOARD DIRT ROAD AT HIGH SPEED WITH THE STEERING WHEEL SHUTTERING UNCONTROLLABLY. I NEED TO SLOW THE TRUCK DOWN TO 50 OR SO JUST TO GET CONTROL BACK. TIRE PRESSURES ARE AT RECOMMENDED SPECS. WHEN DRIVING UNDER CONTROL AND STRAIGHT, THE STEERING WHEEL HAS A LOT OF SLOP LEFT TO RIGHT. I BOUGHT THIS TRUCK NEW IN FEB 05 AND I AM THE ORIGINAL OWNER. *TR

I HAVE A FORD F250 SD DIESEL 2WD TRUCK I HAVE REPLACE THE FRONT WHEEL BEARING 4 TIME IN 137,000 MILES. THE DEALER SAYS IT IS WATER AND DIRT INTRUSION. IT HAS NOT CAUSED ANY ACCEDENTS YET BUT IT IS ONLY A MATTER OF TIME. *CN

2005 FORD F250 SUPER DUTY 4X4. VIOLENT SHAKING AFTER HITTING A SMALL DEFORMED PART OF THE ROAD, SLOW VEHICLE TO 10 MPH TO STOP THE SHAKING. HAVE LOST CONTROL OF THE VEHICLE 2 TIMES IN THE LAST WEEK. I HAVE TAKEN IT TO THE SHOP AND NO ONE COULD FIND ANYTHING WRONG WITH THE VEHICLE. *TR

2005 FORD F250 WITH A CRACKED TRANSMISSION. CONSUMER WOULD LIKE REIMBURSEMENT FOR REPLACING TRANSMISSION WITH A REBUILT TRANSMISSION. *KB THE TRANSMISSION HOUSING CRACKED AND LEAKED FLUID. THE TRANSMISSION HAD TO BE REPLACED AT 44,000 MILES. THE CONSUMER STATED FORD KNEW THERE WAS A PROBLEM WITH THE INTERNAL SNAP RING WHICH CAUSED THE TRANSMISSION CASE TO CRACK. *JB

TL*THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THE EGR VALVE COOLER RUPTURED AND WAS LEAKING ANTIFREEZE THROUGH THE EXHAUST SYSTEM. THE DEALER WAS AWARE OF THE FAILURE; HOWEVER, THE FORD MANUFACTURER ADVISED THEM TO STOP REPAIRING THE VEHICLE. THE ESTIMATED COST WAS $2600. THERE WERE NO VALID WARRANTIES OR RECALLS. THE FAILURE MILEAGE WAS 51,000.

I OWN A FORD 2005 CREW CAB SUPER DUTY, THE VEHICLE SHAKES VIOLENTLY THROUGH THE FRONT END, HAVE TAKEN THE TRUCK TO FORD DEALERSHIP FOR "REPAIR" BUT IT DID NOT SOLVE THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHEN WHILE DRIVING OVER A ROAD BUMP, THE VEHICLE WOULD JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE VEHICLE NEEDED TO HAVE A CAMBER ALIGNMENT PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 91,000. UPDATED 02/27/12 *BF

TL* THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. THE CONTACT STATED WHEN DRIVING 60 MPH AND UP OVER A ROAD BUMP, THE VEHICLE WOULD BEGIN TO SHAKE VIOLENTLY TO THE POINT WHERE THE CONTACT WAS UNABLE TO MAINTAIN HIS GRIP OF THE STEERING WHEEL. THE CONTACT RECEIVED A TECHNICAL SERVICE BULLETIN IN REGARDS TO THE FAILURE. THE DEALER ADVISED THAT THE FAILURE WAS CAUSED INSTEAD BY INADEQUATE TIRE PRESSURE. THE VEHICLE WAS NOT REPAIRED AND WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A SECOND OPINION. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 75,000.

I HAVE A 2005 FORD F250, 6.0L DIESEL. THIS POWER PLANT IS USED ON SEVERAL FORD MODEL VEHICLES AND HAS AN INHERENT PROBLEM WITH IT'S EGR SYSTEM. WHEN THE EGR SYSTEM FAILS, THE VEHICLES LOOSES ALL THROTTLE RESPONSE. RESEND 03/05/10. *LJ ON NOVEMBER 25TH, 2009, I WAS STOP AT AN INTERSECTION WAITING TO MERGE ONTO A VERY BUSY HIGHWAY. WHEN THE TIME CAME TO MERGE ONTO THE HIGHWAY, MY VEHICLE FAIL TO ACCELERATE, IT CREPT INTO THE PATH OF ON COMING TRAFFIC AND I HAD TO PERFORM AN ADVASIVE MANEUVER (IMMEDIATELY PULL OFF THE HIGHWAY) TO PROTECT ME AND OTHERS FROM A POTENTIAL ACCIDENT. THIS SITUATION HAS HAPPEN TO ME ON MORE THEN ONE OCCASION AND IS INTERMITTENT. WHEN I REPORTED THIS TO MY DEALERSHIP, THEY PERFORMED A PROCEDURE TO CLEAN OUT THE CARBON BUILDUP WITHIN THE INTAKE SYSTEM AND TOLD ME THAT THIS WAS CONSIDERED ROUTINE MAINTENANCE, THIS IS NOT MENTIONED ANYWHERE IN THE OPERATORS MANUAL. I BELIEVE THIS IS A PUBLIC SAFETY ISSUE THAT FORD SHOULD RECOGNIZE AND PROVIDE A FIX. *TR

THE REAR BREAKS LOCK UP ON THE CALIPER PINS. THE CALIPERS AND PADS HAVE BEEN REPLACED UNDER WARRANTEE, AND THREE TIMES OUT OF POCKET. THE FORD DEALER NOW SAYS THE PROBLEM LIES IN THE CALIPER PIN, AFTER LOCKING UP BUY NEW PINS GREASE AND YOU ARE GOOD. THIS ONLY LAST UNTIL THE TRUCK SITS 3-5 DAYS. WHEN THE BREAKS LOCK UP THE REAR BREAK ARE HOT ENOUGH TO CATCH ON FIRE AND THE STOPPING ABILITIES ARE IMPAIRED. YOU LOOK ON THE INTERNET AND THIS IS A VERY COMMON PROBLEM WITH THE SUPERDUTY FORDS. THERE IS NO FIX AVAILABLE. WE ARE AFRAID TO DRIVE THE VEHICLE BECAUSE YOU NEVER KNOW WHEN THEY WILL LOCK. YOU MAY DRIVE TO TOWN FINE BUT ON THE WAY HOME IT IS LOCKED AND DANGEROUS.

RIGHT REAR PARKING BRAKE FAILED. REAR BRAKE ASSEMBLY PLATE CORRODED THROUGH AND ALLOWED RETAINING STUD TO PULL THROUGH PLATE. PARKING BRAKE ASSEMBLY LOST INTEGRITY CAUSING BRAKE DRAG AND SQUEALING NOISE. BRAKE PART FAILED IN 65000 MILES. CONCERNED FAILURE COULD HAVE BECOME CATASTROPHIC AT FREEWAY SPEEDS IF PARKING BRAKE LOCKED UP WHEEL. PART IS AVAILABLE. *TR

OCT. 20, 2009, TRUCK DIED WHILE PULLING 5TH WHEEL UP STEEP MTN. ROAD TO KENNEDY MEADOWS, CA. BAD SITUATION. AFTER 3 WEEKS IN FORD GARAGE, IN RIDGECREST, CA. SEVERAL PARTS REPLACED ALL RELATED TO THE HIGH PRESSURE OIL SYSTEM USED TO FIRE INJECTORS ON THIS 6.0 POWERSTROKE ENGINE. JAN 26, 2010. AFTER PULLING THE 5TH WHEEL FOR ABOUT 100 MILES THROUGH HEAVY TRAFFIC AND PARKING TRAILER IN MY DRIVEWAY, I CAME BACK LATER AND TRUCK WOULDN'T START. TOWED TO LAKE ELSINORE FORD AND THEY REPLACE THE OIL PRESSURE REGULATOR. THIS IS ALL OVER THE POWERSTROKE SITES ON THE NET. MY NEPHEW HAS HAD THE SAME PROBLEMS. FORD KNOWS THIS TOO. BOTH OF THESE INCIDENTS COULD HAVE RESULTED IN WRECKS, THERE IS NO WARNING, THE ENGINE JUST DIES. *TR

FORD F-250 SUPERDUTY- WHILE DRIVING AT 55MPH OR HIGHER,AND YOU HIT A SMALL POTHOLE OR DIP IN THE ROAD, THIS VEHICLE GOES INTO A VIOLENT SHIMMY. THE VEHICLE IS UNCONTROLLABLE AND EXTREMELY DANGEROUS. I WON'T LET ANY OF MY FAMILY MEMBERS RIDE IN THE TRUCK WITH ME AND CRINGE AT THE THOUGHTS OF HAVING TO DRIVE IT ON THE INTERSTATE! IT HAS SHAKEN ME OFF THE ROAD AND INTO THE DITCH OR MEDIAN SEVERAL TIMES. *TR

I OWN A 2005 F250 SUPER DUTY, MY TRUCK EXPERIENCES THE "DEATH WOBBLE" WHEN EVER I GO OVER AN UNEVEN OR A POT HOLE IN THE ROAD. I LIVE IN ARKANSAS, AND OUR ROADS ARE NOT THE BEST. SO THIS HAPPENS JUST ABOUT EVERY TIME I DRIVE THE THING. I JUST PURCHASED THIS VEHICLE IN SEPTEMBER OF 2009. APPARENTLY WHEN I TEST DROVE THE TRUCK I WAS ON SMOOTH PAVEMENT OTHERWISE I WOULDN'T HAVE BOUGHT IT. *TR

2005 FORD F-250 TRANSMISSION CIRCLIP IS COMING OFF CAUSING TRANSMISSION TO LEAK AND ULTIMATELY FAIL. WE KNOW OF 6 PEOPLE THAT THIS HAS HAPPENED TO, NOW US. FORD HAD A "CUSTOMER SATISFACTION BULLETIN 05B27" THAT EXPIRED AT THE END OF 2006. WE FOUND THIS ON OUR OWN. FORD IS ABSOLUTELY NO HELP WITH THIS ISSUE. PLEASE READ THE DIESEL FORMS ON THE INTERNET. *TR

TL*THE CONTACT OWNS A 2005 FORD F250. THE CONTACT OBSERVED THAT THERE WAS A TRANSMISSION FLUID LEAK. THE CONTACT IS A CERTIFIED TECHNICIAN AND CONFIRMED THAT THE FAILURE WAS CONTRIBUTED TO THE TRANSMISSION SNAP RING. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION AT THIS TIME. THE VIN WAS NOT AVAILABLE. THE CONTACT HAD CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 42,000.