2006 Ford F-250 Complaint Log

1. DAILY DRIVING 2. CRACKED 2 DIFFERENT WHEELS ON SEPARATE OCCASIONS, INOPERABLE VEHICLE 3. HAD TO INDEPENDENTLY HAVE WHEELS WELDED BECAUSE MANUFACTURER DENIED RESPONSIBILITY. *TR

I WAS DRIVING ON A CITY STREET AND MADE A LEFT TURN. HALF WAY THROUGH THE TURN THE TRUCK STARTED SHAKING(SHIMMING) TO THE POINT WHERE IT WAS BASICALLY NOT DRIVE ABLE. FORTUNATELY I WAS NOT GOING FAST AT THE TIME SO I COULD SLOW DOWN QUICKLY AND PULL OFF TO THE SIDE OF THE ROAD. WHEN THE EVENT HAPPENED IT WAS QUICK, FROM NOTHING TO THE TRUCK SHAKING VIOLENT. I ENDED UP HAVING THE STEERING GEAR AND U JOINTS REPLACED.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH AND DROVE OVER A POT HOLE WHEN THE ENTIRE VEHICLE BEGAN TO VIBRATE VIOLENTLY AND CAUSED THE DRIVER TO ALMOST LOSE CONTROL OF THE VEHICLE. THE FAILURE WAS EXPERIENCED ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

UPON HITTING BUMPS ON ROADWAY I LOST COMPLETE CONTROL OF TRUCK FOR APPROX 2 TENTHS OF A MILE UNTIL I SLOWED DOWN. FRONT END SHOOK VIOLENTLY SOMEBODY IS GOING TO DIE IN ONE OF THESE DEATH TRAPS,I HOPE ITS NOT ONE OF MY KIDS

VIOLENT SHAKING/ VIBRATIONS @ HIGHWAY SPEEDS. I PULLED OVER TO COMPLETE STOP, WAITED, STARTED UP AND VIBRATION STOPPED. THIS HAS HAPPENED ON 3 OCCASIONS SINCE. *TR

F250SD DIESEL ABOUT 65 MI.S.OF ELI,NV. THE CK ENGINE SYMBOL CAME ON,SO I PULLED OVER AND LOOKED UNDER THE HOOD. THERE WAS OIL ALL OVER THE TOP OF THE ENGINE,[MAYBE 1 GAL.]. OIL WAS COMING OUT OF PLASTIC COOLANT OVERFLOW BOX. NO OIL SHOWED ON CHECK STICK. I GOT 2 GAL OF OIL FROM SOMEONE PASSING BY AND LIMPED INTO ELI NV. THE PICKUP SEEMED TO RUN OK AND NO OTHER WARNINGS SHOWED. [I WATCHED TEMPS CLOSELY]. TURNED OUT THE OIL COOLER INTERNAL [UNDER THE INTAKE MANIFOLD] SPRUNG A LEAK AND FORCED OIL INTO THE COOLANT SYSTEM. MY TRUCK WAS BARELY OVER THE 5 YR. WARRANTY SO NO HELP THERE FROM FORD. I ALWAYS WANTED A FORD DIESEL BUT NOT ANYMORE. COST $2200. FOR REPAIRS, AND LOST 3 WEEKS WITH THE TRUCK. HAD TO HIRE A U-HAUL TO GET HOME TO BOISE AND COME BACK FOR MY PICKUP. MY QUESTION IS WHY NO HELP FROM FORD? I STILL HAVE THE BAD COOLER. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WOULD VIOLENTLY WOBBLE WHILE DRIVING AT HIGHWAYS SPEEDS. THE DEALER ATTEMPTED TO REPAIR THE VEHICLE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT MILEAGE WAS 47,600.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT A CRACK HAD ACCUMULATED ON THE FACTORY WHEEL DIRECTLY IN THE CENTER. THE CONTACT STATED THAT THE CRACK ON THE WHEEL CAUSED THE VEHICLE TO SHAKE WHILE DRIVING 35 MPH. THE CONTACT TOOK THE VEHICLE TO A DEALER TO HAVE THE WHEEL REPLACED AND THE DEALER COULD NOT FIND A REPLACEMENT WHEEL. THE FAILURE MILEAGE WAS 12,000.

TL* THE CONTACT OWNS A 2006 FORD F250. THE CONTACT STATED THAT THERE WAS AN EXTREME VIBRATION IN THE STEERING WHEEL. THE CONTACT DROVE OVER A BUMP OR UNEVEN PAVEMENT WHILE DRIVING THE VEHICLE AT ANY SPEED AND HAD TO USE FORCE IN ORDER TO GAIN CONTROL OF THE STEERING WHEEL ON MULTIPLE OCCASIONS. THE VEHICLE SHOOK VIOLENTLY AND THE STEERING CONTINUED TO BE UNSTABLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT CONTINUED TO EXPERIENCE THE STEERING FAILURE WHICH CAUSED THE VEHICLE TO DRIVE ROUGH. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHO WAS UNABLE TO REPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50000.

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WOULD OVER HEAT AND SMOKE WOULD COME FROM UNDERNEATH THE HOOD. THE DEALER DIAGNOSED THAT THE CONTACT NEEDED TO REPLACE THE HEAD GASKET. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 125,000 AND THE CURRENT MILEAGE WAS 130,000.

MY 17 YR OLD SON HAS AN '06 FORD F-250 SD CC LARIAT 4X4 TRUCK, WHICH I PURCHASED 12/09. HE BEGAN COMPLAINING ABOUT THIS FRONT END "DEATH WOBBLE" EVERYONE ELSE IS COMPLAINING ABOUT. A MECHANIC REPLACED THE BUSHINGS IN THE FRONT TO RESOLVE THE PROBLEM, WHICH COST $210. BUT IT DIDN'T FIX THE PROBLEM, MY SON COMPLAINED AGAIN A WEEK LATER AND HIS NEW TIRES PURCHASED FALL 2010 WERE BASICALLY BARE. SO I DROVE THE TRUCK THROUGH DOWNTOWN ATLANTA ON I-85, WHEN I HIT A BUMP IN THE HOV LANE AT 58 MPH IN A CURVE. THE FRONT END BEGAN SHAKING SO VIOLENTLY I COULD BARELY MAINTAIN MY LANE AND HAD CARS BESIDE, FRONT & REAR OF ME. THIS WOBBLE CAUSED A HUGE CUP OF CHANGE IN THE DASH CUPHOLDER TO SPEW LIKE A BUSTED WATER PIPE. WE JUST PUT NEW BF GOODRICH TIRES ON, BUT I'M CONCERNED THESE WON'T LAST A YEAR EITHER. HOW CAN IT BE FIXED? I'M VERY WORRIED FOR MY SON'S SAFETY. THIS IS A LAWSUIT WAITING TO HAPPEN FOR FORD, AND THIS PARTICULAR WEBSITE HAS A BLETHERA OF COMPLAINTS ABOUT THE SAME DEATH WOBBLE. *TR

UNCONTROLLABLE WOBBLE TO VEHICLE AFTER HITTING BUMP ON FREEWAY AT 65 MPH. NOT FIRST TIME AND LUCKY I DIDN'T END UP OFF THE FREEWAY. HAD SERVICE DONE AT FORD DEALERSHIP FOR THE SAME PROBLEM IN AUG 2010, REPLACED CAMBER CASTING AND TWO WHEEL ALIGNMENT, AND TIRE PRESSURE. PROBLEM IS BACK. *TR

AIR CONDITIONING ISSUE: IN TURNING ON THE AIR CONDITIONING IN MY F250 FORD TRUCK THIS YEAR IT DID NOT COOL THE CAB. IN TAKING IT TO A MECHANIC TO SEE WHAT WAS THE PROBLEM, I WAS TOLD THAT 3 TECHNICAL BULLETINS HAD BEEN ISSUED ON THE A/C UNIT. UNLESS THERE WAS A PROBLEM, NO ONE WOULD HAVE CHECKED THE A/C. BULLETINS 06-17-12, 08-13-5 AND 08-13-5 - LACK OF A/C COOLING DUE TO DEFICIENT MATERIAL CLOGGING ORIFICE TUBE. NOW IT IS COSTING OVER $800 FROM MY POCKET TO FIX A PROBLEM THAT FORD ACKNOWLEDGES THAT IT KNOWS ABOUT AND BECAUSE OF THE BAD PART, THE ENTIRE A/C SYSTEM HAS BEEN COMPROMISED. *TR

THE VEHICLE IS A 2006 FORD SUPERDUTY 4X4. HAS HAD NO MODIFICATIONS TO SUSPENSION. STILL FACTORY TIRES AND CURRENTLY AT 31,000 MILES. I CAN NO LONGER DRIVE THE TRUCK ON THE INTERSTATE. HITTING EVEN A SMALL BUMP AT 65MPH CAUSES THE FRONT END TO SHAKE SO BADLY THAT CONTROLLING THE TRUCK IS NO LONGER POSSIBLE. TODAY 04/13/11 THE MOST RECENT INCIDENT IT HAPPENED IN THE AFTERNOON RUSH ON I95 HERE IN RICHMOND WHERE I LIVE. SENDING ME ACROSS THE LANES AND ALMOST OFF THE ROAD,. I AM A VIRGINIA STATE SAFETY INSPECTOR. I CAN ASSURE YOU THAT ALL STEERING PARTS ARE STILL LIKE NEW AND TIGHT. I EVEN RETORQUED ALL BOLTS. I HAVE TALKED TO THE LOCAL FORD DEALER. THEY SAY THERE'S A TSB FOR A NEW DAMPER. THIS PROBLEM IS FAR BEYOND A STEERING DAMPER.. IT HAS DONE THIS A TOTAL OF 4 TIMES,BUT IM SURE WILL DO IT EVERY TIME YOU HIT A BUMP AT HIGHWAY SPEED. FORD WONT OR CANT FIX IT AND I DON'T KNOW WHAT TO DO WITH A TRUCK THAT I CANT DRIVE ON THE INTERSTATE. IT WOULD MAKE A GREAT TEST TRUCK FOR THE NHTSA SINCE IT ISN'T GOOD FOR MUCH ELSE SINCE I HAVE TO TRAVEL THE INTERSTATE ON A WEEKLY BASIS. *TR

I WAS TRAVELING ON THE FREEWAY AT 60 MPH. THE VEHICLE WENT INTO A VIOLENT SHAKING AFTER GOING OVER AN UNEVEN ROAD SURFACE. THE VEHICLE JUMPED A HALF LANE OVER AND I HAD LOST CONTROL UNTIL MY SPEED WAS REDUCED. AT THAT TIME I WAS AFRAID OF SLAMMING ON THE BRAKES AND LOSING MORE CONTROL OR POSSIBLY FLIPPING OVER. NOW THIS VIOLENT SHAKING OCCURS EVERY TIME I HIT A POT HOLE OR ANY UNEVEN SURFACE AT 55 TO 60 MPH. I HAVE TAKEN MY VEHICLE TO FORD SERVICE AND THEY CAN NOT FIND ANY PROBLEM THAT WOULD CAUSE THE VIOLENT SHAKING. AFTER DOING SOME RESEARCH I FOUND A VIDEO OF THIS ON YOU TUBE AS "F-250 DEATH WOBBLE". THIS VIDEO SAYS IT ALL AND IS BASED ON A STOCK ORIGINAL EQUIPMENT F-250 SUPER DUTY. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH THE VEHICLE BEGAN TO ABRUPTLY DECELERATE UNTIL STOPPING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE EGR VALVE WAS STUCK IN AN OPENED POSITION. THE EGR VALVE WAS REPLACED. THE FAILURE HAD SINCE RECURRED TWICE. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE EGR COOLER AND OIL COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 136,000.

AT AROUND 65 MPH MY 2006 FORD F250 HAS A VERY HORRIBLE SHIMMY IN THE FRONT END. THIS SHIMMY COMES WHEN THE VEHICLE HITS A CHANGE IN THE PAVEMENT OR ANYTHING OTHER THAN A PERFECT SMOOTH ROAD. THIS HAS HAPPENED SEVERAL TIMES.

2006 FORD F-250 EXPERIENCES A SEVERE VIBRATION BETWEEN 50 - 65 MPH. SPECIFICALLY NOTICED AFTER HITTING A POTHOLE OR DRIVING ON UNEVEN ROADS. TRUCK IS COMPLETELY STOCK AND HAS HAD SHOCKS/ STEERING STABILIZER / BRAKES / TIRES / ALIGNMENT / (REPLACED/COMPLETED) AT A CERTIFIED FORD DEALER WITHIN THE PAST 2 MONTHS. ADDITIONALLY, I HAD EVERY BALL JOINT, TIE ROD END, STEERING COMPONENT INSPECTED AT MY COST TO INVESTIGATE THE ISSUE. THE STEERING VIBRATION STILL EXISTS. FORUMS AND OTHER SITES HAVE STARTED TO CALL THIS THE "DEATH WOBBLE". ALTHOUGH IT CAN BE ESCAPED BY SLOWING DOWN OR ACCELERATING THROUGH THE VIBRATION, IT CAN EASILY CAUSE LOSS OF CONTROL TO THE UNEXPECTED DRIVER. I HAVE DRIVEN FORD VEHICLES (TRUCKS) FOR THE PAST 20 YEARS AND THIS IS THE FIRST TIME I HAVE VENTURED TO FILE AN OFFICIAL COMPLAINT. FOLLOWING THE SERVICE BULLETIN TO ADJUST TIRE PRESSURE DID NOT CORRECT THE PROBLEM. BRAND NEW TIRES AND ALIGNMENT OFFERED A MINOR REPRIEVE ONLY FOR ME TO EXPERIENCE THE SAME ISSUES LESS THAN 50 MILES LATER. PEOPLE WHO HAVE EXPERIENCED THIS ISSUE NEED TO GET SPECIFIC IN ORDER TO PROMPT ACTION FROM EITHER THE NHTSA OR THE FORD MOTOR COMPANY. I DID NOT EXPERIENCE THIS ISSUE TILL APPROXIMATELY 60,000 MILES, SOMETIME AFTER A BRAKE CHANGE. THE SUBSEQUENT ISSUES LEAD ME TO CHANGE THE AFOREMENTIONED EQUIPMENT IN ORDER TO RESOLVE THE ISSUE. TO THIS POINT, THE DEALERSHIP CAN FIND NOTHING WRONG BUT THE ISSUE REMAINS. TO REINTERATE, THIS TRUCK IS STOCK, NO MODIFICATIONS HAVE BEEN MADE AND REQUIRED MAINTENANCE HAS BEEN CONDUCTED BY THE DEALER IN EVERY INSTANCE. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. WHILE HAVING THE BRAKES SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE BACKING PLATES FOR THE REAR BRAKES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 40,000.

I OWN A 2006 F - 250 SD, BOUGHT USED WITH < 6K MILES. I DRIVE IT TO HAUL AND TOW SEVERAL ITEMS AND IT HAS BEEN A GOOD TRUCK. THE ONLY MAJOR ISSUE IS THAT IF I HIT A UNEVEN SURFACE, RAILROAD TRACKS OR BUMPS WHILE TRAVELING AT SPEEDS GREATER THAN 50 MPH, THE ENTIRE FRONT END FEELS AS IF TS ABOUT TO FALL OFF. IT SHAKES VIOLENTLY AND THE STEERING BECOMES ALMOST IMPOSSIBLE. THE FIRST TIME THIS HAPPEN I THOUGHT THAT I HAD A FLAT. I STOPPED THE TRUCK ASAP WHICH WAS DIFFICULT. I GOT OUT AND NOTICED NOTHING VISIBLY WRONG. THIS HAPPENED AFTER CROSSING A RR TRACKS THAT IS FAILRY SMOOTH, AND LOCATED ON A FOUR LANE. TIRE PRESSURE IS CHECKED OFTEN (EVERY COUPLE OF WEEKS) AND IS INFLATED TO THE STANDARD. I NOW KNOW IF I'M TO KEEP THIS VEHICLE I MUST SLOW DOWN TO AVOID AN INCIDENT FROM OCCURRING. IT APPEARS THAT MANY COMPLAINTS HAVE BEEN WRITTEN BUT HAVE FALLING ON DEAF EARS. IT WILL LIKELY TAKE A DEATH FOR SOMEONE TO ACT. TIRE PRESSURE IS NOT THE ISSUE. A SERIOUS AND UNDERMINED ISSUES REMAIN. I INVITE YOU TO COME AND DRIVE THE VEHICLE AND GO OVER THE SAME RR CROSSING I DID, THEN YOU MAY UNDERSTAND THE CONCERN. A RECALL HAS BEEN ORDERED FOR LESS AND NEEDS ATTENTION NOW. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHEN TRYING TO DECELERATE HE SMELLED A STRONG ODOR. WHEN HE INSPECTED THE VEHICLE, THE CALIPERS ON THE BRAKE LINE HAD DISINTEGRATED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 108,400. UPDATED 04/12/11*LJ THE CONSUMER STATED WHEN HE PULLED THE BRAKE APART, HE NOTICED ONE OF THE TWO CALIPER PISTONS HAD DISINTEGRATED. UPDATED 04/13/11

TL* THE CONTACT OWNS A 2006 FORD F250 SUPER DUTY. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN HE NOTICED AN ABNORMAL VIBRATION IN THE STEERING WHEEL. AS THE CONTACT INSPECTED THE VEHICLE, HE DISCOVERED THAT THE WHEEL WAS FRACTURED AND THERE WAS DAMAGE TO THE TIRE. THE SPARE TIRE WAS ATTACHED AND THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE BUT ADVISED REPLACING THE WHEEL, TIRE AND CENTER CAP. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 35 MPH, THE VEHICLE SHOOK AND JERKED WITHOUT WARNING. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OPENED SPECIAL FIELD ACTION NUMBER: 09L02, BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 120,000.

I PURCHASED A 2006 FORD F 250 WITH THE TRITON 54 . I HAD IT FOR 2 DAYS WHEN THE MOTOR STARTED TICKING. I'M TOLD THAT IT'S A SPARK PLUG ISSUE AND NO ONE IS WILLING TO WORK ON IT DUE TO THE HIGH COST OF FIXING THE PROBLEM WHEN THE PLUGS BREAK OFF IN THE HEAD AND THEY ALSO SAID IT WILL PROBABLY BLOW A SPARKPLUG OUT . THIS WILL COST APROX. $3000 TO FIX . *TR

EVERY TIME I HIT A POTHOLE ON THE FREEWAY MY FRONT END WOBBLES VIOLENTLY AS THE HOLE FRONT END IS ABOUT TO DROP OUT. IT ONLY STOPS WHEN I SLOW WAY DOWN. *TR

TL* THE CONTACT OWNS A 2006 FORD F250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE ENGINE ERG VALVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT WILLING TO ASSIST WITH THE REPAIRS STATING THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE AND CURRENT MILEAGE WAS 60,000.

POWER TRAIN HAD REAR MAIN SEAL FAILURE AROUND THIS DATE. POWER TRAIN HAS ANOTHER FAILURE AND LEAK IN SEPTEMBER OF THE SAME YEAR WHICH FORD WILL NO LONGER FIX. VEHICLE HAS LESS THAN 100,000 MILES AND ONLY APPROX 81,000 WHEN THE POWER TRAIN BEGAN TO HAVE PROBLEMS. THIS VEHICLE HAS SEVERAL OTHER ISSUES WHICH FORD WILL NOT ADDRESS. THE CUSTOMER ASSISTANCE CENTER AND THE COMPANY REP WILL ONLY OFFER HALF OFF ON REPAIRS WHICH THEY CLAIM THEY ARE NOT RESPONSIBLE FOR AND WILL NOT ACKNOWLEDGE THE PAST OR OTHER CURRENT PROBLEMS THE VEHICLE IS HAVING. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 DIESEL SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH OVER A ROAD BUMP, HE MOMENTARILY LOST CONTROL OF THE VEHICLE ABNORMALLY UNTIL THE VEHICLE SPEEDS WAS SLOWED. THE VEHICLE WAS INSPECTED BY THE DEALER WHO INFORMED THE CONTACT THAT THE FAILURE COULD HAVE BEEN CAUSED BY UNDER INFLATED TIRES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 58,000. UPDATED 06/16/11 *BF UPDATED 06/27/11

2006 F250 SUPERDUTY 6.0: THIS VEHICLE STALLS WHILE DRIVING DOWN THE ROAD JUST ABOUT EVERY DAY. I NOTICED THAT THERE WAS A RECALL FOR THE SAME ENGINE ON THE 2004 F250 FOR THE SAME THING. IT STALLED LAST WEEK GOING INTO A HARD TURN AND I RAN OFF THE ROAD BECAUSE I WAS UNABLE TO CONTROL THE VEHICLE AFTER IT STALLED. IT COULD HAVE BEEN LETHAL IF THERE WERE MORE TRAFFIC....I HAD IT TOWED ($250) IT HAS BEEN IN THE SHOP FOR A WEEK....LOOKING FOR ANSWERS.. THIS VEHICLE IS A DEATH TRAP.... *LN

STEERING WHEEL FREEZES TURNING TO THE RIGHT. MY WIFE WAS GOING TO TOWN AND CAME TO A RIGHT HAND CURVE AND THE STEERING WHEEL WOULD NOT TURN THEN POPPED FREE. THIS HAS HAPPENED NOW WHEN MANEUVERING TO PARK OR JUST DRIVING DOWN THE ROAD AT VARYING SPEEDS. IT IS AT THE FORD DEALER NOW BEING REPAIRED. I TALKED TO THE MECHANIC DOING THE REPAIR WORK. HE ASKED ME WHAT YEAR THE TRUCK WAS AND TOLD HIM IT WAS A 2006 F-250 4X4. HE THEN TOLD ME THAT FORD CHANGED THE TYPE OF STEERING GEAR BOX THAT THEY USE IN 2005 AND HAVE HAD A LOT OF PROBLEMS WITH THE SECTOR GEAR IN THE STEERING GEAR BOXES EVER SINCE THEY DID THAT CHANGE. I INSTALLED A FILTER ON THE RETURN LINE. AFTER DRIVING IT A FEW MILES I REPLACED THE FILTER AND DISMANTLED THE OLD FILTER AND FOUND A THICK LAYER OF SLUDGE ON THE MAGNET PART OF THE FILTER. THIS INDICATED THAT SOMETHING WAS WEARING AND CONTAMINATING THE SYSTEM WITH METAL PARTICLES. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT DROVE OVER AN UNEVEN ROAD SURFACE AND THE STEERING WHEEL BEGAN TO SHIMMY, CAUSING THE VEHICLE TO MERGE INTO ANOTHER LANE. THE FAILURE WOULD RECUR WHEN ATTEMPTING A TURN AND USUALLY WHEN DRIVING BETWEEN 30-60 MPH. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED A CONCURRENT INVESTIGATION OF THE FAILURE UNDER NHTSA ACTION NUMBER: EA08007 (SUSPENSION:FRONT) THAT COULD POSSIBLY HAVE BEEN RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

VEHICLE WAS STOLEN OFF LARSON FORDS LOT WITHIN 30 SECONDS. I WAS TOLD BY A DETECTIVE THAT THIS THE F150, 250, 350 ARE VERY EASY TO STEAL BY JABBING A SCREW DRIVER UP AND BEHIND THE DOOR HANDLE WHICH UNLOCKS THE DOOR THEN PUT THE SCREW DRIVER IN THE IGNITION AND START IT UP AND FORD COMPANY KNOWS ALL ABOUT THIS AND DID NOTHING TO FIX THE PROBLEM. *TR

2006 F250 SD DIESEL SHAKES EXTREMELY VIOLENTLY WHEN CRUISING AT 55MPH+ AND HITTING A BUMP IN THE ROAD. TRUCK IS UNCONTROLLABLE, DIFFICULT TO AVOID OTHER CARS. SLOWING TO ABOUT 35 MPH WILL RESOLVE THE SITUATION. THIS HAS HAPPENED 6 TIMES IN 11 MONTHS, BOTH TOWING TRAILERS, EMPTY, ETC. TIRE PRESSURE, JOINTS, BEARINGS, DAMPENER, ALIGNMENT ETC ARE ALL FINE. RESEARCH SHOWS THIS TO BE EXTREMELY COMMON AMONG 2005-2006 F250 OWNERS, NO PERMANENT SOLUTION IS KNOWN BY FORD. *TR

THE DEATH WOBBLES OR SHIMMY BEEN.GOING ON SINCE 2010. THE WHOLE TRUCK WOULD SHAKE AND SHAKE HARD. UNTIL I SLOW DOWN TO 30MPH. THEN FORD SENT ME A LITTER (09L02) SAYING IT'S CALLED THE SHIMMY AND ITS MY TIRE PRESSURE. I CHECKED TIRE STILL KEPT HAPPENING. YESTERDAY 6/23/2014 MY WIFE AN TWO SONS WHERE ON THE FREEWAY WHEN IT HAPPEN AND THE STEERING DAMPER BROKE OFF. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE REAR BRAKES WOULD MALFUNCTION WHEN DRIVING IN REVERSE. THE CONTACT STATED THAT THE BRAKE LINE COLLAPSED CAUSING THE CALIPERS TO CLOSE IN ON THE BRAKE PADS. THIS CAUSED THE CALIPER SEAL TO BURST AND BRAKE FLUID BEGAN LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE THE ENTIRE REAR BRAKING SYSTEM WAS REPLACED. THE MANUFACTURER ADVISED THE CONTACT THAT REPAIRS WOULD BE AT THE CONTACTS EXPENSE AND THEY WOULD NOT ASSIST. THE CONTACT STATED IF THE VEHICLE WAS TRAVELING AT A HIGHER RATE OF SPEED, A CRASH COULD HAVE POTENTIALLY OCCURRED. THE FAILURE MILEAGE WAS 51,500.

MY F250 P/U HAS A DEATH WOBBLE ABOVE 50 MPH. THAT HAS ALMOST MADE ME CRASH ON SEVERAL OCCASIONS. *TR

I HAVE A 2006 FORD F-250 SUPER DUTY TRUCK. WHEN I HIT A ROUGH SPOT IN THE ROAD THE FRONT END SHAKES SO BAD YOU HAVE NO CONTROL OF THE STEERING. THE ONLY WAY TO GET IT TO STOP SHAKING IS TO GET ON THE BRAKES AND STOP. I HAVE BEEN BACK TO THE DEALER AND THEY TELL ME THERE IS NOTHING WRONG. SOMEONE IS GOING TO GET KILLED IF THIS IS NOT CORRECTED. *TR

SEPT. 2010,MY 2006 SD F-250 FORD TIRE,WITHOEM17"ALLOY 8HOLE WHEEL ,EXPLODED VIOLENTLY IN MY DRIVEWAY. DISCOVERED INSIDE OF RIM HAD CRACKED AND PEELED ALONG TIRE BEAD ALLOWING TIRE TO BLOW. RIM AND TIRE HAD TO BE REPLACED, IT EVEN BLEW OFF THE RUBBER STOP BLOCK ON THE FRAME FOR AXLE TO HIT. USED TRUCK SO ASSUMED IT WAS PREVIOUSLY DAMAGED. CLOSE INSPECTION SHOWED OTHER WHEELS WERE OK. JUNE 2011, SHIMMY IN FRONT END, DISCOVERED OTHER FRONT WHEEL CRACKED IN THE SAME WAY AND CLOSE TO FAILURE. LOCAL FORD DEALER SAYS NO RECALLS. E-MAIL TO FORD CANADA GOT NO RESPONSE. I HAVE PICTURES OF BOTH WHEELS. THIS IS MY FOLLOW UP. PLEASE CHECK YOUR WHEELS. FOR THEIR SAFETY, HAVE YOUR TIRE DEALER INSPECT WHEELS WHEN REPLACING TIRES. *TR

MY 2006 F250 SD FRONT END SHAKES VERY BAD OVER POT HOLES AND STOPS WHEN I GET UNDER 20 MPH. *TR

F250 4X4 TRUCK EXPERIENCED FOR THE 3RD TIME THE "DEATH WOBBLE" WHILE DRIVING DOWN THE FREEWAY AT ABOUT 65 MPH. STEERING WAS OUT OF CONTROL AND THE TRUCK BOUNCED OUT OF THE LANE NEARLY HITTING ANOTHER VEHICLE AND CAUSING SEVERAL CARS TO SLAM ON THEIR BRAKES. THIS WAS AFTER HITTING A SMALL BUMP IN THE ROAD. *TR

I WAS DRIVING DOWN A STREET IN MY 2006 F250 SD, WHEN ALL OF A SUDDEN THE HORN HONKED AND STAYED ON (NOT LIKE HONK HONK BUT LIKE HHHHOOONNNKK) I HAD TO STOP AND PULL THE FUSE TO GET THE HORN TO TURN OFF. IT IS A SAFETY RISK DUE THE WAY OTHER DRIVERS GET STARTLED BUY THIS SUDDEN NOISE. AND MAY VERY WELL CAUSES AND ACCIDENT OR KILL SOME ONE IF IT HAPPENS AT THE WRONG TIME. I HAVE READ ONLINE THAT IS HAPPENS ALOT IN THE 03-06 F250, AND WHEN FORD FIXED MY TRUCK THEY REPLACED THE FUSE BOX, DRIVER SIDE AIR BAG AND HORN ASSEMBLY(AT A COST OF 1486.80). STATING THAT IF I HAD BEEN IN AN ACCIDENT THE AIR BAG MIGHT NOT HAVE DEPLOYED. SO MY LIFE COULD HAVE VERY MUCH BEEN IN DANGER......... THANKS FORD... *TR

FORD 2006 F250 DEATH WOBBLE. I WAS DRIVING MY TRUCK TODAY AND I HIT A LITTLE POT HOLE IN THE ROAD AND NEARLY LOST CONTROL OF MY TRUCK. THE TRUCK WAS SHAKING SO BAD I THOUGHT FOR SURE THE FRONT WHEELS WERE OFF AND WE WERE DEAD. SCARIEST THING EVER. FORD NEEDS TO RECALL THIS ISSUE BEFORE IT KILLS SOMEONE IF IT HASN'T ALREADY. THIS IS VERY SERIOUS WE PAY GOOD MONEY FOR THESE VEHICLES AND SHOULD NOT HAVE TO PAY OUT OF POCKET FOR THE FIX. THANK YOU VERY MUCH FOR TAKING THE TIME TO READ THIS HOPE FORD DOSE THE RIGHT THING AND RECALLS THIS ISSUE. *TR

I HAVE A 2006 FORD F250 PICKUP, 4WD, DIESEL. WHEN I HIT A BUMP ON THE HIGHWAY IT CAUSES A FRONT END SHIMMY THAT NEARLY CAUSES ME TO LOSE CONTROL. IT HAS 52,000 MILES ON IT BUT HAS DONE THIS SINCE NEW. IT HAS NO LIFT KIT, NO MODIFICATIONS. I HAVE INQUIRED WITH OTHER LATE MODEL F250 OWNERS AND THEY HAVE EXPERIENCED THE SAME PROBLEM. FORD SAYS IT'S DUE TO LIFT KITS, OURS HAVE NO LIFT KITS. THIS IS A DANGEROUS CONDITION AND COULD CAUSE AN ACCIDENT. *TR

DRIVING ON A COUNTY ROAD, THERE WAS A SECTION OF SMOOTHED PAVEMENT THAT HAD BEEN REPAIRED, SLIGHT BUMP IN ROAD. WHEN THE TRUCK WENT OVER IT, THE ENTIRE TRUCK BEGAN SHAKING, THE FRONT WHEELS VIOLENTLY SHOOK OUT OF CONTROL. IT DID NOT MINIMIZE AT ALL UNTIL I WAS ABLE TO SLOW THE TRUCK DOWN TO ABOUT 10MPH AND IT WENT AWAY. IT WAS ENOUGH TO SCARE MY CHILD IN THE BACK SEAT AND MYSELF. THERE HAVE BEEN SEVERAL INSTANCES OF THIS SINCE I PURCHASED THIS TRUCK, THIS BEING THE WORST. I WOULD BE VERY AFRAID OF AN ACCIDENT IF THIS HAD HAPPENED TO THIS DEGREE OUT ON A HIGHWAY AT HIGHWAY SPEEDS. I HAD BEEN TO THE DEALER AFTER THE FIRST COUPLE TIMES IT HAPPENED, THEY BLAMED THE TIRE PRESSURE AND ACTED LIKE THEY HAD NOT HEARD OF THIS PRIOR. THE VEHICLE WAS JUST AT THE DEALER A FEW WEEKS AGO FOR SERVICE WHERE THEY SET THE TIRE PRESSURES THEMSELVES. *TR

WHILE DRIVING MY 2006 F250 SUPER DUTY TRUCK ON THE HIGHWAY I HAVE EXPERIENCED THE "DEATH SHAKE" I COULD NOT STEER THE TRUCK OR STOP IMMEDIATELY THE TRUCK,IT VEERED INTO THE NEXT LANE THANK GOD THERE WAS NO CARS THERE. THIS SCARED ME MY TWO CHILDREN AND MY FATHER IN-LAW I DON'T KNOW WHAT WOULD HAVE HAPPENED IF WE WERE ON A ROAD WITH NO GUARD RAILS. WE COULD HAVE EASILY ALL BEEN KILLED, THIS TRUCK HAS 40,000 ADULT DRIVEN MILES NO LIFT NO BIG TIRES NO OFF USE. THIS NEEDS TO BE ADDRESSED BY FORD AND BE PUT IN THE MEDIA BEFORE SOME ONE IS KILLED. *TR

WHILE DRIVING MY 2006 F250 DIESEL SUPER DUTY (HAVE ABOUT 35000 MILES ON IT) PULLING A 26 FOOT RV TRAVEL TRAILER LOST THE ELECTRICAL SYSTEM. THE SPEEDOMETER WENT TO 0, CRUISE CONTROL RESET AND BASICALLY ALL ELECTRICAL SYSTEMS SHUT DOWN. THE TRUCK GOT REAL QUIET. ABOUT 5 SECONDS LATER THE ELECTRICAL SYSTEM RESTORED AND ONLY LIGHT THAT CAME ON, THE DASH WAS THE ABS LIGHT. THE ABS LIGHT REMAINED ON FOR ABOUT ANOTHER 100 MILES AND THEN WENT OFF. DROVE ANOTHER 200 MILES WITH NO MORE PROBLEMS. BROUGHT THE TRUCK TO FORD BUT THERE WERE NO ENGINE CODES STORED AND PROBLEM COULD NOT BE RECREATED. *TR

2006 F-250 SUPER DUTY CREW CAB SHORT BED WITH 5.4L FRONT END HAS A BAD VIBRATION/RATTLE WHEN SPEED EXCEEDS 60 MPH. I DRIVE 15 MINUTES TO WORK EACH DAY ON THE HIGHWAY AND DURING MY TRAVELS I BET WHETHER OR NOT THE RATTLE AND VIBRATION WILL SHOW UP WHILE EN ROUTE. I NOTICE THE RATTLE EVEN AT LOW SPEEDS IN TOWN ESPECIALLY ON PATCHED ROADS OR POT HOLE TYPE DIPS. AT HIGH SPEEDS THE VIBRATION MAY LAST FOR 5 MILES OR MORE OR IT MAY CLEAR UP IN A FEW HUNDRED FEET DEPENDING ON HOW THE NEXT BUMP IN THE ROAD STRIKES THE FRONT TIRES. I SHARE THE SENTIMENT OF OTHER THAT HAVE REPORTED THIS PROBLEM THAT IS AN ISSUE IF YOU CANNOT MAINTAIN THE MINIMUM HIGHWAY SPEED SAFELY IN YOUR VEHICLE. FORD NEEDS TO INVESTIGATE THE ISSUE. WHETHER ITS BAD HARMONICS WITH CERTAIN SHOCK ABSORBERS, TO HARD OF TIRES, FRONT HUB ASSEMBLY BEARING ISSUES,TOE AND CAMBER ADJUSTMENTS GETTING MESSED UP, ETC. THERE HAS GOT TO BE A COMPONENT OR SET OF RELATED ITEMS CAUSING WHAT WE ALL ARE EXPERIENCING. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250 SUPERDUTY. THE CONTACT STATED THAT THE PASSENGER FRONT AND REAR WHEELS ON THE VEHICLE WERE CUTTING THE TIRES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO OFFERED NO ASSISTANCE. THE CONTACT CALLED THE MANUFACTURER WHO ALSO DID NOT ASSIST. THE FAILURE MILEAGE WAS 87,853.

FREQUENT VIOLENT FRONT END SHAKING WHEN VEHICLE HOT SMALL BUMPS IN THE ROAD. 9 OUT OF 10 FORD F250 OWNERS WE HAVE SPOKEN TO HAVE THE VERY SAME PROBLEM AND WE CANNOT FIGURE OUT WHY THIS AGENCY HAS NOT RECALLED THESE TRUCKS. *TR

I HAVE A 2006 F250 DIESEL, SUPERDUTY, SUPERCAB, LONG BED, 4X4. ON THE RIGHT REAR TIRE AREA, THE EMERGENCY BRAKE LINE LOOPS DOWN BELOW THE UNDERCARRIAGE OF THE VEHICLE. ON THE LEFT SIDE IT LOOPS UP. ON ALL FORD TRUCKS THAT I HAVE SEEN, WITH THE EXCEPTION OF THE 2006, BOTH SIDES LOOP UP. THIS IS A 4X4 TRUCK. I BELIEVE THAT IT IS UNSAFE TO HAVE THE EMERGENCY BRAKE LINE LOOP DOWN, AS THE LOWEST POINT ON THE VEHICLE, ON A TRUCK THAT WILL BE USED OFF ROAD. THIS TRUCK IS USED ON A RANCH AND FOR TRAILERING HORSES, SO THE POSSIBILITY OF DRIVING OVER BRANCHES AND ROCKS THAT COULD CATCH ON THE EMERGENCY BRAKE LINE IS HIGH. IN THIS DOWNWARD POSITION, IT IS LIKELY TO BREAK IF IT HITS A ROCK OR BRANCHES. I HAVE REQUESTED THE DEALER AND FORD CORPORATE TO FIX IT, BUT THEY HAVE INFORMED ME THAT THEY CANNOT MODIFY THE VEHICLE DESIGN. I HAVE PHOTOS THAT I CAN SEND, BUT I DO NOT SEE WHERE TO ATTACH ON THIS CONTACT FORM. I BELIEVE THAT THE EMERGENCY BRAKE LINE SHOULD BE ADJUSTED TO LOOP UP TO BE IN A SAFER POSITION AND NOT BE THE LOWEST POINT, HANGING BELOW THE UNDERCARRIAGE OF THE VEHICLE. *TR