2006 Ford F-250 Complaint Log

TL* THE CONTACT OWNS A 2006 FORD F250. THE CONTACT ATTEMPTED TO ACCELERATE FROM A COMPLETE STOP, BUT THERE WAS NO ENGINE POWER. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FUEL FILTER WAS REPLACED. THE FAILURE REOCCURRED TWO DAYS AFTER THE REPAIR. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE BACK TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE FAILURE COULD POSSIBLY BE CONTRIBUTED TO THE FUEL INJECTORS. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE VEHICLE HAD NOT BEEN DRIVEN FOR ONE YEAR DUE TO THE INTERMITTENT FAILURES AND INSUFFICIENT REPAIRS. THE FAILURE OCCURRED FOUR DIFFERENT TIMES. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. THE VIN WAS UNAVAILABLE. UPDATED 12/10/10. *LJ

SEE ATTACHED DESCRIPTION WITH THIS REPORT USING TCN: CCN26-19640 DESCRIPTION WRITE-UP... ..UPDATED 04/19/12 *BF THE CONSUMER STATED THE DEFECT INVOLVED SEVERE FRONT SUSPENSION AND STEERING WHEEL OSCILLATION THAT CAN RESULT IN LOSS OF CONTROL AND LANE CHANGE AT HIGHWAY SPEEDS. THE CONSUMER STATED THE VEHICLE PERFORMS PERFECT WHEN NOT TRANSPORTATION A LOAD AT ANY SPEED ON ANY ROAD CONDITION. HOWEVER, WHEN TRAVELING DOWNGRADES OF 6% OR MORE WITH THE 5TH WHEEL TRAILER AT SPEEDS ABOVE 50 MPH, A LIGHT TOUCH OF THE BRAKES TO SLOW THE COMBINATION VEHICLE DOWN INITIATES THE OSCILLATION WHICH WILL NOT STOP THE UNTIL THE VEHICLE SPEED FALLS BELOW 50 MPH. UPDATED 05/02/12

I OWN A 2006 F-250 SD. THE TRUCK WAS BOUGHT USED,ALSO HAS PRO COMP SUSPENSION LIFT AND OVERSIZED TIRES.DRIVING AT 45 50 MPH IF YOU HIT ANY KIND OF IRREGULARITIES ON THE ROAD SURFACE AND THE TRUCK STARTS SHAKING VIOLENTLY TO THE POINT OF LOSS OF CONTROL UNTIL TRUCK IS ALMOST STOPPED. I'M SURE FORD WILL BLAME THIS ON MY SUSPENSION LIFT / TIRES. ONLY PROBLEM WITH THAT IS ITS HAPPENING TO STOCK TRUCKS AT AN ALARMING RATE FROM WHAT I'VE READ HERE AND ELSEWHERE. THIS WILL CAUSE INJURY OR DEATH IF IT HASN'T ALREADY. FORD KNOWS ABOUT THIS IE THE TIRE PRESSURE LETTER( NOT THE PROBLEM ). THIS MUST BE ADDRESSED NOW. SOON WILL BE TO LATE. THANK YOU FOR YOUR TIME. *TR

WAS DRIVING NORTH ON I-95 ON 31 OCT 2009 WITH A 12' TRAILER FULL OF POTTERY IN TOW SPEED BETWEEN 75 AND 80. JUST COMPLETED TRANSITION FROM BRIDGE BACK TO HIGHWAY WHEN TRUCK BEGAN TO SHAKE VIOLENTLY. INITIAL REACTION WAS A BLOWOUT BUT QUICKLY REALIZED THAT THIS WAS THE SAME PROBLEM MY DAUGHTER INCURRED A WEEK EARLIER. SLOWED TRUCK DOWN AND WORKED WAY ACROSS HIGHWAY TO SHOULDER OF ROAD TO CHECK OUT THE SITUATION. AFTER VERIFYING NO TIRES WERE FLAT AND STEERING WAS ALL IN TACT RESUMED TRIP (VERY CAUTIOUSLY) TO NC. *TR

THE FAILURE OCCURS WHEN YOUR 2006 FORD F250 SUPER DUTY IS MOVING 45-65 MPH AND YOU HIT A BUMP, THE TRUCK STEERING BECOMES OSCILLATING AND YOU CAN EASILY LOOSE CONTROL IF YOU DON'T SLOW DOWN IMMEDIATELY. IT FEELS LIKE THE TIRE IS COMING LOOSE. WE HAVE TALKED TO OUR LOCAL MECHANIC AND HE CURRENTLY HAS TWO OTHER TRUCKS WITH THE SAME PROBLEMS AND IS NOT SURE HOW TO FIX IT. *TR

I LOST CONTROL OF MY FORD F-250 TRUCK GOING DOWN THE ROAD. THE FRONT END STARTED A WOBBLE AND SHAKE. (DEATH WOBBLE) *TR

FRONT END BOUNCES VIOLENTLY IF YOU HIT AS LIGHT BUMP IN THE FREEWAY. *TR

FORD F250 2006 VIOLENTLY SHAKES WHEN IT HITS A BUMP AT 40+ MILES A HOUR. YOU HAVE TO BRAKE LIGHTLY TO GET IT TO STOP. THOSE IN THE TRUCK AND AROUND THE TRUCK ARE AT RISK. *TR

1. I OWN A 2006 FORD F250 SUPER DUTY TRUCK AND WHEN I HIT THE SMALLEST POT HOLE OR BUMP IN THE ROAD MY TUCK SHAKES VIOLENTLY TO THE POINT OF LOSING CONTROL. THE ONLY WAY TO STOP THE VIOLENT SHAKING IS TO COME TO A COMPLETE STOP. THIS HAS HAPPENED TO ME (6) TIMES OVER THE LAST MONTH. I DRIVE 80 MILE ROUND TRIP TO WORK ON THE INTERSTATE EVERY DAY. I AM SCARED TO DRIVE THIS TRUCK ANYMORE IN FEAR OF KILLING MYSELF OR ANOTHER VEHICLE ON THE ROAD WHEN THIS PROBLEM OCCURS. I HAVE DONE A LOT OF RESEARCH ON THE INTERNET AND THIS APPEARS TO BE A VERY WELL KNOW ISSUE. I WILL BE CONTACTING FORD TODAY AND SEE IF THEY HAVE ANY FIXES. BASED ON MY RESEARCH FORD SEEMS TO BLOW OFF THIS ISSUE AND HAS NOT CAME UP WITH A FIX. THIS IS A VERY DANGEROUS PROBLEM AND MAY END UP KILLING SOMEONE BEFORE THEY (FORD) TAKES IS SERIOUSLY.*TR

WHILE DRIVING MY 2006 FORD F250 SUPER DUTY APPROX. 55MPH I HIT A BUMPY PART OF THE ROAD WHICH PUT THE VEHICLE IN AN UNCONTROLLABLE SHAKE. I WAS ABLE TO GET THE TRUCK STOPPED WITHOUT DAMAGE BUT HAD NO CONTROL OVER THE VEHICLE AND COULD ONLY BRAKE. HAD I BEEN IN A CORNER I DON'T THINK THERE IS ANY WAY I COULD HAVE STAYED ON THE ROAD. I CALLED THE FORD DEALER IN DAVENPORT IOWA AND WAS TOLD IT IS CALLED THE DEATH SHAKE AND THERE WAS NO KNOWN CAUSE FOR IT. I WILL GO AHEAD AND TAKE THE VEHICLE IN TO THE DEALER BUT HAVE NO CONFIDENCE IN THEM FIXING ANYTHING. I RECEIVED A LETTER FROM FORD STATING LOW TIRE PRESSURE COULD CAUSE THIS BUT MY TIRES WERE FINE. THERE WAS ALSO A PASSENGER WITH ME WHO HAS VERY SCARED WE WERE GOING TO WRECK. *TR

SEVERE SHAKING AND VIBRATION AFTER HITTING ROUGH PAVEMENT, BRIDGE TRANSITION, POTHOLE. HAVE TO SLOW DOWN TO BELOW 40 MPH TO GET IT TO STOP. ALMOST VIBRATED INTO NEXT LANE HITTING OTHER VEHICLE ON INTERSTATE. VERY DANGEROUS. HAS HAPPENED OVER 25 TIMES IN PAST YEAR OR SO. *TR

FRONT-END SHIMMY AFTER CROSSING UNEVEN OR SLIGHT ROUGH PAVEMENT AT HIGHWAY SPEED. PURCHASED TRUCK WITH 6500 MILES ON THE ODOMETER. AT THIS TIME, SHIMMY SEEMED TO BE INDUCED BY ROUGH PAVEMENT AT SPEEDS FROM 62 TO 75 MPH. RECEIVED A "RECALL" THAT STATED THE PROBLEM WAS WITH TIRE PRESSURE. I CHECKED MY TIRES AND FOUND MY PRESSURE TO BE 65 PSI. AS TRUCK MILEAGE HAS INCREASED, THE SHIMMY NOW STARTS AT 50 MPH ON ROUGHER PAVEMENT. THE FRONT TIRES ARE WORN EXCESSIVELY ON THE OUTSIDE EDGES BUT NOT THE INSIDE EDGES INDICATING THIS IS NOT A PRESSURE PROBLEM. THE SIPES ON THE SIDE OF THE PIRELLI SCORPIONS IS ALMOST GONE INDICATING OVER A QUARTER INCHED DIFFERENCE IN THE INSIDE VERSUS THE OUTSIDE EDGES. THE SHIMMY CAN BE SO BAD THAT MY ARMS HURT AFTER IT OCCURS. I WILL NOT LET MY WIFE DRIVE MY TRUCK AND HAVE LIMITED MY DRIVING TO DECREASE RISK. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED WHEN DRIVING OVER AN UNEVEN ROAD SURFACE AT SPEEDS LESS THAN 70 MPH, THE FRONT END WOULD WOBBLE ABNORMALLY. THE DEALER REPLACED THE TRANSMISSION SHIFT AND INSTALLED A DAMPER ON THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED WITHIN FOUR MONTHS. THE VEHICLE WAS NOT DIAGNOSED OR FURTHER REPAIRED. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 47,000.

WHEN I HIT A BUMP IN THE ROAD MY 2006 F250 4X4 STARTS SHAKING LIKE A TIRE IS FALLING OFF. I REPLACED THE STEERING STABILIZER AND SHOCKS WHICH FIXED IT FOR 20, 000 MILES BUT NOW IT IS BACK TO SHAKING. IT IS TO THE POINT THAT I HAVE TO BORROW MY DADS TRUCK IF I NEED ONE TO HAUL BECAUSE I AM AFRAID THAT MY TRUCK IS GOING TO GO OFF THE ROAD OR IN ANOTHER LANE. IT JUST SITS BECAUSE I DON'T WANT TO KILL MYSELF OR SOMEONE ELSE AND I DON'T WANT TO SELL IT LIKE IT IS. *TR

I OWN A 2006 FORD F250 SUPER DUTY. IT HAS JUST PASSED 16,000 MILES ON IT. WHEN I DRIVE ON A HIGHWAY AND HIT A BUMP OR POTHOLE THE FRONT END OF THE VEHICLE BEGINS TO SHAKE VIOLENTLY. IT RADIATES THROUGH THE WHOLE VEHICLE AND IT BECOMES VERY HARD TO CONTROL AND YOUR ONLY OPTION IS TO SLOW DOWN AND WAIT FOR IT TO PASS. I WILL NO LONGER ALLOW MY CHILDREN TO RIDE IN MY TRUCK AS I FEEL IT IS VERY UNSAFE. THIS HAS HAPPENED ON SEVERAL OCCASIONS AND APPEARS TO BE GETTING WORSE. FORD SENT OUT A BULLETIN TO OWNERS OF THESE VEHICLES THAT WE MUST CHANGE OUR TIRE PRESSURE TO 65 PSI, BUT THIS STILL DOES NOT RESOLVE THE PROBLEM. *TR

HELLO; I HAVE A 2006 FORD SUPER DUTY 4X4 DIESEL. I HAVE LOW MILES 23,000 AND NO MODIFICATIONS TO TRUCK. I HAVE HAD A FEW TIMES WHERE THE FRONT END WILL SHAKE AFTER HITTING A POT HOLE OR BRIDGE BUMP. IT NOW DID THIS AGAIN ON 9/2/2009 AND WAS VIOLENT AND DANGEROUS, ALMOST LOST CONTROL. I HAVE SEARCHED THE INTERNET THIS MORNING AND ITS CALLED THE 'DEATH WOBBLE' AND SEEMS ALOT OF FORD SUPER DUTY'S ARE EXPERIENCING THIS PROBLEM. PLEASE ADVISE ME WHAT STEPS TO TAKE AS I AM EXTREMELY CONCERNED. THANKS *TR

HIGH SPEED WOBBLE. *TR

DRIVING ALONG AT ABOUT 45 MPH, HIT A ROUGH PATCH OF PAVEMENT AND THE FRONT END OF THE TRUCK BEGAN TO BOUNCE AND THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH, ALTHOUGH THE TRUCK DID NOT GO LEFT OR RIGHT FROM THE LINE OF TRAVEL. AFTER SLOWING DOWN THE TRUCK CAME BACK UNDER MY CONTROL, BOUNCE AND OSCILLATION STOPPED. THIS HAS HAPPENED NUMEROUS TIMES (WEEKLY), WITH THE ORIGINAL TIRES AND WITH REPLACEMENT TIRES. I HAVE HAD THE FRONT END ALIGNED AND TIRES BALANCED. I CHECK THE AIR PRESSURE WEEKLY. ALL OF THIS HAD NO AFFECT ON THE OSCILLATIONS. I WOULD DRIVE OVER THE SAME AREAS DAILY ANDCOULD CONTINUE TO REPEAT WHAT HAD HAPPENED BY DRIVING THE SAME SPEED OVER THE SAME PIECE OF BAD PAVEMENT. IT IS NO WORSE OR BETTER THAN WHEN IT FIRST HAPPENED. BUT HAVING MY WIFE DRIVE THE TRUCK AND HAVE THE SAME ISSUE CONCERNED ME. I DID RESEARCH THAT LED ME TO FIND OUT THAT THIS IS A PROBLEM AFFECTS NUMEROUS F-250S AND TO YOUR WEBSITE. I WISH I HAD COMPLAINED ABOUT THIS WHEN IT BEGAN, BUT MY TRUCK WAS OUT OF WARRANTY AND I THOUGHT I WAS OUT OF LUCK (STILL MAY BE). *TR

ON 8/3/2009 AT 1730 AND 2045 HOURS I WAS DRIVING MY 2006 F250 SUPERDUTY 4X4 ON I-10 EASTBOUND AND DROVE OVER A BRIDGE/CULVERT SEAM IN THE ROADWAY. THE LEFT FRONT WHEEL AND STEERING WHEEL SHOOK VIOLENTLY AND WOULD NOT STOP SHAKING UNTIL MY SPEED SLOWED FROM 70 TO 25 MPH. IT WAS NEARLY IMPOSSIBLE TO BRAKE WITH CONSTANT PRESSURE. I HAD TO FEATHER THE BRAKE TO SLOW THE VEHICLE. I INSPECTED THE VEHICLE TO THE BEST OF MY ABILITY AND SAW NOTHING OBVIOUSLY WRONG. THE SECOND INCIDENT OCCURRED IN THE RAIN IN THE DARK AT 70 MPH. MY WIFE WAS DRIVING AND WAS SCARED TO DEATH. BOTH INCIDENTS NEARLY CAUSED ACCIDENTS WITH VEHICLES BEHIND US. I INJURED MY LEFT SHOULDER ON THE FIRST ONE THAT'S WHY MY WIFE DROVE BACK. I RETURNED HOME AT 65-70 MPH AND HAD NO FURTHER INCIDENTS. I CHECKED THE TIRE PRESSURE ON THE 31 INCH BFG'S AND IT WAS ACCURATE AND WITHIN THEIR SPECS. *TR

OVER THE PAST 9 MONTHS I HAVE NOTICED A FRONT END/STEERING WHEEL VIBRATION AT HIGHWAY SPEEDS IN MY 2006 FORD F250. AT FIRST, THE VIBRATION WOULD GO AWAY IF I ACCELERATED THROUGH IT OR SLOWED DOWN. IT HAS WORSENED TO THE POINT WHERE IT HAS CAUSED ME TO PARTIALLY LOSE CONTROL OF THE TRUCK. I FIRST BOUGHT FOUR NEW TIRES. I THEN HAD THE LARGE RETAIL CHAIN WHERE I PURCHASED THE NEW TIRES ROTATE AND BALANCE THE THEM MULTIPLE TIMES WITH NO IMPROVEMENT. THEY SUGGESTED TAKING THE TRUCK TO THE DEALERSHIP TO HAVE IT CHECKED. I HAVE SINCE HAD THE TRUCK INTO THE DEALERSHIP MULTIPLE TIMES (BALANCING AND ROTATING, STEERING DAMPENER, AND CARRIER BEARING). *TR

SEVERE SHAKING OF THE FRONT END OCCURRED 3-4 TIMES AT HIGHWAY SPEEDS (70 MPH) AFTER HITTING A ROUGH SPOT IN THE ROAD. THIS CONDITION WAS SO SEVERE AND FRIGHTENING THAT I HAD TO HOLD THE TRUCK STRAIGHT AND COME TO AN ALMOST COMPLETE STOP. THE FIRST TIME IT HAPPENED I GOT OUT TO CHANGE THE TIRE AND DISCOVERED THAT NONE WERE FLAT. I THEN REMEMBERED THAT FORD HAD SENT ME A LETTER DESCRIBING A PROBLEM WITH "SHIMMY", A SEVERE VIBRATION AND OSCILLATION IN THE STEERING WHEEL. THEY THEN BLAMED IT ON PRESSURE. I DON'T RECALL THE PRESSURE IN MY TIRES AT THE TIME BUT I BELIEVE THEY WERE NOT TOO LOW. I HAVE MY TRUCKED SERVICED REGULARLY AT THE FORD DEALERSHIP. MY TIRES WERE WORN (OVER 50000) BUT STILL HAD A LITTLE TREAD LEFT. BTW- I BOUGHT THE TRUCK NEW WITH THESE SAME TIRES. I HAVE NOT MODIFIED MY TRUCK. I DO NOT BELIEVE IN "LIFTING" A 4WD VEHICLE. I DO HAVE A CAMPER ON MY TRUCK BUT IT ONLY WEIGHS 1300 LBS. MY TRUCK IS AN 2006 F-250 WITH A CAMPER SUSPENSION (I BELIEVE THIS IS AN EXTRA 300 LB. RATING) WHICH SHOULD EASILY ACCOMMODATE THIS WEIGHT. I BELIEVE AT THE TIME THE DEALERSHIP BLAMED IT ON THE TIRES (WORN AND UNDER-INFLATED). I HAD THEM PUT NEW TIRES ON (SAME EXACT KIND). AND DO A GOOD BALANCE JOB. NORMALLY I WOULD NOT HAVE BOUGHT TIRES AT THE DEALERSHIP. THIS FIXED THE PROBLEM. I STILL HAD THIS ISSUE IN THE BACK OF MY MIND AND WANTED TO RESOLVE IT. I WOULD NOT WANT TO SELL A VEHICLE WITH THIS CONDITION. I JUST GOT BACK FROM A 2 WEEK TRIP TO MONTANA AND HAD THE ISSUE COME BACK (I NOW HAVE 95000 ON MY TRUCK (40000) ON THIS SECOND SET OF TIRES. IT HAPPENED TWICE IN UTAH COMING DOWN STEEP HILLS WITHIN MILES OF EACH OTHER. THIS TIME IT SEEMED TO BE A RESULT OF HEAVY BRAKING AND WAS NOT AS SEVERE, AS I DIDN'T HAVE TO COME TO A COMPLETE STOP. I PUT AIR IN THE TIRES PRIOR TO THE TRIP. RIGHT NOW I JUST MEASURED THE PRESSURE @ 70 PSI ON BOTH FRONT TIRES (SPEC SAYS 80) AND MEASURED .185 INCHES OF TREAD LEFT.THIS CONDITION SHOULD NOT OCCUR EVEN IF THE TIRES ARE WORN.I NEED THIS FIXED. *TR

WHILE DRIVING A 2006 F250 SUPER DUTY XL 4X4 ON I-40 THE VEHICLE BEGAN TO SHAKE VIOLENTLY AT 70 MPH. THIS OCCURRED AFTER DRIVING OVER A BRIDGE. THE VEHICLE SHOOK SO VIOLENTLY IT WAS HARD TO MAINTAIN CONTROL AND BRING IT TO A STOP. AFTER THIS INCIDENT IT ALSO OCCURRED THROUGHOUT THE REMAINDER OF THE TRIP. APPARENTLY THIS HAS HAPPENED TO OTHER DRIVERS OF THIS VEHICLE SINCE IT IS A COMPANY OWNED VEHICLE. AND SEVERAL DEALERS HAVE ATTEMPTED TO REPAIR THIS PROBLEM TO NO AVAIL. *TR

I DRIVE A 2006 F250 AND IT HAS BEEN EXPERIENCING VIOLET FRONT END VIBRATIONS. THIS OCCURS AT VARIOUS SPEEDS AND I HAVE TO SLOW DOWN OR STOP TO GET IT TO RETURN TO NORMAL. IT ALMOST CAUSED AN ACCIDENT THE OTHER DAY WHEN I HAD TO SLOW DOWN TO 10 MILES PER HOUR ON THE FREEWAY TO GET IT TO STOP. FORD CLAIMS IT IS TIRE PRESSURE BUT HAD TIRES ROTATED AND BALANCED TWO DAYS PRIOR. THIS APPEARS TO BE A MAJOR DESIGN ISSUE AND A VERY DANGEROUS ONE. *TR

EXTREME SHAKING AND NEAR LOSS OF CONTROL AFTER CROSSING OVER A MINIMAL BUMP AT SPEEDS ABOVE 55 MPH. HAPPENED 9 TIMES WITHIN THE LAST TWO YEARS. ONLY WAY TO END SHAKING WAS TO LEAVE THE ROADWAY AND SLAM ON THE BRAKE. *TR

FRONT BRAKES SEIZED UP WHEN DRIVING DOWN ROAD JUST AS WARRANTY WAS TO EXPIRE. CONTACTED DEALER AFTER THIS HAD HAPPENED 4-5 TIMES. DEALER REPLACED FRONT CALIPERS BUT WAS OUT OF WARRANTY. 4 MONTHS LATER HAD TO REPLACE BOTH REAR CALIPERS FOR SEIZURE PROBLEM. FORD DEALER WOULD NOT PROVIDE ANY COMPENSATION. NOW 2 MONTHS LATER, CHECK BRAKE LIGHT IS ON. *TR

I HAVE ON SEVERAL OCCASIONS HAD MY F250 SUPER DUTY 6.0 DIESEL SHIMMY VERY VIOLENTLY. THESE OCCURRENCES HAPPENED AT SPEEDS OF 50 TO 65 MPH. ON ONE OCCASION ON THE INTERSTATE I ACTUALLY PULLED OVER THINKING I HAD A BLOWOUT. NOW AT 75000 MILES, IT IS STARTING TO SHIMMY ON ROUGH PAVEMENT EVEN AT SLOWER SPEEDS OF 35 TO 45 MPH. *TR

SEVERE FRONT END SHIMMY WHEN HITTING POTHOLE OR ROUGH ROAD SURFACE. ESPECIALLY AT HIGHWAY SPEEDS AND GOING OVER INTERSTATE BRIDGES. HAVE COME VERY CLOSE TO HITTING OTHER VEHICLES WHEN THIS HAPPENS. HAS HAPPENED OVER 20 TIMES. FORD DEALER SAID TO CHECK TIRE PRESSURE. THAT DID NOT HELP. ALSO SAID TO SLOWLY APPLY PRESSURE TO BRAKES AND SLOW DOWN. *TR

WITH ONLY 35,000 MILES ON IT, MY 2006 F-250 SD DIESEL TRUCK HAS DEVELOPED A FRIGHTENING BOUNCING IN THE FRONT END. ONCE IT HAPPENED GOING 65 MPH WHEN I HIT A FREEWAY POT HOLE. THE FRONT TIRE BOUNCED UP AND DOWN SO SEVERELY, THAT I PULLED OFF ONTO THE SHOULDER TO SEE IF SOMETHING HAD COME UNBOLTED. I HAVE EXPERIENCED THE SAME BOUNCING AT 40 AND 50 MPH FROM HITTING POT HOLES. FORD EVEN SENT ME AN ADVISORY ON THIS PROBLEM, CLAIMING THAT IT WAS RELATED TO INCORRECT TIRE PRESSURE. I HAVE BEEN FANATIC ABOUT TIRE PRESSURE, SO THAT WAS NOT INVOLVED. THE DEALER FOUND NOTHING WRONG WITH THE TRUCK AND CLAIMED THAT A $375 STEERING STABILIZER KIT WOULD CORRECT THE PROBLEM. WHY SHOULD I PAY FOR CORRECTING FORD'S DESIGN PROBLEMS? I AM JUST CONCERNED THAT THE BOUNCING COULD CAUSE ME TO LOSE CONTROL OF THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE BEGAN SHAKING VIOLENTLY AFTER DRIVING OVER A BUMP IN THE ROAD. THE CONTACT MENTIONED THE VEHICLE VEERED INTO ANOTHER LANE. THE VEHICLE WAS TAKEN TO A MECHANIC, AND THERE WAS NO DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000, AND THE CURRENT MILEAGE WAS 120,000.

ANY TIME I GET ON THE INTERSTATE PULLING MY 7000 GVW TRAILER, THE CHECK ENGINE LIGHT COMES ON. THE CODE IS ALWAYS THE SAME, UNDER/OVER BOOST AND THEN YOU LIMP ALONG FOR A FEW MILES AND IT WILL START WORKING AGAIN. DURING THIS TIME IT'S HARD TO MAINTAIN A CONSTANT SPEED. THE CHECK ENGINE LIGHT WILL COME ON WITHIN 10-15 MILES OF HIGHWAY USE AT AROUND 60 - 65 MPH. EVERY OWNER THAT I TALK TO THAT HAS THE 6.0 LITRE DIESEL TELLS ME THAT THEY ALL DO THIS AND THE ONLY WAY TO FIX IT IS TO INSTALL A EGR DELETE KIT AT AROUND $1,200.00. THIS WILL CURE THE PROBLEM BUT WILL POLLUTE THE AIR MORE. IT'S JUST A BAD DESIGN AND FORD'S NOT GOING TO DO ANYTHING ABOUT IT UNLESS THE NHTSA STEPS IN. *TR

LIKE TOYOTA CARS, IF "WINTER-STYLED, RUBBER FLOOR MAT ON DRIVERS SIDE BECOMES UNHOOKED & SLIDES FORWARD, IT CAN LODGE THE ACCELERATOR DOWN CAUSING A HIGH SPEED. IT HAS HAPPENED TO ME SEVERAL TIMES, ALMOST CAUSING ME TO LOOSE CONTROL. THESE ARE FORD FACTORY INSTALLED MATS I PAID EXTRA FOR AT TIME VEHICLE WAS PURCHASED NEW. OCCURS WHEN I ACCELERATED HARD, SUCH AS TO PASS ANOTHER CAR OR ENTER/MERGE ONTO AN INTERSTATE. HAD TO PUT CAR IN NEUTRAL AND PULL MAT BACK. HAS HAPPENED SEVERAL TIMES SINCE VEHICLE WAS PURCHASED.

2006 FORD F250 HAS A STEERING PROBLEM. *NJ THE CONSUMER WAS TOWING A CAMPER. THE CONSUMER STATED WHILE DRIVING, THEY HIT A ROUGH SPOT IN THE ROAD AND THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONSUMERS HUSBAND IMMEDIATELY LET OFF THE GAS AND MERGED INTO THE SLOW LANE. A BOLT, BRACKET AND E-DAMPER ASSEMBLY WERE REPLACED. THE CONSUMER RECEIVED A LETTER FROM FORD STATING THAT SOME F-250 TRUCKS DID HAVE A VIBRATION/SHAKING IN THE STEERING. *JB *JB

I OWN A 06 F250 SD, AND EVERYTIME I HIT A SMALL BUMP IN THE ROAD WHEN DOING 65+ SPEED I GET EXTREME SHAKING. I GOT A LETTER FROM FORD RECENTLY ABOUT THE SHIMMY THING, AND I TRIED WHAT THEY SAID AND ADJUSTED THE TIRE PRESSURE BUT I FOUND THIS DOES NOT WORK I STILL GET IT. IT SAID IN THE LETTER THAT YOU ALL APPROVED THIS BUT I DON'T SEE HOW YOU COULD LET SUCH AND UNSAFE THING STILL BE ON THE ROADS. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE WOULD SHIMMY WHEN IT DROVE OVER A BUMP IN THE ROAD. THE DEALER COULD NOT PROVIDE A REMEDY; THEREFORE, THE VEHICLE COULD NOT BE REPAIRED. THE CONTACT FEELS THAT A CRASH COULD OCCUR ONE DAY. THE CURRENT MILEAGE WAS 74,000 AND FAILURE MILEAGE WAS 32,000.

I OWN A 2006 FORD F-250 EXT CAB TRUCK AND I AM EXPERIENCING A HYPER-SHAKE IN THE FRONT END AFTER HITTING UN EVEN SURFACES. THE HYPER-SHAKE MAINLY HAPPENS WHEN GOING SPEEDS OVER 50 MPH. I LIVE ON A DIRT RODE WITH LOTS OF POT HOLES AND EVEN WHEN DRIVING SLOW THE FRONT END BOUNCES ALL OVER THE RODE.I BROUGHT THE TRUCK TO A FORD DEALER AND THEY FOUND AND REPLACED THE STEERING STABILIZER. IT HAD A SLIGHT BEND IN IT. IT HELPED A LITTLE BUT TRUCK STILL SHAKING WHEN HITTING ANY BUMPS. THE SHAKE IS VERY DANGEROUS ESPECIALLY ON THE HIGHWAY. WHILE EXPERIENCING THE HYPER-SHAKE YOUR BRAKES DO NOT SLOW IT DOWN QUICK ENOUGH AND I VEERED INTO ANOTHER LANE WHILE GOING 65MPH. *TR

FRONT WHEEL BEARING ASSEMBLY ON FORD 2006 F-250 SD. IT HAS BEEN REPLACED THREE TIME IN THE LAST YEAR. TOTAL REPLACE OF ASSEMBLY COST @$1000.00. *TR

COMPLETE ENGINE FAILURE IN ONE DAY ON FORD F250 5.4 GAS ENGINE WITH 43,000 MILES. *TR

MY 2006 FORD F250SD GOES INTO A VIOLENT SHAKE WHEN YOU HIT A BUMP WHEN TRAVELING AT SPEEDS OF 60 MPH. IT FEELS LIKE THE FRONT END IS GOING TO FALL OFF. *TR

2006 FORD F250 SUPER DUTY, DIESEL, 6.0 L, 4X4, CREW CAB, SHORT BED: TOTAL LOSS OF THROTTLE RESPONSE WHILE DRIVING. THE ENGINE RUNS, BUT THE TRUCK COMPLETELY STOPS AND WILL NOT MOVE WHEN THE ACCELERATOR IS PRESSED. THERE IS NO ADVANCE WARNING. IT JUST STOPS MOVING RIGHT WHERE IT IS. THIS HAS HAPPENED FIVE TIMES NOW WITHIN TWO MONTHS AND 2500 MILES DRIVING. THE EGR VALVE HAS BEEN REPLACED SEVERAL TIMES OR CLEANED THE OTHER TIMES, BUT THE VEHICLE IS UNSAFE ON THE ROAD BECAUSE IT STOPS SUDDENLY RIGHT IN THE MIDDLE OF THE TRAFFIC LANE. *TR

MY 2006 FORD F250 4WD SUPERDUTY PICKUP SHAKES VIOLENTLY WHENEVER I HIT THE SMALLEST POTHOLE OR DRIVE OVER RAILROAD TRACKS. IT IS A DANGER TO MYSELF, MY CHILDREN AND ANYONE DRIVING AROUND ME ON THE ROAD. TOOK THE TRUCK TO MY DEALER AND ALMOST GOT THROWN OUT AFTER GETTING INTO AN ARGUMENT WITH BOTH THE MECHANIC AND SVC MANAGER WHO SAID THERE WAS NOTHING WRONG WITH THE TRUCK, THEY NEVER HEARD OF THIS PROBLEM AND I NEED TO BUY NEW TIRES. TIRES ARE BRAND NEW WITH LESS THAN 20K ON THEM. *TR

2006 F250 CREW 4X4 XL - AROUND 50 MPH THE FRONT END SHAKES ME OFF OF THE ROAD - EITHER HAVE TO ACCELERATE THROUGH 50 OR HIT THE BRAKES - FRONT END IS TIGHT AND RIMS AND TIRES GOOD. *TR

FORD F-250 SD, 5.4L ENGINE. REPEATED OCCURRENCES OF ABS LIGHT ACTIVATION AFTER ONE TO ONE-AND-A-HALF HOURS AT CRUISING SPEEDS BETWEEN 55 AND 70 MPH. IF CRUISE CONTROL IS ACTIVE WHEN ABS LIGHT ACTIVATES, CRUISE CONTROL IS DISABLED. ON SEVERAL OCCASIONS, THE SPEEDOMETER NEEDLE GYRATED ERRATICALLY FOR A FEW SECONDS ALSO. AFTER THE ABS LIGHT IS ACTIVATED, IT STAYS ON. FREQUENTLY, IT COMES BACK ON IMMEDIATELY, SOMETIMES THROUGH SEVERAL RESTARTS OF THE TRUCK. THAT IS, SOMETIMES THE ABS LIGHT COMES BACK ON IMMEDIATELY WHEN THE TRUCK IS RE-STARTED. BRAKING SEEMS UNAFFECTED. *TR

2006 F250 FRONT END SHIMMY, WOBBLE. TOOK TO DEALER FOR FRONT END CHECKUP AFTER LETTER FROM FORD. THEY SAID THEY AIRED UP THE TIRES AND IT WAS GOOD TO GO...? I WENT 5 MI DOWN THE ROAD AND SAME ISSUE HAPPENED AGAIN. HIT BUMP IN ROAD AND THEN ANOTHER THE TRUCK STEERING WAS OUT OF CONTROL. I ALMOST HIT ANOTHER CAR TRAVELING NEXT TO ME GOING DOWN THE HIGHWAY. SCARED TO DEATH.. I JUST PURCHASED THIS TRUCK IN FEB 2009 AS A FORD CERTIFIED TRUCK. I WANT TO GET RID OF THIS TRUCK. I BELIEVE IT IS A LEMON. DEALERSHIP JUST SAID TIRES WERE UNDER INFLATED, AT 65LB AND AIRED TO 70PSI?? DID NOT SOLVE PROBLEM. THIS TRUCK WAS TO PICK UP MY KIDS FROM SCHOOL, AND NOW I DON'T WANT TO DRIVE THEM IN IT AND I FEEL IT IS NOT SAFE. I WORK FOR FORD AND AM FEELING VERY DISCOURAGED AND THE HELP I AM RECEIVING? WHAT NOW, DO I KEEP TAKING BACK? *TR

I HAVE A 2006 F250 SUPERDUTY THAT HAS NUMEROUS ISSUES. LATEST IS WHEEL SHAKE AFTER HITTING A BUMP, POWER STEERING BOX HAS OVER 3" OF STEERING WHEEL PLAY, AND BALL JOINT JUST HAD TO BE REPLACED. NOT TO MENTION DIESEL ENGINE ISSUES AND EXCESSIVE AIR NOISE. I AM BEING TOLD THIS IS COMMON PROBLEMS IN FORD DIESELS DO TO ENGINE WEIGHT. *TR

MY F-250 SUPER DUTY, HAS A SEVERE FRONT END SHIMMY AT HIGHWAY SPEED. MY WIFE AND I COULD HAVE DIED IN ONE INSTANCE,WE HAD TO MOVE ACROSS TWO LANES TO THE SHOULDER AS THE TRUCK BOUNCED UNCONTROLLABLY. I THOUGHT THE TIE RODS WERE GOING TO SNAP . THIS DID NOT HAPPEN JUST ONCE, BUT NUMEROUS TIMES. EVERY TIME I APPROACH A BRIDGE DECK, BUMP OR POT HOLE I'M AFRAID THE TUCK MAY HAVE A UNCONTROLLABLE SHIMMY AND LOSING CONTROL! YOU NEVER KNOW IF THE TRUCK WILL HAVE A SLIGHT,OR SEVERE SHIMMY,SOMETIMES THERE IS NO SHIMMY AT ALL. THIS IS A PROBLEM THAT HAS TO BE RECTIFIED!!! JUST SO YOU ARE MADE AWARE MY TIRES ARE FINE AS IS MY SPEED. *TR

WHEN DRIVING WHEN YOU GO OVER A BUMP ,RXR CROSSING OR MAN HOLE COVER THE FRONT END OF THE VEHICLE SEVERELY SHAKES TO THE POINT YOU HAVE TO JAM ON THE BRAKES OR WRECK. I REPLACED THE STEERING STABILIZER AS INSTRUCTED TO BUT THE OUTCOME HAS NOT CHANGED. I HAVE CALLED FORD NUMEROUS TIMES,BOTH THE DEALER AND FORD MANUFACTURER. THEY BOTH ACT LIKE THEY HAVE NEVER HEARD OF THIS SEVERE PROBLEM. *TR

I OWN A 2006 FORD F250. IT SHAKES VIOLENTLY WHEN I HIT A POTHOLE OR GO OVER A BRIDGE. TRUCK ONLY HAS 60,000 MILES ON IT. MY LIFE IS IN DANGER. FORD NEEDS TO TAKE CARE OF THIS PROBLEM. *TR

FORD 250 SWB 4X4 2006, WHEN CROSSING BRIDGES, HITTING BUMPS IN THE ROAD OR HITTING POT HOLES, THE TRUCKS FRONT END WILL GO INTO A VIOLENT SHIMMY AND SHAKE EPISODE, THE ONLY WAY TO CORRECT IT IS TO SLOW DOWN - THIS CAN BE VERY DANGEROUS ON INTERSTATE OR HIGH SPEED ROADWAYS. FRONT END ALIGNMENTS, TIRE BALANCING, NEW TIRES AND STEERING STABILIZERS HAVE BEEN INSTALLED.NOTHING STOPS THIS FRONT OF FROM VIOLENTLY SHAKING. FORD DEALERSHIPS HAVE BEEN NO HELP. THIS IS A VERY DANGEROUS PROBLEM IN WHICH FORD PROBABLY NEEDS TO RE-ENGINEER THE FRONT END. PLEASE HELP PUT SOME PRESSURE ON FORD TO MAKE A RECALL ON THESE FRONT ENDS. *TR

TL * THE CONTACT OWNS A 2006 FORD F250. THE CONTACT STATED THAT WHILE TRAVELING AT SPEEDS OF 40 MPH IN CLEAR WEATHER CONDITIONS, THE ENTIRE FRONT END OF THE VEHICLE WOULD SHAKE EXCESSIVELY. HE ATTEMPTED TO SHUT OFF AND RESTART THE ENGINE TO CORRECT THE FAILURE TO NO AVAIL. THE FAILURE WOULD OCCUR SEVERAL TIMES WHILE OPERATING THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED TAKING THE VEHICLE TO THE DEALER FOR FURTHER INSPECTION. THERE HAD BEEN NO REPAIRS TO THE VEHICLE AS OF YET. THE FAILURE MILEAGE WAS 18,000 AND THE CURRENT MILEAGE WAS 28,000.

FRONT END WOBBLE AND SHIMMY, REALLY SCARY. *TR