There are 3 stored owner reports matching the fuel system leading-label group for the 2009 Ford F-250 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 3 of 3 matching reports.
Open the full vehicle complaint log (all categories)The contact owns a 2009 Ford F-250. The contact stated while driving 55 MPH, the vehicle lost motive power. The contact stated that the cruise control was inoperable. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The dealer changed the filters and sensors. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, where it was diagnosed that the fuel pump needed to be replaced. The contact stated that the fuel tank was contaminated. The vehicle was repaired. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 128,484.
CHECK ENGINE LIGHT CAME ON - THOUGHT IT WAS BAD SEALING GAS CAP. IT WASN'T. TOOK TO FORD DEALER AND THEY ENDED UP REPLACING FUEL CARBON FILTER AT FUEL FILL AREA - SAID IT WAS FOULED WITH GASOLINE. THEY DON'T KNOW HOW IT COULD HAPPEN AND IT PROBABLY WOULD NOT HAPPEN AGAIN. THIS WAS A NO CHARGE, UNDER WARRANTY FIX. *TR
WHILE DRIVING WITH FUEL LEVEL BETWEEN 1/8 AND 1/4 TANK, TRUCK SHUT DOWN COMPLETELY. THE "50 MILES TO EMPTY" INDICATOR HAD ILLUMINATED APPROX. 2 MILES BEFORE FAILURE. HAD TRUCK TOWED TO DEALER AND WAS FORCED TO PAY APPROX. $250 FOR DIAGNOSTIC AND TOW. DEALER COORDINATED WITH FORD CORPORATE AND DETERMINED I DROVE TRUCK UNTIL FUEL WAS EMPTY. APPROX. 4 WEEKS LATER, TRUCK SHUT DOWN AGAIN. DEALER EXPLAINED I WOULD HAVE TO "PLACE A BET" THAT THE FUEL INDICATOR SENSOR WAS "OUT OF TOLERANCE." THEY WOULD HAVE TO REMOVE FUEL TANK AND CHECK SENSOR. PER TECH, IF SENSOR WAS WITHIN TOLERANCE, I WOULD HAVE TO PAY THE ENTIRE BILL. I TOLD THEM TO GO AHEAD AND PERFORM THE CHECK. SENSOR WAS IN FACT OUT OF TOLERANCE AND WAS INDICATING MORE FUEL THAN WAS ACTUALLY IN THE TANK. SENSOR WAS REPLACED AND THE DEALER, NOT FORD, REFUNDED THE ORIGINAL AMOUNT OF REPAIR. LAST FORD I WILL PURCHASE. GM/CHEVY WILL BE MY NEXT DIESEL PURCHASE. *TR
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Sep 3, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.