2003 Ford F-350 Complaint Log

When the 03 Ford F350 dually, is placed in Park, it will just roll away!

I was under the truck working on it and the truck was on I had the emergency brake on and the truck went into reverse and ran me over

The wires for the camshaft position sensor are failing just like they have in others models of the f series and cause the truck to suddenly die while driving. There was already a recall in place but it doesn't cover this vin and so I would like to request the recall be extended to this trucks vin

JUST DRIVING ON HIGHWAY 41 AND IT JUST STOPPED. ENGINE WENT DEAD. PULLED OVER TO SIDE OF ROAD AND TRIED STARTING AGAIN AND IT WOULDNT START. HAD TO GET IT TOWED. ITS BEEN IN SHOP FOR 20 DAYS. NEEDS A NEW FUEL TANK BECAUSE THE INNER LINING IS PEELING AND PARTICLES ARE GOING THROUGH ENGINE! NEED HELP I PURCHASED THIS TRUCK IN 2015 AND ITS BEEN IN SHOP 7 DIFFERENT TIMES.

I AM INTERESTED IN THE HISTORY OF BF GOODRICH RUGGED TERRAIN T/A TIRES MADE IN 2014. I BOUGHT A SET OF FOUR LT 265/75-16 LRE FOR MY F350 ON 31 MAY, 2014. THEY CAME WITH A 6 YEAR/50K MILE WARRANTY. I HAD TIRES ROTATED PER WARRANTY. ON 11 APRIL, 2019, I EXPERIENCED A DRIVERS REAR TIRE FAILURE ON THE FLORIDA TURNPIKE (WITH CRUISE CONTROL SET @ 77MPH) CAUSING MINOR DAMAGE. CONTACTED DEALER WHO SAID "ROAD HAZARD" NOT COVERED. CONTACTED BFG WHO REQUESTED TIRE REMAINS BE SENT FOR ANALYSIS (TO PROVE ROAD HAZARD). ON 10 MAY DEPARTED FROM HOME TO GO TO VIRGINIA. 150 MILES UP I75 HAD TIRE VIBRATION AGAIN. PULLED OVER IN TIFTON, GA AND CHECKED TIRE TIME WITH IR GUN. ALL TIRES RUNNING BETWEEN 95-108 F. FELT TIRES AND HAD A BULGE IN DRIVERS FRONT. INSTALLED SPARE AND STARTED LOOKING FOR A BFG DEALER THAT HAD TWO TIRES IN INVENTORY (ONE TO INSTALL/ONE TO CARRY IN CASE OF FURTHER TROUBLE WITH SET). AS I APPROACHED MACON, GA, ANOTHER TIRE STARTED VIBRATING. WITHIN 5 MILES - IT BLEW HARD AT THE DRIVERS REAR POSITION AGAIN CAUSING OVER $3200 DAMAGE. CALLED EMERGENCY TIRE SERVICE AND REPLACED THE THREE REMAINING TIRES FROM THE 2014 SET. NOTIFIED BFG AND THEY ONLY WANTED THE THIRD FAILURE (SECOND BLOW) FOR ANALYSIS. CUSTOMER SERVICE REP STATED ALL TIRE BULGES ARE CAUSED BY "ROAD HAZARDS". IN SUMMARY - I EXPERIENCED THREE FAILURES IN JUST OVER 800 MILES ON A SET OF TIRES THAT ONLY HAVE 17,000 MILES ON THEM (REMAINING TREAD IS 11/32 PER DEALER INSPECTION). SINCE I STILL HAVE ALL OF THE TIRES - PHOTOS AVAILABLE UPON REQUEST. FIRST TIRE DID SHOW ONE SECTION 7 INCHES LONG WITH FOUR RADIAL SPLITS STARTING AT THE RIM. SECOND TIRE HAS NUMEROUS RADIAL SPLITS BUT NONE ARE CLOSELY CLUSTERED. IS MY EXPERIENCE UNIQUE TO MY SET OF CONDITIONS OR ARE THERE OTHER SIMILAR OCCURRENCES. THANK YOU FOR ANY HELP OR INSIGHT YOU CAN PROVIDE (XXXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

WHILE PREPARING FOR A CAMPING TRIP THIS PASS SUMMER, I WENT TO CHECK THE OIL LEVEL. WHEN I WENT TO REMOVE THE OIL DIPSTICK, THE DIPSTICK TUBE BROKE, DUE TO CORROSION. THIS IS THE FIRST TIME IN MY 25 YEARS OF OWNING A VEHICLE FOR THAT TO HAPPEN. IT WOULD BE ALRIGHT, BUT IN ORDER TO REPLACE THE TUBE, IT IS REQUIRED TO REMOVE THE EXHAUST MANIFOLD TO PROPERLY REPLACE IT. IN TURN IT COST MORE MONEY TO REPLACE A PRODUCT THAT SHOULD NOT BREAK. I WAS FUELING MY TRUCK AND WANTED TO CHECK ALL MY FLUIDS.

MY DOME AND RUNNING BOARD LIGHTS ON MY 2003 FORD F350 SUPER DUTY, 4 DOOR TRUCK, STAY ON WHEN I AM DRIVING AND WHEN THE VEHICLE IS TURNED OFF AND LOCKED. ALSO WHILE DRIVING, THE DASH VEHICLE LIGHT IS RED SHOWING THAT ALL 4 DOORS ARE OPEN. ICAN BE PARKED OR MOVING, THE LIGHTS STAY ON. BOTH MY BATTERIES DRAIN. SO I HAV TO CARRY JUMPER CABLES.

AS I AM SURE YOU MUST BE AWARE OF THIS ISSUE: I PURCHASED USED A 2003 FORD -F350. I HAD MANY ISSUES AND HAD WORKED MOST OF THEM OUT. THERE WERE MANY ISSUES THAT WERE POSSIBLE I WAS CLEARLY UNAWARE OF. ONE BEING OF UTMOST SAFETY TO MYSELF AND OTHERS. MY HIGH PRESSURE OIL PUMP LOCATED INSIDE THE ENGINE OF MY 2003 FORD F-350 6.0 DIESEL FAILED. WHEN THAT HAPPENS THE ENGINE STOPS. THE HIGH PRESSURE OIL PUMP PROVIDES NEEDED PRESSURE TO THE INJECTORS IN ORDER TO HAVE A RUNNING ENGINE. BEING PARKED AND THE HPOP FAILING IS ONE THING HOWEVER DRIVING 55MPH ON A 2 LANE HIGHWAY AGAINST ONCOMING TRAFFIC ON A TURN IS A VERY BAD SITUATION. I AM FORTUNATE THAT I AM STILL VERY STRONG AT THE AGE OF 54. MY HPOP FAILED GOING 55MPH ON A LONG LEFT HAND TURN. AS THE ENGINE SHUTS DOWN BY BRAKES ARE LIMITED TO A SMALL AMOUNT OF STORAGE AND THEN THEY FAIL. THE STEERING HOWEVER FAILS IMMEDIATELY. I WAS HEADING STRAIT HEAD ON I TO A TRACKTOR TRAILER RIG. IT TOOK EVERY OUNCE OF STRENGTH TO ATTEMPT TO STEER THIS VEHICLE OUT OF THE OTHER LAND AND BRAKE GETTING IT OFF THE ROAD ASAP. IF THE BIG RIG HAD NOT MADE AN ATTEMPT TO MISS ME, I WOULDNT BE SENDING THIS LETTER. I WONDER HOW MANY OTHER PEOPLE HAD NOT THE STRENGTH TO STEER OUT OF A SITUATION OR HAVE TIME TO STOP AND WERE KILLED. THE REPORT MOST LIKELY SAID" DRIVER FELL ASLEEP." OR SOMETHING TO THAT AFFECT. THERE IS NO WAY THIS ENGINE SHOULD BE ALLOWED TO CONTINUE OPERATION ON THE ROAD PERIOD. FORD SHOULD HONOR ALL CURRENT OWNERS OF THIS VEHICLE WITH A VERY REASONABLE SETTLEMENT NOT TO MENTION HAVING A FORMAL INVESTIGATION INTO THIS MATTER. I KNOW OF NO OTHER VEHICLES ON THE ROAD THAT HAVE SUCH AN ISSUE. COMPLETE FAILURE OF STEERING AND BRAKES DUE TO AN UNFORESEEN INTERNAL MECHANICAL ISSUE IS A VERY POOR DESIGN. RUNNING OUT OF FUEL IS ONE THING, HOWEVER RUNNING OUT OF CONTROL IS ABSURD. HAD I KNOW WHO TO WRITE TOO SOONER I WOULD HAVE.

THE PASSENGER SIDE REAR SPARK PLUG BLEW OUT OF THE SOCKET

TL* THE CONTACT OWNS A 2003 FORD F-350. WHILE DRIVING 50 MPH, THE CONTACT CRASHED INTO ANOTHER VEHICLE. NONE OF THE AIR BAGS DEPLOYED. THE VEHICLE WAS TOWED TO A COLLISION CENTER AND THE DEALER WAS NOT CONTACTED AS OF YET. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A NECK FRACTURE THAT REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.

I PURCHASED LT265/75/16 BF GOODRICH RUGGED TERRAIN T/A TIRES FOR MY TRUCK EXACTLY 5 YEARS AND JUST OVER 21K MILES LATER I HAD 2 SEPARATE TIRE FAILURES LESS THAN A FEW HUNDRED MILES APART. FIRST TIRE A BELT SLIPPED. HAD A GIANT BULGE IN THE TREAD. I PUT MY SPARE ON AND INSPECTED THE OTHER TIRES. ALL OK. NO CRACKS NO DRY ROT. I HAVE PICS. TIRE PRESSURE SET EQUALLY AT 78 PSI. I WAS AWAY CAMPING AND PULLING A 9000 LB TRAILER. LOCAL TIRE STORE DIDN'T HAVE A REPLACEMENT SO I HEADED HOME FIGURED I WOULD REPLACE IT WITH ANOTHER MATCHING TIRE AT HOME. ABOUT 100 MILES LATER WE HAD A SECOND TIRE FAIL. THIS ONE BLEW OUT AT HIGHWAY SPEED, CAUSING A LOT OF DAMAGE TO THE TRUCK AND LEFT ME STRANDED WITH NO SPARE. AFTER DOING SO RESEARCH AND READING BFG RECALLS FOR TIRES SIMILAR TO THIS ONE BUT DIFFERENT SIZES, I AM LEFT TO WONDER IF ALL OF THESE SIZES SHOULD HAVE BEEN INCLUDED IN THE RECALL. THE RECALL TIRES FAILED IN THE SAME MANNER AS MINE THAT WAS NOT INCLUDED ONLY BECAUSE OF THE SIZE AND I WAS NEVER NOTIFIED. I HAD MY WIFE AND 3 KIDS IN THE TRUCK AND IT WAS A DANGEROUS SITUATION. THE TIRE BLEW OUT ON THE PA TURNPIKE. 65 MPH WHILE TOWING A HEAVY TRAILER. SUNNY. 85* DAY. THE BULGED TIRE HAPPENED A LOW SPEED. 25 MPH ON BACK ROADS. ALL OF THESE TIRES SHOULD HAVE BEEN INCLUDED IN THE RECALL IT IS DANGEROUS TO HAVE THEM ON THE ROAD.

TL* THE CONTACT OWNS A 2003 FORD F-350 EQUIPPED WITH BF GOODRICH RUGGED TERRAIN T/A TIRES, SIZE: 285/75/16. WHILE DRIVING 75 MPH, THE FRONT PASSENGER SIDE TIRE SUSTAINED TREAD SEPARATION. THE CONTACT STATED THAT THERE WAS DAMAGE DOWN TO THE FENDER AND FENDER WELL OF THE VEHICLE. THE CONTACT STATED THAT THE TIRE WAS STILL FULLY INFLATED. THE CONTACT STATED THAT AAA WAS ABLE TO REPLACE THE TIRE, BUT ALL OF THE REMAINING TIRES ALSO SHOWED EVIDENCE OF TREAD SEPARATION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND DOT NUMBER WERE UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.

FUEL TANK DELAMINATION LEADING TO STALLING AND EVENTUAL REPLACEMENT OF THE TANK AT MY COST

DRIVING ALONG LOUD NOISE PULLED OVER TO FIND A SPARK PLUG BLEW OUT OF THE ENGINE BLOCK TAKING THE THREADS WITH IT. NO FIRE THANK GOODNESS!

TIRE FAILURE. DESTROYED MY OUTER FENDER ON 2003 F350 DUALLY DAMAGED INCLUDED, OUTER FENDER, INNER FENDER, DAMAGE TO THE BED OF THE TRUCK, AND DAMAGE TO THE SUPPORT BRACKETS. BOUGHT THIS TRUCK USED ABOUT A MONTH AGO. NOT SURE WHEN THE TIRES WERE PURCHASED. MILEAGE ON TIRES IS AN ASSUMPTION

TRUCK STARTS TO HAVE A VIBRATION AND AT HIGHER SPEED GETS WORSE BY THE TIME YOU THINK IT MAY BE A BAD TIRE YOU MAY GET PULLED OVER BEFORE IT BLOWS OUT OR IT BLOWS DOING EXTENSIVE VEHICLE DAMAGE BEFORE YOU GET STOPPED. BETWEEN 04/15/09 TO 08/16/12 I PURCHASED 6 UNIROYAL LAREDO 265/75R16 TIRES FOR 2003 F-350 FORD TRUCK. ON 9/15/2910 A TIRE SEPARATED AND HAD A HUGE KNOT AND ADJUSTED WITH A NEW TIRE. ON 8/16/2012 ANOTHER TIRE SEPARATED AND HAD A KNOT IT WAS REPLACED AND ADJUSTED WITH A NEW TIRE. SINCE 2012 EVERY ONE OF THE 6 TIRES HAS SEPARATED AND HAD A KNOT. 2 BLEW COMPLETELY BEFORE I COULD GET STOPPED DOING EXTENSIVE VEHICLE DAMAGE. THE LEFT FRONT BLEW OUT IN MAY OF THIS YEAR TAKING ME DIRECTLY INTO INCOMING TRAFFIC AND ALMOST HITTING A COUPLE HEADON ON A MOTORCYCLE AND THEN ENDING UP IN THE INCOMING VECHICLES ROAD DITCH AT 65 MPH. THE TIRE STORE RECCOMENDED TO NOT USE THE UNIROYAL LAREDOS BECAUSE THIS HAS BECOME A COMMON QA ISSUE WITH THIS TIRE. THE TECHNICIAN SHOWED ME WHERE THE TIRES START TO COME APART. I LEFT 2 UNIROYAL LAREDOS ON THE REAR WHEELS AND THE TIRE TECHINICIAN LOOKED AT THE TIRES AND HE SAID THEY STILL LOOKED OPERABLE IN LESS THAN 2 WEEKS LEFT REAR STARTED VIBRATING AND IT HAD A KNOT ON IT. SO NOW ALL UNIROYAL LAREDOS HAVE BEEN REPLACED WITH BFG TIRES. 6 OUT OF 6 TIRES ALL WENT BAD AND THE TIRE STORES KNOW THESE UNIROYAL TIRES ARE DEFECTIVE AND YET UNIROYAL HAS DONE NOTHING TO FIX THE PROBLEM OR RECALLED THE TIRE. THIS IS A EXTREMELY DANGEROUS SAFETY ISSUE WHEN A TIRE BLOWS ON THE FRONT YOU HAVE NO CONTROL OVER THE TRUCK YOUR JUST A BOMB HEADING TO INCOMING TRAFFIC.

I WAS DRIVING DOWN THE ROAD AND I HEARD A LOUD POP. THE ENGINE HAD A VERY ABRUPT LOSS IN POWER AND BEGAN SHAKING AS I TRIED TO ACCELERATE. I WAS ON A 2 LANE ROAD AND HAD NO CHOICE BUT TO TRY AND MAINTAIN MY SPEED TO PREVENT CAUSING AN ACCIDENT FROM BEING REAR ENDED. AFTER DRIVING SEVERAL MILES TO A PLACE I COULD SAFELY STOP, I CHECKED UNDER THE HOOD AN A SPARK PLUG HAD BEEN SHOT FROM THE ENGINE. AFTER REVIEWING THIS ON THE WEB, THERE ARE MANY COMPLAINTS LIKE MINE WHERE SPARK PLUGS WERE SHOT OUT OF ENGINES. NHTSA NEEDS TO EVALUATE THIS AS REVIEW. HAD THE ENGINE CAUGHT FIRE I WOULD NOT HAVE KNOWN AND I HAD NO WHERE TO PULL OFF THE ROAD. THIS IS A RESULT OF AN CYLINDER HEAD WITH INADEQUATE THREADS FOR SPARK PLUGS TO THREAD INTO AND TAKE HOLD OVER TIME THE ALUMINUM WEAKENS AND THIS HAPPENS. IF THIS WASN'T A PROBLEM WHY DID FORD REDESIGN CYLINDER HEADS AFTER THESE MODEL ENGINES TO ACCOMMODATE MORE THREADING TO HOLD THE SPARK PLUGS IN THE ENGINE?

VEHICLE STALLED AT 55 MPH ON HIGHWAY. *TR

I THOUGHT MY FOOT SLIPPED OFF THE BRAKE AND TAPED THE REAR END OF THE CAR IN FRONT OF ME. SCRATCHED THE BUMPER OF THE CAR I TAPPED. I WAS ON I 95S TOWARDS FREDERICKSBURG, VA WHEN MY BRAKE WARNING LIGHT CAME ON. TAPED BRAKE AND THE PEDAL ALMOST WENT TO THE FLOOR, BUT I DID HAVE SOME BRAKING. GOT THE TRUCK TO THE REPAIR SHOP, DIAGNOSED WILL HOLE IN BRAKE LINE CAUSED BY RUST. REPLACED 18 FT OF LINE. *TR

TL* THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT THE ENGINE COOLANT LEVEL WAS FOUND TO BE PREMATURELY LOW. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, WHO ADVISED THE CONTACT THAT THE HEAD GASKET HEAD BOLTS WERE DEFECTIVE. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT SMOKE BEGAN EMERGING FROM UNDER THE HOOD. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THERE WAS A HOLE IN THE FUEL LINE AND DIESEL FUEL HAD LEAKED ONTO THE ENGINE. THE DEALER STATED THAT THE FUEL LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 158,057.

ON 05/31/2013 AFTER DRIVING APROX 50 MILES AT HIGHWAY SPEEDS THE TRUCK WAS PARKED AND A SMALL FIRE STARTED DUE TO LEAKING OIL ON THE HOT EXHAUST SYSTEM FROM A RUSTED OIL PAN. THE FIRE WAS EXTINGUISHED BEFORE IT CONSUMED THE ENTIRE VEHICLE. I HAVE CONTACTED FORD MOTOR CO. CUSTOMER CARE AND WAS TOLD THAT THE TRUCK WAS OUT OF WARRANTY AND THAT THE COST TO REPAIR 1500.00 TO 2000.00 WOULD BE MY RESPONSIBILITY. I AM DISABLED AND ON SOCIAL SECURITY WITH A VERY FIXED INCOME AND CANNOT AFFORD THE COST OF THIS REPAIR. FROM LOOKING AT ALL THE OTHER POSTS AND LIVING IN MICHIGAN WITH WINTER SALT, FORD HAS RECALLED MANY OF THEIR VEHICLES DUE TO RUST AND CORROSION OF VARIOUS COMPONENTS THAT COULD CAUSE A ACCIDENT OR DEATH. PLEASE INVESTIGATE THIS MAJOR PROBLEM WITH FORD TRUCKS AND OTHER VEHICLES WITH THE 7.3 LITER DIESEL ENGINE. I HAVE CONTACTED MY DEALER AND THEY SAID THIS IS A VERY COMMON PROBLEM. THANK YOU IN ADVANCE. THE TRUCK IS CURRENTLY PARKED AND UNDRIVEABLE. *TR

BOUGHT TRUCK IN 2009 . ABS LIGHT IS ON WANTED TO FIND OUT IF THERE WAS A RECALL ON HUBS AND IF SO WOULD LIKE TO FIND OUT IF TRUCK WAS SERVICED , AND IF NOT HOW WOULD I PROCEED TO DO RECALL . THANK YOU *TR

TL* THE CONTACT OWNS A 2003 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 45 MPH THE TRANSMISSION STARTED SLIPPING AND THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART VEHICLE. THE VEHICLE WAS NEITHER REPAIRED NOR TAKEN FOR DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF INCIDENT. THE FAILURE MILEAGE WAS 47,000. *TR

VEHICLE WAS ACCELERATING ONTO ON-RAMP TO INTERSTATE 90 WEST BOUND AT PINES ROAD IN SPOKANE VALLEY WA. VEHICLE WAS DRIVEN BY MY WIFE. AT APPROXIMATELY 30 MPH THEIR WAS A LOUD BANG AND NOISE THAT SOUNDED LIKE AN EXHAUST LEAK. VEHICLE WAS DRIVEN TO THE SHOULDER AND SHUT OFF. MY WIFE CALLED ME AND I CAME TO INVESTIGATE WHAT HAD HAPPENED. I TURNED THE ENGINE OVER AND DETERMINED IT WAS NOT AN EXHAUST LEAK BUT THAT A SPARK PLUG HAD BEEN BLOWN OUT OF THE RIGHT SIDE OF THE ENGINE. IT WAS THE NUMBER 4 SPARK PLUG FROM THE FRONT ON MY V-10 GAS ENGINE. I LOCATED THE BENT SPARK PLUG AT THE APPROXIMATE LOCATION OF WHERE THE INCIDENT OCCURRED. OTHER THAN BEING BENT THE THREADS ON THE PLUG WERE INTACT AND DID NOT APPEAR TO HAVE BEEN CROSS THREADED. I HAD THE PLUGS REPLACED AT JUST OVER 100,000 MILES AS PER THE OWNERS MANUAL. I CHECKED WITH THE AUTO REPAIR SHOP I USED, (AAFES AUTO HOBBY SHOP ON FAIRCHILD AFB), AND INFORMED THEM OF WHAT HAD OCCURRED. THEY INFORMED ME THAT FORD HAD A TECHNICAL SERVICE BULLETIN ON THIS VERY SUBJECT. THIS APPEARS TO BE A MANUFACTURING DEFECT IN THAT REPLACING SPARK PLUGS SHOULD NOT LEAD TO AN EXPLOSIVE EVENT STRONG ENOUGH TO DENT MY HOOD FROM THE INSIDE. I AM NOW EXPECTING TO HAVE 9 MORE LITTLE TIME BOMBS JUST WAITING TO GO OFF UNDER THE HOOD OF MY TRUCK. I AM JUST THANKFUL THAT MY WIFE HADN'T YET GOTTEN UP TO THE SPEED LIMIT OF 60MPH. *TR

TL* THE CONTACT OWNS A 2003 FORD F-350 SD. WHILE PARKED, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT BOTH REAR BRAKE LIGHTS WERE INOPERABLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V352000 (EXTERIOR LIGHTING:BRAKE LIGHTS) AND CONTACTED THE MANUFACTURER. THE MANUFACTURER INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.

MY WIFE AND I WERE TAKING OUR SON BACK TO COLLEGE. THERE WAS A NOISE COMING FROM THE FRONT RIGHT TIRE THAT SOUNDED LIKE THE WARNING FOR YOUR BRAKE PADS, EXCEPT WHEN I APPLIED THE BRAKES IT DIDN'T STOP. SOUNDED LIKE MY BRAKE ROTOR WAS GRINDING. THE NEXT DAY I TOOK MY VEHICLE TO MY MECHANIC TO HAVE MY BRAKES AND ROTORS CHECKED. THEY WERE FINE, BUT I WAS SURPRISED WHEN MY MECHANIC TOLD ME IT WASN'T MY BRAKES BUT INSTEAD IT WAS MY ALUMINUM ALLOY RIM (FACTORY RIMS) HAD CRACKED ALL THE WAY THROUGH ONE OF THE SPOKES ON THE RIM AND HAD STARTED CRACKING ABOUT AN 1 1/2" THROUGH ANOTHER! I TOLD MY MECHANIC THAT I HAD NEVER HAD THIS HAPPEN BEFORE IN MY LIFE. MY MECHANIC REPLIED THAT HE HAD SEEN THIS SAME THING ON 5 OR 6 OF THE SUPER DUTY'S. SO, I BROWSED THE INTERNET TO SEE IF ANYONE ELSE HAD EXPERIENCED THE SAME PROBLEM. COME TO FIND OUT THAT THERE ARE HUNDREDS OF PEOPLE THAT HAVE HAD THE EXACT PROBLEM NOT ONLY WITH THE ALUMINUM ALLOY RIMS BUT THE STEEL RIMS AS WELL AND NOT SPECIFIC TO ANY YEAR. FROM FLORIDA TO CALIFORNIA ALL OVER THE U.S. INFORMED FORD CUSTOMER RELATIONS OF MY FINDINGS AND THERE RESPONSE WAS TO HOLD ON TO MY RECEIPT IN CASE THERE IS A CUSTOMER SATISFACTION PROGRAM (CSP) OR A RECALL EVER PUT IN PLACE. *TR

TL* THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, HE LOST CONTROL OF THE VEHICLE AS THE VEHICLE INDEPENDENTLY DECELERATED TO A COMPLETE STOP. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE AIR BLOCKERS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ACKNOWLEDGED THE FAILURE BUT PROVIDED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGE WAS 98,000.

I WAS HAULING A LOADED HORSE TRAILER AND HAD JUST MERGED ONTO THE HIGHWAY. AS I WAS TRYING TO ACCELERATE, THE ENGINE WAS "CATCHING" AND WOULDN'T LET ME ACCELERATE PAST 35 MPH AND WAS REVVING VERY HIGH AND WOULDN'T SHIFT UP INTO THE NEXT GEAR. IT FINALLY STALLED AND COMPLETELY SHUT OFF IN THE MIDDLE OF TRAFFIC AND I HAD TO COAST TO THE SIDE OF THE ROAD WHERE WHITE SMOKE STARTED POURING OUT FROM UNDER THE HOOD. MY ENTIRE RIG - TRUCK, TRAILER AND HORSES, HAD TO BE TOWED HOME AND THEN THE TRUCK TOWED TO THE MECHANIC. HE FOUND THE ENGINE RUNNING POORLY, AND FOUND LOW COMPRESSION ON CYLINDERS #3 AND #8. HE FOUND LOW OIL PRESSURE AND WHEN HE REMOVED THE OIL PAN FROM THE CHASSIS, HE FOUND PISTON MATERIAL IN THE OIL PUMP. HE REMOVED THE ENGINE AND FOUND THE PISTONS IN CYLINDER 3 AND 8 MELTED DOWN. HE HAD TO BORE OUT AND HONE ALL THE CYLINDERS, REPLACE ALL 4 VALVES IN CYLINDER #3 HEAD, REPLACE ALL PISTONS, REPLACE THE MAIN BEARING AND ROD BEARING, UPDATE THE OIL COOLER AND REPLACE 8 PISTONS AND 6 HEAD GASKETS. WHEN HE PUT IT ALL BACK TOGETHER AND TEST DROVE IT, HE FOUND AN EXHAUST LEAK FROM THE EBP SENSOR AND TUBE. THOSE HAD TO BE REPLACED. BEFORE ALL THIS HAPPENED, I HAD NOTICED THAT THE ENGINE SEEMED TO BE "SKIPPING" WHEN I WAS HAULING MY HORSE TRAILER. IT ONLY HAPPENED WHEN I WAS OVER 55 MPH AND IT ONLY HAPPENED WHEN I WAS HAULING. I HAD TAKEN THE TRUCK TO THE MECHANIC BEFORE THE BIG BREAKDOWN (DESCRIBED ABOVE) AND HE COULDN'T FIND ANYTHING WRONG. I THINK THAT IS BECAUSE HE WAS NOT HAULING A TRAILER AND THAT'S THE ONLY TIME THE PROBLEM OCCURRED. THE TOTAL BILL FOR ALL THESE REPAIRS IS $6400.00 AND I HAVE BEEN TOLD THAT FORD WILL DO NOTHING TO HELP ME. *JB

PURCHASED 4 LT CONTINENTAL CONITRAC 275/70R18 TIRES/FORD OEM WHEELS FROM BARNEY'S TIRE AND WHEEL IN TEMECULA, CA FOR MY 2003 F350 FORD TRUCK. THESE TIRE AND WHEELS WERE IN NEW CONDITION. JUNE 2, 2011 I HAD DINSAUR TIRE LOCATED IN CALIMESA CA REPLACE THE LEFT FRONT TIRE DUE TO TIRE SEPARATION. NEITHER I OR DINOSAUR TIRE WERE AWARE OF THE CONTINENTAL TIRE RECALL. MARCH 22, I HAD THE LEFT REAR TIRE SEPARATE AND AGAIN CONTACTED DINOSAUR TIRE TO SCHEDULE A REPLACEMENT. AGAIN, THEY WERE UNAWARE OF THE RECALL. THINKING TWO TIRE SEPARATIONS WERE ODD, I PERFORMED A SEARCH ON THE WEB FOR PROBLEMS RELATED TO THESE TIRES AND DISCOVERED CONTINENTAL HAD RECALLED CERTAIN TIRES. EMAILED CONTINENTAL THE DOT NUMBERS OF THE TIRES AND THEY CONFIRMED WITH A EMAIL THESE WERE TIRES SUBJECT TO THE RECALL AND I WAS DIRECTED TO CONTACT AN AUTHORIZED DEALER. CONTACTED DINOSAUR TIRE (AUTHORIZED DEALER) AND FAXED ALL CORRESPONDENCE TO THEM. THEY WERE STILL UNAWARE OF THE RECALL AND DID NOT KNOW THE PROCESS TO FILE A CLAIM. DINOSAUR TIRE CALLED CONTINENTAL WITH ME IN THEIR COMPANY TO GET AN AUTHORIZATION. UNFORTUNATELY AND WRONGFULLY, CONTINENTAL WILL ONLY PRORATE THE REMAINING THREE TIRES BECAUSE THERE WAS A COMPLIANCE DATE OF OCTOBER 15, 2011 AND STATED ALL PERSONS WHO PURCHASED THE TIRES WERE CONTACTED. HAD THE AUTHORIZED DEALER DINOSAUR TIRE BEEN MADE AWARE OF THE RECALLED TIRES LAST JUNE, I COULD OF REPLACED THE 4 TIRES WITHOUT ANY FEES AND FREE OF CHARGE. HOWEVER, BECAUSE CONTINENTAL FAILED TO COMMUNICATE THIS TO THE PUBLIC AND AUTHORIZED CONTINENTAL DEALERSHIPS, DEMONSTRATES A LACK TO TAKE FULL RESPONSIBILITY TO THE PUBLIC FOR TIRES THE PUBLIC ACCIDENTALLY CAME IN POSSESSION OF, AND SOLD BY UNAWARE TIRE COMPANIES. CONTINENTAL WOULD NOT PROVIDE ANY REIMBURSEMENT FOR THE TIRE REPLACED LAST JUNE, 2011. AGAIN - FAILURE TO COMMUNICATE THE RECALL TO THE PUBLIC DEMONSTRATES A LACK OF RESPONSIBILITY. *TR

HAVE FICM FAILURE AND MULTIPLE FUEL INJECTORS FAIL, WHEN TOOK TO DIESEL SHOP WAS INFORMED THAT THIS IS COMMON FAILURE AND THEY HAD AT LEAST 6 IN REPAIR SHOP WITH SAME PROBLEM. *TR

DURING HIGH SPEED HIGHWAY DRIVING THE TURN SIGNAL BECAME STUCK IN RIGHT HAND TURN POSITION. AFTER CLICKING THE SIGNAL LEVER FROM LEFT, CENTER, AND RIGHT HAND TURN POSITIONS THE RIGHT HAND TURN SIGNAL REMAINED ON IN ALL POSITIONS. I HAVE BEEN DRIVING FOR 6 DAYS NOW WITH THE FOUR WAY HAZARDS ON. I FOUND ONLINE THERE WAS A SAFETY RECALL ON THE MULTI FUNCTION TURN SWITCH, BUT WHEN I TOOK VEHICLE TO THE DEALER THEY TURNED ME AWAY AND SAID THERE WAS NO RECALL. THEN I CALLED FORD CUSTOMER RELATIONSHIP CENTER AND THEY SAID THERE WAS NO RECALL EITHER AND ALSO SAID THAT EVEN THOUGH MY TRUCK WAS WITHIN THE YEARS AND MODELS STATED THAT THE VIN # WAS NOT WITHIN THE RECALL. HOW COULD THAT BE? IS A FORD F-350 SD 2003 DIFFERENT FROM ANOTHER FORD F-350 SD 2003. I STILL HAVE THE PROBLEM DESCRIBED IN THE RECALL. SAFETY HAZARD INDEED. *KB

TL* THE CONTACT OWNS A 2003 FORD F350. THE CONTACT STATED THAT THE ELECTRICAL SYSTEM FAILED AND WAS INOPERABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE AFTER MARKET RADIO COULD HAVE POSSIBLY CAUSED OTHER ELECTRICAL FAILURES WITHIN THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED BUT NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 155,000.

TL* THE CONTACT OWNS A 2003 FORD F-350 SD. THE CONTACT WOULD SHIFT THE VEHICLE INTO PARK, BUT INSTEAD THE VEHICLE WOULD SHIFT INTO REVERSE. THE CONTACT STATED THAT THE GEAR SHIFT WOULD READ PROPERLY, BUT PERFORM IN INACCURATELY. THE MANUFACTURER NOR DEALER WERE NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2003 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY WITHOUT WARNING. IN ADDITION, THE VEHICLE WOULD HESITATE WHEN ATTEMPTING TO START. THE DEALER DIAGNOSED THAT THE INJECTION CONTROL PRESSURE MODULE WOULD NEED REPLACING. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING) RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 60,200.

I HAD SEVERAL BREAKDOWNS WITH MY TRUCK AND HAD TO HAVE IT TOWED TWICE. THE FIRST PLACE IT WAS TOWED TO COULD NOT FIND THE PROBLEM THEN AFTER SEVERAL MORE INSTANCES I HAD IT TOWED TO THE DEALERSHIP WHERE I PURCHASED THE VEHICLE AND THEY NEW THE PROBLEM RIGHT AWAY. THE FUEL TANK DELAMINATED AND I WAITED TWO MONTHS FOR ONE BECAUSE THEY WERE IN PRODUCTION AT A COST OF $2000.00 TO BE REPAIRED. THIS SEEMS TO BE A WIDE SPREAD PROBLEM WITH THESE TRUCKS AND IT SHOULD BE WARRANTIED. *TR

MY 2003 F350 HAS ALL OF THE DEATH WOBBLE ISSUES, DRIVING AT 55 OR 70 ON THE HIGHWAY THE FRONT END WILL JUST GO INTO A CRAZY WOBBLE IN WHICH I HAVE TO SLOW DOWN TO TRY AND FIX. SOMETIMES WHEN I USE THE BRAKE PEDAL IT WILL ALSO GO INTO THE SAME EVENT. I'VE READ ALL THESE ISSUES ON THE NET AND CANNOT UNDERSTAND THAT IF ITS SUCH A HUGE PROBLEM WHY IS IT NOT BEING ADDRESSED. WILL IT TAKE ONE OF THESE VEHICLES KILLING A FAMILY MEMBER OF THE PEOPLE AT FORD TO GET THIS UNDER CONTROL OR MAYBE THEY JUST DON'T CARE AS LONG AS THEY ARE MAKING MONEY. TO THE FAMILY MEMBERS OF THE FORD PEOPLE AND EVERYONE ELSE I PRAY FOR YOU. I DO NOT KNOW WHAT TO DO FOR MY TRUCK TO FIX IT. *TR

TL* THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT HE FELL ASLEEP WHILE DRIVING AND THE VEHICLE TRAVELED OFF THE ROADWAY WHERE HE CRASHED INTO TWO TREES. THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS UNINJURED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 140,000.

SPARK PLUG EJECTION FROM 2003 FORD F-350 SUPER DUTY ENGINE: TRITON 5.4L V8 DATE OF FAILURE: 03-10-11 MILEAGE OF TRUCK: 139414 THIS INCIDENT HAPPENED WHILE TRAVELING ON A STATE HWY51 NEAR POSTVILLE, IA EJECTION OF SPARK PLUG FROM NUMBER 7 CYLINDER ON 5.4L V8 ENGINE. DAMAGE TO CYLINDER HEAD OF ENGINE AND SPARK PLUG COIL. THIS IS A WELL MAINTAINED 2003 F-350, SPARK PLUGS REPLACED AT A FORD DEALER 01-19-09: 109156 MILES. *TR

TL* THE CONTACT OWNS A 2003 FORD F-350 6.0L DIESEL SD. THE CONTACT WAS DRIVING APPROXIMATELY 10-20 MPH AND ATTEMPTING A RIGHT TURN WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ICP SENSOR WAS REPLACED YET THE FAILURE RECURRED TWO DAYS FOLLOWING THE REPAIRS. THE VEHICLE WAS TAKEN BACK TO THE LOCAL MECHANIC AND THE CONTACT WAS REFERRED TO THE DEALER. THE DEALER WAS INSTALLED A FLAT RECORD ON THE VEHICLE BUT WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING) WHICH INCLUDED THE 2005 MODEL FORD 350 DIESEL AND STATED THAT HE WAS EXPERIENCING THE EXACT SAME FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT MILEAGE WAS 25,000.

ON THE FORD F350 7.3 DIESEL, THE CLAMP BENEATH THE TURBO HOLDING THE HIGH PRESSURE DIESEL FUEL LINE IN PLACE IS A POOR DESIGN. THE CLAMP APPEARS TO BE ALUMINUM WITH A RUBBER COATING. THE RUBBER COATING WEARS AWAY AND THE FUEL LINE PASSES METAL ON METAL THROUGH THE CLAMP CAUSING WEAR. IN THIS PARTICULAR CASE THE PINHOLE LEAK IN THE HIGH PRESSURE FUEL LINE CAUSED BY THE WEAR CREATED A MIST OF FUEL TO BE BLOWN ON THE HOT TURBO CAUSING A FLAMMABLE CLOUD OF DIESEL. I IMMEDIATELY SHUT THE VEHICLES IGNITION OFF AND STOOD BY WITH AN EXTINGUISHER. THIS IS GOING TO HAPPEN AGAIN TO SOMEBODY AND NEEDS TO BE REPAIRED. SOMEBODY IS GOING TO BE INJURED OR THE VEHICLES ENGINE COMPARTMENT WILL CATCH FIRE. THE FUEL LINE NEEDS TO PASS THROUGH A CLAMP OF BETTER DESIGN. *TR

I CALLED FORD MOTOR COMPANY MY 2003 FORD F350 SD. SC. 4X4 5.4 ENG. WITH THE PROBLEM WITH BOTH EXHAUST MANIFOLDS ROTTING AWAY & THE STUDS & NUTS THAT HOLD THE EXHAUST MANIFOLDS TO ENGINE HEADS THAT THEY WERE ALL ROTTING AWAY , THEY TOLD ME WE WON'T FIX THE PROBLEMS FOR FREE . I WOULD LIKE FOR TO INVESTIGATE THIS PROBLEM BEFORE MANY PEOPLE WILL GET INJURY OR MANY FATALITY WILL HAPPEN WHEN THE EXHAUST MANIFOLDS FALL OFF AND CATCH ON FIRE & BURN UP BECAUSE FIRE COMES OUT OF THE ENGINE TO THE EXHAUST MANIFOLDS . I TALKED TO MANY FORD DEALERS THEY TOLD ME THAT THEY HAVE REPLACED MANY OF THESE EXHAUST MANIFOLDS WITH THE SAME PROBLEMS I HAVE & HAD TO CHARGE THE OWNER OF THESE TRUCKS & MANY OTHER YEARS OF THESE FORD TRUCKS . PLEASE HELP ME & MANY OTHER OWNERS OF THESE FORD TRUCKS TO MAKE FORD MOTOR COMPANY RECALL THIS PROBLEMS BEFORE PEOPLE WILL DIE & FIX THIS PROBLEM FOR FREE . THANKS *TR

FAULTY FORD FUEL TANK. DIESEL TANKS ARE DELAMINATING, CAUSING FUEL LINE/FILTER TO CLOG AND VEHICLE NOT TO RUN PROPERLY. 6/16/10 REPLACED FUEL FILTER, RAN FOR ONE DAY. TOOK TRUCK TO HENRY CURTIS FORD ON 6/17/10, THEY TOLD US ABOUT DELAMINATION, NOT THEIR FAULT. CHARGED US $909.28 TO REMOVE TANK, CLEAN AND REPLACE MICRON FILTER. HCFORD SAYS THAT THE NEW GAS TANKS FROM FORD ARE ON BACK ORDER, NOT AVAILABLE UNTIL APPROX. SEPT 2010. ON 6/30/10 TRUCK RUNS IMPROPERLY AGAIN,FUEL FILTER CLOGGED DUE TO DELAMINATION, CHANGED FUEL FILTER. ON 7/1/10 TRUCK RUNS BAD AGAIN, LEAVE TRUCK AGAIN WITH HENRY CURTIS FORD WITH AN ODOMETER READING OF 73812 AND A 1/4 TANK OF GAS. THEY CALLED AND SAID THE FUEL FILTER IS CLOGGED, THEY AGAIN WANT TO PULL THE TANK AND REPLACE THE MICRON FILTER AT A CHARGE OF $900 + ONLY ELEVEN DAYS AFTER THEY JUST DID IT. WE DECLINED, THEY CHARGED US $122.00 AND RETURNED OUR TRUCK WITH AN ODOMETER READING OF 73896 AND AN EMPTY TANK OF GAS. WHEN QUESTIONED HCFORD ABOUT ODOMETER AND GAS THEY SAID THEY ONLY DROVE TRUCK 5 MILES. NO ACCOUNTABILITY. 100'S OF COMPLAINTS ON INTERNET REGARDING DELAMINATION OF FORD FUEL TANKS. PLEASE INITIATE A FORD FUEL TANK RECALL. *TR

TL*THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, A SPARK PLUG FLEW OUT OF THE ENGINE COMPARTMENT AND HIT THE HOOD OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE A COIL AND THE SPARK PLUG WERE REPLACED. THE FAILURE OCCURRED TWO ADDITIONAL TIMES AFTER. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 101,000.

I CALLED FORD MOTOR COMPANY ON MY 2003 FORD F350 SD. SC. 4X4 5.4 ENG. WITH THE PROBLEM WITH BOTH EXHAUST MANIFOLDS ROTTING AWAY & THE STUDS & NUTS ROTTING , THEY TOLD ME WE WON'T FIX THE PROBLEM FOR FREE . I WOULD LIKE FOR YOUR HELP TO MAKE FORD MOTOR COMPANY FIX THIS PROBLEMS FOR FREE BECAUSE I TALKED TO MANY FORD DEALERS THEY ARE REPLACING THIS SAME PROBLEMS ON ALL 5.4 ENG. ON FORD TRUCKS AND HAVE TO CHARGE FOR THESE PROBLEMS . PLEASE INVESTAGATE THIS PROBLEMS BEFORE ALL THESE TRUCKS WILL CATCH ON FIRE AND PEOPLE WILL BE INJURY OR FATALITY WILL HAPPEN . PLEASE HELP ME AND MANY PEOPLE CAN GET THESE PROBLEMS FIX FOR FREE FROM FORD MOTOR COMPANY THANKS. *JS

I OWN A 2003 FORD F-350 DUELLY WITH THE ALUMINUM RIMS WITH THE TRIANGULAR CUT OUTS IN THEM. AT ABOUT 172,000MI MY PASSENGER FRONT RIM CRACKED FROM ONE CUT OUT TO ANOTHER ALL THE WAY THROUGH AND WAS OFFSET FROM THE RIM ABOUT 1/4 INCH. I REPLACED THAT ONE AND THEN ABOUT 2000MI LATER THE DRIVERS SIDE CRACKED JUST LIKE THE PASSENGER SIDE DID ONLY IN 2 PLACES. IT WAS REPLACED WITH A USED ONE. THE LOCAL TOWING/ TIRE DISTRIBUTOR SAID HE HAS OWNED FORD SUPERDUTYS FOR OVER 10 YEARS AND HAS NEVER HAD ONE OF HIS RIMS CRACK NOR HAS HE EVER SEEN ONE DO THAT. FROM MY PERSPECTIVE IT LOOKS AS THOUGH THERE MIGHT BE A DEFECT IN "FORDS" WHEELS THAT THEY MADE THAT YEAR. THERE ARE OTHER PEOPLE ON DIFFERENT ONLINE FORUMS THAT ARE HAVING THE SAME PROBLEMS WITH THE 2003 FORD SUPERDUTYS ONLY THERE'S HAVE BETWEEN 50K AND 178K MI ON THERE'S. I HOPE THIS CAUGHT YOUR ATTENTION BECAUSE FORD ISN'T DOING NOTHING ABOUT IT AND IF THE WHEEL CRACKED BAD ENOUGH AND SOMEONE DIDN'T CATCH IT IN TIME IT COULD DETACH FROM THE VEHICLE AND CAUSE A WRECK. THANKS FOR READING THIS. *TR

SPARK PLUG BLEW FROM ENGINE ON 2003 FORD F-350 5.4 TRITON ON MAY 10TH 20010. ON FREEWAY APROX.65MPH. CANNOT RE-INSTALL PLUG DUE TO THREAD DAMAGE. *TR

TL* THE CONTACT OWNS A 2003 FORD F250. THE CONTACT NOTICED THAT THE FRAME UNDERNEATH THE VEHICLE WAS COVERED WITH RUST. HE ALSO NOTICED THAT THE RUST WAS AFFECTING THE DRIVERS SIDE DOOR PANEL. THE DEALER DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE MANUFACTURER ALSO OFFERED NO ASSISTANCE. THE CURRENT MILEAGES WERE 65,000 AND THE FAILURE MILEAGES WERE 50,000. UPDATED 5/24/11 *CN UPDATED 06/10/11

FOR SEVERAL YEARS, WE HAVE HAD EXHAUST GASES GOING INTO OUR TRUCK CAB. WE DO NOT DRIVE THE TRUCK DUE TO THIS REASON. ONE YEAR AGO, WE TOOK THE TRUCK TO DIESEL SPECIALISTS HERE IN LAS VEGAS. THEY SAID THAT THERE WAS A PROBLEM WITH THE MANIFOLD. THEY TRIED TO FIX IT AND IT WAS GOOD FOR ABOUT A WEEK UNTIL IT STARTED TO FORCE EXHAUST GASES BACK INTO THE CAB OF THE TRUCK. I UNDERSTAND THAT THERE IS A LARGE RECALL OF FORD VEHICLES DOING THE SAME ISSUE. IT APPEARS THAT FORD IS STILL MAKING VEHICLES WITH FAULTY EQUIPMENT ON THEM. WE WOULD HAVE TAKEN OUR TRUCK BACK TO THE DEALER BUT WE DO NOT HAVE A WARRANTY.

FORD F350 EQUIPPED WITH 6.0L DIESEL ENGINE EXPERIENCED STALLING WITHOUT WARNING WHILE DRIVING AND/OR WHILE APPLYING BRAKES. THIS LOOKS TO BE THE SAME ISSUE THAT AFFECTED VEHICLES IN THE 2004-2005 RECALL. ICP SENSOR LIGHT IS LIT AND MOST LIKELY WILL NEED TO BE REPLACED. SEPARATE OR RELATED ISSUE? : ENGINE WILL "REV-UP" WHILE DRIVING AND PRODUCE ACCELERATION WITHOUT GAS PEDAL BEING APPLIED. ENGINE WILL REV-UP AND/OR IDLE HIGH WHILE IN PARK AND WHEN STOPPED/BRAKES APPLIED. *TR