2004 Ford F-350 Complaint Log

The contact owns a 2004 Ford F-350. The contact stated that while driving approximately 76 MPH with his wife in the front passenger seat, the vehicle shuddered uncontrollably and stalled. The contact and his wife were concerned for their safety. There was no warning light illuminated. The contact was able to regain control of the vehicle and pulled over to the side of the road. The vehicle failed to restart and was towed to the residence. The contact stated that as an independent mechanic, he used a code reader to retrieve diagnostic trouble codes for the fuel control module wiring harness failure. The contact related to the failure to NHTSA Campaign Number: 05V270000 (Electrical System). The contact stated that the fuel control module wiring harness failure had caused warning lights to fail to illuminate as needed. The dealer was notified of the failure and informed the contact that the vehicle had previously been repaired under the recall. The manufacturer was notified of the failure and informed the contact that an elbow vacuum tubing connector was previously replaced under the recall; however, the contact advised the manufacturer that the recall involved replacing the entire fuel control module wiring harness. The manufacturer informed the contact that the recall was already marked completed and no further repairs could be covered. The contact stated that the dealer and the manufacturer had failed to honor the recall repair. The vehicle was not repaired. The failure mileage was 190,019.

While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several accidents with this truck. Once it is stalled it can take numerous times to restart the vehicle. This issue seems to occur more on slopes going up hill. This does not seem to occur as often going downhill or on areas with no incline. Currently vehicle has 126,931.8 miles on it. Regularly serviced and otherwise running fine.

The contact owns a 2004 Ford F-350 equipped with Cooper Tires, Tire Line: Discover AT3, Tire size: 265/75/R16, DOT Number: UPWM1M11718M16L. The contact stated that while driving 65 MPH, the rear driver’s side tire had a sidewall blowout. The contact stated that all four tires had sidewall blowouts months apart. The tire blowouts had damaged the rims. The contact replaced the front driver’s, passenger’s, and rear driver’s side tire with the spare after each blowout. The dealer was made aware of the failure and replaced the rear passenger’s side tire. The manufacturer was made aware of the failure and the rear driver’s side rim, rear driver’s and front passenger’s side tire were sent to the manufacturer. The failure mileage was not available.

MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE HOWEVER, THE FAILURE RECURRED. UPON INSPECTION, THE CONTACT DISCOVERED THE FUEL FILTER WAS COVERED WITH SILVER DEBRIS. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS CONTACTED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 332,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND MADE MULTIPLE ATTEMPTS TO RESTART THE VEHICLE HOWEVER, THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THE VEHICLE WITH A DEFECTIVE FUEL INJECTION CONTROL MODULE. CASA FORD (5815 MONTANA AVE, EL PASO, TX 79925) AND THE MANUFACTURER WERE CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 220,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. ALSO, WHILE IDLING, THE ENGINE RPMS REMAINED VERY HIGH AND THE VEHICLE WOULD ATTEMPT TO SURGE FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE ICP SENSOR AND INJECTOR CONTROL SENSOR, BUT THE FAILURES CONTINUED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 200,000.

TAKATA INFLATORS; MY VEHICLE STARTED ALL TYPES OF PROBLEMS INTERMITTENT ONES THAT COST ME SEVERAL THOUSAND DOLLARS NEVER FIXING THE PROBLEM THIS IS WERE IT ALL BEGAN,,.MY VEHICLE DIED GOING UP FAIRLY STEEP HILL TO GRAVE YARD, IT IMMEDIATELY ROLLED BACK SHOVING A FAMILY MEMBERS VEHICLE DOWN HILL A WAYS UNTIL THEY TURNED AWAY FROM THE CLIFF EDGE LEAVING ME ALL ALONE.UNTIL GOING THROUGH A RUN OFF DITCH STOPPING OVER IT INTO 2 TREES. I HAD NO STEERING NO BRAKES AND THANK GOD THE TREES WERE THERE TO STOP MY TRUCK IF NOT THEIR WAS A 100 FOOT CLIFF NEXT.. I KNOW NOTHING ABOUT RECALLS OR SUCH I JUST TRIED TO FIX MY TRUCK PROBLEM BY PROBLEM AS SYMPTOMS CAME ON I HAVE ALL TYPES OF RECENT RECEIPTS THAT ALL CAME FROM SILVERISH DARK MAYBE EVEN GRAY MATTER STUFF IN THE TANK. WHEN I GET MY BANK STATEMENT I WILL ITEMIZE ALL AND SUBMIT THEM WHEN FINAL COST IS OVER.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE FUEL TANK STRAP WAS SEVERELY CORRODED AND THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THIS WAS THE SECOND TIME THE FAILURE OCCURRED. AN UNKNOWN FORD DEALER WAS CONTACTED AND REFERRED THE CONTACT TO FORD USA. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS NO RECALL AND HE WOULD BE RESPONSIBLE FOR THE REPAIR COST. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000. UPDATED 11/02/17*LJ *TT

WHEN GOING AROUND CURVES, HITTING SMALL BUMPS, OR STOPPING, THE FRONT END STARTS TO SHAKE VIOLENTLY. SLOWING DOWN OR STOPPING IS THE ONLY WAY TO STOP THE SHAKING. THE TRUCK HAS BEEN TAKEN TO SEVERAL REPAIR SHOPS WITH NO AVAIL. THEY CAN'T FIND ANYTHING WRONG. THIS PROBLEM IS VERY DANGEROUS. I'M GETTING SCARED TO DRIVE IT.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER TO A COMPLETE STOP. THE VEHICLE WAS STARTED NORMALLY, BUT STALLED AGAIN THE SAME AFTERNOON. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 05V270000 (ENGINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,307.

WE HAVE HAD FOUR SEPARATE INCIDENTS INVOLVING UNINTENDED ACCELERATION WITH OUR 2004 FORD F350. WHEN APPLYING THE BRAKES, THE VEHICLE SUDDENLY ACCELERATES. IT HAS HAPPENED TWICE GOING DOWN OUR DRIVEWAY, ONCE WHEN DRIVING IN CITY TRAFFIC, AND ONCE WHEN WE WERE PARKING AT A REST STOP. THE VEHICLE WAS DRIVING AT LOW SPEEDS IN ALL OF THESE INSTANCES. IN THE MOST RECENT INCIDENT, THE VEHICLE SUDDENLY ACCELERATED, JUMPED THE CURB AND STRUCK A TRASH CAN AT A REST STOP. THANKFULLY NO ONE WAS IN FRONT OF OUR VEHICLE AS THEY COULD HAVE BEEN KILLED. THE VEHICLE ALSO REAR ENDED ANOTHER VEHICLE IN ANOTHER INCIDENT. THIS HAS HAPPENED THREE TIMES WHEN MY HUSBAND WAS DRIVING AND ONCE WHEN I WAS DRIVING. AFTER THE MOST RECENT INCIDENT WE GOOGLED THIS AND FOUND THERE ARE NUMEROUS CLASS ACTION LAWSUITS AGAINST FORD FOR THIS ISSUE, AND THAT OUR YEAR VEHICLE (2004) HAS ONE OF THE HIGHEST INCIDENT RATES.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, IT WAS OBSERVED THAT THE DRIVER AND PASSENGER SIDE INNER ROCKER PANELS HAD SEVERE CORROSION, FAILED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE FRAME WAS CRACKED. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER (FORMULA FORD, 4318 MIDDLE RD, RUTLAND, VT, 05701) WHERE IT WAS CONFIRMED THAT THE FRAME WAS FRACTURED, BUT THEY WOULD NOT REPAIR THE VEHICLE. THE FRAME WAS REPAIRED. THE CONTACT GOT THE DEPARTMENT OF MOTOR VEHICLES INVOLVED; THEREFORE, THE DEALER PAID SOME OF THE REPAIR COST TO BE WELDED BY THE CONTACT'S INDEPENDENT PROFESSIONAL WELDER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,590.

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING THE VEHICLE, IT EXPERIENCED A COMPLETE LOSS OF POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN NUMBER: 07E066000 (EQUIPMENT). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

TL* THE CONTACT OWNS A 2004 FORD F-350 SD EQUIPPED WITH BF GOODRICH BAJA CHAMPION ALL TERRAIN (NA) TIRES, SIZE: FT285/75/R16 (NA). WHILE DRIVING 40 MPH, THERE WAS AN ABNORMALLY LOUD POPPING NOISE THAT CAME FROM THE LOWER PART OF THE VEHICLE. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SHOULDER, WHERE IT WAS WITNESSED THAT A REFLECTOR HAD LODGED ITSELF INTO THE REAR DRIVER SIDE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRE FAILED DUE TO IT BEING PUNCTURED AND WOULD NEED TO BE REPLACED. THE TIRE WAS REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 145,006 AND THE TIRE FAILURE MILEAGE WAS 60.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

WHILE APPLYING BRAKES IN AN ATTEMPT TO STOP, THE BRAKE PEDAL UNEXPECTEDLY WENT DIRECTLY TO THE FLOOR, THUS DISALLOWING THE TRUCK TO STOP. THE PEDAL WAS ABLE TO BE PUMPED,UP ENOUGH IN ORDER TO STOP THE TRUCK, BUT ONLY ONE TIME. ATTEMPTS TO PUMP THE PEDAL AND INCREASE THE PRESSURE ENOUGH FOR FUTURE ATTEMPTS AT STOPPING THE TRUCK WERE UNSUCCESSFUL. INSPECTION OF THE VEHICLE BY CERTIFIED MECHANICS REVEALED RUST BUILDUP ON/NEAR A WEAK SPOT ON ONE OF THE BRAIDED, FLEXIBLE FRONT BRAKE LINES WHICH HAD BURSTED, VIRTUALLY MAKING THE BRAKES USELESS BY DISALLOWING PRESSURE TO BE BUILT UP IN THE SYSTEM. A FURTHER INSPECTION OF THE SYSTEM REVEALED A SECOND BRAIDED, FLEXIBLE BRAKE LINE THAT WAS SHOWING SIGNS OF RUST BUILDUP AND EMINENT FAILURE. THE POINT OF FAILURE ON BOTH LINES WAS THE FLEXIBLE, BRAIDED SECTION ITSELF, JUST ADJACENT TO WHERE IT CONNECTED WITH THE PRE-MOLDED PORTION OF EACH LINE.

WHILE DRIVING ON THE HIGHWAY AT AROUND 55MPH, THE TRUCK STOPPED RUNNING WITH NO PRIOR WARNING OR ANY PRIOR ISSUE. AFTER IT SHUT OFF THE TRUCK WOULD CRANK BUT NOT START. INCIDENT WAS VERY UNSAFE AS THE VEHICLE SHUT OFF AT HIGHWAY SPEEDS.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY SHUT OFF AND ON SEVERAL OCCASIONS WOULD NOT START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE FUEL INJECTION CONTROL MODULE WIRE HARNESS NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER, WHO EXPLAINED THAT THE HARNESS WAS REPLACED IN 2005 UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE POWER STEERING FAILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2004 FORD F-350 SD. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE OIL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 161,000.

TL*THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT OIL WAS LEAKING FROM THE HEAD GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.

THE TRUCK STARTED TO STALL ON SEVERAL OCCASIONS AS I WAS ATTEMPTING TO GET UP TO ROAD SPEED OF 55 MPH. THE TRUCK WAS LOSING SPEED, JERKING AND BLACK SMOKE COMING OUT OF THE EXHAUST. THERE WERE NO INDICATIONS OF ENGINE FAILURE TO WARN ME OF ANY PROBLEMS, IE. ENGINE LIGHT. THIS OCCURRED ON MORE THAN ONCE, CAUSING POTENTIAL TRAFFIC HAZARD. THE CAM SENSOR AND FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE REPAIR COSTS INVOLVED WERE HIGH THANK GOODNESS THERE WERE NO INJURIES OR ACCIDENTS DUE TO THE STALLING. THANK YOU,

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37,237.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE ENGINE STALLED AND WAS ABLE TO RESTART. THE FAILURE OCCURRED ON FOUR OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.

VEHICLE WILL NOT START, CRANKS BUT DOES NOT START. DIAGNOSED AND REPLACED CAM POSITION SENSOR. *TR

TL- THE CONTACT CALLED PERTAINING TO A 2004 FORD F-350 SUPER DUTY COMPANY TRUCK. THE CONTACT STATED THAT WHILE PULLING INTO A PARKING SPACE THE VEHICLE STALLED. THE CONTACT HAD TO WAIT A BRIEF MOMENT AND WAS ABLE TO RESTART THE VEHICLE. THE CONTACT ALSO INDICATED THAT THE FAILURE RECURRED A SECOND TIME AND THE VEHICLE WAS NOT ABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO THE BUSINESS DUE TO THE FAILURE. AN INDEPENDENT MECHANIC WAS TO INSPECT AND DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE. DYD

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE AT A STOP, THE VEHICLE SURGED FORWARD. THE CONTACT ALSO STATED EXCESSIVE FORCE WAS APPLIED TO THE BRAKE PEDAL WHEN MAKING A STOP. IN ADDITION, THE VEHICLE STALLED ON MULTIPLE OCCASIONS. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT AN OIL CHANGE AND THE ICP SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 18,000. UPDATED 9/12/14*CN UPDATED 1/27/15 *JS

SHORTLY AFTER STARTING FROM A STOP THE VEHICLE LOST POWER AND HAD TO BE TOWED TO REPAIR SHOP. PROBLEM DIAGNOSED AND REPAIRED AS REPLACING THE PCM AND REFLASH OF THE ONBOARD COMPUTER. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD SUDDENLY HESITATE AND THE SPEED WOULD DECELERATE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE INJECTOR CONTROL PRESSURE SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THE EXHAUST SYSTEM WARNING LIGHT ILLUMINATED AND THE ENGINE LOSS POWER. THE VEHICLE RESTARTED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 07V139000 (POWER TRAIN). THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE EXHAUST SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

DRIVER WAS LEAVING BASE YARD WITH 2004 FORD F350 SD. WHILE DRIVING ON A SIDE STREET AT APPROXIMATELY 15 MPH, THERE WAS A TOTAL LOSS OF STEERING CONTROL THE VEHICLE CRASHED INTO A CHAIN LINK FENCE AS THE DRIVER WAS TRYING TO BRAKE TO A STOP. THE STEERING SECTOR SHAFT SHEARED OFF RIGHT AT THE PITMAN ARM.

WHILE DRIVING VEHICLE HAS INTERMITTENT LOSS OF POWER, DIAGNOSED AND SERVICED EGR VALVE, REPLACED EGR THROTTLE VALVE AND SEALED THE BOOST INLET TUBE. *TR

CHECK ENGINE LIGHT/NO POWER/HARD STARTING- REPLACED EXHAUST BACK PRESSURE SENSOR- VEHICLE FAILURE OF AMBULANCE RESPONDING TO A CALL. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350 SD EQUIPPED WITH MICHELIN LTX MS II TIRES SIZE LT235/85 R16. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SIDEWALLS WERE CRACKED. THE TIRES WERE TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE TIRES WERE REPLACED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 131,956 AND THE DOT WAS UNAVAILABLE.

VEHICLE HARD STARTING CAUSED BY FAILURE OF HIGH PRESSURE OIL PUMP, REPLACED ICP REGULATOR, REPLACED EGR VALVE AND INTAKE GASKETS. *TR

FOR UNKNOWN REASONS ON 12/20/13 AT 0030 HRS MY TRUCK CAUGHT ON FIRE AS IT SAT IN MY DRIVEWAY. I DROVE THE TRUCK LAST ON 12/14/13. THE FIRE STARTED IN THE ENGINE COMPARTMENT ON THE DRIVERS SIDE. I HAVE OWNED THE TRUCK FOR ABOUT 8 MONTHS AND IT HAD 105000 MILES ON IT WHEN I PURCHASED IT. THE FIRE DEPARTMENT ADVISED IT COULD BE DUE TO SOME TYPE OF ELECTRICAL ISSUE NEAR THE MASTER CYLINDER. I TOLD THEM THAT I HAVE NOT DONE ANY WORK UNDER THE HOOD IN MONTHS AND THAT WAS OIL/FILTER CHANGE. STILL UNDER INVESTIGATION. *TR

WHILE TRAVELING THROUGH TN, TOWING A TRAILER, THE FRONT DRIVER'S SIDE TIRE DELAMINATED AND BLEW. THIS CAUSED THE VEHICLE TO VEER ACROSS THE MERIDIAN AND ALMOST INTO ON-COMING TRAFFIC. THE DAMAGES INCLUDE THE RIM, FENDER, WHEEL WELL, FRONT BUMPER AND FAIRING. THIS IS A ESTIMATE, THE VEHICLE GOES INTO THE SHOP TOMORROW TO BE EVALUATED BY A MECHANIC AND RECEIVE REPAIRS. THIS IS A SIMILAR INCIDENT THAT OCCURRED IN MAY OF 2011, WHILE HAULING A 5TH WHEEL CAMPER TO AR, THE PASSENGER FRONT TIRE DELAMINATED WITHIN 3 HOURS OF STATING THE TRIP. THE TIRE DID NOT BLOW AND I WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. IT GOES WITHOUT SAYING THAT I WILL RESEARCH REPLACEMENT TIRES AND REMOVE THE OTHER 5 TIRES (DUALLY + SPARE). AS A SAFETY SPECIALIST/INVESTIGATOR, I ORIGINALLY THOUGHT THAT I HAD RECEIVED "RETREAD" TIRES ON MY VEHICLE WHEN I PURCHASED IT. AFTER READING THIS SECTION I SEE/FEEL THAT THIS IS MORE A CASE OF POOR DESIGN/WORKMANSHIP. *TR

TRUCK WITH 6.0L DIESEL ENGINE EXPERIENCES STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART THIS HAS HAPPENED ON SEVERAL OCCASIONS. *TR

TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, WHITE SMOKE EMITTED FROM THE TAIL PIPE AT AN ALARMING RATE AND ACCELERATION POWER WAS LOST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 65 MPH. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE AN INDEPENDENT MECHANIC PERFORMED A DIAGNOSTIC. THE FAILURE WAS LOCATED AT THE FUEL INJECTION PRESSURE SENSOR. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO EMIT HEAVY AMOUNTS OF SMOKE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT TWO FUEL INJECTORS, TWO OIL COOLERS, AND THE EGR VALVE WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 157,000.

I WAS LEAVING MY HOME WITH MY TRAVEL TRAILER FOR VACATION. I MADE IT TO THE FIRST TRAFFIC LIGHT AND HAD GREAT DIFFICULTY STOPPING THE VEHICLE. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, I NEEDED TO USE THE TRAILER BRAKES TO STOP. AFTER DRIVING VERY SLOWLY HOME I DIAGNOSED THE PROBLEM AS A FAULTY BRAKE LINE. THIS WAS NOT AN ORDINARY TYPE LINE, THIS WAS A STAINLESS STEEL LINE THAT HAD SOME TYPE OF SEALING DEVICE IN THE ENDS THAT FAILED. THERE ARE TWO MORE OF THE SAME TYPE LINES ON THE VEHICLE. I HAVE GREAT CONCERN THAT IF ONE OF THESE LINES FAILED WILL THE OTHER TWO FAIL? THIS COULD HAVE BEEN A HORRIFIC ACCIDENT HAD I NOT BEEN ABLE TO USE TRAILER BRAKES TO STOP THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,000. *TR

CRACKED HEAD, RESULTING IN COOLANT IN ENGINE OIL, HARD STARTING OR FAILURE TO START. *TR

CAM POSITION SENSOR FAILURE, VEHICLE WILL NOT START, FOUND COOLANT IN OIL ON REPAIR. *TR