2005 Ford F-350 Complaint Log

TL* THE CONTACT OWNS A 2005 FORD F350 SD. THE CONTACT STATED THAT WHEN ACCELERATING FROM A COMPLETE STOP, THE ENGINE POWER WAS SIGNIFICANTLY REDUCED AND THE VEHICLE RESPONDED AS THOUGH IT WERE GOING TO STALL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER EIGHT DIFFERENT TIMES FOR THE SIMILAR FAILURE AND REPAIRED YET THE FAILURE PERSISTED. A DIAGNOSTIC TEST WAS PERFORMED AND DETECTED TROUBLE CODES WITHIN THE ENGINE. MOST RECENTLY, THE EGR VALVE WAS REPLACED YET THE FAILURE PERSISTED AFTER THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE CONTINUOUS DEFECT BUT NO ASSISTANCE WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

SHIMMY IN THE FRONT END AFTER TRAVELING OVER BUMPY ROADWAY, CAUSING A TEMPORARY LOSS OF STEERING CONTROL. THE LOSS OF CONTROL CAUSED THE VEHICLE TO TRAVEL INTO THE ONCOMING LANE OF TRAFFIC. PRIMARILY OCCURS OVER 35 MPH. HAPPENED OVER 10 TO 15 TIMES SINCE THE VEHICLE WAS NEW. *TR

TL*THE CONTACT OWNS A 2005 FORD F350. THE MOTOR IN THE VEHICLE CONSTANTLY FAILS. WHILE TOWING A FIFTH WHEEL AT APPROXIMATELY 65 MPH, THE TURBO CHARGER BLEW OUT. THE DEALER INSTALLED A NEW TURBO CHARGER UNDER WARRANTY. APPROXIMATELY THREE MONTHS LATER, THE FAILURE RECURRED AND THE MOTOR OVERHEATED WHILE DRIVING APPROXIMATELY 65 MPH. THE VEHICLE WAS TOWED TO A LOCAL DEALER AND THEY TESTED THE MOTOR AND REPLACED TWO HEADS, THE OIL COOLER, AND THE EGR VALVE. THE MECHANIC ADVISED HIM TO NOT USE STRETCH VOLTS TO PREVENT THE FAILURE AGAIN. THE CONTACT WAS INFORMED THAT NON STRETCH VOLTS WOULD INCREASE THE CHANCES OF THE FAILURE NOT RECURRING BECAUSE IT WAS A BETTER PRODUCT THAN WHAT THE MANUFACTURER USED. THE CONTACT DID NOT WANT TO PAY ADDITIONAL MONEY FOR AN AFTERMARKET PRODUCT BECAUSE HE BELIEVED THAT THE PRODUCTS USED BY THE MANUFACTURER SHOULD WORK PROPERLY. AFTER THE REPAIRS WERE MADE, THE VEHICLE WORKED WELL FOR LESS THEN A MONTH. THE VEHICLE IS NOT CURRENTLY WORKING. HE ATTEMPTED TO TURN ON THE VEHICLE, BUT THERE WAS NO POWER TO THE MOTOR. THE VEHICLE WILL BE RETURNED TO THE SHOP FOR MORE REPAIRS. THE CONTACT FEELS THAT THIS IS A MANUFACTURER DEFECT THAT SHOULD BE RECALLED. THE FAILURE MILEAGE WAS 27,000 AND CURRENT MILEAGE WAS 30,000.

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT WOULD NOT BACK UP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE REVERSE CLUTCH RETAINER RING, THE REVERSE PISTON RETAINER RING, THE CLUTCH HOUSING, AND THE TRANSMISSION CASE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,726.

MY 2005 F350 6.0 DIESEL OVER HEATED, WAS TOLD BY FORD DEALER THAT THE EGR VALVE & EGR COOLER WENT OUT, THEY REPLACED UNDER WARRANTY. ONLY HAVE 56,963 MILES ON TRUCK. WAS ALSO TOLD THAT FORD HAS A LOT OF PROBLEMS WITH THIS. WHY DON'T THEY LET US KNOW ABOUT THIS OR HAVE A RECALL. I WAS ON A MOUNTAIN ROAD AND IT COULD HAVE CAUSED AN ACCIDENT WHEN I LOSS POWER. I'VE ALSO HAD THE NHTSA ACTION # EA08007 HAPPEN TO MY TRUCK 2 TIMES NOW. *TR

I WAS SLOWING DOWN TO A STOP LIGHT WHEN MY DRIVERSIDE REAR TIRE WAS SMOKING PROFUSELY. I STOPPED TO CHECK THE PROBLEM OUT AND THE REAR BRAKE WAS LOCKED UP. I SPOKE TO WORKERS AT THE FORD DEALERSHIP AND THEY TOLD ME THIS IS A NORMAL OCCURRENCE WITH THIS PARTICULAR MODEL TRUCK. I REPLACED THE DRIVERSIDE REAR CALIPER AND WENT ON MY WAY. TWO WEEKS LATER THE SAME THING HAPPENED TO THE PASSENGER SIDE REAR CALIPER. THE DEALERS I HAVE SPOKEN TO ONCE AGAIN SAID THIS IS A NORMAL OCCURRENCE AND THAT YOU ONLY GET ABOUT A YEAR OUT OF THE CALIPERS. AT OVER $250 A CALIPER THIS IS VERY EXPENSIVE. I DON'T TOW WITH MY VEHICLE OR ABUSE IT IN ANY WAY. I AM STRICT WITH MAINTAINING IT. *TR

TRUCK TENDS TO SHIMMY UNCONTROLLABLY AFTER HITTING BUMP 55 TO 70 MPH, WHEN THE TRUCK HAD 2500 MILES SHOCKS WERE REPLACED HELPED PROBLEM UNTIL 15,000 MILES RETURNED TO FORD. TSB FOR PROBLEM WAS TO INSTALL SHIMMY DAMPER ON LR OF TRUCK. NOT INSTALLED DUE TO CAMPER TIE DOWNS. PROBLEM CONTINUED TO GET WORSE, UNDRIVEABLE ABOVE 55 MPH AT 27,000 MILES. PROBLEM DOES NOT OCCUR WHEN HEAVILY LOADED ( CABOVER CAMPER) TIRE PRESSURE NOT A FACTOR LOADING IS. I ADDRESS THE PROBLEM AND THE SHIMMY WAS RELATED TO ONE PARTICULAR TIRE BEING MOUNTED ON THE FRONT. FURTHER INVESTIGATION REVEALED A BELT SEPARATION IN THE TIRE. ALL THE TIRES HAD SOME DEGREE OF BELT SEPARATION. REPLACED TIRES PROBLEM CURED SOMEWHAT. THE TRUCK STILL EXHIBITS THE TENDENCY TO SHIMMY ESPECIALLY WHEN LIGHTLY LOADED NO MATTER WHAT THE TIRE PRESSURE IS. I AM A ASE CERTIFIED MASTER TECH AND HAVE CURED 2 OTHER VEHICLES. ALL THREE VEHICLES STILL EXHIBIT THE SHIMMY TENDENCY BUT SELF DAMPEN WITH GOOD TIRES. ALL THREE VEHICLES HAD CONTINENTAL 275/70 18 TIRES OEM. THE SHIMMY TENDENCY SEEMS TO BE ENHANCED WITH THE CONTINENTAL TIRES FITTED AND GET WORSE WITH WEAR. THERE SEEMS TO BE A RESONANCE IN TRUCK FRONT SUSPENSION THAT GETS SYNCHRONIZED AS THE TIRES WEAR AND OR GET A BELT THAT IS NOT QUITE TRUE. THE VEHICLES WERE ALL 05 & NEWER F250 OR 350 4X4 SRW WITH THE 275/70 18 TIRES. ALL THREE VEHICLES HAVE BEEN MADE BETTER BY REPLACING THE CONTINENTALS WITH MICHELIN LTX AT 2 TIRES. THEY ALL STILL HAVE IDENTICAL CHARACTERISTICS AS FOLLOWS, TENDENCY TO SHIMMY BUT SELF DAMPEN WITH THE MICHELINS FITTED. ARE SENSITIVE TO FRONT AXLE LOAD, MORE WEIGHT ON THE AXLE LESS TENDENCY TO EXHIBIT THE TENDENCY TO SHIMMY, TIRE PRESSURE DOES NOT SEEM TO BE A FACTOR CONTRARY TO FORDS CAMPAIGN 09L02. I AM CONCERNED THIS CAMPAIGN ADVOCATES OVER INFLATING TIRES WITH LIGHT LOADS AS CURE FOR A VEHICLE OR TIRE DEFECT THAT NEEDS FURTHER INVESTIGATION. HAVE MORE OF A TENDENCY TO SHIMMY AS THE TIRES WEAR. *TR

I HAVE A 2005 FORD F350 SUPER DUTY, WITH DANGEROUS FRONT END PROBLEMS. WHEN GOING AT HIGHWAY SPEEDS (55-70MPH), AND HITTING A BUMP IN THE ROAD(EVEN WORSE WHILE GOING THROUGH A SLIGHT CURVE) THE FRONT END STARTS TO SHAKE VIOLENTLY. THIS OSCILLATION IS SO STRONG, THAT IT ALMOST YANKS THE STEERING WHEEL OUT OF MY HANDS. THE ONLY THING THAT MAKES IT STOP IS TO SLOW DOWN TO ABOUT 20MPH. VERY DANGEROUS TO DO ON THE INTERSTATE!!! AFTER DOING SOME RESEARCH AND READING SOME OF THE ONLINE FORUMS FOR FORD TRUCK OWNERS, I FIND THAT THIS IS A MAJOR PROBLEM AND ALSO A VERY COMMON ONE TO BOOT. THE MOST WORRISOME PART OF THIS PROBLEM, IS THAT IS VERY UNPREDICTABLE. SOMETIMES I CAN GO A MONTH OR SO WITH NO PROBLEMS. HOWEVER, THIS PAST WEEKEND, IT DID THIS THREE TIMES DURING A 10 MILE TRIP HOME FROM A RESTAURANT. THIS IS A MAJOR PROBLEM THAT FORD MOTOR CO. SHOULD BE RESPONSIBLE FOR CORRECTING. IF SOMETHING IS NOT DONE SOON MANY PEOPLE COULD GET HURT, AND GOD FORBID, BE KILLED. *TR

FORD F350 STEERING SHAKES TO THE POINT OF LOOSING CONTROL AT ABOUT 60 MPH ON ROUGH UNEVEN FREEWAY OR HITTING POT HOLE. *TR

WHILE DRIVING ON THE HIGHWAY PULLING A TRAILER MY 2005 F -350 DIESEL QUIT RUNNING AND ALMOST GOT RUN OVER BY A SEMI. AFTER PULLING OFF TO THE SIDE OF THE ROAD AND RESTARTED THE TRUCK IT RAN ROUGH. WAS ABLE TO GET IT BACK TO THE SHOP WITH THE HAZARDS ON. TO FIND OUT FROM THE DEALER THAT THE FUEL TANK IS DELAMINATING WHICH CAUSE DEBRIS TO GET INTO THE FUEL PUMP AND INJECTORS CAUSING IT TO STALL. FORD HAS KNOW ABOUT THIS PROBLEM AND THEY CHANGE THERE FUEL TANK DESIGN BUT DID NOT INFORM ANY OWNERS OF THIS SAFETY DEFECT THAT COULD HAVE KILLED ME. NOW I AM ALSO LOOKING AT A $3000. REPAIR BILL THAT FORD WILL NOT BACK ME ON. TO REPLACE THE FUEL TANK WITH A NEW SAFE ONE. I AM ALSO LOOKING AT MY OTHER TWO TRUCKS AND WONDER IF THEY ARE SAFE TO DRIVE. I HOPE THAT NO ONE WILL GET KILLED DUE TO THIS LACK OF PUBLIC INFORMATION BY FORD. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK SO VIOLENTLY THAT HE LOST CONTROL. WHILE DRIVING 65 MPH, HE WAS INCAPABLE OF CONTROLLING THE STEERING. IT WOULD MOVE FROM LEFT TO RIGHT AND HE UNSUCCESSFULLY COMPENSATED FOR THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER TWICE, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE DEALER STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 95,000 AND FAILURE MILEAGE WAS APPROXIMATELY 93,000.

WHILE DRIVING AT HIGHWAY SPEED (65-70 MPH) I HIT A POTHOLE OR BUMP THE WHOLE FRONT END OF THE TRUCK (2005 FORD F-350) STARTED TO SHAKE VIOLENTLY. I HAD TO SLOW DOWN TO 50 MPH WHERE THE SHAKING STOPPED. I WAS ALMOST REAR ENDED BY A SEMI BECAUSE OF MY SUDDEN DECELERATION. THIS HAS HAPPENED 4 TIMES. *TR

TL* THE CONTACT OWNS A FORD 2005 F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD MAKE A LOUD SQUEAKING NOISE WHENEVER THE BRAKES WERE APPLIED, AND SHE WOULD ALSO SMELL A BURNING ODOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A BRAKE CALIPER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTUER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGES WERE 18,413 AND THE CURRENT MILEAGE WAS 38,156.

THIS IS A DESIGN ISSUE. THE 2005 FORD F350 HAS A LARGE PART OF ITS REAR BUMPERS' HORIZONTAL SURFACE REMOVED. THE BUMPER IS THEN COVERED IN A HARD PLASTIC. I STEPPED OFF THE DECK OF MY TRUCK ONTO THE BUMPER AND THE PLASTIC SURFACE GAVE WAY. I ALMOST BROKE MY ANKLE AND LOST MY BALANCE , NOT BECAUSE THE PLASTIC BROKE THROUGH , IT JUST HAD WAY TOO MUCH FLEX IN IT. I'VE TRIED TO DEAL WITH FORD CO REGARDING THIS BUT AS YOU PROBABLY KNOW ,THEY WANT ZERO TO DO WITH THE RETAIL / POST WHOLESALE APPARATUS. I WAS TOLD TO TALK TO THE DEALER. I WOULD HAVE MORE COMPETENCE AND HONEST FEEDBACK FROM MY DOG. *TR

1. TRYING TO SHIFT TRUCK INTO 4X4 LOW 2. THE TRUCK WILL NOT SHIFT INTO 4X4 LOW. THERE IS A "SHIFT ON THE FLY" KNOB ON THE DASH AND YOU CAN SHIFT TRUCK INTO 4X4 HIGH, OR 4X4 LOW. IT WILL SHIFT INTO 4X4 HIGH BUT NOT 4X4 LOW. 3. I HAVE TAKEN THE TRUCK INTO THE DEALERSHIP TO ADDRESS THE PROBLEM. THEY VERIFIED THE PROBLEM BUT COULD NOT FIX. *TR

1. DRIVING 2. CRUISE CONTROL DOES NOT DISENGAGE WHEN BRAKE IS APPLIED. IN FACT, WHEN BRAKE IS APPLIED, THE TRUCK TRIES TO COMPENSATE FOR REDUCED SPEED BY DOWNSHIFTING AND ACCELERATING. I HAVE HAD IT HAPPEN TWICE WHERE IT NEARLY CAUSED ME TO HIT THE VEHICLE IN FRONT OF ME. THE DEALERSHIP VERIFIED THE PROBLEM BUT COULD NOT FIX IT. THEY SENT ME AWAY WITH THE PROBLEM STILL OCCURRING AND IT IS SO DANGEROUS THAT I DO NOT USE CRUISE CONTROL AT ALL. 3. DEALERSHIP ATTEMPTED TO ADDRESS THE PROBLEM BUT COULDN'T FIX IT. THEY VERIFIED THE PROBLEM AND DOCUMENTED IT IN MY FILE WITH THEM. *TR

2005 FORD F-350 DEVELOPS SEVER VIBRATION AND THE OSCILLATION OF THE STEERING WHEEL CAUSES SEVERE STEERING DIFFICULTY. THIS PROBLEM DOES NOT DISSIPATE UNTIL SPEED IS REDUCED TO APPROXIMATELY 40 MPH. OBVIOUSLY THIS IS VERY DANGEROUS ON A FAST MOVING FREEWAY WHERE SPEEDS CAN EXCEED 70 MPH. THE CONDITION IS ADDRESSED IN LITERATURE PROGRAM 09L02 LETTER DATED NOVEMBER 2011. THE VEHICLE HAS BEEN CHECKED AFTER AN EVENT AND THE TECHNICIAN HAS NEVER DISCOVERED A DEFICIENCY THAT HE CAN ATTRIBUTE TO THIS MALFUNCTION. THE TECHNICIAN HAS CHECKED ALL SUSPENSION, STEERING AND TIRE RELATED ITEMS. THE TIRES THAT ARE ON THE TRUCKS ARE LOAD RANGE E TIRES AND ARE PROPERLY INFLATED TO THE MAXIMUM PRESSURE PER THE MANUFACTURERS (BIG O) SPECIFICATIONS. ALL SUSPENSION AND STEERING PART ARE FACTORY INSTALLED OR OEM PARTS AND THE SHOCK ABSORBERS ARE HEAVY DUTY. *KB

I HAVE A FORD F350 KING RANCH 2005 AND IT WOBBLES VIOLENTLY AFTER HITTING A BUMP OR UNEVEN PATCH. IT DOES IT ABOVE 40 MPH. DEALER HAD ME PURCHASE A STABILIZER AND THEY PUT IT ON- IT HELPED BUT DIDN'T SOLVE IT. I JUST DRIVE THE TRUCK WHEN I NEED. I TOOK IT IN 6 MONTHS LATER AND THEY SAID THEY MUST INVESTIGATE BY DEDUCTION. THEY WANTED TO CHARGE ME TO FIRST DO A BALANCE, THEN A WHEEL ALIGNMENT. I TOLD THEM NO- IT SHOULD BE A RECALL. MY FEAR IS THAT THE VIOLENT WOBBLE WILL LEAD TO OTHER PROBLEMS. HELP. *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SD. WHILE DRIVING 65 MPH, THE CONTACT LOST CONTROL OF THE STEERING AND THE VEHICLE SWERVED ALL OVER THE ROAD. WHEN DRIVING OVER ROUGH PAVEMENT, A BRIDGE EXPANSION, OR A SLIGHT BUMP, THE STEERING WORSENS. HE HAS TAKEN THE VEHICLE TO THE DEALER FOUR TIMES AND WAS INFORMED THAT THE TIRES NEEDED TO BE ROTATED, THE BUSHING NEEDED TO BE CHANGED, AND THE TIRE PRESSURE WAS INCORRECT. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 36,674 AND FAILURE MILEAGE WAS 10,000. THE ENGINE LIGHT ILLUMINATED. UPDATED 02-12-08 *BF

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY. THE ENGINE MUST BE TURNED OFF IN ORDER FOR THE VEHICLE TO STOP SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES AND THEY REPLACED THE SWAY BAR. THE FAILURE CONTINUED AND THE DEALER STATED THAT THEY COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER IS AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000 AND CURRENT MILEAGE WAS 83,000.

THE F350SD HAS A SHIMMY WHEN YOU HIT A DIP IN THE ROAD OR A BUMP. THIS IS VIOLENT ENOUGH FOR CONCERN THAT IT'LL CAUSE AN ACCIDENT. IT DOESN'T GO AWAY ON IT'S OWN YOU HAVE TO COME TO A STOP OR GET TO ABOUT FIVE MILES AN HOUR FOR IT TO RESET. THIS HAS HAPPENED MULTIPLE TIMES. I HAVE HAD THE LOCAL FRONT END SHOP REPLACE THE FRONT STEERING COMPONENTS, EVEN THOUGH THE COMPONENTS CAME WITH IN SPEC THAT FORD SAYS IS SAFE AND CORRECTIVE ACTION NEEDS BE TAKEN. THIS HELPED FOR ABOUT 10 MONTHS BUT NOW I'M BACK TO THE SAME OLD PROBLEM. FORD SAYS TO TAKE IT TO A FORD AUTHORIZED DEALER AND HAVE THEM CHECK IT OUT. I'LL DO IT ONE MORE TIME, THIS IS REPETITIVE, THEY DON'T SEE A PROBLEM IN THEIR PRODUCT SO WHY AM I WASTING MY TIME. EVERYBODY SAYS ITS YOUR TIRE PRESSURE, WRONG, I RUN IT AT MAX AND I'VE EVEN TRIED RUNNING IT FIVE POUNDS HIGHER THAN RECOMMENDED. WOULD SOMEONE PLEASE HELP US AND GET THIS FIXED RIGHT. I KNOW FORD WONT EVER ACKNOWLEDGE THAT THERE IS A PROBLEM FOR THE CHANCE OF A LAWSUIT. SO I GUESS IT'S UP TO THE HIGHWAY SAFETY COUNCIL TO HELP. I'LL GIVE ALL OF YOU A RIDE AND SHOW YOU HOW BAD IT IS. AND THEN I CAN GIVE YOU ALL THE DOCUMENTS SHOWING FORD SAYS THE FRONT END ARE WITHIN SPEC. YOU KNOW ITS BAD WHEN IT SHIMMIES YOU OFF THE ROAD, THIS IS AS BEST YOU CAN DO TO AVOID AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350 DIESEL. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART DESPITE THE ATTEMPTS OF THE CONTACT AND WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THE FUEL TANK WAS DELAMINATED AND THE INTERIOR PAINT HAD CLOGGED THE ENGINE. THE DEALER REPLACED THE FUEL TANK, FUEL FILTERS AND SEVERAL FUEL INJECTORS DECEMBER 2007. THE FAILURE RECURRED MARCH 2011 AND THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL TANK WAS RUSTED FROM THE INSIDE OUT AND THE FUEL TANK, FUEL PUMP, FUEL FILTERS, FUEL INJECTORS, AND EGR VALVE WERE REPLACED AT A COST OF $4,200. THE CONTACT THEN CONTACTED THE MANUFACTURER AND FILED A COMPLAINT REGARDING THE FAILURE BUT NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 46,000. UPDATED 06/01/11*LJ UPDATED 06/02/11

WHEN DRIVING ON UNEVEN PAVEMENT OR DRIVING OVER CHUCK HOLES AND PARTICULARLY WHEN MANEUVERING TURNS, THE FRONT END "HOPS" SEVERELY CAUSING THE DRIVER TO ALMOST LOSE CONTROL AND SKID SIDEWAYS. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 45 MPH, THE VEHICLE WOBBLED. THE STEERING VEERED TO THE LEFT WHEN THE WHEEL WAS TURNED TO THE RIGHT AND VICE VERSA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT TIE RODS, FRONT STABILIZER BARS, GEAR BOX, AND MULTIPLE PARTS ON THE FRONT OF THE VEHICLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INJECTORS, CAM SHAFT SENSOR, AND THE WIRING HARNESS FOR THE INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000.

OSCILLATION OF FRONT SUSPENSION. MY 2005 F350 HAVE BEEN IN FOR REPAIRS SEVERAL TIMES BOTH BY THE DEALER UNDER WARRANTY AND SINCE BY OTHER VEHICLE SERVICE AGENCIES. IT CONTINUES TO GIVE ME PROBLEMS AND AT ITS WORSE, CAUSED THE VEHICLE TO MOVE SIDEWAYS SLIGHTLY INTO THE NEXT LANE. BASICALLY I HAVE BEEN TOLD THAT ?THIS IS NORMAL? *TR

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 65 MPH, THE VEHICLE SHUT OFF AND THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER AND IT WAS TOWED TO THE DEALER. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT COULD NOT WAIT FOR THE WORK TO BE PERFORMED ON THE VEHICLE AND TRADED IT IN FOR A 2008 MODEL. THE CURRENT AND FAILURE MILEAGES WERE 20,392. UPDATED 12/18/07 *TR

I HAVE 2005 FORD F350 6.0L DIESEL. TRUCK STALLS ON THE ROAD AND WILL NOT RESTART. I HAD TRUCK TOWED TO FEDUKE FORD 3 TIMES. WILL NOT FIX BECAUSE THEY CAN'T DUPLICATE PROBLEM. ALMOST HAD SERIOUS CRASH WHEN STALLED, TRACTOR TRAILER ALMOST TOOK ME AND FAMILY OUT. FORD HAD RECALL FOR THIS DEFECT. RECALL#-05S34.NHTSA#-05V270000 I CALLED FORD AND THEY TOLD ME MY VIN# WAS NOT INCLUDED IN RECALL,I TOLD THEM MY TRUCK HAS SAME ISSUE AS RECALL. I NEED HELP. *JB

TL*THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING 40-60 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT STATED THAT HE WAS UNABLE TO RESTART THE VEHICLE AND HAD IT TOWED TO THE DEALER. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. AS OF JANUARY 2, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THERE IS A RECALL FOR THE ELECTRICAL SYSTEM: WIRING (NHTSA CAMPAIGN ID # 05V270000) HOWEVER, THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 37,000 AND CURRENT MILEAGE WAS 38,757.

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE VEHICLE LOSES POWER INTERMITTENTLY AND WITHOUT WARNING. THE VEHICLE STALLS WHILE ACCELERATING AND DECELERATING. ONCE IT LOSES POWER, THE VEHICLE IS ABLE TO BE RESTARTED. THE FAILURE OCCURS AT SPEEDS BETWEEN 30 AND 60 MPH. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY CANNOT FIND ANYTHING WRONG. THE CONTACT STATED THAT THE FAILURE OCCURS APPROXIMATELY 20-30 TIMES PER DAY AND IS PROGRESSIVELY GETTING WORSE. THE CURRENT MILEAGE WAS 127,058 AND THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 01-14-08. *KB UPDATED12/12/07. *JB

WE HAVE A 2005 FORD F350 SUPER DUTY. ON VACATION IN SEPTEMBER 2007, WE HAD 2 VALVE STEMS FAIL FROM CRACKS WHICH CAUSED FLAT TIRES. THE FIRST WAS AS THE TRUCK WAS PARKED. THE SECOND FAILED AS WE WERE ON THE INTERSTATE DOING ABOUT 60 MILES PER HOUR. WE HEARD IT BLOW AND GOT PULLED OVER WITH NO PROBLEM. WE HAD BOTH VALVE STEMS REPLACED AND DISCOVERED THAT A THIRD ONE WAS ALSO CRACKED. WE SUBSEQUENTLY REPLACED ALL FIVE VALVE STEMS WITH METAL STEMS. *TR

3RD TIME IN LESS THAN A MONTH....WOULD NOT START????? STRANDED FOR 12 HOURS, TOWED 30 MILES TO DEALERSHIP AND PAYING AGAIN FOR A HOTEL AND CAR RENTAL.... *TR

2ND TIME WAS WHITE SMOKE COMING OUT EXHAUST, THEN IT OVERHEATED AND OIL WAS MIXED WITH ANTIFREEZE, STRANDED FOR 5 HOURS, TOWED 18 MILES TO NEAREST FORD DEALERSHIP, COST US 4 DAYS IN A HOTEL. *TR

I HAVE A 2005 FORD 350 SUPERDUTY 6.0 DIESEL TRUCK. I PULL A LARGE 5TH WHEEL UNIT. IT IS WITHIN THE WEIGHT RANGE INDICATED BY FORD. I HAVE INSTALLED A THERMOCOUPLE GAUGE TO MONITOR THE ENGINE EXHAUST TEMPERATURE. I WAS TOLD BY FORD DEALER THAT THE NORMAL EXHAUST GAS TEMPERATURE (EGT) SHOULD BE BETWEEN 750 AND 900 WHILE PULLING THE UNIT. UNDER A NOMINAL HILL CLIMB, I NOTED THE EGT NEVER GOT BELOW 1000, EVEN WHEN THE TRANSMISSION SHIFTED TO A LOWER GEAR. IT WAS HARD KEEPING THE EGT UNDER 1400. I HAD TO TRAVEL AT 55 MPH AND IN 4TH GEAR TO MAINTAIN THE 1000 DEGREE TEMPERATURE BOOST WAS BETWEEN 24 AND 28 PSI. NEAR THE TOP OF A CLIMB, THE TURBO HOSE BLEW. THE DEALER SAID IT WAS A DIRTY GATE VALVE OR DIRT IN THE VANES OF THE TURBO. DURING THE VACATION THEY REPLACED THE GATE VALVE AND THE TURBO. AFTER VACATION AND WITHOUT THE 5TH WHEEL ATTACHED, I NOTED THE EGT, UNDER NORMAL STREET DRIVING, RUNS AT 800 TO 1000 DEGREES. IF THIS IS AN INDICATION OF THE ENGINE/TURBO DESIGN, THIS ENGINE IS DOOMED TO FAIL. I BELIEVE FORD SHOULD HAVE KNOWN THESE ISSUES BEFORE THEY SOLD THESE TRUCKS. I KNOW THE TURBO WILL FAIL AGAIN. IF THERE IS RECOURSE, I WOULD LIKE TO KNOW. *JB

TL*THE CONTACT OWNS A 2005 FORD F 350 SUPER DUTY. WHILE DRIVING 65 MPH THE VEHICLE AND STEERING WHEEL WOULD SHAKE VIOLENTLY WHEN GOING OVER A BUMP. THE CONTACT WAS CONCERNED ABOUT LOSING CONTROL OF THE VEHICLE. THE DEALER STATED THAT THERE WAS A DESIGN FLAW WITH THE VEHICLE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 17,600.

TL-THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 55 MPH, THE RUBBER BEGAN TO SEPARATE FROM THE TIRES WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE VEHICLE WAS CONSTANTLY PULLING. THE DEALER PERFORMED AN ALIGNMENT ON THE VEHICLE. NO TIRE INFORMATION WAS AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

FIRST TIME TRUCK QUIT ON NORTH I-25, WE WERE DRIVING AND THE TRUCK JUST QUIT, WOULD NOT RECRANK, STRANDED ON THE SIDE OF THE ROAD FOR 8 HOURS, FINALLY A TOW TRUCK TOWED US 80 MILES TO THE NEAREST FORD DEALERSHIP, WE PAID A TOWING BILL OF $250 ALSO 2 DAYS IN THE HOTEL. *TR

DRIVING STRAIGHT ON A HIGHWAY AT 55 MPH WHEN AFTER HITTING A SMALL BUMP IN THE ROAD THE FRONT TIRES SHOOK UNCONTROLLABLY. THIS CAUSED THE TRUCK TO SHIFT LANES AND NEARLY HIT ANOTHER CAR. THE SHAKING WOULDN'T STOP UNTIL THE TRUCK SLOWED DOWN. TOOK 2 HAND STRUGGLING WITH THE STEERING WHEEL TO KEEP THE TRUCK UNDER CONTROL. THIS HAS HAPPENED NUMEROUS TIMES AND IS EXTREMELY DANGEROUS. TODAY THE TRUCK IS STILL TOTALLY STOCK WITH 33500 MILES. PLEASE HAVE FORD ISSUE A RECALL! *TR

REPEATED BRAKE CALIPER PROBLEMS. BRAKE PADS LOCK IN ON POSITION WHILE CALIPER RELEASES. RESULT IS THAT ONE BRAKE PAD IN A SET WILL QUICKLY BECOME WORN WHILE OTHER PAD IS LIKE NEW. FAILURE RESULTS WHEN LOCKED PAD IS UNDETECTED, THEN CALIPER, ROTOR AND BRAKE LINE DAMAGE RESULT. THIS HAS OCCURRED ON 3 SEPERATE INSTANCES AND ON SEPERATE WHEELS. FORD HAS PAID FOR ONE REAR CALIPER, FRONT ROTORS.THIS PROBLEM BEGAN ON OR BEFORE 16,000 MILES. VEHICLE HAS BEEN SERVICED AND REPAIRED AT FORD GARAGES ONLY. THIS VEHICLE IS NOT A SEVERE DUTY TRUCK, HAS A TOW HAUL PACKAGE. FURTHER: IMMEDIATELY, AFTER ONE REPAIR ABS LITE CAME ON AND BRAKES WENT TO FLOOR. ABS STAYED ON FOR 10 MINUTES AND THEN WHEN BRAKES WERE PUMPED THEY WENT OUT AND BRAKE RETURNED. IMMEDIATE THOUGHT WAS THAT ABS MALFUNCTION WAS DUE TO BRAKE REPAIR AND CORRECT AND THAT IT WAS A TEMPORARY PROBLEM. FRONT BRAKE PADS DID HOWEVER MALFUCTION WITHIN 400 MILES OF THIS INCIDENT. FROM THE BEGINNING THIS TRUCK HAS HAD AN OCCASIONAL SPONGEY BRAKE PROBLEM. INCIDENT DATE IS THE LAST DATE NOTED. FIRST DATE OCCURRED 02/30/07. INCIDENT DATE OF THIS REPORT REFLECTS LAST TO DATE INCIDENT.

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 65 MPH, THE VEHICLE OVERHEATED AND SMOKE POURED FROM THE EXHAUST PIPE. THE VEHICLE WAS PULLED OVER AND WOULD NOT EXCEED 30 MPH. THE VEHICLE THEN LOST POWER. THERE WERE NO WARNING INDICATORS. THE AROMA OF ANTIFREEZE WAS POTENT. THE CONTACT TOOK THE VEHICLE TO THE DEALER THE FOLLOWING DAY. THE VEHICLE HAS BEEN TO THE DEALER SEVEN PREVIOUS TIMES FOR THE SAME FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 56,000.

TURBO PIPE BLEW OFF GOING UPHILL TOWING A HORSE IN TRAILER, LOST MOST OF MY POWER, SPEED DROPPED TO 40 MPH WITH TRUCKS BEARING DOWN. PUT CLAMP BACK ON DID IT AGAIN 50 MILES LATER. DEALERSHIP TOLD ME RUST FORMED INSIDE TURBO IF I DID NOT DRIVE IT HARD OR CORRECTLY. I DID'NT THINK I BOUGHT A TRUCK WITH INSTRUCTIONS HOW TO RIVE IT !*AK

(1) TRUCK WOULD NOT START (2) POTENTIAL OF TRAVELING AND FUEL PUMP STOPS PROVIDING FUEL TO MOTOR; POTENTIAL TO LOOSE CONTROL OF VECHICLE (3) HIGH PRESSURE (R&R IPR SENSOR,FLEX PIPE AN DCONNECTOR) WAS REPLACED

I HAVE A 2005 FORD F350 SUPERDUTY AND ON SEVERAL OCCASIONS I HAVE BEEN DRIVING DOWN THE ROAD AND HAVE GONE OVER BLEMISHES IN THE HIGHWAY AND IT HAS CAUSED A VIOLENT SHAKING IN THE FRONT END. IT HAS GOTTEN SO BAD AT POINTS THAT IT ALMOST CAUSED A SEVERE ACCIDENT WHICH MIGHT HAVE INVOLVED MANY. THIS HAS HAPPENED ON MANY OCCASIONS AND I HAVE TO SLOW DOWN AND STOP BEFORE IT SUBSIDES. I HAVE BEEN TO SEVERAL DEALERS AND THEY ALL SAY THAT THEY HAVE A QUICK FIX BUT NOTHING SEEMS TO WORK. EVERYTIME I HAVE TRIED TO FIX THE PROBLEM I HAVE PAID FOR IT OUT OF MY OWN POCKET. I HAVE SPOEKN WITH MANY FOR SUPERDUTY OWNERS THAT HAVE HAD THIS PROBLEM AND THEY ALL SAY THE SAME THING. THIS IS NOT ONLY A PROBLEM FOR THE DRIVER OF THE VEHICLE BUT ALSO FOR OTHERS ON THE ROAD AS WELL. DO PEOPLE NEED TO START DYING BEFORE THERE IS A SERVICE RECALL TO FIX THE PROBLEM. FORD DIDN'T START REPLACING TIRES ON TRUCKS AND SUV'S BEFORE SO MANY PEOPLE DIED IN CARE CRASHES. THIS IS A SEVERE PROBLEM AND NEEDS TO BE ADDRESSED. THERE SHOULD BE NO CALL FOR PAYING FOR AND BEING FINANCIALLY LOCKED INTO A $50,000 VEHICLE THAT COULD BE CONSIDERED A DEATH TRAP. THIS PROBLEM EXISTS IN ALL MODELS OF THE FORD SUPERDUTY AND FORD STILL PRODUCES THESE AND SELLS THEM TO CONSUMERS AND DOESN'T FIX THEM.

05 AND 06 FORD F350 AMBULANCE BRAKE CALIBER PISTONS BREAK OR CRACK AND HOLD PISTON OUT MAKING BRAKES UNABLE TO FULLY RELEASE, BOTH OUR 05 HAVE HAVE DONE IT ONE ON ALL FOUR WHEEL AND THE OTHER JUST THE FRONTS SO FAR AND NOW OUR 06 HAS THE FRONTS ON BOTH SIDES TOLAL OF THREE OF THE FOUR PISTONS BROKE

WE OWN A FORD F350, 2005 MODEL WITH ABOUT 6000 MILES. ON SUN.,3/4, AS MY WIFE DROVE AWAY FROM A SERVICE STATION PUMP, SHE LOST CONTROL OF THE TRUCK, I.E. SHE COULD NOT STEER. LUCKY FOR HER SHE WAS ABLE TO STOP BEFORE ENTERING A HEAVILY TRAVELED HIGHWAY. WE FOUND THAT THE NUT HOLDING THE PIVOT ARM WITH THE STEERING LINKAGE HAD SHEARED OFF ALONG WITH THE COTTER PIN HOLDING THE NUT. THE NUT THREADS WERE STRIPPED OFF. I HAVE THE FAILED NUT ALONG WITH RING/CLIP HOLDING THE COTTER PIN. THE BOLT THREADS ON THE LINKAGE, TO THE EYE APPEAR TO BE O'K. AS STATED THOUGH, THE NUT THREADS WERE STRIPPED OFF. WAS THIS DUE TO A SOFTER METAL BEING USED, OVER TORQUING OR A BAD NUT??' THE TRUCK WAS TOWED TO NEWBERG FORD IN NEWBERG, OR. *JB

VEHICLE HAS ENGINE FAILURE THE REPAIR HAS BEEN ATTEMPTED FOUR TIMES AND VEHICLE CONTINUES IN ITS SAME STAGE.. *JB

TL*THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 55 MPH OVER A BUMP, THE FRONT END OF THE VEHICLE WOULD SHAKE VIOLENTLY. THE CONTACT ASKED THE DEALER ABOUT THE FRONT END SHAKE AND THE DEALER STATED THEY'VE NEVER HEARD OF THIS ISSUE. TWO OTHER DEALERS INFORMED THE CONTACT THAT VEHICLE NEEDED TO HAVE THE TIRES REPLACED. THE CONTACT REPLACED THE TIRES AND THE VIOLENT SHAKING STILL OCCURRED WHENEVER THE CONTACT DROVE OVER A BUMP AT HIGHWAY SPEEDS. THE FAILURE MILEAGE WAS 19,000.

TL* - WHEN CONTACTWAS DRIVING AND GOING OVER A SERIES OF SMALL BUMPS LOST CONTROL OF THE STEERING WHEEL WHICH WENT FROM RIGHT TO LEFT QUICKLY TO THE POINT OF BEING ALMOST UNCONTROLLABLE. IN ORDER FOR CONTACT TO GET CONTROL OF THE STEERING WHEEL SHE HAD TO SLOW THE VEHICLE DOWN TO A SPEED OF 5 MPH OR COME TO A COMPLETE STOP. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP ,AND THEY STATED THAT THEY NOTICED THE SAME INCIDENT AS WELL ON A TEST DRIVE OF THE VEHICLE, BUT THEY COULD NOT DO ANYTHING ABOUT THE INCIDENT BECAUSE THE MANUFACTURER HASN'T GIVING THE DEALERSHIP ANY ADVISE ON HOW TO FIX THE FAILURE.*AK

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD OFTEN FAIL TO START AND ONCE STARTED, BLACK SMOKE WOULD EMIT FROM THE EXHAUST PIPE AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE PROBLEM BUT REPLACED THE FUEL INJECTION CONTROL MODULE AND FUEL INJECTOR NUMBER FOUR BUT TO NO AVAIL. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED THAT THE SHORT BLOCK WAS CRACKED. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL AND FRONT END OF THE VEHICLE STARTED TO SHAKE. THE CONTACT RELEASED THE ACCELERATOR PEDAL AND THE SHAKING BECAME MORE EXTREME. AFTER DEPRESSING THE BRAKES, THE VEHICLE WAS MOVED OFF THE ROADWAY AND THE CONTACT INSPECTED THE VEHICLE. THE CONTACT FOUND NOTHING LOOSE OR HANGING. THE VEHICLE WAS THEN TAKEN TO A DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PERFORMING NORMALLY WHEN DRIVING AT HIGHWAY SPEEDS. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE CURRENT MILEAGE WAS APPROXIMATELY 62,000. THE VIN WAS UNAVAILABLE.

WHILE VEHICLE WAS PARKED IN MY DRIVEWAY, LEVEL GROUND, PUSHED ON BRAKE PEDAL TO PUT VEHICLE IN GEAR. BRAKE PEDAL FELT SPONGY, PUSHED ON IT AGAIN, BANG, RIGHT TO THE FLOOR. THERE THE PEDAL STUCK, UP AGAINST THE FLOORBOARD. UPON INVESTIGATION, FOUND THAT THE PORTION OF THE MASTER CYLINDER THAT THE PLUNGER BOLTS ONTO, BROKE AWAY. THE PLUNGER BOLTS TO THE MASTER CYLINDER IN TWO PLACES. BOTH BOLT HOLES BROKE AWAY FROM THE CASTING. THE CASTING LOOKS FAULTY, NO FRESH BREAK LOOK TO IT AT ALL. THE VEHICLE HAS 43000 MILES ON IT. BRAKES HAVE NOT BEEN DONE YET, STILL ROUGHLY 50% PAD WEAR. MORE OF A DAILY DRIVER UNIT, THAN A HEAVY PULLER. I'M JUST GLAD THAT I WASN'T DRIVING DOWN THE HIGHWAY OR PULLING MY HOLIDAY TRAILER, WHEN THIS OCCURED. WHO KNOWS WHAT WOULD HAVE HAPPENED! I FEEL THIS IS A MAJOR SAFETY ISSUE. IS IT A RARE CASE OR ARE THERE OTHER FAULTY MASTER CYLINDERS OUT THERE. SOMEONE BETTER LOOK INTO THIS BEFORE THERE ARE ACCIDENTS OR EVEN CASULTIES.