2006 Ford F-350 Steering Problems

The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower speed to allow the shimmy to self-correct. There was no warning illuminated. The contact had taken the vehicle to an independent mechanic to be diagnosed; however, no cause for the failure was found and the failure was not duplicated. The vehicle was not repaired. The mechanic checked for recalls related to the failure and advised the contact that the manufacturer had issued a recall for the failure (09L02) for severe steering wheel and front wheel vibrations. The manufacturer was not informed of the failure. The failure mileage was approximately 265,000.

My truck experiences what I have learned is called the death wobble. The condition occurs intermittently but usually at speeds above 50mph and seems to be initiated by hitting any small bump. The whole front end shakes violently like the tires have been half filled with lead causing them to rotate wildly out of round. The truck actually bounces up and down rapidly and the steering wheel shakes violently creating a very unsafe driving circumstance. My research into this issue uncovered that this is a well-known condition that has been reported multiple times by many different Ford truck owners and that it occurs on Ford trucks of various year make and model. I also am aware of Fords service letter 09L02 advising owners to maintain proper air pressure to combat the issue. It is my opinion that Fords efforts to address this issue are woefully inadequate and the NHTSA has allowed this manufacturer to produce and provide an unsafe vehicle to the public for way to long. This is a hazardous condition that needs to be properly addressed.

MY 2016 F350 SUPER DUTY 4WD DISESAL HAS A DEATH WOBBLE WITH ONLY 46,OOO MILES. THE DEALERSHIP AT SEMINOLE FORD, SEMINOLE OKLAHOMA 405-382-2222 TOLD ME I WOULD HAVE TO PAY 1200 TO FIX THIS. I WAS DRIVING 70MPH ON THE HIGHWAY YESTERDAY AND MY VEHICLE WENT OUT OF CONTROL ALMOST CAUSING ME TO WRECK. I IMMEDIATELY SCHEDULED AN APPOINTMENT WITH THE DEALERSHIP. I WILL FORWARD THE BILL WHEN I RECEIVE IT. THIS IS A SAFETY HAZARD AND A FACTORY DEFECT THAT I SHOULD NOT BE RESPONSIBLE FOR, I HAD THE VEHICLE AT THE DEALERSHIP ONE MONTH AGO AND HAD TO PAY FOR A NEW DEF HEATER AT THE TUNE ALMOST $1,000. AT THAT TIME THEY DID THEIR MULTI-POINT INSPECTION WHICH SHOWS THAT THE PARTS THAT FAILED WERE ALL FINE. PLEASE HELP ME AS FORD IS TRYING TO SCREW ME OVER ON A 70K TRUCK WITH MINIMAL MILES. THIS SHOULD BE A RECALL ISSUE THAT FORD SHOULD PAY FOR NOT THE CONSUMER.

DRIVING EAST ON INTERSTATE I10 EAST OF BENSON, AZ AT AROUND 75MPH, HIT A ROUGH PATCH OF ROAD AND THE VEHICLE WENT WILD, SHAKING, VIBRATING, LOSS OF CONTROL. I HIT THE BRAKES AND WENT ACROSS 3 LANES OF TRAFFIC INTO THE MEDIUM, WHERE I SKIDDED TO A STOP. I SEE FROM THE INTERNET THIS IS CALLED THE F350 DEATH WOBBLE! THE FORD F350 AND ALL RELATED VEHICLES NEED TO BE TAKEN OFF THE ROADS, THEY ARE A POTENTIAL DEATH TRAP. I COULD HAVE BEEN KILLED OR SERIOUSLY INJURED IN THIS ACCIDENT OR EVEN WORSE SOME INNOCENT FAMILY COULD HAVE BEEN KILLED IN A HEAD ON ACCIDENT! MY FORD F350 VEHICLE HAS AROUND 60,000 MILES, SUPERDUTY, 4X4. IT IS IN EXCELLENT CONDITION WITH A CAB OVER CAMPER.

I WAS RIDING DOWN HWY55 AT ABOUT 65 TO 70 MPH AND TRUCK STARTS TO WOBBLE AND BOUNCE UNCONTROLLABLY. THE TRUCK BOUNCED TO THE OTHER SIDE OF THE ROAD. I THOUGHT I HAD A FLAT. AFTER GATHERING MYSELF I GOT OUT TO CHECK TRUCK AND THERE WAS NO FLATS AND ALL LUGS WAS THERE. I THOUGHT MAYBE I RAN OVER SOMETHING BUT ABOUT 12 MILES DOWN THE TRUCKS DOES IT AGAIN. BUT THERE ARE MANY CARS BEHIND AND ON THE SIDE OF ME. CARS AND TRUCKS ARE GOING DOWN THE OF ROAD TO GET OUT OF WAY. THIS IS SO A VERY FRIGHTEN AND HORRIBLE EXPERIENCE WHEN YOU ARE NOT PREPARED OR AWARE OF ABOUT THIS TRUCK. FORD TO BE ON OF THE TOP TRUCK MANUFACTURE IT GREATLY SADDEN ME TO KNOW THAT YOU ARE VISUALLY AWARE OF THE TRUCKS DEATHLY DEFECT FOR OVER 15 YEARS. YOU HAVE NOT MADE AN EFFORT TO PROVIDE A SAFE DURABLE PRODUCT TO PROTECT YOUR ROYAL CUSTOMERS OR YOURSELVES. TECHNOLOGY HAS AFFORDED MANY SEEN APPLICATION TO DO SO. YET YOU HAVE IGNORE WHAT IS YOUR COMPANY FUTURE.

DEATH WOBBLE, THE TRUCK SHAKES VIOLENTLY WHEN I DRIVE ON THE FREEWAY SINCE DAY ONE WHEN I BOUGHT IT . THE DEALER WON'T FIX IT THAT , THERE'S NOTHING WRONG WITH IT .AND THE DEALER SAYS TO REMOVE AIR FROM THE TIRES AND IT SHOULD STOP THE SHAKING .

TRUCK HAS A STEERING PROBLEM.MOST OF THE TIME TRUCK TRAVELS STRAIT.SOME TIMES AFTER MAKING A TURN RIGHT OR LEFT THE TRUCK CONTINUES TRAVEL IN THAT DIRECTION! I HAVE TO YANG HARD ON THE STEERING WHEEL BACK IN OPPOSITE DIRRECTION TO GET TRUCK BACK IN ITS LANE!ALSO SOMETIMES THE TRUCK OUT OF THE CLEAR BLUE TRUCK TAKE OFF TO THE RIGHT OR LEFT AN I HAVE T PULL THE WHEEL IN OPPOSITE DIRECTION TO GET TRUCK BACK IN IT'S LANE!OTHER TIMES GOING THAN THE ROAD THE TRUCK HITS A BUMP IN THE ROAD AN TRUCK WILL EITHER GO RIGHT OR LEFT AN STEERING WHEEL HAS TO BE PULL THE OPPOSITE DIRECTION TO GET IT BACK IN IT'S LANE! I NOTICE THIS SAME PROBLEM HAS BEEN REPORTED BEFORE AN NO ONE HAS BEEN ABLE TO FIX IT! MECHANICS SAY IT'S THE STEERING PUMP OR STEERING BOX WHICH HAS NOT CORRECTED ANY BODY'S TRUCK THAT THAT HAS BOTH THESE PARTS REPLACE! THIS CAN CAUSE A MAJOR ACCIDENT FORD SHOULD FIX THIS PROBLEM

DRIVING ON INTERSTATE AT APPROX 60 MPH, HIT PATCH IN ROAD, LOST CONTROL OF VEHICLE, DEATH WOBBLE, ALMOST CAUSED CRASH WITH 6 OTHER VEHICLES. WENT STRAIGHT TO DEALERSHIP TOLD IT WAS STEERING SHIMMY SHOCK FAILURE. ALIGNMENT. PAY FOR OUT OF POCKET, ALTHOUGH HAD SAME TRUCK IN SHOP FOR FRONT END REPAIRS IN JANUARY 2019.

SHAKES STEERING WHEEL AROUND 40MPH, BUT SPORADICALLY.

WHILE TOWING MY LARGE CAMPER, ON THE FREEWAY, I HIT A BUMP. THE FRONT END OF THE TRUCK STARTED SHAKING VIOLENTLY. IT WAS ALL I COULD DO TO STOP THE TRUCK WITHOUT WRECKING. I HAD TO STOP IN THE TRAFFIC LANE. THIS WAS AN EXTREMELY DANGEROUS SITUATION. AFTER RESUMING TRAVEL, THE FRONT END WOULD SHIMMY AT ABOUT 45 MPH. I HAD TO DRIVE HOME AT 40 MPH...ROUGHLY ANOTHER 75 MILES. I THINK I HAVE SEEN AN ADVISORY LETTER FROM FORD, TO OWNERS, CONCERNING THIS. THERE ARE MANY, MANY INSTANCES OF THIS HAPPENING. ONE CAN FIND DOZENS OF EXAMPLES OF THIS HAPPENING IF ONE LOOKS ON LINE. NEITHER FORD NOR THE LOCAL FORD DEALER SEEMS TO BE AWARE OF THE PROBLEM. WE WERE TRAVELING AT ABOUT 60 MPH AT THE TIME OF THE INCIDENT.

FORD F-350 2006 OSCILLATION I HAVE FILED A PREVIOUS COMPLAINT BEFORE RE THE VIOLENT OSCILLATION THAT HAPPENS WITH OUR FORD F-350 TRUCK. WE HAVE HAD MORE EVENTS AT SLOWER SPEEDS AND THE SHAKING IS ALMOST UNMANAGEABLE NOW. WEDNESDAY MAY 11 APPROX 1PM EXITING THE BOURNE BRIDGE MA. I WAS DRIVING AT APPROX 40MPH AND EXITING THE BRIDGE. THERE WAS A ROUGH CONSTRUCTION PATCH ON THE ROAD RIGHT WHERE THE ROAD CONNECTS TO THE BRIDGE. AS I HIT THE ROUGH PATCH, THE OSCILLATION BEGAN AND THE TRUCK SHOOK UNCONTROLLABLY APPROACHING THE ROTARY. THERE WAS A LOT OF TRAFFIC AND CARS IN THE LANE BESIDE ME THAT COULD HAVE BEEN DAMAGED. MAY 20, 2016 AT APPROX 5PM. MY HUSBAND WAS DRIVING WEST ON HIGHWAY ROUTE 6, CAPE COD MA AT APPROX 55MPH. AS HE PASSED EXIT 6, HE HIT A ROUGH PATCH AND THE TRUCK BEGAN OSCILLATING VIOLENTLY. HE WAS UNABLE TO CONTROL IT AND SWERVED IN BOTH LANES OF THE WESTERLY 2-LANE HIGHWAY ALSO RUBBING AGAINST THE CURB. LUCKILY THE TRAFFIC STOPPED WHEN SEEING HIS TRUCK OUT OF CONTROL AND NO ONE WAS HURT OTHER THAN MY HUSBAND BEING TOTALLY SHAKEN. THE TIRES HAVE BEEN INFLATED AS RECOMMENDED BY FORD WHEN THE SENT A LETTER RE THIS DEFECT. THIS TRUCK IS DANGEROUS, NOT ONLY TO US BUT OTHERS WHO ARE ON THE ROAD. I HAVE CONTACTED THE PLYMOUTH FORD DEALER WHERE THE TRUCK WAS PURCHASED, FORD CUSTOMER SERVICE AND FORD HEAD OFFICE. EVEN THOUGH THEY ACKNOWLEDGE THE TRUCKS ARE DEFECTIVE, THEY SAY THEY ARE NOT RESPONSIBLE FOR REPAIRING THEM. OUR TRUCK IS OSCILLATING REALLY BADLY AND IS DANGEROUS TO DRIVE. THIS SHOULD BE A RECALL, NOT ONLY FOR THOSE OF US DRIVING THESE DEFECTIVE FORD F-350 2006 TRUCKS, BUT FOR THE OTHER INNOCENT LIVES ON THE ROAD.

SHIMMY IN FRONT END FORCES LOSS OF STEERING CONTROL. SHIMMY OCCURS AT SPEEDS OVER 50 MPH. HAS NOTHING TO DO WITH TIRE PRESSURE, CONTRARY TO FORD MOTOR COMPANY CLAIMS. THIS IS A PROBLEM WITH THE FRONT END STEERING DESIGN AND SHOULD BE REVIEWED IN GREATER DETAIL BY THE NHTSA AND FIXED WITH MORE THAN A LETTER FROM FORD TELLING ME TO CHECK THE AIR PRESSURE IN MY TIRES. AIR PRESSURE IS PERFECT AND THE PROBLEM STILL EXISTS.

FORD F-350 2006 COMPLAINT. WE HAVE EXPERIENCED VIOLENT SHAKING (SHIMMYING) WHEN THE TRUCK HITS A BUMP ON THE HIGHWAY AND AS A RESULT, EXTREME DIFFICULTY MAINTAINING THE VEHICLE ON THE ROAD. OUR FIRST EXPERIENCE WAS IN AUGUST 2015, ON THE INTERSTATE HIGHWAY WHILE TRAVELLING AT 75MP. WE HIT A BUMP AND THE TRUCK / STEERING WHEEL SHOOK VIOLENTLY FOR ABOUT 10 SECONDS CAUSING US TO SWERVE ACROSS LANES AND STRUGGLE TO KEEP THE TRUCK IN THE LANE AND OUT OF TRAFFIC'S WAY. WE HAVE SINCE EXPERIENCED THIS PROBLEM FOUR MORE TIMES HITTING BUMPY HIGHWAYS AT SPEEDS AS LOW AS 50MMP AND AS RECENT AS 2 WEEKS AGO. WE HAVE CHECKED IT OUT AND OUR MECHANIC ADVISED THAT HE COULD NOT FIND ANYTHING WRONG. IT HAS BEEN A GREAT CONCERN OF OURS AS IT PUTS OUR LIVES (AND THOSE ON THE ROAD WITH US) AT DANGER WHEN THIS ISSUE OCCURS. ADDITIONALLY, EVERY TIME THE VIOLENT SHAKING OCCURS, IT THROWS OFF THE ALIGNMENT AND BALANCING FOR THE TRUCK. WE HAVE JUST RECEIVED A LETTER FROM FORD ADVISING OF THIS PROBLEM AND I HAVE CALLED THE SERVICE CENTER FROM THE FORD DEALER WE BOUGHT THE VEHICLE FROM. FORD IS NOT ASSUMING RESPONSIBILITY FOR ANY DIAGNOSIS OR REPAIRS TO THESE DEFECTS AT THIS TIME. OUR TIRE PRESSURE IS IN KEEPING WITH FORD'S RECOMMENDATIONS AS THEY SUGGEST IN THEIR LETTER. FORD F-350 TRUCKS SHOULD NOT BE APPROVED FOR USE ON HIGHWAYS AS THIS DEFECT COULD RESULT IN FATAL ACCIDENTS IF THE SHAKING CANNOT BE CONTROLLED. ALSO, FORD SHOULD BE RESPONSIBLE FOR REPAIRING THE FAULTY TRUCKS.

PURCHASED THIS VEHICLE LESS THAN A YEAR AGO AND WAS ORIGINALLY VERY PLEASED. SUDDENLY WE ARE NOW EXPERIENCING THE DEATH WOBBLE AS OTHER HAVE DESCRIBED. THE VIOLENT SHAKING OF THE FRONT END. THIS USUALLY OCCURS WHEN YOU ARE APPROACHING THE SPEED OF 60MPH. WE DO NOT HAVE TO HIT A BUMP FOR IT TO HAPPEN. THE OTHER COMPLAINT, IS THAT WE BOUGHT THIS TRUCK WITH VERY LOW MILEAGE FOR THE YEAR, RAN GREAT, LOOKED GREAT, VERY PLEASED UNTIL THIS LAST MONTH WHEN THE CHECK ENGINE LIGHT CAME ON AND IT SEEMS TO SPUTTER. PUT SOME HIGH QUALITY FUEL INJECTOR CLEANER IN THE TRUCK, THINKING IT MAY BE A INJECTOR STICKING. NOPE, DIDN'T FIX THE PROBLEM. LIGHT NEVER WENT OFF. TOOK IT TO A DEALERSHIP, THEY TESTED IT AND CAME BACK WITH YOUR FUEL TANK IS DETERIORATING PUTTING LITTLE METAL SHARDS IN YOUR ENGINE. YOU ARE LOOKING AT A POTENTIAL FULL ENGINE REBUILD COSTING A MINIMUM OF $6000. THIS IS UNACCEPTABLE FOR ANY VEHICLE MANUFACTURER TO NOT RECALL A VEHICLE THAT HAS A SERIOUS KNOWN PROBLEM. WE ARE STUCK WITH THIS TRUCK THAT IS NOT WORTH THE [XXX] PAPER THE TITLE IS WRITTEN ON. IT IS TIRING OF READING ALL THESE SIMILAR COMPLAINTS AND NO ONE IS DEFENDING THE CONSUMERS. AT WHAT POINT, DOES THE MANUFACTURER NEED TO BE HELD RESPONSIBLE TO OWN UP TO THE FAULTY EQUIPMENT AND FIX THE PROBLEMS? WHEN MY CHILD IS KILLED BECAUSE OF THE INABILITY TO CONTROL THE VEHICLE DUE TO THE STEERING PROBLEMS IN THE FRONT END OR THAT IT STOPS RUNNING IN THE MIDDLE OF THE HIGHWAY OR DOWNTOWN TRAFFIC BECAUSE THE FUEL TANK DETERIORATED FOR NO REASON AND DESTROYED THE ENGINE. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DECELERATED AND FAILED TO RESPOND WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN SOME INSTANCES, THE VEHICLE STALLED AND THE POWER STEERING AND BRAKES MALFUNCTIONED. THE DEALER STATED THAT THE FUEL INJECTORS WERE FAULTY. THE FUEL INJECTORS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 102,000.

FORD TRUCKS HAVE A SEVERE SHIMMY AT HIGHWAY SPEEDS THAT WILL MAKE THE TRUCK CHANGE LANES OR GO OFF THE ROAD,MY WIFE HAD TO STOP IN THE FAST LANE BECAUSE IT WOULD NOT STOP SHAKING,WE HAD IT TOWED TO FORD AND WERE TOLD THIS IS A NORMAL CHARACTERISTIC OF TRUCKS AND THAT THERE IS NO FIX ? WHAT IS THE NUMBER OF PEOPLE THAT MUST DIE BEFORE YOU ADDRESS THIS PROBLEM ? THE TRUCK HAS NEW TIRES OF FACTORY SPECS. ?*TR

OUR TRUCK EXPERIENCED A SEVERE, VIOLENT WOBBLE THAT STARTED AFTER TRAVELING OVER A UNEVEN SPOT ON THE ROAD. WE FEARED FOR OUR LIVES AS THIS OCCURRED WHILE PASSING ANOTHER TRUCK ON A BRIDGE WITH HEAVY TRAFFIC BEHIND US. THE SHAKING AND WOBBLE CONTINUED FOR ABOUT 20 SECONDS, AND DID NOT STOP UNTIL THE TRUCK SLOWED DOWN TO ABOUT 40 MILES AN HOUR. ALL OUR TIRES HAVE BEEN RECOMMENDED AND INSTALLED AT THE FORD DEALERSHIP. I MAINTAIN TIRE PRESSURES AS INDICATED ON DOOR JAM. 75 LB ON FRONT AND 60 LB ON REAR TIRES. THERE ARE NO AFTERMARKET MODIFICATIONS ON OUR TRUCK. I CONSIDER THIS ISSUE VERY DANGEROUS, AND WONDER HOW MANY FOLKS MAY HAVE BEEN INJURED OR KILLED AS A RESULT OF THEIR TRUCK SUDDENLY BECOMING UNCONTROLLABLE, AS OURS DID. *TR

THE DEATH WOBBLE THAT YOU SAY HAD ONLY 76 COMPLANTS IS [XXX] ! OVER THE LAST 3 YEARS IT HAS HAPPENED OVER 18 TIMES WITH NEW CORRECT SIZE TIRES @ CORRECT PRESSURE ! I HAVE HAD TO MAKE RAPID LANE CHANGES SLAMMING ON THE BRAKES TO GET TO THE SIDE OF THE ROAD SO IT WILL STOP ! IF YOU THINK THIS IS NOT A PROBLEM MAYBE YOU SHOULD GO TO WORK FOR FORD ,ON SECOND THOUGHT ITS APPARENT YOU ALREADY DO ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE POWER STEERING MALFUNCTIONED AND BECAME LOOSE. THE CONTACT MADE A STOP AND NOTICED THAT THE POWER STEERING ASSIST HAD FAILED. THE CONTACT TURNED THE STEERING WHEEL, HOWEVER THE WHEELS DID NOT RESPOND. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT INSPECTED BY THE DEALER OR MECHANIC TO DETERMINE A CAUSE FOR THE FAILURE. THE FAILURE WAS NOT REPORTED TO THE MANUFACTURER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 70,100.

WAS TRAVELING ON THE HIGHWAY AT A RATE OF SPEED OF 55MPH ON A 2006 F350 SUPER DUTY 4X4 WHEN I WENT OVER AN UNEVEN SURFACE ON THE HIGHWAY WHICH CAUSED THE FRONT END TO SHAKE VIOLENTLY ALMOST CAUSING ME TO HIT A VEHICLE ON MY RIGHT HAND SIDE. THOUGH I HAD EXPERIENCED A FLAT BUT EVERYTHING LOOKED FINE. CANNOT DRIVE THIS VEHICLE IN THIS CONDITION. TIRE PRESSURE ON ALL WHEELS IS FINE. *TR