2020 Ford F-550 Powertrain & Transmission Problems

At ~93,000 miles, my 2020 Ford F-550 (7.3L “Godzilla” V8) suffered catastrophic engine failure due to a roller lifter bearing failure, causing internal valvetrain damage and requiring full engine replacement. Ford dealer stated they recommended 90% coverage of the repair under goodwill through corporate, but later reduced coverage to 40% without explanation. After repairs, Ford corporate recommended a 3-year/36,000-mile PremiumCare warranty, then rescinded it a week later and offered only free oil changes. The 7.3L engine in my truck shares the same design as the F-53/F-59 motorhome chassis, which have multiple Technical Service Bulletins (TSBs) for lifter bearing failure, overheating of cylinders #2–3, and low oil pressure at idle. My vehicle shows identical symptoms but was excluded from those VIN ranges, suggesting Ford is segmenting related defects to limit recall exposure. Inspection revealed a cracked and arcing spark-plug wire on cylinder #2, matching the motorhome TSB’s overheating issue. This arcing poses a fire risk and likely contributed to localized heat and mechanical failure. The truck was often driven in Eco Mode, which holds low RPMs under load. This can increase cylinder pressure, reduce oil flow, and exacerbate heat in cylinders #2–3—factors that align with the failure pattern. This combination of design-related overheating, lifter bearing failure, oil-pressure fluctuation, and spark-wire arcing presents a clear safety hazard. Engine stall or fire could occur under towing or heavy-load conditions. NHTSA investigation is warranted into Ford’s 7.3L Godzilla engine design and VIN-exclusion practices.

The contact owns a 2020 Ford F-550. The contact stated that while starting the vehicle, the vehicle unintentionally rolled away while the transmission was in park(P). No warning light was illuminated. Additionally, the vehicle jerked while driving uphill. The vehicle also jerked violently while downshifting from third to second gear. The vehicle was taken to the dealer, who determined that the transmission needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V256000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.

The contact owns a 2020 Ford F-550. The contact stated while driving 45 MPH, the transmission started slipping. The check engine warning light was illuminated. The contact pulled to the side of the roadway. The vehicle was towed to an independent mechanic. The vehicle was taken to an independent mechanic where it was diagnosed that the planetary ring gear needed to be replaced under NHTSA Campaign Number: 22V256000 (Power Train). The VIN was included in the recall. The vehicle was then towed to the local dealer who informed the contact that they could not accommodate the vehicle for the recall repair due to the size of the vehicle. The vehicle was towed to a second dealer, Northside Ford Truck Sales, Inc. (6221 NE Columbia Blvd, Portland, OR 97218) who informed the contact that the vehicle would be repaired at his own expense. The manufacturer was notified of the failure and advised the contact to follow up with the dealer. The vehicle was not repaired. The failure mileage was approximately 80,000.