There are 3 stored owner reports matching the suspension leading-label group for the 2012 Ford Flex in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 3 of 3 matching reports.
Open the full vehicle complaint log (all categories)I was driving around 55 and suddenly lost control and fish tailed to the right, then to the left over the center line, then back to the right. Luckily no other vehicles on the road. The rear driver side toe link broke. I discovered there's a recall for this exact problem with the exact possible worst case scenario that I went through. [FORD RECALL CODE: 2oSo4] This recall includes "2013-18 Ford Flex and Lincoln MKT vehicles built at Oakville Assembly Plant, Sept. 12, 2011, to June 1, 2017" My vehicle was manufactured at the same plant in 02/12 but for some reason is not qualified. I think my 2012 model needs to be included in this recall, obviously. I talked with Ford Dealer and Ford Customer Service and they said they would pass this info to NHTSA. I had both links replaced at a local mechanic and hope to get reimbursed in the future.
I am writing you in regards to NHTSA # 20V-072, Ford Recall # 20S04. I own a 2012 Ford Flex. It was not included in this recall. The recall included Ford Flex years 2013 through 2018. Though my SUV wasn’t included in the recall for the defective toe links, my SUV’s toe links were found to be defective on June 1, 2015 at Taylor Ford in Michigan. At that time my vehicle had 56,071 miles on it and was still under warranty. My toe links were replaced with part 5A972 which is the same part that is now the cause of Ford Recall 20S04. On 11-6-21 we took my SUV, with 96,930 miles, into Belle Tire for brake work and tire rotation. At that time we were told that the toe links were defective and needed to be replaced and that my tires were bad and needed replacement too. The tires and toe links had been replaced at Ford 40,859 miles prior! At this point we investigated and found the recall for the toe links. We had never been notified by Ford even though part 5A972 which was later found to be defective, had been put on our SUV in 2015. A Ford Part Employee has confirmed that this part is defective. The defective part is a welded part and the part Ford is using to replace this part is a forged part. Defective toe links are very dangerous. The defect can cause loss of steering/control of SUV. I have contacted multiple levels of Ford Customer Care with no response and no assistance offered. My SUV is currently at a Ford Service Center waiting for Ford to respond so that my SUV can be repaired. I'm unable to drive while waiting because this is very dangerous. It is also very expensive to repair.
MY VEHICLE WAS MANUFACTURED JUST A FEW MONTHS SHY OF A RECALL FOR BAD TOE LINKS IN THIS MAKE AND MODEL. I HAVE HAD MY CAR DIAGNOSED WITH HAVING BAD TOE LINKS AND WOULD LIKE TO SEE ABOUT GETTING MY VEHICLE INCLUDED IN THE RECALL SINCE IT WAS MANUFACTURED AROUND THE SAME TIME AS THE VEHICLES INCLUDED IN THE RECALL.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 29, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.