There are 5 stored owner reports matching the lighting leading-label group for the 2004 Ford Focus in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 5 of 5 matching reports.
Open the full vehicle complaint log (all categories)DRIVING MY 2004 FORD FOCUS, WHEN I TURN ON THE LEFT BLINKER AND IT STARTS BLINKING VERY FAST SO I ASSUME IT NEEDS A NEW BULB OR FUSE. I GO TO REPLACE THE BULB ONLY TO FIND THAT THE HOUSING UNIT HOLDING THE BULB FOR THE BLINKER IS MELTED. NOW I HAVE TO REPLACE THE ENTIRE THING AND THIS COST ME $120.00 DOLLARS. FAST FORWARD SIX MONTHS, NOT ONLY IS THE LEFT BLINKER OUT BUT NOW THE RIGHT BLINKER AS WELL, AND GUESS WHAT SAME PROBLEM NOT JUST A BULB BUT BOTH HOUSING UNITS HAVE MELTED AND NEED TO BE REPLACED. LOOKED TO SEE IF THERE IS A RECALL ON THIS ISSUE, SINCE ONE, IT IS THE MATERIAL OF THE CAR THE HEAT GENERATED BY THE MANUFACTURES BULB AND IT CONTINUES TO HAPPEN EVEN WHEN REPLACED WITH NORMAL DRIVING. PLUS NO BLINKERS IS A HUGE SAFETY ISSUE. NO RECALL! LOOKS LIKE FORD THINKS MELTING CAR PARTS ON THEIR VEHICLES IS NORMAL. *LN
2004 FOCUS ZWT 1. LOSS OF FRONT WIPER PARK FUNCTION ! 2. LOSS OF HEADLIGHT / AUXILIARY LAMP FUNCTION ! HAPPENED AT 2 SEPARATE INCIDENTS DURING 2009. *TR
1) TURNED HEADLIGHT SWITH TO "ON" ON MY 2004 FORD FOCUS ZTW 2) TURNING THE HEADLIGHTS ON CAUSED THE REAR HATCH TO OPEN UNCOMMANDED. 3) I REMOVED THE COVER FROM THE HATCH AND DISCONNECTED THE WIPER MOTOR AND LATCH UNLOCK SOLENOID CONNECTORS. THEN, TO FIND THE POSSIBLE PROBLEM, I INSPECTED THE WIRE BUNDLE IN THE AREA OF THE HATCH HINGE AND FOUND SEVERAL WIRES FRAYED AND BROKEN. SO TURNING ON THE HEADLIGHTS APPARENTLY SENT A SIGNAL (SHORT) TO THE LATCH SOLENOID. A FRIEND HAD A SIMILAR PROBLEM. HIS HATCH WOULD POP OPEN WHEN THE IGNITION WAS TURNED TO START THE CAR. TWO DEALERS TOLD ME THEY WOULD NOT BE OF ANY HELP UNLESS I PAID AT LEAST $350 TO REPAIR THE PROBLEM. THIS IS A SAFETY ISSUE. REMEBER THE CHYSLER MINI VAN HATCH RECALL? I HAVE BEEN WATCHING THE TOYOTA SUA HEARINGS AND DECIDED TO CHALLENGE YOU GUYS AND SEE IF YOU WOULD REVIEW AND CONTACT ME AS MR. LAHOOD SAID YOU WOULD. I KNOW YOU ARE BUSY AND UNDERSTAFFED. I DO NOT BLAME YOU AS SOME ARE INTENT UPON. I SPENT MY LIFE AS AN A&P MECHANIC AT AMERICAN AIRLINES AND KNOW THE IMPORTANCE OF SAFETY. THANKS FOR READING AND HOPE TO HEAR FROM YOU SOON. PS FORD HAS HAD KNOWLEDGE OF THIS PROBLEM IN OTHER MODEL YEARS OF THE FOCUS. *TR
TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE PREPARING TO MAKE A RIGHT TURN AT APPROXIMATELY 45 MPH, THE RIGHT TURN SIGNAL FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE BURNING AND MELTING OF THE TURN SIGNAL BULB SOCKET. THE VEHICLE WAS REPAIRED AT THE COST OF $300.00. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A THREE SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES. THE MANUFACTURER WAS NOTIFIED AND REIMBURSED FOR THE PRIOR SERVICE REPAIR. ALSO, PERFORMED ONE FREE REMEDY REPAIR ON THE VEHICLE. THE FAILURE MILEAGE WAS 45,000. THE CURRENT MILEAGE WAS 120,000.
THE INDICATOR LIGHTS ON THE INSTRUMENT PANEL FOR THE HIGH BEAM HEADLIGHT AND TURN SIGNALS WERE NOT BRIGHT ENOUGH. *AK *NM
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 29, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.