There are 8 stored owner reports matching the tires & wheels leading-label group for the 2015 Ford Focus in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 8 of 8 matching reports.
Open the full vehicle complaint log (all categories)Cannot change my tires due to swollen lug nuts. Because of this my tires have not been able to be rotated and will need to be replaced because of too much wear. Several mechanics have had difficulty getting them off and on and have said that I need to purchase replacements because Ford lug nuts are notoriously bad. If I were to get a flat tire, I would be stranded.
Two part lug nuts experience swelling over time and make removal of the lugs very difficult and may result in the lugs not being adequately tight when the wheel is put back on. The dealer confirmed that this is a known problem and when they repair this issue, they use an after market lug that is not a two part lug, and therefore doesn't have the swelling issue. I was not aware of this problem till my most recent annual inspection and when I expressed surprise, the dealer mechanic stated that even though Ford is well aware of this issue, Ford will not cover this item and its the owner's problem.
FLAT TIRE WHILE PARKED. VEHICLE STRANDED IN DRIVEWAY. LUG WRENCH THAT CAME WITH THE VEHICLE DOES NOT FIT LUG NUTS. UNABLE TO REMOVE WHEEL TO INSTALL SPARE. TRIED USING SOCKET WRENCH. COULD NOT FIND A SOCKET THAT FIT. TRIED THE FOLLOWING SOCKETS: 3/4", 13/16', 19MM, 21MM. THE LUG NUT SIZE IS SOMETHING IN BETWEEN THESE. THE LUG WRENCH THAT CAME WITH THE VEHICLE IS 3/14' AND FITS THE WHEEL LOCK ADAPTER THAT CAME WITH THE VEHICLE.
When a transmission recall was corrected I was advised that the lug nuts were warping and needed to be replaced. Substandard lug nuts should be covered by the manufacturer
I PURCHASED THIS CAR FROM SCHALLER AUTO WORLD ON 11/14 18 AND THE FOUR TIRES ON THE CAR BY STATE LAW ARE UNSAFE TO BE ON THE ROAD,STATE LAW IS 5.0 AND ABOVE,ALL FOUR WERE MEASURED TO BE 2.0 AND ABOVE TO BE BELOW 3.0. I WENT TO THEM WITH MY COMPLAINT AND THEY WON'T HELP ME .I HAVE PROVE WITH PICTURES AND PAPERWORK TO BACK MY SITUATION UP.WHAT AM I TO DO?
THE LUG NUTS ON ALL TIRES HAD TO BE REPLACED TWICE IN LESS THAN A THREE YEAR PERIOD.
PASSENGER SIDE FRONT BALL JOINT SNAPPED, CAUSING LOWER CONTROL ARM BOLT TO SNAP-SEPARATED AND DAMAGED AXLE. CAR SKIDDED APPROXIMATELY 70 FT BEFORE STOPPING. VEHICLE WAS MOVING FORWARD ON A CITY STREET.
11/4/15 MY WIFE WHILE DRIVING IN HER WORK PARKING LOT AT A SPEED OF APPROXIMATELY 10 MPH EXPERIENCED A TIRE BLOWOUT ON THE LEFT FRONT TIRE. THE BLOWOUT CAUSED A SMALL TEAR IN THE TIRE AT THE SEAM WHERE THE SIDEWALL JOINS THE TREAD. WE COULD FIND NO EVIDENCE OF ANYTHING OTHER THAN A DEFECT IN THE TIRE WHICH COULD HAVE ATTRIBUTED TO THE BLOWOUT. IT WAS ACCOMPANIED BY A LOUD NOISE AND IMMEDIATELY LOSING ALL AIR PRESSURE IN THE TIRE. THE TIRE IS A CONTINENTAL CONTIPRO CONTACT SIZE 215/55 R 16 93H | DOT NUMBER CNB3 WBPC 0615.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 29, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.