2017 Ford Focus Engine Problems

My vehicles engine died in traffic and left me stranded in the middle of a busy road. Upon a mechanics review the issue is a siezed engine because of the oil pump pickup tube clogged with pieces of the oil pump or timing chain pulleys that had broken off.

engine failure - coolant entering engine cylinder #2, Internal engine failure. Car was stalled loss of power on highway and almost killed. Towed to nearest mechanic shop. Need to disassemble and confirm failure point. Ford law suits for coolant internal engine damage and failure. This is a known defect with Ford Ecoboost engines. Including coolant/antifreeze entering the engine. Also, the coolant intrusion into cylinders. Requesting good will assistance as unable to use car for over 2 months. Ford headquarters is acting like they know nothing about this.

UNKOWN my rpms rev up randomly I can’t shut my car off when I get gas and makes a raving up sound I can’t reverse

Ford refuses to respond to emails nor return calls...... Cracked cylinder head caused from a known issue Ford failed to recall. The 2.0L Ecoboost uses an aluminum cylinder head with relatively thin casting areas between the combustion chamber and coolant passages. Coolant passages run very close to the exhaust valve seats. The turbocharged exhaust temperatures are EXTREMELY high. Thin aluminum sections are repeatedly exposed to rapid heating and cooling cycles. Over time this creates micro-fractures int he heat casting, which eventually grow into a crack between the combustion chamber and coolant jacket. This defect tends to occur between 60k - 100k miles. Safety: Car was smoking so bad that it could have caught fire. The car has been inspected by a Ford dealership and declared this to be the problem. The fix is a new engine that costs 12k. There were no warning lamps or symptoms prior to the failure. Car is still deemed inoperable as Ford refuses to help with the fix.

After recall Campaign 23S64 and the engine being replaced with G1FG-6006-DA and traceability Code [XXX] . Incident Description On Saturday [XXX], while driving on the freeway, my vehicle began sputtering and lost power. The RPMs increased but the speed did not. The check engine light illuminated briefly and then went out. This created an Immediate serious safety hazard to me my passenger and other drivers on the road as I was unable to maintain speed in traffic and had to leave the freeway Immediately. Diagnostic Findings •Initial AutoZone OBD-II scan revealed P0302 (Cylinder 2 Misfire). •Dealer’s own diagnostic later reported P0301 (Cylinder 1 Misfire), with carbon tracking on all spark plugs and ignition coil boots. •Dealer noted the locking tab on Cylinder 3 ignition coil connector was broken, requiring a new pigtail. •Dealer also identified a broken front motor mount, but is attempting to charge me for replacement despite the fact that the mount must be removed and reinstalled during an engine swap. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased this vehicle 4 days ago. On the second day I noticed a shutter when accelerating, going uphill and often continuous. I have been told that it is the clutch. I am aware that the same issue on the 2017 focus has been recalled. I do not understand why it is just certain vehicles. Especially, since it is the same year and issue as the recalled ones. I am a police officer that has had some health issues with my heart. My parents gave me the money to buy this car. They do not have the money to repair it and neither do I. I called two Ford dealerships as well as the Ford manufacturer. Nobody was willing to help. I discovered that this is the place to file a complaint all on my own. Please try and help me.

The contact owns a 2017 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 ( ENGINE AND ENGINE COOLING). The contact stated that the local dealer was contacted; however, the contact was informed that parts were not yet available to repair the vehicle. The vehicle was not repaired. The manufacturer was contacted about when parts would be available. The contact had not experienced a failure.

The contact owns a 2017 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The local dealer was contacted and refused to repair the vehicle. The contact was informed that, unless a failure occurred with the engine, the recall repair would not be performed. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Vehicles Canister Purge Valve was replaced and acting up again.

The engine oil light came on during late September or early October of 2024 while on the highway. There was a severe loss of power. I was able to get the car back to my residence and changed the oil filter and oil. The error persisted, I then changed the oil pressure switch to see if that was the issue, but it did not resolve. In approximately December of 2024, a friend who is a mechanic and has thousands of hours of experience offered to look at the issue. He pulled the engine and found that the oil pump belt and timing belt were severely degraded and had clogged the oil screen. He replaced the two belts and cleaned the screen hoping it would resolve the issue. In approximately late may or early June 2025 I got the car back and by the beginning of August the engine had seized due to damage received when the oil pressure had failed due to a clogged screen back in 2024. Thankfully I was not on the highway when the engine seized.

The contact owns a 2017 Ford Focus. The contact stated while driving approximately 20-25 MPH, the vehicle felt like it was struggling to accelerate. The contact pulled to the side of the road and turned off the vehicle; however, the fan remained engaged for approximately two minutes. The vehicle was taken to the residence, where the check engine warning light illuminated. The contact became aware that the VIN was included in NHTSA Campaign Number: 23V905000(Engine and Engine Cooling), which the contact related to the failure; however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer for the recall repair, but the dealer did not provide any assistance. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 81,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Ford Focus. The contact stated that while driving on the highway at 65 MPH, the vehicle lost automotive power with the check oil and check engine warning light was intermittently illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that there were metal shavings were found in the oil filter, causing engine damages. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 97,221.

The contact owns a 2017 Ford Focus. The contact stated while driving 55 MPH in traffic, the brake pedal was depressed; however, the brake pedal was firm. There was no warning light illuminated; however, an engine message was displayed on the instrument panel. The vehicle was taken to the dealer and was diagnosed and determined that the oil pump drive belt had fractured and there were debris inside the engine, causing engine failure. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The contact related the failure to NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the VIN was not included. The failure mileage was 55,784.

The contact owns a 2017 Ford Focus. The contact stated while driving 45 MPH, the low oil pressure warning light illuminated, and the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed that the oil pump had failed, causing damages to the engine. The dealer determined that the oil pump, the engine block, and unknown parts that were damaged due to oil contamination needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 108,442.

The contact owns a 2017 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Ford Focus. The contact stated that while driving at 55 MPH, the oil light illuminated, and the contact became aware that there was oil leaking from the oil pan. The contact also became aware that there was a rod that had slightly detached from the oil pan. The vehicle was taken to the dealer to be diagnosed, and the failure was linked to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The manufacturer was contacted; however, the contact was unable to speak with a representative. The failure mileage was 114,000.

The contact owns a 2017 Ford Focus. The contact stated while driving 70 MPH, the accelerator pedal was depressed, and the vehicle hesitated and stalled. The contact was able to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the residence, and then was towed to the dealer. The vehicle was diagnosed that the timing belt had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000.

The contact owns a 2017 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact called on behalf of the owner of a 2017 Ford Focus. The contact stated that while driving approximately 65 MPH, the "Service Immediately" message was displayed, and the vehicle started losing motive power and stalled. The contact was unable to restart the vehicle and the vehicle was towed to a local dealer. The vehicle was diagnosed, and it was determined that the oil pump had failed and caused damage to the engine. The dealer related the failure to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The dealer informed the contact that the engine and oil pump needed to be replaced; however, the parts to complete the repair were not yet available. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 53,000.