2007 Ford Freestar Complaint Log

The contact owns a 2007 Ford Freestar. The contact received notification of NHTSA Campaign Number: 13V081000 (Seats); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was unavailable.

The contact owns a 2007 Ford Freestar. The contact stated that he discovered two large holes located on both sides of the third-row seats. The contact stated that the holes were located at the seat anchors; the structural degradation at the seat anchor were mounted to the rear wheel wells. The contact then discovered that his vehicle was placed under NHTSA Campaign Number: 13V081000 (Seats). The contact then notified the dealer and was informed that the part to repair the vehicle was not available and also that the corrosion on the vehicle was too severe to complete the repair. The manufacturer was also notified of the failure and referred the contact to the Better Business Bureau for further assistance. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The failure mileage was approximately 100,000. Parts distribution disconnect.

PASSENGER SIDE MIRROR BURNED, SMOLDERED WITH A GREAT DEAL OF SMOKE. COULD SEE ORANGE GLOW BEHIND THE MIRROR. SMELLED LIKE AN ELECTRICAL BURN. CAR WAS PARKED, NO KEY IN IGNITION, HAPPENED RIGHT AFTER UNLOCKING CAR WITH KEY FOB.

TORQUE CONVERTER IS SHOWING SIGNS OF FAILURE WITH VAN A LESS THAN 50K MILES. A TRANSMISSION FLUSH AND SERVICE INCLUDING FORD'S FRICTION MODIFIER DID NOT FIX.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE THE VEHICLE WAS BEING REVERSED WITH PASSENGERS SEATED IN THE THIRD ROW, THE THIRD ROW SEAT ATTACHMENT BOLT FRACTURED. THE CONTACT STATED THAT THE SEAT SHIFTED AND WAS NO LONGER SECURELY FASTENED TO THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED AS THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 89,000. *JS

I HAVE A 2007 FORD FREESTAR SE. VIN# [XXX]. AT 102,296 MILES THE TRANSMISSION FAILED. I WAS DRIVING IT ON A SIDE STREET AT APPROXIMATELY 15 MILES PER HOUR. I WAS ACCELERATING FROM A STOP SIGN, WHEN THE TRANSMISSION APPEARED TO SLIP INTO NEUTRAL. I LOOKED AND IT WAS STILL IN DRIVE, I TRIED DOWNSHIFTING, PUTTING IT INTO NEUTRAL AND BACK INTO DRIVE AND NOTHING WORKED. I COASTED TO THE SIDE OF THE ROAD AND PUT IT INTO PARK. THAT APPEARED TO WORK. I THEN TRIED USING REVERSE AND IT DID NOT ENGAGE. I THEN TRIED ALL GEARS AND NOTHING HAPPENED. I THEN HAD THE VEHICLE TOWED TO MY HOUSE. I LET IT COOL DOWN AND IT STILL DID NOT WORK. THE TRANSMISSION FLUID IS A CLEAN PINK AND SMELLS BRAND NEW. I PROCEEDED TO DO ONLINE RESEARCH TO DETERMINE THE PROBLEM AND IF IT CAN BE EASILY REPAIRED, WHAT I FOUND WAS VERY INTERESTING. IT WAS A VERY COMMON PROBLEM OCCURRING AROUND 103,000 MILES. MANY (HUNDREDS IF NOT THOUSANDS OF PEOPLE HAD THE SAME ISSUE WITH THIS VEHICLE SPANNING SEVERAL YEARS, MOST NOTABLY FROM 2004 THROUGH 2006. THERE WAS A RECALL ISSUED FOR THOSE YEARS. THERE WAS NOT, HOWEVER, A RECALL FOR THE 2007 MODEL YEAR. THERE ARE NUMEROUS PEOPLE WITH THIS YEAR AND PROBLEM AS WELL. I AM CURIOUS AS TO WHY THE 2007 MODEL YEAR WAS NOT INCLUDED WHEN IT OBVIOUSLY SUFFERS THE SAME ISSUE.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

"TAKATA RECALL" WHILE DRIVING MY VAN I LOST TO GO TO THE BANK, WHEN I WENT TO PUT MY FOOT ON THE GAS PEDAL IT WOULD NOT GO. THERE WAS NO MOVEMENT. IT MADE THIS FUNNY SOUND UNDER THE HOOD. I HAD NO WARNING, IT SHIFTED GEARS, MY HUSBAND EVEN PLUGGED IN THE CODE READER AND NOTHING CAME UP. AS WE ARE LOOKING INTO THE ISSUE THE TORKE CONVERTER WENT OUT IN THE TRANSMISSION. SO NOW THIS NEEDS TO BE REPLACED. WE WE'RE ON A IT STREET AT A STOP LIGHT GETTING READY TO MAKE A LEFT HAND TURN.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 25 MPH, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE CONTACT HEARD A RATTLING NOISE UNDER THE HOOD. THE CONTACT STATED THAT THE RATTLING NOISE SEIZED ONCE THE SPEED WAS REDUCED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HOMER SKELTON FORD OF MILLINGTON (9030 US-51, MILLINGTON, TN 38053 (901) 873-3673) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.

NOISE FROM THE TRANSMISSION. CAR WILL SURGE JUMP WHILE IN GEAR.MY CAR ONLY HAS 48000 MILES

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE WHEELS SEIZED WHILE DRIVING, WHICH RESULTED IN A LOSS OF CONTROL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 142,900.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DEPRESSING THE ACCELERATOR PEDAL AT ANY SPEED, THE VEHICLE DID NOT RESPOND AND A WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000.

TRANSMISSION JUST STOPPED WORKING WITH ROUGHLY 77,835 MILES, IN A STATIONARY MODE PARKED. FORD TRANSMISSION THEY PUT IN HAD A BETTER WARRANTY THAN ON THE NEW CAR.

WHEN I TOUCHED THE TRANSMISSION GEAR SHIFT ONE MORNING, THE CAR BEGAN ROLLING DOWN MY DRIVEWAY & ROLLED INTO THE STREET. I HAD A HARD TIME STOPPING THE VEHICLE BECAUSE THE ENGINE WAS NOT YET RUNNING & THE POWER BRAKES WERE NOT ON. THE GEAR SHIFT LEVER WOULD NOT HOLD IN PARK OR ANY OF THE OTHER GEARS. I HAD THE VEHICLE TOWED TO A TRANSMISSION REPAIR SHOP. WHEN I TOLD THE MECHANIC WHAT HAD HAPPENED, HE SAID IT WAS THE TRANSMISSION TORQUE CONVERTER & SAID, "THIS IS A COMMON PROBLEM WITH THIS VEHICLE." "I HAVE REPLACED HUNDREDS OF THEM OVER THE YEARS. OTHER INDEPENDENT TRANSMISSION REPAIR SHOPS HAVE SAID THE SAME THING. WHEN I ASKED THE CLERK AT THE LOCAL FORD DEALER PARTS DEPT., THEY WOULD NOT TELL ME HOW MANY OF THE TORQUE CONVERTERS THEY HAVE REPLACED. NOR COULD I GET ANY INFORMATION FROM THEIR TRANSMISSION REPAIR MECHANICS. MY INDEPENDENT MECHANIC DID SHOW ME THE DEFECTIVE PART OF MY TRANSMISSION & DEMONSTRATED HOW THE SPLINE IN THE CONVERTER HAD WORN OUT BECAUSE IT WAS NOT PROPER HEAT TREATED FOR PROPER HARDENING & THUS THE PART MALFUNCTIONED. NEEDLESS TO SAY, THE PUMP SHAFT GEAR WHICH INSERTS ITSELF IN THE SPLINE DOES NOT HAVE THIS MALFUNCTION. THEREFORE, ANY TRANSMISSION MECHANIC OR LAYMEN CAN ONLY COME TO THE CONCLUSION THAT THIS PART #06050700015 IS A DEFECTIVE PART & SHOULD HAVE BEEN RECALLED. THIS MALFUNCTION IS CORRECTED WITH AN AFTER-MARKET PART. I HAD TO PAY $1200 TO HAVE THIS DEFECTIVE PART REMOVED & REPLACED. YOU CAN IMAGINE THE HUNDREDS OR THOUSANDS DOLLARS FORD OWNER ALL OVER THE COUNTRY HAVE HAD TO REPLACE THIS DEFECTIVE PART. I HAVE SPOKEN TO TWO FORD MOTOR CO. CUSTOMER SERVICE REPRS. & THEY SAY, "THERE IS NOTHING THEY CAN DO ABOUT IT." I ALSO WROTE A REGISTERED LETTER TO FORD MOTOR CO. CORPORATE OFFICE & RECEIVED A MAIL REPLY WITH THE SAME RESPONSE. INITIALLY I WAS ONLY ASKING FORD MO. TO COMPENSATE ME $250. FOR THE DEFECTIVE PART & NOT THE $1200.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS UNKNOWN WHAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,430. THE VIN WAS NOT AVAILABLE. UPDATED 11/09/15*LJ *CN

REPORTED THIS INCIDENT AS IF HE LIVED IN THE US, IN FACT THIS STEP IN VANCOUVER CANADA SERCA THE BORDER WITH UNITED STATES, CAN NOT FIND WHO RECEIVES MY COMPLAINT IN CANADA, CALL TRANSPORT CANADA TRABJO IN HOURS AND NOBODY ANSWERS. NOT COMMIT ANY CRIME BUT IF I COMPLAIN I'M VERY ANGRY ESTUBO ENDANGER MY LIFE DRIVING DOWN THE HIGHWAY AT 55-60 MILES / HOUR WHEN THE CAR STOPPED ROLLING, PROBE D, 3.1, R AND DO NOT PERFORM ANY MOVEMENT, NOT PRESENT ANY NOISE OR NO LIGHT IS LIT IT, THE MOTOR TURNS ON AND SOUNDS GOOD BUT NOT MORE. *TR

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHEN THE CONTACT ACTIVATED THE VENT CONTROL FOR THE AIR CONDITIONER, THERE WAS A PROGRESSIVE FAILURE AND THE VEHICLE SURGED FORWARD. THE CONTACT HAD TO ENSURE THAT THE BRAKE PEDAL WAS APPLIED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE IDLED VERY POORLY WHILE DRIVING AT A LOW RATE OF SPEED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBER: PE11018 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

WAS DRIVING AND PULLED INTO A SHOPPING CENTER, WHEN ALL OF THE SUDDEN, THE VAN WAS NO LONGER RESPONSIVE TO THE GAS PEDAL. THE VAN COASTED TO A STOP, AND I HAD TO THEN PUSH THE CAR OUT OF MOVING TRAFFIC INTO A PARKING LOT. THE VAN ACTED AS IF IT WAS IN NEUTRAL, AND COULD BE PUSHED WHEN IT WAS IT R, N, D,1AND 3. THIS OCCURRED IN THE LATE EVENING, IN SUB-ZERO WIND CHILL TEMPERATURES AND I HAD MY 5 YEAR OLD SON WITH ME AT THE TIME. LUCKILY THE VAN WAS ABLE TO KEEP RUNNING, SO WE HAD HEAT UNTIL WE COULD GET PICKED UP. HAD THE VEHICLE TOWED TO A LOCAL MECHANIC SHOP, AND THE INITIAL VALUATION IS THE TORQUE CONVERTER FAILED DUE TO SPLINE SHAFT BEING STRIPPED, JUST LIKE IN THE PREVIOUS 2005-2005 MODEL FREESTARS. FAMILY OF SEVEN, NOW WITH NO VEHICLE!! *TR

STEERING KNUCKLE-WHEN DRIVING GOING TO MAKE TURNS EITHER WAY THE STEERING GETS HARD,ACTS LIKE THERE NO POWER STEERING.WAS TOLD TO SPRAY WITH WD40,DID THAT MAKES IT EASER BUT YOU HAVE TO DO IT ONCE A WEEK. *TR

I WAS AT A COMPLETE STOP AT ELKHORN/WATT. I WAS HIT BY THE BACK WITH A FORD FREESTAR VAN, 1 ADULT DRIVING WITH 2 KIDS IN THE BACK. I GOT OUT OF MY CAR WALKED HALF TO THE BACK AND TOLD HIM TO PULL OVER AT MCDONALD'S. WE WAVED AND SHAKE HIS HEAD. I WOULD ASSUME HE WAS GOING TO PULL OVER. GREEN LIGHT HIT, CARS STARTED TO MOVE AND I TURNED ON MY BLINKER AND GO OVER TO THE MIDDLE LANE. FORD VAN DRIVER KEPT DRIVING, I NOTICED HE WASN'T GETTING OVER SO I GOT BACK INTO THE FAST LANE AND FOLLOWED HIM. FORD VAN AT THAT POINT RAN A RED LIGHT, I WAITED UNTIL LIGHT TURNED GREEN WHICH WAS A SECOND LATER. DROVE THRU RESIDENTIAL AREA, BLOWING OFF STOP SIGNS. (X4). I WAS HONKING MY HORN TO GET HIS ATTENTION AND WAVING HIM DOWN TO PULL OVER. NO RESPONSE. FORD VAN DROVE ALL THE WAY HOME. I PARKED RIGHT BEHIND HIM IN A DRIVE WAY, SO HE COULD GET OUT. WHEN I GOT OUT OF MY CAR, HE WAS YELLING AT THE KIDS TO RUN INSIDE. I WALKED UP TO HIM AT THE POINT AND SAID YOU HIT ME AND I ASKED YOU TO STOP AT THE MCDONALD'S AND YOU KEPT DRIVING. HE KEPT YELLING AT ME SAYING HE DIDN'T HIT ME THAT HE HAD TO SLAM ON HIS BRAKES. WOULDN'T GIVE ME INSURANCE CARD CAUSE HE SAID THERE WAS NO DAMAGE TO REPORT. I TOLD HIM THAT WAS NOT THE POINT, HE RAN FROM AN ACCIDENT WITH KIDS IN THE CAR. HE WOULDN'T GIVE ME HIS INS CARD UNTIL I TOLD HIM I WAS CALLING THE POLICE. MY CONCERNS: RAN FROM THE ACCIDENT RAN THRU A RED LIGHT / STOP SIGNS (WITH KIDS IN CAR) NOT SURE IF HE HAS CURRENT DRIVER LICENSES. INSURANCE CARD SHOWS EXPIRED DID HE GET CONFUSED ON BRAKE/GAS? IS THERE ANYTHING WE CAN DO? I DRIVE THAT STREET EVERYDAY, I DON'T KNOW IF HE SHOULD BE DRIVING. I DON'T KNOW HIS AGE 80? I JUST KNOW I WOULDN'T WANT HIM DRIVING BEHIND ME AGAIN. I KNOW THE KIDS FELT THE HIT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVEN CAR STARTED TO SOUND LIKE BROKEN AXLE,TOOK TO FORD DEALER GEORGE WALL SHREWSBURY,N.J. IT COST A $ 150.00 THEY HELD CAR FOR 2 DAYS AND TOLD US THAT THERE WAS NOTHING WRONG WITH THE CAR. NOISE KEPT GETTING WORST FREND FOR CHRYSLER LISTENED TO IT AND DROVE IT HE SAID IT WAS TRANSMISSION PROBLEM. I HAD NEW TRANSMISSION PUT IN CAR AT COST OF $3500.00. I KEPT CALLING FORD WITH NO LUCK. THIS VEHICLE WAS MANUFACTURED IN JUNE06,2006

WITHOUT ANY WARNING THE VAN WILL JUST LOSE POWER DURING TRAVEL. THIS HAPPENS EVERY FEW DAYS. MECHANICS DON'T KNOW WHY. *TR

INTERMITTENTLY LOCKS OUT THE IGNITION CAUSED BY THE FACTORY INSTALLED ANTI-THEFT SYSTEM. NOT EVER SURE WHEN THE CAR MIGHT START. THIS VAN IS A NIGHTMARE. *TR

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT HE BEGAN TO DRIVE IN REVERSE AND HEARD A LOUD BANGING SOUND. THE CONTACT STATED THAT HE PUT THE VEHICLE IN PARK AND EXIT THE VEHICLE; HOWEVER, IT BEGAN TO ROLL BACKWARDS. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION .THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 54,423. ...UPDATED 08/22/13 *BF THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER. AN INSPECTION REVEALED, THE RIGHT FRONT AXLE WAS BROKEN.

TRANSMISSION FAILED WITH NO SIGNS. I AM PREGNANT AND HAD MY 3 OTHER CHILDREN WITH ME. CHECKED ONLINE AND FOUND OUT THAT FORD IS USING A FAULTY TORQUE CONVERTER/TRANSMISSION. *TR

WHILE DRIVING ON A FOUR LANE IN CHARLESTON SC MY VAN STARTED JERKING AND I LOST ALL POWER AND FELT LIKE I WAS GOING TO HAVE A HEART ATTACK ! IT DID COAST ENOUGH TO GET TO THE SIDE OF THE ROAD. AFTER IT SAT FOR SEVERAL MINUTES IT STARTED UP FINE. BUT LET ME TELL YOU I ONLY LIVE 5 MILES FROM THE FIRST POWER SHUT DOWN BUT IT HAPPENED 3 MORE TIMES BEFORE I GOT HOME. *TR

DRIVING OUT OF TOWN ON THE HIGHWAY TRAVELING AT 55MPH AND MY VAN QUIT ACCELERATING AND QUICKLY LOST SPEED. PRESSED ON GAS PEDAL WITH NO RESULTS. WAS ABLE TO PULL SLIGHTLY OFF THE ROAD AND PUT MY CAR IN PARK, TURNED IT OFF AND TURNED VEHICLE BACK ON TO FIND IT WOULD NOT REVERSE DRIVE FORWARD IN ANY GEAR OR MOVE. CAR DOES START AND RUN BUT WILL NOT DRIVE. *TR

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE TRANSMISSION FAILED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THE CONTACT WAS ADVISED THAT THE POWER TRAIN REQUIRED REPLACEMENT. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT WATER HAD ENTERED THE COMPUTER AND THE COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY FILED A COMPLAINT. THE FAILURE MILEAGE WAS 102,000.

PULLED IN TO DRIVEWAY TO PICK UP A PASSENGER, STOPPED AND PUT IT IN REVERSE AND BANG, THE MOTOR DIED. RESTARTED AND SAME THING. GOT IT TO GO FORWARD BUT SAME PROBLEM, STARTS FINE AND RUNS UNTIL YOU PUT IT IN GEAR, AND IT DIES. *JB

WATER LEAKS DOWN THE HOOD THRU THE COWL. VANS PCM HAD TO BE REPLACED. THERE IS A TSB ON THIS. POOR DESIGN OF HOOD ALLOWS WATER TO LEAK INTO COWL AND INTO THE PCM. HAD PCM REPLACED AT $500 PLUS. THIS VAN IS A NIGHTMARE. *TR

VEHICLE LUNGES FORWARD AND TACHOMETER SHOWS MOMENTARY ENGINE RPMS UP TO 2500 CAUSING VEHICLE TO SURGE. USING THE BRAKE PEDAL TO CONTROL THE UNEXPECTED MOTION STALLS OUT THE ENGINE WHICH WHEN RESTARTED CAN ONLY DRIVE AT VERY REDUCED SPEED. FORD DEALERSHIP REPLACED THROTTLE BODY AND REPROGRAMMED SENSOR FOR MORE TOLERANCE AS PER NEW FORD SPECS. SERVICE ADVISOR ATTRIBUTED THE BAD THROTTLE BODY TO LOW QUALITY GASOLINE. *TR

DRIVING AT HIGHWAY SPEEDS IN TRAFFIC WITH THREE CHILDREN IN THE CAR, WHEN THE TORQUE CONVERTER/TRANSMISSION FAILED WITH NO WARNING OR INDICATION OF PREVIOUS PROBLEM. VEHICLE WOULD NOT RESPOND TO ACCELERATOR. FORTUNATELY,WAS ABLE TO COAST OFF EXIT RAMP SAFELY. WOULD NOT GO FORWARD OR BACKWARD. 300 MILES FROM HOME. TOWING, CAR RENTAL AND REPAIRS. DEALER SAID RECALL NOT APPLIED TO THIS YEAR BUT SAME PROBLEMS AS PREVIOUS YEARS. FORD SHOULD FIX THIS BEFORE SOMEONE IS KILLED. THEY ARE AWARE OF THE SITUATION.

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WOULD UNEXPECTEDLY JERK FORWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 90,258. THE VIN WAS NOT AVAILABLE.

WHILE PARKING THE CAR, THE ENGINE/GAS SURGED TAKING ME SLIGHTLY FORWARD UNTIL I PUT ON THE BRAKE. THE FIRST TIME HAPPENED IN MAY, BUT IT CONTINUES TO HAPPEN ESPECIALLY WHEN I AM GOING SLOWLY (PARKING ETC) BOTH IN FORWARD AND REVERSE AND HAVE THE AIR CONDITIONING ON. *TR

TRAVELING ON THE PA INTERSTATE VAN LOST ALL POWER. TOWED NEED COMPLETE TRANSMISSION REBUILD DUE TO FAILURE OF TORQUE CONVERTER. WE WERE LUCKY WE WERE NOT HURT. THERE WAS NO WARNING AT ALL THAT THERE WAS A ISSUE. VAN IS A NIGHTMARE. *TR

I WAS MAKING A LEFT HAND TURN FROM THE MIDDLE LANE OF A BUSY 5 LANE HIGHWAY WHEN I LOST ALL POWER TO THE DRIVE TRAIN. FORTUNATELY I HAD GAINED ENOUGH SPEED FROM THE DRIVE TRAIN TO BARELY AVOID ON COMING TRAFFIC. THREE SECONDS EARLIER AND THIS COULD HAVE BEEN A TRAGEDY. THERE WAS NO WARNING OR INDICATION OF FAILURE. THERE WERE NO SOUNDS, SMELLS, OR ERADICATE MOTIONS. I IMMEDIATELY HAD THE VEHICLE TOWED TO A FORD DEALERSHIP GARAGE. AFTER AN INSPECTION THE SERVICE ADVISOR STATED THAT THE TORQUE CONVERTER HAD COME APART AND WOULD NEED TO BE REPLACED. SINCE THEN I HAVE DONE SOME INVESTIGATIVE RESEARCH INTO FORD FREESTAR TORQUE CONVERTER FAILURES. IT APPEARS THAT THIS IS A PROBLEM THAT STARTED WITH THE 2004 FREESTAR. I HOPE THAT FORD TAKES CARE OF THIS PROBLEM BEFORE INJURY OR FATALITY. IN MY CASE, THREE SECONDS MADE THE DIFFERENCE. *TR

SUDDEN FAILURE OF THE TRANSMISSION. *TR

MY HUSBAND WAS DRIVING HOME FROM WORK WHEN ALL OF A SUDDEN NO WARNING, NO CHECK ENGINE LIGHT NOTHING, HE LOSES ALL GEARS AND SPEED. THERE WAS A LOT OF CARS BEHIND HIM, THE ROAD HE WAS ON IS VERY BUSY WITH SEVERAL HILLS AND BLIND SPOTS. WE HAVE CHECKED INTO THIS PROBLEM WITH FORD AND THEY STATE THAT YES THEY ARE AWARE OF A DESIGN PROBLEM WITH THE HOOD BY THE WIND SHIELD WIPERS THAT ALLOWS WATER TO GO IN, DRAIN DOWN THE FIRE WALL AND LEAK INTO THE PCM MODULE AND THE TRANSMISSION. THIS WATER SHORTS THEM OUT AND WITH NO WARNING YOU LOSE SPEED AND GEARS TO CONTINUE DRIVING. THIS IS A HUGE SAFETY ISSUE, I JUST THANK GOD OUR CHILDREN WERE NOT IN THE VAN, AND THAT HE WAS ABLE TO GET THE VAN OFF TO THE SIDE OF THE ROAD.

I WAS AT A BUSY INTERSECTION IN MY TOWN. WHEN THE LIGHT TURNED GREEN, I STARTED THROUGH THE INTERSECTION BUT SUDDENLY THERE WAS NO POWER. I WAS STALLED BUT EVENTUALLY DISCOVERED THAT I COULD PUT THE VEHICLE INTO 3RD GEAR AND COULD EKE MY WAY THROUGH THE INTERSECTION. I HAD MY 5 YEAR OLD SON IN THE CAR, PEOPLE WERE HONKING, IT WAS A MESS. FORTUNATELY, WE DIDN'T GET HIT. I TOOK THE FORD FREESTAR TO TWO SHOPS THAT BOTH TOLD ME THE TRANSMISSION HAD FAILED AND NEEDED TO BE REPLACED. THE SHOP I TOOK IT TO ALSO TOLD ME THE RADIATOR WAS LEAKING INTO THE TRANSMISSION SO THE RADIATOR NEEDED TO BE REPLACED AS WELL. THE WHOLE ORDEAL COST ME $4,900 FOR THE CAR REPAIR + RENTAL CAR. I'M VERY GLAD MY CHILD AND I DIDN'T GET HURT, AND I AM DEFINITELY UPSET THAT A CAR THAT WAS ONLY A FEW YEARS OLD WOULD REQUIRE SUCH AN EXPENSIVE REPAIR. ALTHOUGH I GOT THE CAR FIXED, I WONDER IF THE TRANSMISSION WILL FAIL AGAIN. *TR

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE LOST POWER WITHOUT WARNING. A LOCAL MECHANIC DIAGNOSED THE PROBLEM AS THE TORQUE CONVERTER WHICH HAD SPLINED OFF AND SENT METAL SHAVINGS INTO THE TRANSMISSION. THE DEALER WAS CONTACTED BUT THE CONTACT REFUSED SERVICE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 130,000. UPDATED 04/19/12*LJ UPDATED 04/30/12

MY 2007 FORD FREESTYLE HAD BEEN SURGING FORWARD. I THOUGHT I WAS CRAZY. THEN 6/21/11 IT WOULD ONLY DRIVE 35MPH. I HAD TO REPLACE THE THROTTLE BODY. *KB

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE ACCELERATED ABNORMALLY WHEN IN REVERSE AND WITH THE BRAKES DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE VEHICLE WAS IN NEED OF MAINTENANCE AND NEEDED A TUNE UP PERFORMED. THE REPAIRS WERE PERFORMED ON THE VEHICLE BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 105,000.

MY FORD FREESTAR HAS SPORADIC ISSUES, I HAVE NOTICED THAT THIS ISSUE ONLY HAPPENS WHEN IT RAINS. I HAVE TAKEN IT TO MECHANIC AND THEY ARE NOT ABLE TO LOCATE THE PROBLEM. I HAVE BEEN DOING RESEARCH ONLINE AND NOTICE THAT THERE IS A LOT OF COMPLAINTS ABOUT THIS ISSUE AND NOTHING IS BEING DONE ABOUT IT. WE GET THE PCM REPLACED AND THEN BECAUSE OF THE DEFECT IT GETS WET AGAIN. WHEN WILL THIS ISSUE BE RESOLVED? *TR

MY 2007 FREESTAR WITH 64K MILES STARTED OVERHEATING. I HAD TO ADD 2 GALLONS OF WATER TO MAKE IT HOME. COOLANT WAS POURING OUT BY PASSENGER TIRE. HAD IT TOWED TO FORD AND FOUND OUT THAT THE OIL COOLANT LINES HAD CORRODED THRU AND WAS LEAKING. FORD DOES NOT SELL THE METAL LINES AND HAD TO REPLACE THE ENTIRE OIL COOLING SYSTEM AT A COST OF $756.00. FORD WOULD NOT HELP US OUT. SAID IT WAS NOT THERE PROBLEM AND THE VAN WAS OUT OF WARRANTY. IF MY WIFE WAS OUT WITH OUR GRAND DAUGHTER AND IT WAS IN THE WINTER IT COULD HAVE BEEN DEADLY BEING STRANDED ON A BACK ROAD. A 4 1/2 YEAR OLD VAN SHOULD NOT HAVE LINES ROTTING OUT LIKE THIS. *TR

TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT WAS DRIVING IN REVERSE AT APPROXIMATELY 5 MPH INTO A PARKING SPACE WITH THE BRAKE PEDAL ENGAGED WHEN THE VEHICLE BEGAN TO LUNGE UNEXPECTEDLY. THE FAILURE OCCURRED SPORADICALLY WHILE DRIVING AT LOW SPEED. THE VEHICLE RECENTLY STALLED WITH THE ILLUMINATION OF THE ENGINE WARNING INDICATOR. THE VEHICLE RESTARTED AND RESUMED AS NORMAL. THE CONTACT NOTIFIED THE DEALER AND THEY RECOMMENDED THE VEHICLE BE DIAGNOSED TO DETERMINE THE CAUSE OF FAILURE. THE CONTACT PLANNED TO TAKE THE VEHICLE FOR DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THERE WAS AN OPEN INVESTIGATION RELATED TO THE FAILURE UNDER NHTSA ACTION NUMBER PE10033 (VEHICLE SPEED CONTROL; POWER TRAIN: AUTOMATIC TRANSMISSION: CONTROL MODULE/TCM,). THE FAILURE MILEAGE WAS 90,000.

I WAS ON MY WAY TO CALDWELL COMMUNITY COLLEGE FOR EVENING CLASS AND THE TRANSMISSION WENT OUT. I WAS DRIVING AT 55 MILES PER HOUR IN THE FAR LEFT LANE AND HAD TO TEDIOUSLY MANEUVER OVER TO THE RIGHT HAND LANE TO GET INTO A PARKING LOT. IT WAS VERY CONGESTED ON THE HIGHWAY DUE TO IT BEING AT ABOUT 5:30PM AND I COULD HAVE EASILY BEEN INVOLVED IN A MOTOR VEHICLE CRASH. *TR

FORD'S RECALL 11S25 SAYS IT PERTAINS TO 2004-05 MODEL YEARS ON THE TORQUE CONVERTER FAILURE. MINE IS A 2006 FREESTAR AND IT HAS THE SAME EXACT PROBLEM. THE TORQUE CONVERTER FAILED ON IT DRIVING DOWN THE HIGHWAY. WHY IS YEAR NOT COVERED ? *JS

I HAVE NOTICED THAT THIS ISSUE ONLY OCCURS WHEN IT RAINS. I HAVE TAKE IT TO SEVERAL MECHANIC AND THEY WHERE NOT ABLE TO PIN POINT THE ISSUE SINCE IT DOES NOT HAPPEN REGULARLY. WHILE DOING SOME RESEARCH ON THE INTERNET I HAVE NOTICED THAT THIS IS A COMMON THING AMONG FORD FREE STAR. I PLAN TO TAKE MY VEHICLE TO A MECHANIC WITH THE INFORMATION REGARDING PCM ISSUE, IF THIS A COMMON DEFECT I HOPE THERE WILL BE A RECALL. THIS IS AFAMILY VEHICLE I DRIVE MY CHILDREN IN IT EVERYDAY AND THIS IS A POTENTIAL HAZARD IF MY VAN WAS TO DIE ON THE INTERSTATE. *TR