2012 Ford Fusion Engine Problems

Vehicle loses power while driving, with no response when accelerator is depressed further. The engine continues to run but no throttle response. No engine warning light came on. No codes stored. Must stop, turn off engine and perform an engine restart to continue driving again.

THE WRENCH LIGHT COMES ON AND THE VEHICLE CUTS OFF IT WILL START BACK UP BUT IT'S RANDOM AND CUTS OFF ANYTIME IT WANTS. IT'S DONE THIS WHILE PARKED AND MOVING. THROTTLE BODY EXTENDED WARRANTY. MY CAR IS UNDER THE 150,000 MILES AND MET THE REQUIREMENTS FOR THIS TO BE REPLACED AND I TOOK IT TO RAVENEL FORD RAVENEL SC AND WAS TOLD THAT BECAUSE THEY DIDN'T GET THAT CODE THAT THEY WE'RE ALLOWED TO FIX IT

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE OVERHEATED WHILE DRIVEN AT VARIOUS SPEEDS. THE CONTACT'S HUSBAND A CERTIFIED MECHANIC, REPLACED ONE WATER HOSE. THE CONTACT BECAME AWARE OF NHTSA CAMPAIGN NUMBERS: 12V551000 (ENGINE AND ENGINE COOLING) AND 17V209000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

ELECTRONIC THROTTLE BODY ERROR CODES LEAD TO LOSS OF ENGINE POWER AND ENGINE BEING THROTTLED BACK TO APPROX. 10 MPH IN "LIMP HOME MODE". ISSUE IS INTERMITTENT, AND NHTSA HAS STUDIED THE PROBLEM PREVIOUSLY. FORD SAYS MY ETB IS NOT INCLUDED IN THE RECALLS, AND THAT I NEED TO PAY FOR THE REPAIRS. IT IS A KNOWN PROBLEM WITH THIS YEAR FORD FUSION, AND FORD SUPPOSEDLY MADE A 10YR 150,000 MILE WARRANTY ON THE PART....JUST NOT MY ETB.

I EXPERIENCING A 'THROTTLE BODY' MALFUNCTION. MY VEHICLE STALLS WHILE DRIVING IN TRAFFIC. THERE ARE NUMEROUS COMPLAINTS IN REFERENCE TO THIS ISSUE, BOTH ONLINE AS WELL AS IN PERSON. THIS IS A HIGHLY DANGEROUS PROBLEM FOR MYSELF AND MY FAMILY. ON THE HIGHWAY THIS CAN / WILL CAUSE A VERY DANGEROUS SITUATION TO MANY OTHER MOTORISTS AS WELL. FORD REFUSES TO ACKNOWLEDGE THIS AS A MANUFACTURING DEFECT ISSUE AND, BY DOING SO, IS PLACING COUNTLESS PEOPLE AT RISK UNNECESSARILY. I AM FED UP WITH DEALERSHIPS COVERING UP FOR DANGEROUS MANUFACTURING ISSUES. THIS PROBLEM NEEDS TO BE ADDRESSED ASAP. THIS PROBLEM IS GETTING WORSE EVERY DAY.

CAR STALLED WITHOUT ANY WARNING. THEN IT STARTED IMMEDIATELY. NEXT DAY STARTED, THEN STALLED IMMEDIATELY AND WOULD NOT START. THE FIRST TIME WE WERE ON TRAFFIC CIRCLE, AND SECOND TIME IN GARAGE

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 68 MPH, THE VEHICLE STALLED AND THE POWER ASSIST INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A LOCAL DEALER (BOB ALLEN FORD, 9239 METCALF AVE, OVERLAND PARK, KS 66212), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND ADVISED THE CONTACT THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 130,000.

CAR INTERMITTENTLY SHUTS DOWN/STALLS OUT WITH NO WARNING WHEN ACCELERATING ,AT ALL SPEEDS AND CONDITIONS. THE LITTLE WRENCH LIGHTS UP ON THE DASH BUT VEHICLE IS NOT THROWING ANY CODES. VERY DANGEROUS SITUATION!!! CALLED THE DEALERSHIP AND NO RECALLS OR ACKNOWLEDGEMENT FROM FORD THAT THERE IS A PROBLEM. HARD TO BELIEVE NO ACTION BEING TAKEN AS OF YET WITH ALL OF THE OTHER COMPLAINTS I HAVE READ FROM OTHER OWNERS. VERY DISAPPOINTED HERE. CAR HAS ALL ROUTINE MAINTENANCE PERFORMED ON IT AND IS VERY WELL CARED FOR, MILEAGE IS JUST OVER 58,000. SURE WOULD APPRECIATE FORD STEPPING UP TO THE PLATE AND STANDING BEHIND THEIR PRODUCT!

MY VEHICLE BEGAN TO OVERHEAT AS A RESULT OF A RECALL. I BROUGHT THE VEHICLE INTO MY DEALERSHIP AND THEY TOLD ME THE MANUFACTURERS DEFECT HAD RUINED MY ENGINE AND IT NEEDED TO BE REPLACED. FORD HAS REFUSED TO REPAIR THE VEHICLE WHICH IS NOW INOPERABLE. THEY CLAIM IT'S OUT OF WARRANTY BUT HOW CAN MY WARRANTY BE VOID IF IT'S A RECALL DEFECT.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING APPROXIMATELY 30 MPH, THE BOLT FROM THE ENGINE FRACTURED AND HIT THE CV JOINT. GREASE FLOODED THE CV JOINT WHICH MADE IT DIFFICULT TO DRIVE THE VEHICLE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS NOT SURE IF THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 83,894. UPDATED 07/11/17*LJ CONSUMER STATED HE WORKED ON THE VEHICLE ENGINE TO GET THE BROKEN BOLT OUT, BUT WAS NOT ABLE, BECAUSE HE DID NOT HAVE THE RIGHT TOOL. UPDATED 9/28/18 *JB

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING AND SLOWING TO A STOP, THE CONTACT NOTICED AN ABNORMAL SMOKE ODOR EMITTING FROM THE FRONT OF THE VEHICLE. THE CONTACT STATED THAT THE ODOR WAS LIKE BURNING OIL. AN INDEPENDENT MECHANIC DETERMINED THAT THERE WAS EVIDENCE OF AN OIL LEAK, BUT COULD NOT LOCATE ITS ORIGIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 97,900.

PLEASE REFER TO ATTACHED FILES.

ENGINE STALLS WITHOUT WARNING

DRIVING ON THE 605 FWY WITH MY 5 YEAR OLD GOING ABOUT 65MPH WHEN MY CAR SUDDENLY LOST POWER AND A ORANGE WRENCH LIGHT APPEARED, I WAS ABLE TO PULL OFF TO THE SHOULDER WHEN MY CAR JERKED AND COMPLETELY SHUT DOWN. IT TOOK ME 3 TIMES TO GET IT STARTED ONLY TO HAVE THIS HAPPEN AGAIN ABOUT 2 MILES UP THE ROAD. I WAS ABLE TO SAFELY GET HOME BUT MY MECHANIC HAS ADVISED THAT I HAVE AN ERROR CODE P2111 AND MY THROTTLE BODY WILL NEED TO BE REPLACED. THIS IS EXTREMELY DANGEROUS AND I AM NOT A HAPPY FORD CUSTOMER. I WILL BE TAKING IN MY CAR TO THE DEALER TOMORROW IN HOPES THAT THEY WILL STAND BEHIND THIER PRODUCT AND REPLACE THIS PART.

2015 HAD THROTTLE BODY REPLACED BY FORD FOR NOTHING ..8 MONTHS LATER IT HAPPENED AGAIN 6/3/16..FORD PAID FOR THE FIRST WONT DO THE SECOND WITHOUT ME PAYING FOR IT..THIS CAN BE DANGEROUS AS IT JUST STOPS , YOU HAVE NO POWER TO MOVE, THEN IT SHAKES AND DIES. I DID START IT RIGHT AFTER AND GOT HOME BOTH TIMES. JUST SAYING IF THIS IS A FAULTY PART..WHY ARENT THEY FIXING IT, NOT US. I F YOUR GOING FASDT I WOULD HATE TO THINK WHAT WOULD HAPPEN ON A BIG HIGHWAY.

CAR EXHIBITS A DRONE/MOAN OR RATTLE NOISE. THE NOISE TYPICALLY OCCURS WHILE DRIVING UP A SLIGHT INCLINE, UNDER LIGHT THROTTLE AT 45-61 KM/H (28-38 MPH) AT 1300-1400 RPM, IN 5TH GEAR. THE NOISE MAY BE PRESENT WITH THE A/C ON OR OFF BUT IS TYPICALLY AGGRAVATED WHEN THE A/C COMPRESSOR CYCLES ON. THIS IS THE EXACT SAME ISSUE AT TSB 11-10-26, BUT THAT TSB ONLY APPLIES TO ESCAPE AND MARINER VEHICLES EVEN THOUGH THE ISSUE ALSO APPLIES TO FUSIONS. THIS TSB SHOULD APPLY TO ALL VEHICLES AFFECTED, NOT JUST SOME. SEE VIDEO FOR EXACT SOUND: HTTPS://WWW.YOUTUBE.COM/WATCH?V=PMCS-0SAU5W THANKS

DRIVING AT 10 MPH TURNING INTO A CITY STREET AND THE CAR STALLED. I SHUT OFF THE CAR AND RESTARTED IT AND IT WORKED TO GET ME TO MY DRIVEWAY (~400 FEET).

I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH. I HAD BEEN DRIVING FOR ABOUT 30 MINUTES. THE CAR SUDDENLY LURCHED. THE "WRENCH" LIGHT ILLUMINATED AND I HAD NO POWER FROM THE ENGINE. I COASTED TO THE EMERGENCY LANE. THE IDLE WAS VERY ROUGH AND SPUTTERING. I RESTARTED THE CAR AND IT OPERATED NORMALLY FOR THE NEXT 15 MILES WHEN I REACHED MY DESTINATION.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND THE WRENCH WARNING LIGHT ILLUMINATED. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED MULTIPLE TIMES AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

SMALL EVAPORATIVE LEAK ATTRIBUTED TO THE FUEL FILLER NECK AS PART OF THE CAPLESS GAS SYSTEM. THIS YEAR, MAKE, MODEL PRESENTS CONSISTENT ISSUES IN THIS AREA. PREVIOUS MODEL YEARS HAD RECALLS ASSOCIATED WITH THIS ISSUE, BUT NOT THE 2012 FOR SOME REASON.