2022 Ford Maverick Electrical System Problems

"Powertrain System Fault" was given from App, "service engine soon" on dash along with check engine light and "wrench". Dealership said Hybrid battery needs replaced. Dealership said "We don't know what the battery issue will effect if it does go bad." Corporate says "wear and tear item after 36000 miles or 3 years". I have also had to replace the 12V battery this year. I do not see how both batteries can "go bad" within 4 years of manufacturing... Online says truck could go into limp mode with no warning. Truck is available for inspection upon request. If truck will go into limp mode with no warning, could cause many safety issues. Problem initially occurred 3 days ago. Dealership cleared codes and has not happened again. Vehicle has only been inspected by dealership Only issue with electrical before EV battery was the 12V battery that went bad and had to be replaced. Went to start up the truck one afternoon (had been driving all day before this) and the lights on the dash popped on and the "Service Engine Soon" popped up and beeped. Drove it home that Saturday and did not drive it until dropped it off at dealership Monday morning. There must be something electrically causing problems since I just replaced my 12V battery about 6 months ago and now the EV battery is "bad". I've never heard of a Ford 12V battery not lasting at least 8 years. Multiple people I know have original 12V batteries in vehicles 2018 and older... Batteries should not be considered a "wear and tear item" batteries should be covered under their own warranties. Having basically no warranty on batteries poses a severe health risk with the disposal and creation of the old and new batteries.

The contact owns a 2022 Ford Maverick. The contact stated that while her husband was driving 55-65 MPH, the vehicle shut off. The driver was unable to pull over to the side of the road. The driver was able to jumpstart the vehicle and continued driving. The contact stated that the failure recurred while pulling into a parking lot. The dealer was contacted and informed the contact that the vehicle could not be picked up due to safety concerns. The vehicle was towed to the dealer, where it was diagnosed, and determined that a new 12-Volt battery cable overlay was needed, and the current battery cable needed to be disabled. The dealer related the failure to the Ford Customer Satisfaction Program: 22B39 (2022 Maverick HEV No Start Condition), but the contact was informed that the Customer Satisfaction Program had expired. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure but denied assistance. The failure mileage was 80,000.

Per a video posted on LinkedIn on March 20, 2026 by Chris Hackney, a Fountainhead Logistics Class 8 tractor displaying a Texas License plate on the front bumper & equipped with the Kodiak Robotics "Kodiak Driver" autonomous system was pulling three 40' belly dump trailers used to transport frac sand on an unknown public roadway in the West Texas Permian Basin in violation of Texas State law which prohibits triple trailers on public roadways. I can't confirm that the movement of the triple trailers shown in the video actually occurred on a public roadway vs a private lease road in the oil & natural gas fields where Fountainhead Logistics operates. I request NHTSA reach out to Fountainhead Logistics &/or Kodiak Robotics to confirm if such alleged illegal movement was made on a public roadway.

The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.

I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.

In cold weather -6F The cover over the positive terminal used to jump start the vehicle is impossible to remove. This causes a situation where the vehicle can not be jump started or render assistance to another that needs jump started. The issue stems from the fact that the plastic cover over the positive terminal is unable to bend when it is cold and can not be "unclipped".

After a little over 3 years, my truck has had issues maintaining its 12v battery putting me at risk of being stranded. The battery was replaced once under warranty. Now that I am out of warranty, the replacement battery is now going bad.

Battery in the passenger compartment is charging at 15.2 volts constantly. Ford dealer claims this is not a problem, but the battery life has been shortened, and the battery model number states it should be charged between 13.8 and 14.2 volts. The battery is located under the rear seat, inside the passenger compartment. From my limited understanding of battery technology, over-charging can produce hydrogen into the passenger compartment. My vehicle is now on the third battery, and has only 73,511 miles.

The contact owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to respond. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed, and determined that the battery needed to be replaced. The contact stated that the failure had occurred on several occasions. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 19,150.

My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises

The contact owns a 2022 Ford Maverick. The contact stated that after driving the vehicle and parking, the vehicle failed to restart. The vehicle was jump-started. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 36,000. The VIN was invalid.

My 2022 Ford Maverick Hybrid experienced a complete electrical system failure at approximately 15,933 miles, resulting in a no-start condition. The failure involved the vehicle’s electrical distribution system. An authorized Ford dealership (Autos Vega Ford) diagnosed that voltage was not reaching the Body Control Module (BCM) due to a fault in the battery cable and wiring system. The repair required replacement of the 12V battery, high-voltage battery cables, and wiring components. The failure was confirmed by the dealership (Autos Vega Ford) and required multiple jump starts, but the vehicle would not consistently restart after being turned off. There were no prior warning indicators before the failure. The issue occurred suddenly without warning. This failure created a safety risk because the vehicle could not be started or operated. If this failure occurred in an unsafe or remote location, it could leave occupants stranded and unable to move the vehicle. Service records are available through the authorized dealership (Autos Vega Ford). This appears to be a premature electrical system failure at low mileage involving critical components such as battery cables and wiring. Similar issues involving electrical systems, battery defects, and wiring faults have been reported in Ford Maverick Hybrid vehicles. The vehicle became inoperable without warning and required towing/assistance to reach a repair facility. A sudden no-start condition in a hybrid vehicle can create hazardous situations if it occurs in traffic, at intersections, or in remote areas where assistance is not immediately available.

2022 Ford Maverick had water build up under the front passenger seat floor. I'm at 3.5 years of ownership and the dealer is telling me it will cost $1100 to fix because of an improperly installed windshield and cowl issue which ruined the internal filter and air circulation motor. Now i have to pay out of pocket because of a crappy manufacturer defect. I have seen in Maverick forums that this is a common issue and yet we are the ones having to fork out the cash.

At a intersection turning lane as I got a green arrow, ( as I pushed down on accelerator)a loud pop sounded and all vehicle operations stopped immediately. The battery had popped in the top front side, with battery liquid all over battery. No hazard lights, no putting into gear, only driver door operational at a very busy intersection. Flagging traffic and trying to call for new battery, very tough. Plant city Florida police arrived 20 minutes later. They waited with me until 40 minutes a battery arrived. I cleaned up acid with towel I had in front and tech changed battery. [THIS INCIDENT [XXX]- intersection [XXX] ] I can't express th [XXX] ot changing every battery thats compromised is beyond crazy. I paid $385 for the battery and spent $10 thousand of my life in that intersection. Fords are a lifetime of Dad's/my Family vehicle purchase history and I wish I had some of Ford Brass in the intersection with me. If they think they have a problem, I can guarantee it. Bartow Ford can't do anything because ( its Ford problem/remedy. I was discouraged they didn't say bring it in, but my buying any future product may be my remedy. Their were no warning lights, no smells from engine, no signs of any whisps of smoke coming up from hood. All I can finish with is when it happens, your out of business completely, where ever your at. The tech took the battery and I didn't take a picture because getting out of traffic was No.1. You can't sit inside and read your manual, with no emergency hazards at a busy intersection. You won't get this adrenaline rush/anxiety on a Universal thrill ride. You have a good chance of being hit by one or more vehicles on the inside or outside. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

while i was driving the truck lost power and i could not turn on my 4 way flashers when i was on the side of the road. when i called ford and asked if i would replace the battery if i would get compensation they told me no even though there is a recall

The contact owns a 2022 Ford Maverick. The contact stated that while attempting to park the vehicle, the rearview camera became inoperable. The contact stated that the image displayed on the screen was frozen. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 52, 000. VIN tool confirms parts not available.

The contact’s father owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that the electrical components in the vehicle were on; however, the engine was off. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that no cause for the failure was found. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 24,104.

The vehicle constantly goes into deep sleep mode and will not start. Battery was tested good at the dealer but would die after 2 hours of sitting. Battery was replaced with an AGM and still has the same issues. Dealer cant find an issue. Happened again today and left me stranded.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 25V019000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The service engine light turned on. Observed the outside temperature displayed was incorrect at 189 degrees in the winter. The heat stopped working and front window defroster stopped working.