2020 GMC Acadia Engine Problems

Check engine light codes: P01F0; P0128 Engine coolant thermostat opening at a lower temperature than intended. Replace thermostat.

Failed component was thermostat and I do not have possession of it. Over several months, I would receive infrequent and unrepeatable messages of "steering assist reduced" and my temp gauge would drop all the way to the cold side. No other recorded codes were being set after frequent trips to Autozone for verification and there were no check engine light warnings. No other signs of vehicle malfunctioning were present either. Recently, a code was finally set P01F0, so I had something tangible to take into shop as the prior condition was not repeatable. Hoping it was only the coolant temperature sensor, then ultimately learned the thermostat had failed - the much more expensive repair option. Seeing this complaint relatively frequently with the 3.6L engine on NHTSA. Plus, the tech says he has changed at least 100 of these - Acadias, Traverses, Enclaves, etc., any GM product with this engine and poor design/position for the thermostat.

Rear heater line leak detected during evaluation of engine code P01F0 and empty expansion tank was noted. There was never any puddle in my garage prior to the incident, and nothing detected after the fact either. Pictures included demonstrate a leak at the double-crimp near the farthest rear point of the vehicle. The other hose behind the drip photo was also leaking at the crimp under the secondary piece of hose insulation. The design of the system requires replacement of the entire heater line assembly (4 pipes, associated hoses and fittings) traversing the entire length of the vehicle. I was told this is a dealer-only part.

The contact owns a 2020 GMC Acadia. While the vehicle was at the dealer for maintenance, the contact was informed that the radiator was leaking and needed to be replaced. In addition, the contact was advised that there was coolant intrusion. The contact stated that it was not specified if the coolant intrusion had gone into the engine. No warning lights were illuminated. The vehicle was not repaired due to the cost. The contact was informed that the fueling system needed cleaning service, as well as the brake fluid and transmission fluid needed to be serviced. The vehicle was taken to several independent mechanics, and no leaks were found with the radiator. The manufacturer was not made aware of the failure. The failure mileage was approximately 62,000. The VIN was not available.

I'm not sure of the exact sequence of events here, but there are multiple exhaust leaks. One is a crack somewhere in the catalytic converter that is now leaking exhaust from the back of the engine into the passenger compartment. The other leak is at the point of a bracket which fastens the two front exhaust pipes together. At the time we first noticed an exhaust leak sound upon cold start, there were are around 58,000 miles on the car. Now a month later there are still less than 60,000 miles on the car. The dealership originally estimated repair costs to replace the catalytic converter and two front pipes at $3,200. When I had another service garage look at the problem, they asked why the GMC dealer wasn't willing to replace the catalytic converter under the 80,000 mile / 8 year warranty. When I raised this with the dealership, they said this was a "gray area" becasue they believe what happened was that the exhaust bracket at the front pipes failed first, which then caused the catalytic converter to crack. Ultimately, they indicated they would be willing to pay parts and labor related to the catalytic converter (approx $2,000) if we paid the other $1,200 to cover the front pipes. What I don't understand is why, when both Chevrolet and Buick have extended their front pipe warranties on comparable model years of the Chevy Traverse and Buick Enclave, which use the exact same part numbers for the catalytic converters and pipes to 150,000 miles/15 years, why GMC has not offered the same special coverage on the Acadia. Regardless of which cracked first, the front pipe bracket or the catalytic converter, there is likely an engine vibration/movement issue that casues the cracks, giving rise to exhaust venting into the passenger compartment. Since we have yet to be able to schedule the repair (catalytic converter was on back order), we can now only drive the vehicle with the windows down to lessen the exhaust smell. The Acadia deserves a Special Coverage Advisory on this.

Engine coolant thermostat failed under 55,000 miles and had to have it repaired on my 2020 Acadia. The 2021 Acadia has a recall on the thermostat.