2009 GMC Canyon Fuel System Problems

I WAS DRIVING APPROX. 65 MPH IN HEAVY TRAFFIC ON THE NEW YORK STATE THRUWAY WHEN I LOST ALL POWER TO MY TRUCK AND WAS BARELY ABLE TO MANUEVER OFF THE ROAD. I HAD MY TRUCK TOWED TO MY MECHANIC & WAS TOLD THAT IT WAS THE FUEL PUMP FLOW CONTROL MODULE. RECALL NO. 08411 2009 GMC CANYONS WERE RECALLED BECAUSE OF THIS PROBLEM. THE RECALL STATED THAT THE FUEL SYSTEM CONTROL MODULES HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE RTV SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE. WATER IN THE MODULE COULD CAUSE A SHORT, ILLUMINATION OF THE SERVICE ENGINE SOON LIGHT (WHICH WAS ON IN MY TRUCK). ALSO THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL. IF THE VEHICLE STALLS WHILE IT IS MOVING, A CRASH MAY OCCUR! THIS HAPPENED TO ME BUT I WAS FORTUNATE ENOUGH TO NOT CRASH AND DIE. LIKE OTHERS MY TRUCK DID NOT FALL WITHIN THE VIN #S. OBVIOUSLY THERE WAS A PROBLEM WITH THIS PART. MY TRUCK HAD THE PROBLEMS STATED IN THE RECALL AND THIS WAS CONFIRMED BY MY MECHANIC & DEALERSHIP. HOWEVER, GMC DENIED THE REIMBURSEMENT BECAUSE IT WAS NOT WITHIN THE RECALLED VIN#S. GMC WAS NOT BROAD ENOUGH WITH THEIR RECALL!! I'M ATTACHING A PHOTO OF THE MODULE AND YOU CAN CLEARLY SEE THE CORROSION .

INTERMITTENT AND REPEATED PARTIAL FAILURE OF FUEL SYSTEM CONTROL MODULE PART NUMBER 20850907 DURING DRIVING, INCLUDING ROUGH ENGINE OPERATION, LOSS OF MOST OF ENGINE POWER ON MODERATE HIGHWAY GRADE, SLOWING TO 15 MPH UNDER SPEED LIMIT, AND FAILURE TO RESTART APPROXIMATELY 15 MINUTES AFTER SHUTDOWN. MALFUNCTION INDICATOR LAMP LIT AND DIAGNOSTIC CODE FOR LOW FUEL RAIL PRESSURE WAS RECORDED, BUT FSCM MALFUNCTION DIAGNOSTIC CODE WAS NOT RECORDED UNTIL AFTER AT LEAST TWO INCIDENTS HAD TAKEN PLACE. VEHICLE (VIN) ENTRY INTO DATABASE RETURNED "0 RECALLS", SO NHTSA CAMPAIGN 09V154000 REMAINED UNKNOWN AND ORDINARY REPLACEMENT OF FSCM WAS ATTEMPTED. WHEN FSCM 20850907 REPLACEMENT WAS ORDERED, GM FSCM PART 20759945 WAS SUPPLIED, WHICH FAILED TO OPERATE. GM DEALER REFUSED TO VERIFY CORRECT PART NUMBER AND WITHHELD ALL INFORMATION ABOUT NHTSA CAMPAIGN 09V154000.

ATTEMPT TO START THE ENGINE AFTER SITTING FOR A FEW HOURS IN DRIVEWAY, THE ENGINE STARTS THEN SPUTTERS AND STALLS AS IF NOT GETTING ENOUGH GAS AND ATTEMPTS TO DIE. AFTER A FEW MOMENTS, IT FINALLY CATCHES UP AND RUNS. ENGINE HAS STALLED WHILE SITTING AT TRAFFIC LIGHS SEVERAL TIMES. ACCORDING TO DOCUMENT ID # 2274089--- #08411 PRODUCT SAFETY- HARD START, NO START, ENGINE STALL- REPLACE ENGINE CONTROL MODULE- ( MAY 7, 2009) I HAVE TAKEN MY VEHICLE TO A GMC DEALERSHIP SEVERAL TIMES IN THE PAST ALONG WITH A COPY OF RECALL BUT THEY CLAIM THAT IT IS A SERVICE BULLENTIN AND NOT A RECALL SO THEY WOULD NOT FIX THE PROBLEM. I TOOK MY VEHICLE TO AN INDEPENDENT GATEWAY SERVICE DEALERSHIP AND TOLD THEM THE PROBLEM I WAS HAVING WITH THE ENGINE STALL. THEY PULLED UP THE RECALL AND SHOWED IT TO ME AND ADVISED ME TO TAKE MY VEHICLE TO A GM DEALERSHIP FOR THE RECALL THAT THE GM DEALERSHIP SAYS THAT THERE IS NO RECALL. I HAVE HAD THIS TRUCK FOR 4 YEARS NOW AND THE SAME PROBLEM EXIST BUT GM DENYS THAT A RECALL EXIST EVEN WHEN I HAVE THE PAPERWORK IN HAND.THE RECALL PERTAINS TO TRUCK NUMBERSBETWEEN 98104805 - 98123129. MY TRUCK # IS 98123053 WHICH FALLS IN THAT CATEGORY. MY VEHICLE FALLS INTO THIS CATEGORY BUT HAS NOT BEEN REPAIRED SINCE I HAVE HAD POSESSION. I WOULD APPRECIATE IT IF THIS PROBLEM CAN BE RESOLVED.

TO START OUT I WOULD LIKE TO SAY THAT THIS IS MY FIRST BRAND NEW VEHICLE I HAVE EVER BOUGHT. I WAS ON I 475 DRIVING APPROX. 65 MPH WHEN I LOST ALL POWER TO MY TRUCK AND WAS BARELY ABLE TO COAST OFF TO THE SIDE OF THE ROAD. I HAD MY TRUCK TOWED TO THE NEAREST GMC DEALERSHIP TO DETERMINE THE PROBLEM. I WAS TOLD THAT IT WAS THE FUEL PUMP FLOW CONTROL MODULE. I RESEARCHED THIS PROBLEM AT HOME AND FOUND OUT THAT 2009 GMC CANYONS WERE RECALLED BECAUSE OF THIS PROBLEM. THE RECALL STATED THAT THE FUEL SYSTEM CONTROL MODULES HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE RTV SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE. WATER IN THE MODULE COULD CAUSE A SHORT, ILLUMINATION OF THE SERVICE ENGINE SOON LIGHT (WHICH WAS ON IN MY TRUCK). ALSO THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL. IF THE VEHICLE STALLS WHILE IT IS MOVING, A CRASH MAY OCCUR! HELLO, THIS HAPPENED TO ME BUT I WAS FORTUNATE ENOUGH TO NOT CRASH AND DIE. SO BACK TO THE RECALL ON MY TRUCK. GUESS WHAT? MY TRUCK DID NOT FALL WITHIN THE VIN #S THAT WERE RECALLED AND I WAS REQUIRED TO PAY FOR THE REPAIR. TO MAKE MATTERS WORSE MY WARRANTY COVERED THIS PROBLEM IF THE TRUCK WAS WITHIN 3 YEARS OR 36,000 MILES WHICHEVER COMES FIRST. WELL MY MILEAGE WAS ONLY 31,000 SO THAT WOULD QUALIFY BUT MY TRUCK WAS OVER 3 YEARS OLD. THIS IS SOOOOOOOOOOOOOOO WRONG!!! OBVIOUSLY THERE WAS A PROBLEM WITH 2009 GMC CANYONS BEING BUILT. HOW CAN YOU SAY IT WAS JUST A CERTAIN FEW THAT HAD THIS FAULTY PART PUT IN IT. MY TRUCK OBVIOUSLY HAD THE PROBLEMS STATED IN THE RECALL AND THIS WAS CONFIRMED BY THE DEALERSHIP.HOWEVER AFTER MANY AGGRAVATING HOURS TO GMC THEY STILL DENIED THE FIX BECAUSE IT WAS NOT WITHIN THE RECALLED VIN#S AND THAT IS WRONG ON SO MANY LEVELS. HOW MANY PEOPLE HAVE TO DIE OR GET HURT BEFORE THEY DO SOMETHING ABOUT THIS? *TR

THIS INCIDENT HAS HAPPENED ON SEVERAL OCCASIONS. WHEN TAKING OFF FROM A STOPPED POSITION AND GOING THROUGH THE GEARS WHEN ACCELERATING QUICKLY, THE ACCELERATOR HAS STUCK EVEN WHEN MY FOOT IS TAKEN OFF OF THE PEDAL. THIS HAPPENS AS I AM SHIFTING FROM FIRST TO SECOND GEAR, WHEN I TAKE MY FOOT OFF THE GAS THEN PUSH IN THE CLUTCH AND SHIFT GEAR AND RELEASE THE CLUTCH, THE COMPUTER DOES NOT RESPOND TO MY FOOT COMING OFF THE THROTTLE. THE TRUCK CONTINUES TO ACCELERATE EVEN WITH MY FOOT OFF OF THE THROTTLE. THE ONLY WAY TO STOP THE ACCELERATION IS TO REPEATEDLY TAP THE PEDAL UNTIL IT RELEASES. THE FIRST TIME THIS HAPPENED I THOUGHT THAT I MIGHT HAVE INADVERTENTLY HIT THE CRUISE CONTROL BUT THIS IS NOT THE CASE. IT SEEMS THAT I NEED TO ALLOW APPROXIMATELY A ONE SECOND DELAY FROM WHEN I REMOVE MY FOOT FROM THE THROTTLE UNTIL I PUSH IN THE CLUTCH TO AVOID THIS SITUATION. IS THIS TYPICAL OF TODAY'S COMPUTER CONTROLLED VEHICLES? *TR

TL* THE CONTACT OWNS A 2009 GMC CANYON. THE CONTACT WAS DRIVING 65 MPH WHEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE DEALER ADVISED THAT THE FUEL CONTROL MODULAR WOULD NEED REPLACING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V154000 (FUEL SYSTEM, GASOLINE) AND WAS ADVISED THAT HIS VIN WAS NOT INCLUDED WITH THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 105,000.