2000 Hyundai Elantra Engine Problems

The contact owns a 2000 Hyundai Elantra. The contact stated while driving at an unknown speed, there was an abnormal odor entering the cabin of the vehicle, causing the contact to be nauseated. The vehicle was taken to the dealer and the contact was informed that there was no cabin air filter installed in the vehicle. The cabin air filter was not replaced. The manufacturer was contacted and informed the contact that the vehicle was out of warranty. The failure mileage was 19,000.

FAX FROM CONGRESSMAN DENT ON BEHALF OF CONSTITUENT WHO IS REQUESTING ASSISTANCE IN REGISTERING A COMPLAINT AGAINST HYUNDAI. *NJ THE CHECK ENGINE LIGHT ILLUMINATED AND A LOUD NOISE WAS HEARD. THE EXHAUST MANIFOLD WAS REPLACED DUE TO IT BEING CRACKED. (THE CONSUMER WHO WROTE IN, WORKS FOR THE DEALERSHIP THAT SOLD THE CONSUMER THE VEHICLE. THE DEALERSHIP DIDN'T CHARGE THE CONSUMER FOR THE REPAIRS, HOWEVER THE DEALERSHIP IS REQUESTING REIMBURSEMENT FROM HYUNDAI) *JB

RECALL NOTICE FOR 2000 HYUNDAI ELANTRA. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR POSSIBLE CRACKS IN THE MANIFOLD. IT WAS INSPECTED AND THE REPAIRS WERE COMPLETED. *NJ THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THE CONSUMER WAS INFORMED THE MANIFOLD WAS CRACKED AND HAD TO BE REPLACED ALONG WITH THE ATTACHED CATALYTIC CONVERTER. *JB

I THOUGHT MY MUFFLER HAD A HOLE IN IT SO I TOOK TO A SHOP AND THEY TOLD ME THERE WAS NOTHING WRONG WITH MY MUFFLER. TO ANOTHER SHOP AND TOLD I HAVE A CRACKED MANIFOLD. I THINK IT'S ABSURD THAT A 2000 MODEL CAR COULD GO THROUGH 2 MANILFOLDS IN 7 1/2 YEARS. WAS AT THE DEALERSHIP ON 10/09/03 REPORTING THE EXHAUST SYSTEM WAS NOISY. WAS TOLD IT WAS NOT MUFFLER BUT WAS A CRACKED MANIFOLD. LUCKILY IT WAS REPAIRED UNDER WARRANTY. THAT WAS LESS THAN 5 YEARS AGO. SOUNDS LIKE A BIG PROBLEM TO ME. I CAN UNDERSTAND ONE MANIFOLD GETTING CRACKED...BUT TWO IN LESS THAN 4 1/2 YEARS. THIS CAR IS DRIVEN LESS THAN SIX MILES ROUND TRIP TO WORK A DAY. IT'S NOT LIKE I'M OUT TEARING UP THE TOWN ALL THE TIME IN THE CAR. *TR

2000 HYUNDAI ELANTRA - NEW------------7/05 W/ 17,923 MILEAGE ON THE CAR. I NEEDED TO REPLACE THE MOTOR ON THE PASS. FRONT WINDOW & BOTH BACK WINDOWS. IT IS NOW 12/07 AND I NEED TO REPLACE THE SAME MOTORS IN ALL 3 WINDOWS , MY CAR NOW HAS 29,420 MILEAGE ON THE CAR. THE WINDOW THAT I WOULD USE THE MOST IS THE DRIVERS FRONT , IS JUST FINE. *TR

MY EXHAUST MANIFOLD IS CRACKED.

DT*: THE CONTACT STATED WHILE DRIVING 15 MPH, THE ENGINE HESITATED, THEN STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THAT THE PROBLEM WAS WITH THE MASS AIR FLOW SENSOR WHICH WOULD NEED TO BE REPLACED. HOWEVER, THE REPLACEMENT PARTS NEEDED TO BE ORDERED. THE MANUFACTURER WAS CONTACTED WHO DETERMINED THERE WAS A RECALL # 00V259001 REGARDING ELECTRICAL SYSTEM:WIRING BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

THIS VEHICLE WAS PURCHASED AS A USED VEHICLE IN APRIL 2004. IT ONLY HAD 38,000 MILES ON IT. I REPLACED ALL THE BELTS, TIRES AND FLUIDS IN THE VEHICLE. IN AUGUST 2004, THE CAR OVERHEATED. I CALLED ATLANTIC HYUNDAI IN EAST ISLIP AND THEY TOLD ME TO HAVE THE CAR TOWED THERE. THREE DAYS LATER THEY INFORMED ME THAT THE HEAT OF THE ENGINE HAD ACTUALLY MELTED THE RADIATOR. THEY ALSO TOLD ME THAT IT HAD BLOWN A HEAD GASKET. THE CAR WAS STILL UNDER WARRANTY BUT THEY DIDN'T WANT TO HONOR THE WARRANTY. AFTER MUCH ARGUING WITH THEM AND THE WARRANTY DEPT., THEY FINALLY AGREED TO DO THE REPAIRS. MUCH TO MY DISAPPOINTMENT, THE PROBLEM WAS NOT FIXED. THE CAR CONTINUALLY OVERHEATED. I TOOK IT TO ANOTHER MECHANIC WHO SAID THE THERMOSTAT HAD NOT BEEN REPLACED AND IT LOOKS LIKE THEY NEVER REPLACED THE HEAD GASKET. I THEN PAID TO REPLACE THE THERMOSTAT. THE CAR CONTINUES TO OVERHEAT IF DRIVEN AT SPEEDS OVER 30 MPH. THE CAR HAS BEEN TOWED 4 TIMES IN THE LAST YEAR DUE TO OVERHEATING. THE CAR CANNOT BE DRIVEN MORE THAN 30 MILES BECAUSE IT WILL OVERHEAT. THE CAR HAS BEEN SERVICED 7 TIMES FOR OVERHEATING ISSUES. THE LATEST ISSUE IS THAT THE ENGINE COOLANT DOES NOT CIRCULATE AND CAUSES THE CAR TO OVERHEAT. MY 19 YEAR OLD DAUGHTER, FOR WHOM THE CAR WAS PURCHASED, WAS RECENTLY TRAVELING ON THE SUNRISE HIGHWAY, LESS THAN 4 MILES DRIVEN, WHEN THE CAR OVERHEATED AGAIN. THE CAR CURRENTLY HAS 46,000 MILES. *JB

I HAVE HAD AN INTERMITTENT LOW-SPEED STALLING PROBLEM WITH MY 2000 HYUNDAI ELANTRA FOR A LONG TIME. FINALLY I RECENTLY HAD A TECHNICIAN DRIVE THE CAR FOR A WEEK, AND HE WAS ABLE TO DUPLICATE THE CONDITION AND THE DEALER SUGGESTED REPLACING THE THROTTLE POSITION SENSOR AND THEN AFTER GIVING THEM THE OK ON DOING IT, THEY INSTALLED THE PART, ONLY TO TELL ME LATER TO DO A VERY EXPENSIVE REPAIR (OVER 1,700 DOLLARS FOR REPLACING THE WIRING HARNESS). HAVING PAID FOR THE THROTTLE POSITION SENSOR, I BEGAN DRIVING THE CAR AGAIN. I NOT ONLY NOTICED NO IMPROVEMENT AT ALL IN THE PERFORMANCE OF THE CAR, THE PERFORMANCE WAS ACTUALLY WORSE. I TRIED TO GET THE DEALERSHIP SERVICE DEPARTMENT TO STAND BY THEIR REPAIR, BUT THEY WOULDN'T. IN "RECALLS" ON MY COMPUTER I FOUND THAT THERE WAS A STALLING PROBLEM FOR ALL MODELS OF 2000 HYUNDAI ELANTRAS IDENTICAL TO THE ONE I HAVE BEEN HAVING THAT CREATED THE RISK OF A CRASH, HOWEVER MY VIN NUMBER WAS NOT INCLUDED IN THE RECALL. THE RECALL INFORMATION ON THE INTERNET STATES WITH REGARD TO THE CAUSE OF THE PROBLEM: "...STALLING COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS." I HAVE BEEN TOLD THAT IN SUCH CASES WHERE THE SAME PROBLEM IS A SERIOUS ISSUE AND SOME VIN NUMBERS WERE NOT INCLUDED IN THE RECALL, THAT THEY ARE OFTEN THEN ADDED TO THE VIN NUMBERS IN THE RECALL. I WOULD APPRECIATE YOUR CONSIDERATION OF INCLUDING MY VIN IN THIS RECALL BASED ON THE FOREGOING. MY [XXX] THE SITE I WENT TO ON THE INTERNET UNDER SERVICE - RECALLS GAVE A CAMPAIGN NUMBER OF 00V259001 AND LISTED THE FAULTY COMPONENTS AS: ELECTRICAL SYSTEM: WIRING, AND THE POTENTIAL CONSEQUENCE AS: " THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING RISK OF A CRASH." AND THE CORRECTIVE ACTION AS: " DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS." *NM UPDATED 07/17/2012*JS

DT: THE CONTACT STATED WHEN CAR HAD 20,000 MILES ON IT STARTED HAVING ELECTRICAL PROBLEMS. THE SRS LIGHT CAME ON, AND IT WAS MAKING A FUNNY SOUND AT 31,000 MILES. SHE SAID DIFFERENT LIGHTS ON THE DASHBOARD WOULD COME ON, BUT SHE WAS NOT SURE WHICH ONES. THE CAR RAN OUT OF OIL, AND THE CONSUMER STATED THERE WAS NO LIGHT TO COME ON TO INDICATE THE CAR WAS LOW ON OIL. THE CAR HAD 118,000 MILES ON IT AT THAT TIME. THE CONTACT HAS TO REPLACE THE ENGINE.*AK

MY WIFE PURCHASED A 2000 HYUNDAI ELANTRA VIN#[XXX] FROM BROWN HYUNDAI OF TOLEDO OH. ON 4/18/05 SHE BROUGHT THE CAR TO BROWN HYUNDAI AT 63,000 MILES DUE TO A NOTICE ABOUT POSSIBLE FOR CRACKS FORMING IN THE EXHAUST MANIFOLD, SPECIFICALLY TSB 05-01-001. NO REPLACEMENT WAS MADE AT THAT TIME. RECENTLY, I NOTICED AN EXISTING CRACK IN THE EXHAUST MANIFOLD AND PERFORMED SOME RESEARCH ON THE INTERNET ABOUT THE PROBLEM. I AM SURE YOU ARE AWARE HOW COMMON OF A PROBLEM THIS HAS BEEN AS THERE ARE NUMEROUS COMPLAINTS ON VARIOUS AUTOMOTIVE FORUMS, THE NHTSA, AND VARIOUS STATES' DEPARTMENT OF CONSUMER PROTECTION. I HAD THE VEHICLE RECENTLY (10/08/12) INSPECTED AT VOSS HYUNDAI OF CENTERVILLE OH WHO HAS CONFIRMED THE EXISTING CRACK. AT 125,000 MILES THE CAR IS PASSED ITS POWERTRAIN WARRANTY. SIMPLY BECAUSE IT WAS NOT VISIBLY EVIDENT IN 2005 DOES NOT MEAN THE MANIFOLD WAS UP TO HYUNDAI'S QUALITY STANDARDS. EXHAUST MANIFOLDS ARE CAST IRON OR STEEL AND ARE NOT A MOVING PART SUBJECT TO FRICTION. THEREFORE, I CANNOT ACCEPT THAT THIS CURRENT PROBLEM IS THE RESULT OF STANDARD OR EXPECTED WEAR-AND-TEAR BUT CAUSED BY A PRE-EXISTING DEFECT THAT HAS SURFACED OVER TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I BOUGHT A BRAND NEW 2004 HYUNDAI ELANTRA FROM FUCCILO'S IN SCHENECTADY, NY IN MARCH OF 2001. I HAVE MAINTAINED THE CAR. ON FRIDAY OCT 08, 2004 I WAS DRIVING ON THE NORTHWAY AND AFTER 20 MINUTES OF DRIVING THE CAR STARTED OVERHEATING AND I PULLED OFF THE ROAD IMMEDIATELY. NO WARNING LIGHTS CAME ON AND THE CAR'S SPEED DROPPED DRAMATIC TO 0. IT WAS TOWED TO MY MECHANIC AND HE LOOKED AT EVERYTHING AND SAID THAT THE COOLING FAN WAS MELTED AND THE WIRE HARNESS ON TOP VALVE COVER WAS TOTALLY MELTED AND THAT THE BELTS LOOKED FINE. HE SAID IT WAS SOMETHING INTERNAL IN THE ENGINE AND I HAD TO HAVE IT TOWED TO FUCCILLO'S BECAUSE THE ENGINE IS GONE AND IT WOULD BE A WARRANTY ISSUE. AFTER HAVING IT TOWED TO FUCCILLO'S MY HUSBAND AND I WENT THERE TO SEE WHAT WAS GOING TO BE DONE. THE MECHANIC OPENED THE HOOD, DID NOT TAKE ANYTHING APART AND SAID IT WAS THE TIMING BELT THAT BROKE AND IT WAS MY FAULT SO IT WOULD NOT BE WARRANTIED. THEY OFFERED ME 50.00 FOR THE CAR TOWARDS A NEW CAR. I ALREADY OWE 5000.00 ON THE VEHICLE, I ONLY HAD IT FOR 3 THREES. I CALLED MY MECHANIC WHO HAD TAKEN IT APART AND CONFIRMED WITH HIM THAT THE TIMING BELT WAS FINE. I CALLED FUCCILLO'S BACK AND THE MECHANIC SAID HE WOULD LOOK AT IT BUT IT WOULD COST ME 80.00. I AGREED BECAUSE I HAD NO CHOICE. I THEN RECEIVED A PHONE CALL DAYS LATER TELLING ME THAT THE BELT "JUMPED" AND DAMAGED THE ENGINE SO IT WOULD NOT BE COVERED HE ALSO STATED THAT ANOTHER CODE (P0118) CAME UP BUT HE DIDN'T KNOW WHAT THAT MEANT. HE TOLD ME THAT THEY WOULD NOT DO ANYTHING ELSE THAT I HAD A CHOICE OF TRADING IT OR PAYING 6000.00 FOR A NEW ENGINE. *AK

WHILE DRIVING AT ANY SPEED VEHICLE STALLED. CONSUMER RESTARTED VEHICLE AND TOOK IT TO DEALER FOR INSPECTION. HOWEVER, MECHANIC COULD NOT DUPLICATE THE PROBLEM.*AK

2000 HYUNDAI ELANTRA GSL. CAR STALLED @ 30MPH. PULLED OVER TO THE NEARES SHOP. PROBLEM NARROWED DOWN TO A FAULT Y SPARK PLUG WIRE. DEALER (LEN STOLER HYUNDAY/CRYSLER OF REISTERSTOWN, MD) REFUSED A WARRANTY REPAIR, CLAIMING THAT THIS COMPONENT IS NOT PART OF THE ENGINE! THAT COVERED UNDER WARRANTY.*AK

WHILE DRIVING 50 MPH, THE VEHICLE STALLED. THE CONSUMER RESTARTED THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC DETERMINED THAT THE COMPUTER NEEDED TO BE RESET, AND THE MECHANIC RESET IT. HOWEVER, THE PROBLEM RECURRED. *AK THE PROBLEM REMAINED THE SAME. *SC

I HAD TO REPLACE THERMOSTAT/RADAITOR/SPARK PLUGS/WIRES, AND OIL CHANGE IN NOVEMEBER, COSTING $800, THE FOLLOWING MONTH I HAD TO PUT A NEW ENGINE IN MY CAR, COSTING $6000. MY CAR IS STILL IN THE 10YEAR 100,000MILE WARRANTY, AND THE HYUNDAI DEALERSHIP HAS HAD MY CAR OVER 3MONTHS.*AK

THE RING ON THE RADIATOR FILLER NECK BROKE OFF. WHILE TRYING TO CHECK THE FLUID LEVELS OF VEHICLE CONSUMER'S SON ATTEMPTED TO REMOVE THE CAP OF THE RADIATOR, AND THE RING BROKE OFF WITH PARTS STILL ATTACHED TO THE OVERFLOW HOSE. *AK

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITH NO WARNING VEHICLE WILL SHUT OFF, CAUSING CONSUMER TO PULL OVER, AND IT WILL BE HARD TO GET THE VEHICLE BACK STARTED.DEALER NOTIFIED.*AK

VEHICLE HESITATES GOING DOWN ROAD. ALSO STALLS AND CUTS OFF AT LOW SPEEDS AND AT A STOP. SOMETIMES HESITATES WHEN TRYING ACCELERATE. RECALL 00V259001 HAS BEEN DONE SEVERAL TIMES AND DOES NOT CORRECT PROBLEM. CAR HAS BEEN TO DEALER SIX TIMES FOR SAME PROBLEM AND STILL NOT FIXED. I'VE TALKED TO THE SERVICE MANAGER, DEALERSHIP MANAGER, OWNER, AND CUSTOMER SERVICE WITH NO HELP. THIS HAS BEEN GOING ON FOR OVER 2 YEARS. THE FIRST WEB SIGHT I CHECKED FOR OTHER COMPLAINTS WAS MYCARSTATS.COM. I FOUND 21 COMPLAINTS OF THE EXACT SAME PROBLEM WITH NO SOLUTION. *LA

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITH NO WARNING VEHICLE WILL SHUT OFF, CAUSING CONSUMER TO PULL OVER AND IT WILL BE HARD TO GET THE VEHICLE BACK STARTED.DEALER NOTIFIED. *AK