2023 Hyundai Santa Fe Speed Control & Cruise Problems

The vehicle's software was updated on Oct 21, 2025. The software has serious flaw. When driving on slight incline on the passing lane the vehicle will apply the brakes without warning. This has happened 3 times. At times, when vehicles were following me they also had to apply the brakes unexpectedly. Had they not applied their brakes, they would have rear ended me at highway speeds. I also recall that there were no vehicles either in front or to the right ahead of me when it occurred. Also there was a guardrail on the left side of the highway at the time. This did not occur with the previous installed software. Every time this happened, the vehicle was in cruise control and driver assist was ON to keep vehicle in the lane.

At 22000 miles wheel speed sensor went out, all control system shut down and car became unstable. At 44000 miles fuel injector went out, was driving on freeway and car started shaking and losing power, then in parking lot would not start at all, had to be towed to dealer. This is way to many breakdowns for a car with such low mileage.

Occasionally the cruise control when accelerating will exceed the set speed and continue to climb and I will be going 20 miles faster than the set speed and climbing. The only way to sop this is to turn cruise off, slow down and restart. My thought is it happens after I have disengaged the cruise and then when safe reengage which is done by pressing the switch straight down. In my previous vehicles I would push the control up. I may be doing this by accident and giving the system an unknown command. Whatever I am doing to create tis situation is too easy to do and creates a safety issue. this has happened multiple times.

Driving on highway with cruise control selected to 80 mph. Left signal is applied to travel to left lane to pass a semi trailer. When the vehicle is half way into the left lane, the automatic system applies hard braking even though the semi trailer has not been detected as too close. Vehicle slowed to 74 to 75 mph before cruise control was turned off. Vehicle behavior is a total surprise to vehicles following since the braking is unexpected on a clear road. Repeated the symptoms several times. This braking does not occur if the vehicle ahead in the right hand lane is an automobile. This only occurs if it is a large vehicle such as a semi. Moving quickly or slowly to the passing lane affects the total time the braking is applied. The slower the movement, the longer the braking is applied. Repeated this behavior at 75 mph and 70 mph with similar results.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the RPM would be elevated while the vehicle was idling. The failure recurred while the brake pedal was depressed. There were no warning lights illuminated. The failure recurred approximately 3-4 times within 30 days. The failure recurred approximately 15 times within 6 months of owning the vehicle. The contact took the vehicle to the dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 12.

I purchased this SUV new and noticed an issue with the automatic intermittent wipers. The dealership has replaced the windshield sensor and issue is now unreliable at best. Service department told me to simply wipe the sensor off or pour water onto the sensor to get the wipers to work. That seems to work for about 3 wipes and then stops again. Also, the driver seat changes position by itself while driving, and the advanced cruise control failed to provide any braking and almost caused me to rear end a stopped car in freeway traffic. Additionally the advanced braking system does not work at all... I had the salesman check the settings and they are turned on, but do not provide any braking function. The alert system does provide a warning if a car turns a corner in front of me, but fails to take any action.