2018 Hyundai Sonata Complaint Log

Car has an engine defect and consumes too much oil. Hyundai Sonata is denying the repair or engine replacement

I have an oil leak. After getting an oil change I have to add 1-2 quarts of oil before my next oil change. I do have my oil change as recommended. This has happened so far on the last 3 oil changes I’ve done.

Had issues with engine consuming oil. Took to dealer who completed an engine oil consumption test to find the engine oil was 3 quarts low. All services had been completed through the dealer for the life of the vehicle. Engine replacement was approved. Vehicle was still under warranty. Vehicle was at 88227 miles when taken to dealer for repairs for oil consumption.

On [XXX] I was driving on [XXX] [XXX] from Rockville, Maryland when my vehicle (2018 Hyundai Sonata Limited) started to lose power and control and all dash lights started to show. I was able to move the vehicle to the highway shoulder before all power and control failed. Had I been moving at a higher speed or in heavier traffic, or been slower to react this could have led to a catastrophic incident. When the roadside assistance showed up they found that my alternator had completely detached from my vehicle. The vehicle was towed to the Sheehy Hyundai dealership in Waldorf, MD and examined on [XXX]. The maintenance staff informed me that there were 3 other similar cases they're working on, and that there is a flaw in the design of the alternator bracket using aluminum materials that failed, and that they've reported this systemic issue to the manufacturer but have yet to receive any indications that this would be considered for a recall despite the catastrophic impact this could have. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine failed, vehicle towed to Hyundai Daytona Beach Florida on [XXX], vehicle under warranty and part of class action suit. Multiple inquiries to dealer and complaint filed with Hyundai North America, Hyundai and dealer have failed to replace engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle 1 operating normally in traffic on [XXX] in Westfield MA. Operator 1 notices alert on dashboard. As Operator 1 looks down briefly and returns eyes immediately to the road, she sees Vehicle 2 braking to slow or stop. Operator 1 depresses brakes, but vehicle does not slow as it usually does, nor does Automatic Emergency Braking engage as it always has in the past. Front of Vehicle 1 makes contact with rear of Vehicle 2. Dashcam footage appears like brakes did not activate at all, either manually or automatically. Vehicle 1 airbags deploy. Westfield Police respond, as well as Westfield Fire, who cut the battery cable. Vehicle towed to Interstate Towing, Inc. Yard 5, 20 Clifton St, Westfield, Ma 01085. (413) 593-1900 interstatetowing.com. Owner 1 viewed vehicle at tow yard, and noted that the battery was completely melted, with only portions of the plastic casing along with internal plates visible. Much of the plastic and rubber components immediately adjacent to battery location were melted and deformed. As a layperson, it almost appears as though the battery was in the process of shorting out just prior to the collision, possibly rendering many of the safety systems inoperable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car was sitting in the parking lot and randomly black smoke started coming from it and then it turned into fire within in minutes. No one was in the vehicle and 911 was contacted.

I have had a new engine put in my Sonata back at the beginning of 2023. For the past two days my car will jerk really hard, and then loose power not accelerating over 25 rpms and my check engine lights comes on when it jerks really hard.

⸻ In early 2024, I brought my vehicle to a Hyundai dealership due to rapid oil loss. I reported having to refill the oil weekly and suspected a leak. They diagnosed a cracked oil pan, claimed to fix it, and returned the car. However, immediately after, the car continued burning oil at an alarming rate. I was forced to buy and add oil every single week, spending hundreds of dollars to maintain drivability. Shortly after the repair, I began experiencing erratic dashboard warnings. The check engine light would frequently come on and off. The oil lamp illuminated every few days. These symptoms were persistent, not isolated incidents. Despite reporting the issue again, I was told the oil burning was “normal” for Hyundai engines and nothing to worry about. That response put my safety and my child’s safety at risk, as I was unknowingly driving a vehicle with worsening engine damage. Eventually, the car stopped running entirely. It was no longer drivable or safe. I took it to a licensed independent mechanic who confirmed there were multiple ongoing oil leaks and extensive engine damage. The issues I originally reported were never properly fixed, and it’s now clear the dealership failed to address the root cause of the oil consumption problem. I also noticed unusual spikes in the odometer after their repair, despite working from home and barely driving. This added further concern that the vehicle’s internal systems may have been compromised or malfunctioning. I believe Hyundai’s failure to act on clear warning signs directly led to this total engine failure and a serious safety risk.

The engine of my 2018 Hyundai Sonata has been losing oil at a significant rate. By the time I take my car in for a regular oil change the oil is either completely out or nearly out. I contacted Hyundai regarding an oil consumption test which is what was recommended to me by Hyundai corporate when I called to report the problem. Hyundai has completed the oil consumption test and although they stated that it is consuming oil at a higher than normal rate, it still meets their “standard” and the recommendation that they have was to fill up my oil every time I put gas in my car which is an unreasonable expectation . The safety risk is significant. Although Hyundai recognizes this is an issue, they have said that there is nothing they can do. For a vehicle that has only 79,000 miles on it, there is no indication of where the oil is leaking to. During my last oil change, valvoline stated that this is a known issue and that the oil leaks into the engine of the vehicle. Hyundai inspected the vehicle and again stated that although it is burning oil off at a higher than normal rate, their standards state that it is not burning off enough to warrant an engine repair. The oil warning light did appear just before my last oil change which was approximately January 2024. When the light came on, I immediately scheduled an oil change and that is when I was first made aware that this was a known issue with certain Hyundai models

The contact owns a 2018 Hyundai Sonata. The contact stated while driving at approximately 70 MPH, the check engine warning illuminated. The contact stated that the vehicle was losing forward momentum. The contact depressed the accelerator pedal but the vehicle was still losing forward momentum and then stalled. The contact stated that he was able to coast to the side of the road. The contact attempted to restart the vehicle but was unable after several attempts. The vehicle was towed to a local dealer who diagnosed the vehicle and determined that the engine needed to be replaced due to a hole in the valve. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 120,000.

Car would not start. Odor of burning wires coming from the engine compartment with a little smoke. Had car towed to the Dealer who replaced the starter. Ok for two weeks then same thing. No Start and an odor of burning wires coming from the engine compartment. Had it towed to the Dealer again where it sits today.

The vehicle is burning oil at a high rate in a short period of time, a known issue that is affecting thousands of other people, and Hyundai refuses to issue a recall to fix this issue. If I forget to add oil every 500-1000 miles, I risk the engine locking up while driving. Their cars are dangerous to drive and are unsafe to be on the road with other drivers. They put profit over the safety of their customers.

We were heading to Lakewood NJ from Bucks County (North of Philly) . Car trouble w/ hybrid system on Rt 1, just past I-95. Got off @ Fairless Hills & took back roads. We could only go 20-30 mph. IDK how many times I pulled over. Several lights on, including "Check hybrid system. Turn Engine off", engine light, low tire pressure, battery & 3 other unidentifiable lights. I turned around to try to make it home, as 2 years ago, I had a similar issue, which turned out to be the hybrid water pump failed. We finally stopped near a park & called AAA & towed to dealer. Prior to driving, we had no fluid on our driveway. My last synthetic oil change was April 19, 2023 @ 49,097mile. I now have about 57,000 miles. Today, dealer said no oil in the car & oil pan was all wet. They claim the oil filer was loose. Why would it take 8 months to loosen to lose oil? After adding oil & taking for test drive, they said the engine seized & would need to be replaced. Not under warranty. Add to complaint - the remaining dashboard lights where checked and non of them was for the oil pressure. If I lost enough oil for the engine to seize I would expect a low oil pressure light to come. The dealer informed me on Dec 26, 2023 that when doing the diagnostic, the oil pressure light came on for them. The photos attached to the case does not show the oil pressure light on.

The contact owns a 2018 Hyundai Sonata. The contact stated while driving approximately 35 MPH, the vehicle jerked and failed to accelerate as designed. The contact stated that the check engine warning light was illuminated. The contact drove the vehicle to the residence and then contacted the dealer. The vehicle was diagnosed but was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 83,920.

The paint if pealing off in large sections due to a manufacturer defect in the primer. The flakes can fly onto the windshields of other vehicles causing collisions.

I own a 2018 Hyundai Sonata SEL. I purchased the car in 2020 with ~17,000 miles on it. At ~50,000 miles the engine begin burning oil. It has progressively gotten worse. I can’t bring myself to have anyone drive my car because of this issue. It is all to likely that the result of the car burning so much oil in a short period of time. That it can pose a serious risk to anyone driving the car if the oil wasn’t checked. This is not a common problem with many cars, this is a problem with Hyundai vehicles. The negligence of not issuing a recall for this is horrible. I have taken my car to private mechanics and Hyundai service centers. The response I get is “oh yeah they’re know for burning oil and there’s not much to do about it.” That’s a ridiculous response to situation like this for the thousands of owners. How long will it take to issue a recall, until a life is taken? When the issue could have been fixed by issuing a recall. Complete negligence on Hyundai and the NHTSA.

Purchased this vehicle with about 64K miles. Vehicle, as per CarFax report, has been meticulously maintained. Upon delivery, we changed the oil and filter with full-synthetic Amsoil. We ensured oil levels were appropriate prior to returning to service. No more than 1,000 miles later, roughly incurred in about a month, we checked oil levels again. This time, it required about 1.25 quarts to return it to the appropriate level .We did research and apparently, there is a class-action lawsuit filed by owners of Hyundai vehicles with this specific engine, the Theta II 2.4L 4-cylinder engine. Here's an article making reference to apparently your organization already looking into these complaints. [XXX] Could you please advise if the NHTSA will take the necessary steps to request Hyundai to issue a recall? I have found multiple articles where Hyundai is rejecting to take any action on their own, in most cases, advising their customers that such level of oil consumption is 'normal'. That clearly contradicts their own owner's manual guidelines. I own a 2001 Chevrolet Suburban 1500LT with 302K miles and the vehicle will go nearly 5K miles between oil changes while requiring no more than 1/2 quart of oil to keep it at the appropriate levels. I also own a 2019 Honda Accord 2.0T that normally requires oil changes every 10K miles and it seldom requires more than 1/8 of a quart to keep at the appropriate oil levels. There is definitely something definitely wrong with this engine type and requires governmental involvement to hold the manufacturer to provide adequate remediation. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Intermittent no-crank, no-start condition. Dash lights illuminate, push-button start produces no response. Brake pedal applied. Vehicle becomes immobilized without warning. I’ve been stranded on multiple occasions. Unable to commute to work, or home. Most recently on December 19,2025 the car completely shut off while driving on the highway.

Hello, I am the original owner for my 2018 Hyundai Sonata. I have now had numerous issues with this vehicle that has now left me stalled on the highway twice resulting in a near accident and the vehicle being towed twice to a dealership. I am now having issues with oil consumption with me needing to put in at least 1q per week to ensure the reading on the dipstick is above “L”. I have my vehicle serviced at the Hyundai dealership and they first brought to my attention at 90k miles that when I would go in for my scheduled oil changes the engine was nearly dry. I took my vehicle to a Midas to have it inspected for an oil leak with their mechanics twice saying there was not an oil leak. It was the mechanic here at Midas that informed me of the oil consumption issues Theta II Hyundai engines have been experiencing and to take it into the dealership to see what can be done. This has been an issue my dealership has known about, but they are refusing to assist stating the vehicle is now out of warranty at 104k miles. I have the receipts proving the vehicle has been maintained according to the manufacturers recommendation. My vehicle now will fill with the smell of burning oil when I’m driving, I’ve had the spark plugs replaced once and the new spark plugs are already coated in oil and my vehicle lurches when I’m accelerating to get onto the highway. I feel very unsafe driving this vehicle and fear it’s a matter of time before it leaves me stranded on the highway again.

The contact owns a 2018 Hyundai Sonata. The contact stated while driving 70 MPH, the vehicle went into LIMP Mode and lost motive power. The contact was able to pull to the side of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that cylinder #1 was misfiring on every cycle due to damage to the piston. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 107,000.

The drivers seat operation is going berserk. I can not get it to move at times and at other times it only partially operates. It also may do the opposite of what control direction I move it! I had to drive home today not being able to to the gas pedal well...very dangerous.

My 2018 Hyundai Sonata began running low on oil around May 2022 when the car had 86,400 miles on it. I informed the local dealership where I bought the car and had all maintenance completed. The dealership and myself contacted Hyundai Corp. Hyundai Corp approved oil consumption testing which resulted in an induction cleaning in Sept. 2022. This did not resolve the oil burning issue. The dealership service staff informed me that I was given a lifetime warranty on the engine and to keep driving it and putting oil in as needed until the engine failed and then to bring it to the dealership for replacement engine. There evidently was not a fix for the problem. Most recently I have been putting oil in the car every Sunday. I sent an email message to Hyundai Corp about a month ago to request to talk with a case manager regarding this excessive oil issue. In the meantime I have taken my car to the dealership for all suggested maintenance and informed them of the continued oil consumption. Before I received a response from Hyundai, my engine failed. I pulled out of my drive way and my car was stalling and would not accelerate properly then my engine light came on. I drove the car about a quarter mile down the road and turned around and came home in this very scary condition. This is a safety issue due to pulling out on a road with no power to accelerate. I had it towed to the dealership. I was give a case manager from Hyundai. My car has burnt valves and excessive carbon build up from excessive oil burning. Hyundai will not cover engine replacement costs, or buy back the vehicle. This vehicle is available for inspection. I'm not sure if I should leave it at dealership or have it towed home.

I was driving and when I made a left turn I heard a sucking type of noise coming from the engine. I immediately made an appointment at my local Hyundai dealership, however they were booked for another month so I made it at my local mechanic shop. After inspection by the mechanic I was told and confirmed that the noise was a result of having barely ANY OIL LEFT IN MY ENGINE!!! Because the oil pan had a hairline crack in it and had leaked the oil out. My check engine light had never come on through this process. This is so dangerous because my engine could have eventually seized while being in traffic with potential harm to both myself, people in my car and other vehicle traffic!!! Also, WHO KNOWS HOW MUCH DAMAGE WAS DONE TO MY ENGINE AS A RESULT OF THIS!!! My engine can be ruined!!!

For now the fifth time in the last 16 months the HEV light and engine light has lit up while the car jerks and sputters and dies. Below is the incident report that I filed on or about August 8, 2022. Again at the end of the day yesterday on October 20, 2023 the same issues still arise for the fifth time. See below for a re-cap of the issues I am once again experiencing after Hyundai claims to have fixed the issues: For the fourth time the HEV light (and others) has come on and the dash has lit up while I was driving, with the last three times leaving us stranded in dangerous road situations with little or no power. The light first came on in July 2020 at 40,089 miles. A dealership reset the codes and I had no problems until June 7, 2022 when the lights lit up on the dash again and the car died and I had to have it towed to a local dealership. They could find nothing wrong with it and checked all the wiring and said none of the codes were coming up and that the car ran fine for them when test driving a day or two after I had it towed. So they released the car back to me deeming it good to go. Then only 19 days later on June 26, 2022 the HEV light among other lit up again and the dash indicated to pull over and cut the car off due to the hybrid system. I had it towed to the nearest dealership again. The then looked at it and said they reset all the codes and everything looked to be good to go. Then AGAIN on Aug 8, 2022 (3rd time in two months), we were put in a dangerous situation trying to get the car off a busy highway when the HEV light (and others) again lit up the dash and our power went almost completely out while the engine jerked violently as we tried to avoid being hit by cars while trying to get off the highway before it completely died on us. Four times now Hyundai dealers have shrugged this off saying "we reset the codes" and we can't find an issue. We have been put in dangerous traffic conditions three of these times.

The contact owns a 2018 Hyundai Sonata. The contact stated that the vehicle failed to start in cold weather, below 50 degrees Fahrenheit. The contact stated that the vehicle would start as needed whenever the weather was warmer. The vehicle was taken to an independent mechanic, where it was diagnosed; however, the cause of the failure could not be determined. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 72,000.

Warning lights keep coming on for ABS and Blind Spot Detection. Please help as I know this has been recalled in other 2018 Sonatas. So why is my VIN # not included in these recent recalls?? I FEAR for mine and my daughter's safety as she turned 16 in February 2023 and started driving this car in August 2023. PLEASE HELP!!

Car continues to burn oil within a week of getting oil changes, the oil will be black and it will be low sometimes there will be no oil and there is not an oil leak. Right now we had to pay for a combustion test and have to drive 1,000 miles then check the oil at Hyundai again and already our oil is starting to burn and is low. Hyundai said if the combustion test comes back still burnt or low Hyundai would give me a new engine and yea it’s low and already a tint dark not as dark as it used to get but still it’s low with no leak and we did not get the promised new engine after paying almost 600$ for the test… Also electrical wise the computer randomly sounds like static when Siri talks also the music does not play and randomly the maps will close out we have tried new cords we have tried everything and it still happens.

My cars engine is failing. My safety as well as other around me are at risk because the more oil my engine consumes, the more it is likely to quite literally blow up. My car just hit 60,000 and my dealership has informed me that I need an engine replacement. The manufacturer will not take accountability for their fault engines, even though my dealership told me they see this same engine problem come in every single day. Since before my car hit 60,000 in October 2023, my oil light came on which is odd because I’ve always maintained my car well. Since then, my car has been burning 4-5 quarts of oil in 1000 miles. My engine has an oil consumption issue, as do many other Hyundai models but Hyundai refuses to acknowledge this issue. Go on Tik tok, look at how many people are having the same problem. Call a Hyundai service center, any one of your choice, they will tell you that they see oil consumption motor issues every day. Hyundai corporate told me it is not their problem, and good luck. This is unethical and immoral and there needs to be a recall. There is no reason why I need an engine replacement at 60,000 miles.

I was the owner of a 2018 Sonata until I was t-boned and the car was totaled. I started to make a left turn into a school parking lot when the engine kind of stalled or more like stuttered and did not go forward as usual. The oncoming car then struck me before I was completely in the driveway. My vehicle was totaled as was the other one. Fortunately no one was on the passenger's side where the other car hit me. However the seat belt did not engage which resulted in me slamming very hard into the steering column. This resulted in bruised on my right side which cleared up in several weeks, but, unfortunately, I received a heart contusion on my left side which is still causing shortness of breath. Hyundai will not acknowledge a problem with the engine or the seat belt.

The contact owns a 2018 Hyundai Sonata. The contact stated while driving 65 MPH uphill, the vehicle shuddered. The check engine warning light and low oil pressure warning light were illuminated. The contact was able to pull to the side of the road and turned off the vehicle. The vehicle was towed to an independent mechanic, where an oil change was performed, and the spark plugs were replaced. The vehicle was repaired. The contact related the failure to NHTSA Action Number: DP22003 (Engine). The dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 77,347.

The contact owns a 2018 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who retrieved DTC Code: P1326 and related the failure to Technical Service Bulletin: 20-01-024H-1 (Theta GDI Engine DTC P1326 - Engine Inspection / Replacement); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 59,000.

My car is misfiring, hesitating accelerating, severely shaking and vibrating which you can feel in the pedals and steering wheel, and the check engine light is on. This issue has been ongoing for over a week already. When the engine light first came on on 9/7, i pulled over on the side of the road and had a mobile mechanic check it out. The code was coming up as a bad ignition coil in cylinder 1. When he took out the coil and spark plugs, he saw scoring on the spark plug from oil as well as oil being consumed in the cylinder itself which has been causing my vehicle to misfire. The mobile mechanic stated on his invoice that I need a new engine. I took my car to Faulkner Hyundai on 9/11 and they said the best they can do is an oil consumption test even though they personally know I need an engine as well. I have not been able to drive the vehicle due to the ongoing issues, I am afraid for my life and safety that god forbid the car stalls out on the highway while I am traveling to or from work I could get into a major accident. They are putting my life in jeopardy.

Engine is failing, stalls frequently. Dealership where I bought the car will not help, other dealership advised us to drive the car until the engine fails. I do not feel safe driving this car with my children.

As detailed in the attached letter to Hyundai, the car has had multiple engine issues that the company refuses to resolve even though they are well aware of the on-going engine problems in Sonatas. The problem started in August 2023 and is on-going.

The contact owns a 2018 Hyundai Sonata. The contact stated that while driving approximately 60 MPH the vehicle suddenly began sputtering and then completely stalled. The contact had to coast to the side of the road and noticed the check engine light illuminated. After approximately 10 minutes, the vehicle was able to restart. When starting the vehicle there would be a sputtering followed by the vehicle shutting off. The failure began to occur while idle as well. The contact stated that while attempting to reverse out of a parking spot the vehicle suddenly accelerated forward instead. As a result, the vehicle ended up crashing into a concrete light post. The air bags did not deploy. There were no injuries or medical attention needed. The vehicle was able to be driven after. No police report was filed. The vehicle had been towed to the dealer who had stated that the starter relay issue may be the cause, however, because of not being able to duplicate the failure they were unable to give an official diagnosis. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 86,000.

While I was driving the car shut off by itself.

RIGHT WHEEL SPEED SENSOR FAILED IN FEB 2023 NOW LEFT REAR WHEEL SENSOR HAS FAILED IN AUG HAS 50486 MILES

Oil pan crack. Leaking oil can get on engine or underbody components causing fire or failure of breaking systems causing an accident resulting in death. Problem was identified by dealer and in fact the dealer rep said this was common. It has not been inspected by police or insurance reps. There is no warning systems in place for a cracked pan.

UNKNOWN. I noticed that there was a check engine light on and I took it to autozone to have it checked out, they told me that it was coming back with the code of an o2 sensor. I thought nothing of it until it started not wanting to start right. On July 1, 2023 I took my car in to the dealership for an oil change and they never said anything about why my car was doing a delayed start. It would eventually start but it took at least a minute. I bought a new battery from walmart to put in my car so that it would not do the delayed start, but it kept doing it anyway. Finally decided to take it to a mechanic and the first time that he started it took at least a minute, he realized that he didn't have his computer (code reader) with him so he turned it off. When he returned with the code reader he plugged it in and started the car then it started smoking, smoking turned into fire that caused the entire underside of my hood to melt including engine, electrical harness, belts, battery and much more. If it wasn't for the mechanic's quick thinking by putting out the fire while calling 9-1-1, the fire would have gone to the fuel tank and exploded. Yes, the safety of others was put at risk.

Starter replaced at less than 50,000 miles. Normally a starter will last 150,000 miles or more. I was past the warranty by 9 months but was under the mileage. Warranty was 5 years or 50,000 miles. Hyundai parts are cheap and do not last long compared to other companies.

When my car suddenly stopped on the highway, I encountered an issue with the “body control module.” The car wouldn’t start, and the key fob was ineffective. Additionally, the airbags stopped working. I don’t recall all the details, but I was unsure of where to report the dangerous vehicle. I’ve noticed several other Hyundai owners complaining about this issue, where their cars suddenly stop in the middle of nowhere.

My engine was burning oil, I was/ am up to date with my oil changes. The oil suddenly kept being dirty. My car broke down twice. One time oil was shooting out of the top of my engine and it was smoking. Hyundai claimed it was neglect and only accepted my paper copy of oil changes but not the ones on my debit card statement.

My 2018 sonata has been stalling out while I’m driving more so when I accelerate.I have a baby that I’m scared to drive with in the car because it does it randomly. It has been happening more & more everyday. I got new parts/starter etc. No codes on dash. Have an appointment next week with Hyundai to take a look.

I own a 2018 Hyundai Sonata 2.0 turbo I paid cash for it in [XXX] with 2011 miles on it for 24,000 cash didn’t start having problems until 2022 then the I kept hearing a knocking on the left front wheel. I had it look at several places because the Hyundai of Louisville dealership kept telling me my title was branded I didn’t know what that meant till I took my title to the tag office and had the sheriffs department check the title out and it was an still is 100 % clean then my engine kept getting worse an in may of 2023 the engine stopped working I had the car towed to the local dealership and they couldn’t even look at it till Aug of 2023 the they told me I shot out a code 99 and they refused to update my software for the knock sensor system and wouldn’t honor the regular 60,000 miles warranty my car only had 48,000 miles on it . They didn’t bother telling me about the faulty GDI 2.0 turbo engine in August of 2023 I had to research it and find out on the internet that it’s a excessive oil consumption problem with this faulty engine. I had my car stolen for 6 days in April of 2023 and everything was taken out of my glove box an trunk . My oil change receipts were kept in an envelope in the glove box and were stolen with all my car registration an insurance papers . So the dealership refused my free engine replacement because I don’t have all my oil change receipts and blamed me for the oil being out of the engine which is due to the faulty GDI 2.0 turbo engine the dealership has now had my car 300 days I’ve been walking to and from my work I can’t afford a new engine all I want is me free engine replacement I have all the articles printed of all the engine problem with the cars catching on fire or just stop running period . I need some representation on having the Hyundai of Louisville Kentucky on Dixie highway to get me my free engine replacement they want 14,000$ for a new engine. I’m extremely mad and frustrated with this entire situation I have retained a lawyer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I first reported issues with my vehicle to a local Hyundai dealer January 16, 2023. I was advised I couldn’t get an appointment until March 8, 2023. Since March 8, 2023 I have taken my car to the dealer my numerous times for a series of testing over the course of 3 months. I was advised my car was burning too much oil of oil per 1000 miles. I was also advised that the transvalve and engine needed to be inspected by an adjuster to determine a faulty engine in order to get approval from the manufacturer. My car was at the dealer for almost a week. On June 15, 2023 the Hyundai dealership advised the engine was faulty. I was also advised warranty approved for a new engine due to faulty engine/oil consumption. I was advised to pick up my vehicle from the dealership. On June 16, 2023 I picked up my vehicle. I was told by the dealership to keep driving my vehicle until the new engine came in due. I was denied a loaner/rental at the time even though they knew the car had a faulty engine. Immediately after leaving the dealership dealership my car started smoking. I pulled over immediately got out. The car caught on fire and burst into flames. This was a very dangerous safety risk. It caused panic attacks, anxiety, headaches, and lots of sleepless nights. If I hadn’t gotten out sooner I could’ve been severely injured or dead. The car is with the insurance company. A field investigation has been done by the insurance. They determined faulty engine and total loss if the vehicle. It is still available for inspection if needed. There were no warning lamps or messages before the car started smoking or caught fire.

The contact owns a 2018 Hyundai Sonata. The contact stated that after starting the vehicle, the engine oil warning light illuminated intermittently. The contact pulled over to check the engine oil level and discovered that there was no oil in the engine. The vehicle was taken to Midas, and engine oil was added. The vehicle was later taken to another Midas, who found a crack in the engine oil pan. The vehicle was then taken to the dealer, who informed the contact that Midas had overtightened the oil pan during an oil change, so the warranty to repair the vehicle would not be honored. The vehicle was taken back to Midas, and the engine oil pan was replaced. The contact stated that he was currently in litigation with the dealer and the manufacturer. The manufacturer was made aware of the failure. The failure mileage was approximately 99,000. The VIN was unavailable.

ABS module stopped working and the ABS module light is on. Car automatically brakes by its self sometimes or locks up at stop lights creating dangerous driving situations

When driving the car on the highway - "check engine - hybrid system" warning lights come on and indicate hybrid system issue and to shut car off immediately. Extreme safety issue as the car goes from highway speeds to 35MPH almost instantly. This has happened seven times now and Hyundai keeps indicating that technicians are following engineering guidance in fixing the issue related to the knock sensor. The seventh occurrence happened on May 23rd of 2023. First one was in December 2021. As Hyundai is unable to correctly fix the issue I have repeatedly asked for them to replace the car since it is an extreme safety issue but they will not do so. Still waiting for diagnosis of the latest occurrence from May 23rd. Hyundai does not acknowledge that this issue is of safety concern and just indicates that the issue has been fixed each time it occurs.

Car consumes TOO much oil. Even after I get an oil change I have to add more oil weeks later and the oil is always black. Several times the sensor has gone out on me on the hwy and I’m not able to accelerate or go over 35 miles which is extremely dangerous .