2018 Hyundai Sonata Engine Problems

Had an oil change, then 2 weeks later car making noise, checked the oil and it was completely empty, so we refilled the oil. Then a month after again same issue no oil, refilled it again and now a week later it's 2 quarts low already. Also when I come to a complete stop when it is time to go again it's very slow at going or if I try to excel it takes it a very long time to actually excel I think something's wrong with the fuel pump

2018 Hyundai Sonata 2.4L Theta II engine experiencing severe oil consumption and loss of oil pressure. Oil pressure warning light actively blinking and dipstick completely dry. This is consistent with the known Theta II engine defect subject to prior NHTSA investigations and class action settlements. Mission Hills Hyundai documented low oil concern in service notes during December 2025 visit but failed to take any action and returned the vehicle without repair. Hyundai Consumer Affairs has been unresponsive and provided conflicting information regarding recall completion on this vehicle. This is a serious safety defect that puts the driver at risk of engine failure while operating the vehicle.

The contact owns a 2018 Hyundai Sonata. The contact stated that while driving approximately 60 MPH, the vehicle started to vibrate roughly. The contact felt the vibration in the steering wheel. The check engine warning light was illuminated. The contact slowed down and pulled off the roadway. The contact turned off and restarted the vehicle and was able to shift to drive(D); however, the vehicle was hesitating and failed to accelerate as needed. The contact drove the vehicle to an independent mechanic at speeds no greater than 40 MPH. The mechanic scanned the vehicle and retrieved codes for a misfire in the engine. The mechanic advised the contact to take the vehicle to a dealer for assistance. The vehicle was towed to the local dealer. The vehicle was not yet diagnosed or repaired. The manufacturer was informed of the failure. The contact requested an engine replacement that was denied by the manufacturer. The failure mileage was approximately 138,000.

The contact owns a 2018 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer advised the contact to have an oil change performed and then return the vehicle after 1,000 miles of driving. The contact stated that after returning the vehicle to the dealer, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 99,000.

I bought this vehicle as a certified pre-owned from a Hyundai dealership on 09/10/2022 with 32,677 miles. Around 85,000 miles, it began burning an excessive amount of oil—about two quarts per month. Now, with approximately 101,000 miles, it still burns two quarts weekly, oil is being expelled from the muffler, and the exhaust has started to glow red. I have tried contacting Hyundai but have not received any response.

Excessive Oil Burning and Oil Consumption. Oil turns black abnormally quickly (within the first 500-1000 miles) even though recommended Full-Synthetic Oil is used. Engine has intermittent rough idle once engine is warm. Occasionally engine experiences "near-stall" and "misfire event", causing the battery light to flash on dashboard. >>>Oil consumption rate is approximately 3-4 quarts per 1,000 miles<<< ***Maintenance completed since purchase*** Coolant Flush - Replaced PCV Valve (NEW) - Replaced Valve cover Gasket + Oil Pan / Oil Pan Gasket (recommended by dealer) (NEW) - Replaced Spark Plugs (recommended by dealer) (NEW) - Replaced Battery (NEW) - Replaced Alternator (NEW) - Replaced both engine accessory belts (NEW) - Replaced 150A main fuse (located on positive battery terminal) (NEW) - Used Hyundai brand oil filters - Used Chevron/Techron Complete Fuel system cleaner twice, between and at oil change (as recommended by "Twin City Hyundai" dealer in Alcoa, TN) ***Had dealership inspect it for approval of known Federal Recall on GDI Engines for excessive oil consumption / engine seizing issues; dealership claimed it did not pass re-call approval*** SYMPTOMS STILL PERSIST Mileage is now approx. 80K

The oil pan is starting to crack, a small drip is now happening but dealership says it could spilt and cause the engine to seize while driving. The pan looks very flimsy compared to my Ford and Toyota.

My 2018 Hyundai Sonata’s oil light flashed briefly while driving, so I checked the oil level and found the dipstick completely dry. The car has been maintained regularly and was still about 1,000 miles away from its next scheduled oil change. There are no visible leaks, and the engine is not smoking. I had to immediately add oil to prevent engine damage. This appears to be a case of excessive oil consumption, which I have since learned is common in Hyundai Sonatas with this engine. I am very concerned that low oil pressure could cause engine failure or sudden loss of power while driving, creating a serious safety hazard. I request that NHTSA investigate this issue for 2018 Sonatas, as many owners are reporting similar experiences, and Hyundai has issued a Technical Service Bulletin (TSB 23-EM-008H) about excessive oil consumption but no recall.

Car started misfiring while driving and engine light came on. It kept losing power but I was able to pull off highway. This put myself and others in danger because speed was significantly reduced suddenly. Dealer said problem was due to oil leaking on spark plugs. The car had been using excessive oil. Dealer said this is known issue but I had to pay for any repairs since I was the second owner. Hyundai still pays for the original owner to get an oil consumption cleaning, but recently stopped paying for secondary owners. If the oil consumption cleaning does not work, then the next step is to replace engine, paid by customer if Hyundai refuses. Mileage on car is 75,769.

Engine consumes oil, more than 1 quart a week. started misfiring on a trip and dealer stated that engine needs to be replaced since valve was burnt. have 116k miles on car and have been diligent in maintenance.

It has oil consumption issues

See attached document for complaint.

The contact owns a 2018 Hyundai Sonata. The contact stated that while driving approximately 60 MPH, the vehicle shuddered before losing automotive power. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the engine and NOx sensor needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same local dealer on several occasions for the repair; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 117,000.

Component or system that failed or malfunctioned: The 2.4L Theta II engine in my 2018 Hyundai Sonata is consuming an excessive and unsafe amount of engine oil—approximately 1 quart every 750–1000 miles. The engine has not seized or failed yet, but the oil consumption is abnormal and dangerous. The engine is available for inspection upon request. Safety risk: This oil consumption issue poses a significant safety risk. If the engine runs out of oil unexpectedly, it could lead to catastrophic engine failure and sudden loss of power while driving—potentially causing a serious accident. The lack of warning or engine light prior to dangerously low oil levels increases the risk. Reproduction/confirmation: The issue has been reproduced and documented by a certified Hyundai dealer through an oil consumption test. However, despite confirming the problem, Hyundai has refused to cover the repair. Inspection history: The vehicle has been inspected by a Hyundai dealership. No other independent agencies (e.g., insurance or police) have inspected it. Warning lamps or messages: No warning lamps appeared before the engine oil was found to be dangerously low. There were no check engine lights or oil pressure warnings prior to discovering the oil consumption issue. Other key information: Hyundai refuses to cover the repair due to the fact that I am not the original owner—even though the original Powertrain warranty would have covered the issue if I were. Hyundai arbitrarily reduces the powertrain warranty to 5 years/60,000 miles for secondary owners, despite the safety risks being identical regardless of ownership. Furthermore, this exact engine has been the subject of multiple lawsuits and class actions due to excessive oil consumption, connecting rod bearing failure, and engine seizure. Hyundai has acknowledged the defect in various settlements but continues to deny coverage for affected owners like me.

My 2018 Sonata has had an oil consumption problem since 2023. We initially thought it was the oil change garage issues. Had an oil consumption study conducted by Hyundai between July -September 2024. We were replacing 1,0 -1.5 qt oil every 700 - 1,300 miles. After the study, Hyundai told me I did not have an oil consumption problem. (Seriously?!?!) We had to replace the starter and now the spark plugs. Photo enclosed of how burnt the spark plugs were. Our mechanic was so mad that Hyundai was not honoring their warranty but allowing my engine and connected parts to just burn up. Hyundai told me to come in for another check tomorrow, 8/25/25. I called the Hyundai Consumer line on 8/18/25 (4th new case number in 13 months) and the person who answered the phone asked if I contacted a lawyer. I asked her if I needed to contact a ? I’ve been reading online about this problem today and found information about NHTSA and decided to file a complaint. This is dangerous because when the engine blows, I may be accelerating on the interstate and merging. That could be a fatal problem with this car. Traveling on the interstate on 8/10/2025 my Sonata stuttered and hesitated upon acceleration. We took back roads and limped home. My mechanic replaced the severely burnt spark plugs and told us our very nice car would be worthless soon if Hyundai did not fix this oil consumption problem. He called our Hyundai dealer on our behalf.

The contact owned a 2018 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle sputtered, jerked, and lost motive power. The check engine warning light was illuminated. The vehicle was able to restart but made an abnormal ticking sound. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 72,000.

The contact owns a 2018 Hyundai Sonata. The contact stated engine oil constantly needed to be added between 1,200 and 1,800 miles. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, and the contact was informed that there were no leaks found, and that the engine was in good operational order. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 118,000.

Engine oil consumption issues. My 2018 Hyundai Elantra falls within the dates of this issue. I had an oil consumption issue done and the dealership claimed it passed. I have to put oil in my car every 3 weeks and change spark plugs at the same time because of engine leaking oil in to them. My engine light is always on, knocking and pinging sound, poor performance issues, and blue smoke coming out of tail pipe. I have stuck on the side of the highway several times and have misses work because of the ongoing issues with the engine. How can a oil consumption issue pass and i have all these issues. I have spent several hundreds of dollars on oil, spark plugs, frequent oil changes and tows. There was only 85,000 miles when I started to notice the problem and had only owned it for 6 months.

Car keeps burning oil faster than normal which has resulted in car not starting multiple times even after a month old oil change.

Crack oil pan