There are 4 owner-reported fuel system complaints for the 2002 Isuzu Rodeo in NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2002 Isuzu Rodeo. The contact stated that while driving at approximately 50 MPH, the vehicle stalled. The contact stated that as she was coasting to the right to stop on the shoulder, she observed that there was smoke in the cabin. The contact stated that after she stopped, she opened the driver's side passenger door and saw that smoke was emitting from under the passenger seat, which had been folded over in "cargo mode." The contact lifted the seat and saw that the seat back was melted, with a black spot in the center. The contact stated that she had a cooler in the back that was full of water, and she poured all of it behind and under the seat. The contact saw that the water evaporated. The contact then checked out outside of the vehicle to see if there was any heat source. The contact observed that flames had formed under the rear driver's side wheel well. The contact stated that a person who lived in the house near where she had stopped had observed what was happening and came out with a fire extinguisher and extinguished the fire. The fire department was not called. The contact had the vehicle towed to her residence. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 05V466000 (Fuel System, Gasoline) due to the location of the fuel tank, which was located on the driver's side rear, by the rear wheel well. The failure mileage was approximately 117,000.
TL* THE CONTACT OWNS A 2002 ISUZU RODEO. WHILE THE VEHICLE WAS PARKED, A FUEL ODOR WAS NOTICED AROUND THE VEHICLE. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
2002 RODEO GAS FUEL PUMP IS DEFECTIVE. *TS THE CONSUMER STATED THE VEHICLE STALLED IN THE MIDDLE OF TRAFFIC. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE CONSUMER WAS INFORMED THE TRANSMISSION HAD FAILED. *JB
DT*: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 05V466000 REGARDING FUEL PUMP FAILURE. THE PARTS NEEDED TO REPAIR THE VEHICLE WERE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE CONTACT SPOKE TO THE MANUFACTURER, WHO HAS CONFIRMED THE PARTS WERE NOT AVAILABLE. *AK
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Sep 8, 2026