2004 Jeep Wrangler Body & Structure Problems

My Jeep's frame is rusted. There are holes and cracks in the frame from the rust. The Jeep will not pass my states safety inspection because of the rust. Parts of the suspension that are attached to the frame are about to fall off.

The frame has been compromised due to rust. The frame rusted from the inside out because the frame was not properly engineered from the factory. There are no weep holes at the lowest point on the frame. This causes water to sit in the frame and rust from the inside out. The rust appears without warning. This is an extremely dangerous because the frame can break without warning and cause loss of control. My vehicle is available to be inspected upon request.

The frame on the Jeep TJ is prone to rot. Mine is so rusted that body shops refuse to repair it, claiming their insurance won't cover them. My Jeep has 123,233 miles and is otherwise in very good condition, but the frame has rust severe enough to make driving the vehicle unsafe. The Jeep Forum on the Internet is full of similar stories, so Chrysler has known about this problem for many years. You should make them recall the Jeeps and repair or replace the frame. A few years ago Toyota did a similar recall on their small pickup trucks.

DASHBOARD COVERING OVER PASSENGER SIDE AIRBAG IS EXTREMELY STICKY. MY CONCERN IS NOT JUST FOR APPEARANCE, BUT FOR PROTECTION OF THE AIRBAG ITSELF AND THE NEED TO CONTINUALLY CLEAN THE PASSENGER SIDE WINDSHIELD DUE TO A SLIGHT FILM PRODUCED FROM THE DECAYING VINYL DASHBOARD. THIS VEHICLE IS HOUSED IN A GARAGE IN FLORIDA. *TR

TL* THE CONTACT OWNS A 2004 JEEP WRANGLER. THE CONTACT STATED THAT THE WELDING ON THE VEHICLE'S FRAME WAS DETERIORATING TO THE POINT OF POTENTIALLY DETACHING ON THE PASSENGER SIDE FLOOR PANELING. IN ADDITION, THE INTERIOR OF THE FLOOR WAS DETACHING FROM THE DRIVER SIDE AND THE FRONT PASSENGER SIDE. THE VEHICLE WAS TAKEN TO TWO PRIVATE MECHANICS WHO STATED THAT THE RUST AND CORROSION WAS EXCESSIVE AND THE PANELS NEEDED TO BE REPLACED AND WELDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,500.

VEHICLE IS A 2004 JEEP WRANGLER 4X4 PURCHASED 12/04. DEBRIS ACCUMULATED UNDER THE SKID PLATE, APPARENTLY IGNITED BY EXHAUST SYSTEM. I SMELLED AND SAW SMOKE AND HAD A FIRE EXTINGUISHER WHICH I USED TO PUT OUT THE FIRE. ENGINE WIRING HARNESS DAMAGED BY THE FIRE, REPAIRS ABOUT $2,000. SKID PLATE DESIGN ALLOWS DEBRIS TO COME IN FRONT OF SKID PLATE BUT NOT BE BLOWN OUT THE BACK OR BOTTOM. I BOUGHT THE JEEP IN PART FOR ITS OFFROAD CAPABILITIES, BUT AM AFRAID TO USE IT NOW. *NM

WHILE DRIVING AT APPROXIMATELY 70 MPH THE CLOTH TOP CAME OFF THE VEHICLE. OWNER HAD TO HOLD IT DOWN WITH HIS HAND. OWNER CONTACTED THE MANUFACTURER, AND WAS TOLD THAT THIS DEFECT DID NOT FALL UNDER THE WARRANTY. *AK

I PURCHASED A NEW 2004 JEEP WRANGLER SPORT ON SEPT 30,2004. ON OCT 1, 2004 I DISCOVERED DEFECTIVE PAINT ON THE LEFT FRONT FENDER NEAR THE ENGINE COMPARTMENT(APPEARS TO BE A CHEMICAL CONTAMINANT AS WELL AS GRAZING OF THE BASE COAT), DENT ON THE UNDERSIDE OF THE RIGHT HAND PASSENGER DOOR, WELDING SPLATTERS ON THE RIGHT FRONT FENDER, DENTS ON THE INSIDE OF THE RIGHT FRONT FENDER, RIGHT FRONT FENDER IS WARPED. ALL BODY DAMAGE APPEARS TO HAVE BEEN PRE-DELIVERY. DEALER SERVICE PERSONNEL TOLD ME TO IGNORE THE PAINT DAMAGE. I DONT UNDERSTAND HOW THE VEHICLE LEFT THE FACTORY IN THIS CONDITION. IAM DISGUSTED AND DEPRESSED AFTER SPENDING $26,000 DOLLARS ON THIS JEEP. IAM A U.S. NAVY VETERAN, AVIATION STRUCTURAL MECHANIC. *AK