2021 Kia Forte Engine Problems

Oil is burning out quickly causing the car to stop abruptly without any warning and caused damages to the engine.

To Whom It May Concern, I am submitting a formal complaint regarding a serious safety issue involving my 2021 Kia Forte. Approximately one year ago, I purchased this vehicle used with approximately 56,000 miles. I have owned the vehicle for nearly a year without prior incident until a recent and significant failure occurred. While driving on a highway after work, the vehicle suddenly lost engine power. The RPMs dropped abruptly, and the vehicle began decelerating rapidly before completely shutting off. This occurred without any prior warning indicators, such as dashboard warning lights or messages. I attempted to restart the engine three times before it successfully turned over. Upon restarting, the engine produced a loud knocking noise that had not been present before. Since this incident, the vehicle has been unable to operate reliably. It will start and run briefly but stalls again after a short distance. The knocking noise persists, suggesting a serious internal engine issue. The vehicle remains in my possession and is available for inspection. Component/System Involved: The failure appears to involve the engine and/or internal engine components. The exact cause has not yet been diagnosed by a professional. Safety Risk: This failure posed a significant safety hazard, as the sudden loss of power occurred while traveling on a highway. This could have resulted in a serious accident, particularly if surrounding traffic had been heavier or less responsive. Inspection and Diagnosis: The issue has not yet been formally diagnosed or confirmed by a dealership or independent repair facility. Additionally, the vehicle has not been inspected by the manufacturer, law enforcement, insurance representatives, or other entities. Warning Indicators: There were no warning lights, messages, or other indicators prior to or during the initial failure. The only symptom Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Was currently stuck in slow walking traffic and once traffic began to progress the car overheated engine notice appeared. Pulled into a parking lot as soon as car was parked the vehicle turned off. This happened during the night and was an extremely traumatic experience! Car does have a diagnosis about the engine been blown. Still in the works of being fixed by the dealership. Very long process!

I am writing to report a serious safety concern involving my Kia vehicle. Shortly after getting an oil change, my car began making unusual noises and then suddenly stopped working in the middle of a busy intersection. This unexpected stall created a dangerous situation for both myself and other drivers. After having it towed to the dealership, it comes down to an engine malfunction which was not covered by my warranty since it just hit 70,000 miles. I have since learned that other Kia owners have experienced similar issues, and I am concerned this may be related to a larger defect or recall issue. I wanted to report this incident to ensure it is properly documented and investigated.

My 2021 Kia forte GT is currently sitting in my driveway, undriveable. It started about 3months or so ago I had realized I was getting more and more frequent oil changes to the point where the car would be consuming a quart of oil in at least a week or less. Fast forward to this previous week, I now had a hard knock/rattle within my engine. The engine gave way on my way home which is a significant safety issue to myself and those who were driving around me. I have contacted Kia customer as they have had previous complaints as well as a lawsuit on the engine for the excessive engine oil consumption leading to possible engine failure. There’s no reason why an only 4 year old car should have a blown motor. I am thankful that I am personally ok and didn’t hurt anyone else while in the midst of driving my vehicle home.

2021 Kia Forte VIN# [XXX] 107,000 miles While driving my Kia Forte on [XXX] i experienced a sudden noise without warning just 2 months to the exact date after an oil change. The vehicle became unsafe to operate and could not accelerate properly. In some cases it would no have it would feel like it was losing power and creating a scary and dangerous situation. A certified mechanic diagnosed there was no oil in my vehicle which matches the oil consumption defect identified in Kia's Theta II GDI engine recalls and nationwide class action settlement. Kia has acknowledged in public filing that is defect poses a risk of engine seizing and fire. Although my VIN is not currently listed under any active recall, my vehicle exhibits the exact same defect pattern as recalled vehicles, including sudden loss of power at highway speeds which is a significant safety hazard. Manufactures Response: I contacted Kia Corporate to request an engine replacement consistent with the recall and the settlement remedies and they refused to cover the repair solely because my VIN is not included in the recall list despite the defect being identical. Safety Concern: The sudden loss of power creates a risk of rear-end collisions, loss of control and potential fire. This defect can be life threatening and should not be excluded from recall coverage simply due to VIN range. Requested Action: I am requesting that NHTSA investigate why vehicles with identical engine defects, including mine have been excluded from recall coverage and compel Kia to provide a no-cost repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Kia Forte. The contact stated while driving 65 MPH, there was an abnormal rattling sound coming from the engine compartment before the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that the cylinders and pistons had failed, and the engine needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 93,532.

On Saturday, March 1, 2025, I took my 2021 Kia Forte LXS for a routine oil change. I had NO PRIOR issues, warning lights or anything with my vehicle. The oil change was performed. I then drove my vehicle less than 20 miles, the vehicle would then not accelerate and started to bog down. I was able to get my vehicle off the major I-4 interstate, however eventually the vehicle then shut down. The vehicle now will still start however is making this terrible clicking noise. I have had video of the engine running looked at by several mechanics who states the engine is blown. I have contacted Kia who clearly has known engine issues on several of their Fortes however Kia continues to state since mine is not currently on recall, they are not taking responsibility. Kia know they have several recalls due to engine issues. I cannot get a mechanic to work on my vehicle due to the recalls as mechanics only want to put in brand new engines due to Kia engine recalls. A new engine will cost upwards of $10,000. Again, Kia knows and had several recalls with engine issues

I get regularly scheduled oil changes but the car is making a noise like a rod knock

While driving on the interstate, multiple dash lights came on, the engine started knocking and shutting down. The vehicle was towed to the dealership and was found that the oil plug had fallen out, causing the oil to drain out and ruin the motor.

Engine is very noisy for quite some time before getting quiet. 40000 miles. Lifters making a lot of noise. Possibly a failing oil pump.

While driving down the highway, the entire crank pulley system fell out from under the car and onto the highway.

Ticking sound under hood at 35000 miles

The contact owns a 2021 Kia Forte. While driving at various speeds, the check engine warning illuminated. The vehicle would start to vibrate. The vibration was more evident while slowing down or stopping at traffic lights. The vibration and the warning light had become a recurring failure. After turning off and restarting the vehicle, the check engine warning light was cleared. However, lately, turning on and restarting the vehicle failed to clear the warning light. Additionally, the vehicle lost motive power and stalled several times. While the vehicle was stopped and idling, the RPM was fluctuating as if the accelerator pedal was depressed. The vehicle was taken to the same dealer several times; however, the dealer was unable to duplicate the failure. The contact was advised that the vehicle was in good working order. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 125,000.