2002 Kia Sedona Engine Problems

I HAD MY CAMSHAFT REAR PLUG REPLACED AFTER IN CAME OUT AND LEAKED OIL EVERYWHERE IN 2014. NOW IT'S COME OUT AGAIN DOING THE SAME THING. WHAT CAN I DO TO KEEP IT FROM HAPPENING AGAIN AND AGAIN. IS IT THE PLUG OR THE CAMSHAFT THAT'S BLOWING IT OUT. I CAN'T FIND ANY SCHEMATIC TO SHOW ME WHY OR WHAT TO DO. *TR

TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SHE HEARD A KNOCKING NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT THE THREADS FOR THE CRANK SHAFT BOLT WERE MISSING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE BALANCER AND BOLT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 105,500.

I OWN A 2002 KIA SEDONA. I PURCHASED IT IN FEBRUARY AND WAS FINE UNTIL A MONTH LATER. I WAS ON MY WAY TO WORK AND I GOT ON THE HIGHWAY AND THE VAN STALLED AND JUST SHUT DOWN. AFTER ABOUT 5 MINUTES LATER IT RESTARTED THEN SHUT OFF AGAIN ABOUT 3 MILES DOWN THE HIGHWAY. I HAD THE FUEL PUMP AND CAMSHAFT REPLACED BUT IT STILL WILL NOT START. THEN THE BATTERY STOPPED WORKING. I REPLACED THAT AND IT STILL WILL NOT WORK. I CALLED KIA AND BECAUSE IT IS OUT OF WARRANTY THEY WOULD NOT HELP. THE DEALERSHIP IS WAY TOO EXPENSIVE BEING THAT I AM A SINGLE PARENT I CANNOT AFFORD THEIR PRICES. KIA CUSTOMER SERVICE IS VERY BAD AND WILL NOT HELP WITH ANYTHING. AFTER SEARCHING ONLINE I HAVE CAME TO A CONCLUSION THAT THIS IS A VERY COMMON PROBLEM AND THERE HASN'T BEEN ONE FIX TO IT. I DON'T HAVE THE ABILITY TO GO OUT AND PURCHASE ANOTHER VEHICLE AND JUST WANT THIS ONE FIXED. PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2002 KIA SEDONA EX. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH WHEN THE ENGINE STALLED. THE BATTERY, BRAKE AND SERVICE ENGINE WARNING LIGHTS WERE ILLUMINATED. THE ENGINE WAS RESTARTED AFTER SEVERAL MOMENTS. THE FAILURE RECURRED AT LEAST EIGHT DIFFERENT TIMES. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR THE SIMILAR FAILURE. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE PROBLEM AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.

TL*THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED. THE FUEL PUMP AND BATTERY WERE REPLACED BUT THE FAILURE CONTINUED. THE DEALER THEN REPLACED THE AIR FLOW SENSOR. SEPTEMBER 2010, THE ENGINE WAS SHAKING FOLLOWED BY THE VEHICLE STALLING AGAIN. THE CHECK ENGINE LIGHT ILLUMINATED AFTER THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 60,735. THE FAILURE MILEAGE WAS 54,084.

2002 KIA SEDONA MINIVAN. PURCHASED USED FEB 2006 W/32K MILES FROM PRIVATE OWNER. MOST RECENT MILES 59K. CAUGHT FIRE WHILE PARKED IN GARAGE AND IS TOTALED. HAVE HAD ELECTRICAL PROBLEMS INCLUDING ELECTRIC SEAT STOP FUNCTIONING, AND DEAD BATTERY WHENEVER PARKED FOR MORE THAN 5 DAYS. REPLACED THE BATTERY, REPLACED THE ALTERNATOR, REPLACED THE SERPENTINE BELT. ON 11/17/07 AFTER 6-MONTHS OF THE SEAT NOT WORKING, THE DRIVERS SIDE ELECTRIC SEAT CONTROLS SUDDENLY BEGAN TO WORK AGAIN, A FEW HOURS LATER THE VAN CAUGHT FIRE (DRIVERS SIDE DOOR AND DASH) AND BURNED THE INTERIOR. INSURANCE DECLARED IT TOTALED. *TR

THE REAR ANTI-FREEZE LINE OF MY 2002 KIA SEDONA RUSTED THROUGH AT 70,000 MILES CAUSING A SEVERE LEAK AND EVENTUAL TERMINAL ENGINE FAILURE. THERE WAS NO OVER HEATING WARNING ALARM BUILT IN AS A SAFETY PRECAUTION. DEALER DETERMINED THAT THE LINES WERE NOT DEFECTIVE SO IT WAS NOT COVERED UNDER WARRANTY. REGIONAL KIA SERVICE REP WAS VERY DISRESPECTFUL. KIA DID NOTHING TO HELP AND IT COST $4,000 TO REPLACE THE ENGINE WITH A USED ONE.

2ND REQUEST LTR FM RICHARD JORGE (FL) RE HIS DEFECTIVE 2002 KIA SEDONA.*MR WHEN THE VEHICLE ONLY HAD 180 MILES IT OVERHEATED AND SHORTED OUT. PRESENTLY, THE CONSUMER IS EXPERIENCING A RECURRING PROBLEM WITH THE BATTERY AND ALTERNATOR. *JB

WHILE DRIVING,THE VEHICLE STARTED SHAKING UNCONTROLLABLY WITHOUT WARNING. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. THEN STALL. THE DRIVER TRIED TO RESTART,BUT WAS UNABLE TO START. THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE PROBLEM CAN NOT BE DUPLICATE AT THIS TIME. PLEASE PROVIDE ADDITIONAL INFORMATION. *NM

WHILE DRIVING THE VEHICLE COMPLETELY STALLED, AND THE ENGINE DIED UPON TRYING TO ACCELERATE. *AK

I HAVE HAD NUMEROUS PROBLEMS WITH MY KIA SEDONA. WITHIN A FEW MONTHS OF OWNERSHIP THE HEAD GASKET BLEW AND IT WAS TOWED IN AND REPLACED. THEN THE WINDSHIELD BROKE DURING THE NIGHT IN THE GARAGE WITH NO WEATHER EXTREMES. I REPLACED THAT. IN 2 YEARS I'VE HAD 2 BLOWOUTS TO THE FRONT DRIVER'S TIRE. THE ONLY 2 IN MY WHOLE 30+ YEARS OF DRIVING.DEALER SAYS ITS NOT THE CAR. THE FRONT WHEEL BEARINGS WERE REPLACED. IN DEC 2004 THE ENGINE WAS REPLACED, THE LUMBAR SUPPORT WAS BROKEN AND FIXED, THE DRIVER'S DOORHANDLE BROKE AND WAS FIXED BY KIA. JAN18 IT WAS BACK IN BECAUSE THE HOOD RELEASE WAS NOT WORKING. IT WAS FIXED AND WE PICKED UP THE VEHICLE 1/19. ON 1/21 THE GAS PEDAL STUCK, I BROUGHT IT IN AND THEY FIXED IT IMMEDIATELY. " THE COVER HAD FALLEN DOWN AND THEY TIED IT BACK UP." OBVIOUSLY NOT A GOOD JOB BECAUSE IT STUCK AGAIN ON THE WAY HOME AT 65MPH. I WAS FINALLY ABLE TO STOP THE CAR AND HAD IT TOWED BACK IN. I THINK IT IS A DEATH TRAP!

OUR KIA SEDONA'S ENGINE HAS BEEN DYING WHEN COMING TO A STOP FOR ABOUT 6 MONTHS. KIA TRIED ON 8-5-04 TO FIX AND WAS TOLD IT NEEDED NEW SPARK PLUGS. REPLACED THE PLUGS. THREE WEEKS LATER ON 9-11-04 VAN ENGINE DYED AGAIN WHEN COMING TO A STOP. KEEPED A LOG OF THIS. ON 9-25-04 WHILE DRIVING 70 MPH ON THE INTERSTATE, THE ENGINE AGAIN DYED WHILE IN THE PASSING LANE. FINALLY GOT A CHECK ENGINE LIGHT. HAD TO WAIT THREE DAYS TO GET VAN INTO KIA, LIGHT WENT OUT BY THEN. KIA DEALERSHIP SAID IT HAS A TRANSMISSION ERROR CODE BUT CAN'T PINPOINT THE DEFECT TO FIX. KIA KEPT THE VAN A WEEK TRYING TO GET ENGINE LIGHT TO REAPPEAR IN VAIN. SO I NOW HAVE A VAN THAT COULD STOPPED RUNNING AT ANYTIME AND PLACE. NOT VERY REASSURING OR SAFE. WE ARE VERY UPSET AND KIA CORP REFUSES TO DO ANYTHING TO REMEDY THE SITUATION. *NM

KIA HAS INFORMED US THAT OUR CAR WILL CONTINUE TO NEED REPAIRS SINCE IT WAS NOT DESIGNED TO BE DRIVEN ON DIRT ROADS. WE LIVE ON A DIRT ROAD AND DRIVE MANY MILES OF DIRT ROADS AND NOW WE ARE SPENDING MONEY REPLACING PARTS NOT PROTECTED FROM DIRT DUE TO FAULTY ENGINEERING DESIGN.*AK

CONSUMER STATED THAT VEHICLE STALLED. CONSUME DROVE IN NORMAL CITY TRAFFIC WHEN SUDDENLY THE VEHICLE STALLED WITHOUT A CAUSE. VEHICLE HAD BEEN TO THE DEALER AT LEAST 4 TIMES. YET, PROBLEM RECURRED. *AK

WHILE DRIVING ON HIGHWAY WITH HEAT ON, THE AIR STOPPED BLOWING INTO THE CAR FROM THE VENTS EVEN THOUGH WE COULD HEAR THE BLOWER MOTOR RUNNING. THIS STARTED OCTOBER 4, 2003 AND STILL HAS NOT BEEN FIXED AS OF JUNE 2004.EVEN THOUGH WE HAVE HAD THE CAR IN THE REPAIR SHOP 11 TIMES. WE HAVE BEEN PLACED IN VERY DANGEROUS SITUATIONS BECAUSE OF THIS. DURING THE WINTER, WHEN THE BLOWER WOULD QUIT, THE WINDOWS WOULD FOG UP OR FREEZE UP IMMEDIATELY. WE COULDN'T EVEN SEE TO GET THE CAR OFF THE ROAD. THERE WAS NO WAY TO CLEAR THE WINDOWS, NOT TO MENTION THE DISCOMFORT OF FREEZING TO DEATH WHEN IT WAS 30 DEGREES BELOW ZERO. THE ENTIRE HEATING SYSTEM, ACTUATORS, BLOWER MOTOR WERE REPLACED AND THE BLENDER DOORS WERE REPROGRAMMED. WE ONLY HAVE HEAT SPORADICALLY. NOW THAT SUMMER IS HERE, THE AIR CONDITIONER DOESN'T WORK,. IT IS IN THE SHOP NOW HAVING THE COMPRESSOR REPLACED. THE TRANSMISSION ALSO WAS REPLACED IN OCT. 2003. WE FEEL THE COMPANY HAS HAD AMPLE TIME TO REPAIR THE CAR. THEY EVEN ADMIT THEY CAN'T FIX IT. WE ARE SEEKING A REPLACEMENT (COMPARABLE) VEHICLE OR A REFUND SO THAT WE CAN GET A VEHICLE THAT WORKS. I REFUSE TO GO THROUGH ANOTHER WINTER LIKE THAT. *AK

CHECK ENGINE LIGHT KEEPS COMING ON, EVERY 2000 MILES. IT IS ALWAYS THE SAME THING, A RICH FUEL MIXTURE. THIS PROBLEM AFFECTS THE ACCELERATION OF THE VEHICLE. WHEN THE DRIVER STEPS ON THE GAS, THE CAR EITHER BUCKS AND WON'T GO, OR JUST BOGS DOWN AND WON'T ACCELERATE. THIS IS DANGEROUS WHEN TRYING TO MERGE IN TRAFFIC ON BUSY, CONGESTED HIGHWAYS. EVERYTIME THIS HAPPENS, WE TAKE IT TO THE DEALER AND THEY KEEP IT SEVERAL DAYS TO A WEEK BEFORE THEY CAN FIGURE OUT WHAT IS WRONG. THIS IS THE 3RD TIME SINCE APRIL 2003 FOR THE SAME ISSUE. *LA

FROM 2ND WEEK WE COMPLAINED OF ENGINE NOISE. EACH TIME NO PROBLEM WAS FOUND. FEW MONTHS LATER CK ENGINE CAME ON. A SPARK PLUG WAS REPLACED. 1 MONTH LATER CK ENGINE LIGHT ON AGAIN. NEW FUEL INJECTOR. 2 DAYS LATER CK ENGINE LIGHT AGAIN. NEEDED NEW MOTOR AT 3800 MILES. 1 WEEK LATER CAUGHT ON FIRE IN OUR GARAGE. KIA REGIONAL MANAGEMENT CHRIS BUTLER SAID THEY WOULD REPAIR DAMAGES FROM FIRE BUT HAD NO CONCERN THAT OUR 6 MONTH OLD VAN WITH ONLY 3800 MILES ALREADY HAD THE MOTOR REPLACE AND CAUGHT ON FIRE. HIS ADVISE DON'T PARK IN THE GARAGE ANYMORE SO WE WON'T HAVE TO WORRY ABOUT IT BURNING DOWN OUR HOUSE. IRONIC THAT WE CHOOSE THIS VAN BECAUSE WE THOUGHT IT WOULD BE EASIER AND SAFER FOR OUR KIDS. NOW I FEAR OUR FAMILIES SAFETY EVERYDAY BECAUSE WE HAVE IT. *AK

THE VEHICLE DID NOT HOLD WHEN GOING DOWN A HILL OR NO LOW RANGE. THERE WAS A KNOCKING SOUND COMING FROM THE MOTOR(DEALER DIDN'T FIND PROBLEM), AND A WIND NOISE HAD COME FROM THE FRONT GLASS WHILE THE VEHICLE WAS IN MOTION. *NLM *SCC

THE MINI-VAN STARTED WITH A SIMPLE OIL LEAK THAT DEVELOPED INTO A CRACKED OIL FILTER HOUSING ON THE ENGINE TO THEN 3 BURNED OUT COILS AND TWO CHECK ENGINE LIGHTS ALL WITHIN 30 DAYS. CAR STILL IN SHOP. EB. *NLM

MY 2002 KIA SEDONA HAS EXPERIENCED MULTIPLE PROBLEMS SINCE I BOUGHT IT IN MARCH, 2002. MAJOR ELECTRICAL PROBLEMS, BATTERY REPLACEMENT, SLIDING DOOR FAILING TO CLOSE, ENGINE NOISE, AIR CONDITIONER PROBLEMS. HAVE CONTACTED MANUFACTURER AND DEALER. SOME ISSUES RESOLVED - - OTHERS UNABLE TO BE DIAGNOSED OR REPLICATED. FEAR THAT ENGINE, ELECTRICAL SYSTEM IS STILL NOT WORKING PROPERLY AND WILL FAIL AND CAUSE AN ACCIDENT.*AK