2011 Kia Sorento Body & Structure Problems

Non working door handles which is a KNOWN issue with Kia! Extremely dangerous obstruction in an event of an emergency where occupants need to get in and out of the vehicle. The ineffective door handles also makes the car less secure because someone who is not authorized can access the safety measures that the vehicle has. This is not right that Kia customers have to spend hundreds for an ongoing issue! This is two out of the four doors now. I replaced one door handle already for well over $300.00! Now will need to spend ANOTHER three hundred plus dollars for the same issue! Again, this is a KNOWN Kia issue! I was originally told there was a recall but only for the back handles and not the front handles in 2020. Now, I am being told it was a warranty and it expired in 2021/2022. A warranty was never relayed to me in any way. No email or mailed letter explaining this. If under "warranty" and again, a known Kia issue why were the backs covered but not the front if they are the same handles? Why not replace all four handles under the said "warranty"? This is a major issues for Kia owners like myself. Also having an issue where when it rains, water will come in from the passenger side panel and back trunk panels. Kia said it was the drains. Kia cleared the drains for well over $200.00. Next rain fall and the SAME issue still remained. Kia then said it was the moonroof assembly and would NOT get back to me with a remedy to solve the issue. I reached out again and I spoke to the general Manager who said he would call me back and NEVER did. I took it to another company who handles moonroofs/sunroofs and has said it is due to the paint separating in the grooves where the assembly sits and is a manufactural issue.

My vehicle has the Snow White Pearl paint on it, and it has been peeling from years. I have taken this to a number of body shops and they say its a factory defect. Kia acknowledges that it is a defect and have offered if I got it fixed to submit a case to see if they would reimburse it, however, this is over 10k out of pocket.

The rear frame on my 2011 kia sorento rusted and broke.

The door latch behind the driver side of the vehicle does not work. It will not open from the outside of the vehicle. This is a safety concern especially since this is my [XXX] daughter's car. I have called KIA, and they will not honor this repair since the car was purchased and used in January 2024. I also have another 2011 Kia Sorento with the same issue. This is definitely a problem with KIA and this should be repaired regardless of how old the vehicle is since it is due to a defect in the product. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Both passenger doors and the driver door will not open from the outside. All three have malfunctioned out of nowhere for no reason.

The door latch behind the driver side of the vehicle does not work. It will not open from the outside of the vehicle. This is a safety concern especially since this is my [XXX] daughter's car. I have called KIA and they will not honor this repair since the car was purchased used in August of 2021. I also have another 2011 Kia Sorento with the same issue. This is definitely a problem with KIA and this should be repaired regardless of how old the vehicle is since it is due to a defect in the product. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Exhaust system flex pipe was repaired and the next day the exhaust muffler/ resonator failed at the seam, causing hot gases to escape into the undercarriage and melt the lower bumper cover assembly on the right passenger side. See photos attached.

Both rear doors will not open from the outside. Driver rear door had child lock engaged when outside latch stopped working making the door completely inoperable. Upon contacting Kia consumer affairs it was stated that although both front door actuators are covered under a campaign number the rear doors are not covered. Kia consumer affairs refused to cover replacement of rear door actuators. Due to both rear doors being inoperable from the outside if an accident was to occurs while my children were in the vehicle emergency personal would not be able to get to them. No warning lamps or prior warning of fault before part malfunction.

My two driver side doors will only open from the inside when unlocked. The handles are not damaged

3 out of 4 doors will not open from the outside, only one that works is front passenger side. So I am forced to crawl in lean across open drivers door shove it open then get out run around to drivers side to get in (hoping the wind does not blow it closed before I get there) I have injured my back doing this, I am vey upset. I called Taylor Kia in Lima twice and no one will call me back. I have read on line this is a frequent problem with the 2011 model but no recall??? This is in deed a safety hazard, as if I had my grandchildren with me and something happened I would be unable to get the doors open to get them out! There were no warnings, the 2 back doors happened a couple weeks ago within a few days of one another, Drivers door just happened 2 weeks ago. This is the second time I have written/emailed you. My car has just under 90,000 miles. I should not have to pay out of my own pocket for something that is faulty by manufacturer! Thank you, I would appreciate a response.

12-29-2023, the Kia Sorento started smoking on the way home. When I got home I opened the hood and saw fire. I put the fire out with a fire extinguisher. On 1-9-2024, I made an appointment with Archer Kia and had the car towed there for a diagnosis. After a month with no response, the service manager at Kia advised me to contact Kia Corporation. I spoke to a representative and was assigned a case number. The representative stated that I should have gotten a software update but could not produce any information that I received a recall notice for the software update. All recall notices that I received were addressed and oil changes were regularly done at a major retail store. I was told that an investigation would be done and that I would be contacted. I didn’t receive a response for two months. I called Kia Corporation and was told that they sent information to an address that belonged to my mother which was calling her number instead of calling me. It was never determined why the information was sent to my mother. The car had been registered to my address for over 10 years. Once we established the correct information, I was asked to send service records. I was sent a letter before the representative received the service records stating that the cause of the fire was normal wear and tear. I went to the Archer Kia dealership to talk about the next step. The service manager stated that Kia didn’t send him anything so I waited. This was May 2023. January 2024, I contacted Archia Kia for information. They had received a decline notice to replace the motor. I called Kia Corporation again. I discovered that the original representative no longer worked there. The new representative wanted to call the dealership on a three way call. The service manager was not available and the representative told me he would call me back. In February 2024, I received a recall notice concerning the software issue and a notice stating that the car could catch on fire. In March 2024, I rec

My rear doors are locked and will only open from the inside. This is very frustrating and I believe very dangerous

Both front and rear passenger side doors do not open from the outside. Both failed within days of each other. There have been no incidents that would have caused this. This appears to be a widespread issue with Sorentos that has been going on for years.

Exterior pearl white paint is rapidly delaminating and causing severe rusting of the body in many places. This is NOT due to any scratches, dents or crashes. Kia corporate is aware of the defect and it appears to be a serious manufacturing defect in the primer or paint. I understand there are hundreds, if not tens of thousands, of Kia vehicles affected who have reported this. A recall needs to be issued as this is a major defect and body shops insist that the only fix is a complete paint strip and repainting of the entire car. The paint is bubbling up and/or coming off in sheets. New places pop up all the time and the rust is damaging the body. This started about 2 years ago and is continually getting worse.

One of the 2011 KIA SORENTO door can't open from outside or inside. This is really frustrating, as I couldn't open a door where my chiled seat. I have 5 year old and I have to sneak one of them into the other door. I am really frightened if what will happen if the child door is locked and child is in the car seat and I am not able to go inside my car. This is a potential hazard for my child. I heard from people is very common problem with Kia, Kia has to really step forward and replace this faulty mechanism. The cost my kia dealer estimates is $1200, I urge the Kia company to really fix this asap before someone gets hurt and/or result into fatality.

I have a 2011 KIA SORENTO and the rear back door handle has stopped working on 7/7/2021. This is safety issue as I can open the door from inside but not from outside. I have a small child and another on the way and not being able to open the door to let her out of the car is unacceptable. I am really frightened if what will happen if my child is inside and I am not able to get inside my car. This is a potential hazard for my child and my future infant child. Kia has to really step forward and replace this faulty mechanism. I urge the Kia company to recall and fix this asap before someone gets hurt and/or it results in a fatality.

The paint is peeling off down to the metal. On the roof (front and back) and on the hood.

I DROVE MY 2011 KIA SORENTO ABOUT 9:15 AT NIGHT. BY 12:45 AM A PASSERBY HAD CALLED 911 DUE TO MY CAR BEING IN FLAMES. I WAS WOKEN UP TO THE FIRE DEPARTMENT ARRIVING AT MY HOUSE AND MY CAR ENGULFED IN FLAMES. AFTER THE FLAMES WERE EXTINGUISHED, THEY CHECKED IT OVER AND DETERMINED THAT IT HAD STARTED IN THE ENGINE AREA. I BOUGHT THE CAR IN 2017 AND IT CURRENTLY ONLY HAS 120,750 MILES ON IT. THEY INVESTIGATED IT AND DETERMINED IT HAD STARTED ON THE PASSENGER SIDE NEAR THE ENGINE. MY CAR IS A TOTAL LOSS AND IT WAS HEARTBREAKING TO WAKE UP TO THAT AT ALMOST 1:00AM. KIA NEEDS TO GET IT TOGETHER AND TAKE CARE OF MY EXPENSES.*DT

Hood opened twice on me while I was driving.

THE DRIVER SIDE DOOR WILL NOT OPEN FROM THE INSIDE, I HAD A SIMILAR PROBLEM WITH THE PASSENGER DOOR ABOUT 6 MONTHS AGO. I LOOKED THIS UP AND IT APPEARS TO BE A PROBLEM WITH MANY OF THESE KIA CARS. I AM AFRAID THAT ALL THE DOOR MIGHT DO THIS AND I WOULD NOT BE ABOUT TO GET MY GRANDKIDS OUT OR IF I HAD TO GET OUT IN AN EMERGENCY I COULD NOT EXIT. NOW I HAVE TO ROLL DOWN THE WINDOW AND REACH OUTSIDE THE DOOR TO ACTIVATE THE DOOR HANDLE FROM THE OUTSIDE. MY FEAR IS THIS WILL STOP WORKING AND I WILL BE STUCK IN THE CAR. I AM AN OLDER PERSON SO CRAWLING OVER THE CONSOLE WOULD BE ALMOST IMPOSSIBLE. I BELIEVE IT IS A BROKEN DOOR LATCH ON THE INSIDE OF THE DOOR